MY TURN SIGNALS AND HAZARD LIGHTS HAVE INTERMITTENTLY BEEN COMPLETELY CEASING TO WORK. THIS COMES AND GOES, BUT SOMETIMES WILL BE TEMPORARILY REMEDIED IF I PUSH THE HAZARD BUTTON AND THEN RELEASE IT. IN RESEARCHING NHTSA, I FOUND NHTSA RECALL 03V327000 WHICH PERFECTLY MIRRORS THE SYMPTOMS I AM HAVING. UNFORTUNATELY, WHEN I CO…
Read full complaint
MY TURN SIGNALS AND HAZARD LIGHTS HAVE INTERMITTENTLY BEEN COMPLETELY CEASING TO WORK. THIS COMES AND GOES, BUT SOMETIMES WILL BE TEMPORARILY REMEDIED IF I PUSH THE HAZARD BUTTON AND THEN RELEASE IT. IN RESEARCHING NHTSA, I FOUND NHTSA RECALL 03V327000 WHICH PERFECTLY MIRRORS THE SYMPTOMS I AM HAVING. UNFORTUNATELY, WHEN I CONTACTED GM REGARDING THE RECALL, THEY SAID MY VIN DOES NOT FALL WITHIN THE RANGE. I FEEL THIS FAILURE IS RELATED. MY VIN IS [XXX]. THE FILE NUMBER WITH [XXX]. AT THIS POINT, THEY SAY THEY CAN'T HELP ME SINCE MY VIN DOESN'T FALL WITHIN THEIR RANGE ASSOCIATED WITH THIS RECALL. *NM UPDATED 07/12/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #10173403
64,000 miles · Sep 14, 2006
Exterior Lighting
DT*: THE CONTACT STATED THE FAILURE OF THE HAZARD WARNING SWITCH CAUSED THE TURN SIGNALS/HAZARD LIGHTS TO WORK INTERMITTENTLY AND RANDOMLY. A NHTSA RECALL, # 03V327000 WAS PERFORMED ON THE VEHICLE ON 2001 PRIOR TO HIS OWNERSHIP. THE RECALL WAS CONCERNING THE EXTERIOR LIGHTING: HAZARD FLASHING WARNING LIGHTS: SWITCH, HOWEVER TH…
Read full complaint
DT*: THE CONTACT STATED THE FAILURE OF THE HAZARD WARNING SWITCH CAUSED THE TURN SIGNALS/HAZARD LIGHTS TO WORK INTERMITTENTLY AND RANDOMLY. A NHTSA RECALL, # 03V327000 WAS PERFORMED ON THE VEHICLE ON 2001 PRIOR TO HIS OWNERSHIP. THE RECALL WAS CONCERNING THE EXTERIOR LIGHTING: HAZARD FLASHING WARNING LIGHTS: SWITCH, HOWEVER THE RECALL DID NOT REMEDY THE PROBLEM. THE DEALERSHIP WOULD NOT OFFER A SECOND REPAIR UNDER THE RECALL. UPDATED 10/25/2006 - THE VEHICLE HAD A THREE YEAR HISTORY OF THE TURN SIGNALS FAILING INTERMITTENTLY. WHILE DOING RESEARCH THE CONSUMER FOUND INFORMATION ON THE HAZARD SWITCH RECALL. *NM
NHTSA ODI #10168216
89,800 miles · Apr 17, 2006
Exterior Lighting
ON MY 2001 OLDSMOBILE ALERO, THE TURN SIGNAL/HAZARD LIGHT BECOMES INTERMITTENT AND/OR INOPERATIVE DURING TEMPERATURE VARIATIONS. THE DEALER AND GENERAL MOTORS REFUSE TO REPLACE WITHOUT COST BECAUSE THIS VEHICLE IS APPARENTLY NOT INCLUDED IN GM RECALL NO. 03043. *NM
NHTSA ODI #10155481
Mileage unknown · Mar 6, 2006
Exterior Lighting
TURN SIGNALS STOP WORKING INTERMITTENTLY, NO WARNING THAT THEY WILL NOT WORK. I HAVE PUSHED THE HAZARD BUTTON IN AND OUT AND THIS SOMETIMES HELPS. VERY DANGEROUS, I HAVE GONE MILES OUT OF MY WAY BECAUSE I CAN'T MAKE A TURN SAFELY WITHOUT BEING ABLE TO SIGNAL. *JB
NHTSA ODI #10151858
Mileage unknown · Feb 23, 2006
Exterior Lighting
MY 2001 OLDSMOBILE ALERO HAD NUMEROUS FAILURES OF THE TURN SIGNALS AND HAZARD WARNING FLASHER. BOTH SYSTEMS EITHER WORKED OR FAILED SIMULTANEOUSLY. THE FAILURES APPEARED TO BE RANDOM, I.E., THERE WAS NO PARTICULAR PATTERN. I BECAME AWARE OF A RECALL (NHTSA: 03V327000) AND CONTACTED THE MANUFACTURER, WHO INFORMED ME THAT MY V…
Read full complaint
MY 2001 OLDSMOBILE ALERO HAD NUMEROUS FAILURES OF THE TURN SIGNALS AND HAZARD WARNING FLASHER. BOTH SYSTEMS EITHER WORKED OR FAILED SIMULTANEOUSLY. THE FAILURES APPEARED TO BE RANDOM, I.E., THERE WAS NO PARTICULAR PATTERN. I BECAME AWARE OF A RECALL (NHTSA: 03V327000) AND CONTACTED THE MANUFACTURER, WHO INFORMED ME THAT MY VEHICLE ISN'T ONE AFFECTED BASED ON ITS VIN. *JB
