NHTSA owner reports · September 18, 2026 snapshot.
Exterior Lighting complaints
68 reportsClear category filter120,000 miles · Oct 27, 2008
Exterior Lighting
TL*THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. WHILE DRIVING APPROXIMATELY 40 MPH ON NORMAL ROAD CONDITIONS, THE TURN SIGNAL INDICATOR SOUNDED WITHOUT ASSISTANCE. THE CLICKING NOISE REMAINED UNTIL THE ENGINE WAS TURNED OFF. RECENTLY, SMOKE APPEARED FROM THE STEERING COLUMN AND A BURNING ODOR WAS PRESENT. THE VIN WAS NOT INCLU…
Read full complaint
TL*THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. WHILE DRIVING APPROXIMATELY 40 MPH ON NORMAL ROAD CONDITIONS, THE TURN SIGNAL INDICATOR SOUNDED WITHOUT ASSISTANCE. THE CLICKING NOISE REMAINED UNTIL THE ENGINE WAS TURNED OFF. RECENTLY, SMOKE APPEARED FROM THE STEERING COLUMN AND A BURNING ODOR WAS PRESENT. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 03V327000 (EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH), ALTHOUGH THE FAILURES WERE IDENTICAL. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 120,000 AND CURRENT MILEAGE WAS 122,000. UPDATED 12/10/08 *CN UPDATED 12/17/08.*JB
NHTSA ODI #10246827
63,000 miles · Sep 26, 2008
Exterior LightingFuel System, Gasoline
TL*THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. WHEN THE CONTACT ATTEMPTED TO START THE VEHICLE, SHE NOTICED THAT THE ENGINE WOULD TURN; HOWEVER, THE VEHICLE WOULD NOT START. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CONTACT ALSO NOTICED THAT THE TURN SIGNALS BEGAN TO MAKE A BUZZING SOUND. THE CURRENT MILEAGE WAS 12…
Read full complaint
TL*THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. WHEN THE CONTACT ATTEMPTED TO START THE VEHICLE, SHE NOTICED THAT THE ENGINE WOULD TURN; HOWEVER, THE VEHICLE WOULD NOT START. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CONTACT ALSO NOTICED THAT THE TURN SIGNALS BEGAN TO MAKE A BUZZING SOUND. THE CURRENT MILEAGE WAS 123,000 AND FAILURE MILEAGE WAS 63,000.
NHTSA ODI #10243552
48,000 miles · May 19, 2008
Electrical SystemExterior LightingSteering
HORN OF THE CAR DID NOT WORK AFTER SERVICE FOR REPLACEMENT OF FLASHER UNIT. NO TRAUMA OR INJURY TO CAR. INSPECTION OF CAR, IT WAS FOUND TO BE CRACKED STEERING WHEEL AT THE BASE AND IT DAMAGED THE HORN RING. WE WERE TOLD THAT WE COULD NOT DRIVE THE CAR UNTIL FIXED AS UNSAFE TO DRIVE. THE DEALER STATED THEY HAD ONLY EVER SEEN 1 OT…
Read full complaint
HORN OF THE CAR DID NOT WORK AFTER SERVICE FOR REPLACEMENT OF FLASHER UNIT. NO TRAUMA OR INJURY TO CAR. INSPECTION OF CAR, IT WAS FOUND TO BE CRACKED STEERING WHEEL AT THE BASE AND IT DAMAGED THE HORN RING. WE WERE TOLD THAT WE COULD NOT DRIVE THE CAR UNTIL FIXED AS UNSAFE TO DRIVE. THE DEALER STATED THEY HAD ONLY EVER SEEN 1 OTHER SUCH CASE IN 37 YEARS OF SERVICE. CAR MUST HAVE HAD A DEFECTIVE STEERING WHEEL WHICH MAY HAVE CAUSED AN ACCIDENT, INJURY OR DEATH. *TR
NHTSA ODI #10228247
90,000 miles · Mar 5, 2008
Exterior Lighting