NHTSA ODI #10151002
Mileage unknown · Dec 28, 2005
Exterior Lighting
MY 2001 OLDSMOBILE ALERO TURN SIGNALS INTERMITTENTLY BECOME INOPERABLE. *JB
NHTSA ODI #10146310
Mileage unknown · Oct 27, 2005
Exterior Lighting
DT:THE CONTACT STATED THE TURN SIGNALS AND HAZARD FLASHING WARNING LIGHT SWITCH WORKED INTERMITTENTLY. NHTSA RECALL 03V327000 WAS ISSUED FOR THIS PROBLEM. HOWEVER, THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN ACCORDING TO THE DEALERSHIP AND THE MANUFACTURER. *AK UPDATED 02/13/06. *JB
NHTSA ODI #10141090
Mileage unknown · Oct 11, 2005
Exterior Lighting
DT THE CONTACT STATED THERE WAS A LOUD TICKING SOUND. FIRST NOTICED THIS PROBLEM ON NOVEMBER 24, 2002. CONTACT STATED THEY RECEIVED A RECALL FOR THE HAZARD BUTTON. THE CONTACT TOOK THE VEHICLE TO THE DEALER, AND THEY DID RECALL REPAIRS, BUT DEALER STATED THE LOUD TICKING SOUND WAS FROM THE TURN SIGNAL AREA. AS SOON AS STARTIN…
Read full complaint
DT THE CONTACT STATED THERE WAS A LOUD TICKING SOUND. FIRST NOTICED THIS PROBLEM ON NOVEMBER 24, 2002. CONTACT STATED THEY RECEIVED A RECALL FOR THE HAZARD BUTTON. THE CONTACT TOOK THE VEHICLE TO THE DEALER, AND THEY DID RECALL REPAIRS, BUT DEALER STATED THE LOUD TICKING SOUND WAS FROM THE TURN SIGNAL AREA. AS SOON AS STARTING THE VEHICLE ONE COULD HEAR THE TICKING SOUND JUST AS IF HAD PUT TURN SIGNAL ON, BUT IT WAS AN EVEN FASTER TICKING SOUND. CONTACT CONTACTED THE MANUFACTURER, THEY WERE OF NO ASSISTANCE. *AK
NHTSA ODI #10139248
Mileage unknown · Oct 5, 2005
Exterior Lighting
DT: 2001 OLDSMOBILE ALERO. THE CONSUMER COMPLAINED ABOUT P EMERGENCY HAZARD LIGHT AND RIGHT AND LEFT TURN SIGNALS PROBLEMS. TURN SIGNALS DID NOT WORK. CONTACTED GMC., AND CHECKED CONSUMER'S VIN, THEN WAS TOLD THERE WAS NO RECALL ON THIS CAR. WENT TO PROGRESSIVE WEBSITE, THE CONSUMER'S INSURANCE COMPANY, AND FOUND RE…
Read full complaint
DT: 2001 OLDSMOBILE ALERO. THE CONSUMER COMPLAINED ABOUT P EMERGENCY HAZARD LIGHT AND RIGHT AND LEFT TURN SIGNALS PROBLEMS. TURN SIGNALS DID NOT WORK. CONTACTED GMC., AND CHECKED CONSUMER'S VIN, THEN WAS TOLD THERE WAS NO RECALL ON THIS CAR. WENT TO PROGRESSIVE WEBSITE, THE CONSUMER'S INSURANCE COMPANY, AND FOUND RECALLS ON 2001 OLDSMOBILE ALERO. CONSUMER JUST PURCHASED MY VEHICLE A WEEK AGO. AS I WAS ON MY WAY HOME WITH VEHICLE AND TURN SIGNALS WOULD NOT WORK. WOULD LIKE THE DEALERSHIP TO FIX THIS PROBLEM. THIS WAS A SAFETY ISSUE. COULD BE AT FAULT IF SOMEONE HIT CONSUMER'S VEHICLE AS IT WAS TURNING BECAUSE OF THE TURN SIGNALS.*AK
NHTSA ODI #10138729
61,000 miles · Oct 5, 2005
Exterior Lighting
TURN SIGNALS WILL WORK ONE TIME AND THEN NOT THE NEXT. *JB
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSAXLES (RPO M86) FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." WHEN A DRIVER ATTEMPTS TO SHIFT FROM 5TH GEAR TO REVERSE, A SHIFT INHIBITOR CAUSES THE TRANSMISSION TO BE MECHANICALLY IN 4TH GEAR EVEN THOUGH THE SHIFT LEVER INDICATES REVERSE GEAR.
Consequence & remedy
Consequence: IN THIS SITUATION, THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE TRANSMISSION IS IN A FORWARD GEAR, WHICH IS NOT PERMITTED BY THE STANDARD.
Remedy: DEALERS WILL DISABLE THE 5TH/REVERSE INHIBITOR BY REMOVING A RETAINING PIN AND REPLACE THE SHIFTER ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
2001 Oldsmobile Alero Problems, Complaints & Recalls | Skip That Year
Illustration