ANYTIME THE CAR IS ON, A CLICKING SOUNDS COME FROM THE INSIDE OF THE CAR AS IF THE TURN SIGNAL IS ON. $200 FOR THE PART AND LABOR TO CHANGE THE TURN SIGNAL SWITCH. THIS SHOULD BE RECALLED, FOR CRYING OUT LOUD, ITS A 2001. I AM EXTREMELY DISSATISFIED WITH THIS. *TR
NHTSA ODI #10220165
89,000 miles · Feb 14, 2008
Exterior LightingInterior Lighting
TL*THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE INTERIOR, HAZARD, AND FOG LIGHTS MALFUNCTIONED. THE MANUFACTURER WOULD NOT REPAIR THE VEHICLE UNDER NHTSA CAMPAIGN ID 03V327000 (EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH) BECAUSE THE SWITCH WAS PREVIOUSLY REPLACED UNDER THE SAME RECALL. THE FAILURE MILEAGE WAS 89…
Read full complaint
TL*THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE INTERIOR, HAZARD, AND FOG LIGHTS MALFUNCTIONED. THE MANUFACTURER WOULD NOT REPAIR THE VEHICLE UNDER NHTSA CAMPAIGN ID 03V327000 (EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH) BECAUSE THE SWITCH WAS PREVIOUSLY REPLACED UNDER THE SAME RECALL. THE FAILURE MILEAGE WAS 89,000 AND CURRENT MILEAGE WAS 100,000.
NHTSA ODI #10218059
62,800 miles · Oct 16, 2007
Electrical SystemExterior Lighting
HARD STARTING. VEHICLE JUST KEEPS ON CRANKING BUT DOES NOT START UNLESS YOU PUMP ACCELERATOR SEVERAL TIMES. THIS HAPPENS DAILY,- EVERY TIME YOU ATTEMPT TO START THE VEHICLE. WE ALSO HAVE A PROBLEM WITH THE HAZARD WARNING SWITCH AND DIRECTIONAL LIGHTS,- POLICE FLASHED ME DOWN AND GAVE VERBAL WARNING. *JB
NHTSA ODI #10205805
61,000 miles · Aug 21, 2007
Exterior Lighting
TL*THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE CONTACT STATED THAT THE TURN SIGNALS WOULD NOT ILLUMINATE WHEN THE SWITCH WAS ENGAGED. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE ON TWO DIFFERENT OCCASIONS, BUT WAS ABLE TO ON THE THIRD OCCASION. THE DEALER STATED THAT THE HAZARD FLASHER SWITCH NEEDED TO BE REPLACED AND IN…
Read full complaint
TL*THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE CONTACT STATED THAT THE TURN SIGNALS WOULD NOT ILLUMINATE WHEN THE SWITCH WAS ENGAGED. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE ON TWO DIFFERENT OCCASIONS, BUT WAS ABLE TO ON THE THIRD OCCASION. THE DEALER STATED THAT THE HAZARD FLASHER SWITCH NEEDED TO BE REPLACED AND INFORMED THE CONTACT THAT HER VIN WAS EXCLUDED FROM RECALL NUMBER 03V327000 (EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH). THE SPEED WAS UNKNOWN. THE FAILURE MILEAGE WAS 61,000 AND CURRENT MILEAGE WAS 71,000.
NHTSA ODI #10200368
73,000 miles · Feb 12, 2007
Electrical SystemExterior LightingService Brakes, Hydraulic
SERVICE VEHICLE SOON, TRAC OFF LIGHT, AND ABS LIGHT TOOK TO DEALER, OUT OF WARRANTY, PRIVATE REPAIR SHOP, COST-$500, GRINDING NOISE BEFORE LIGHTS TURNED ON, DINGING,LIGHTS WENT ON, IT WAS SENSOR IN LEFT FRONT WHEEL BEARING. ALSO HAVE REPLACED FRONT ROTORS, ALTERNATOR AT 65,000 MILES. KEY FOB DOESN''T LOCK DRIVERS DOOR. HOOD ON …
Read full complaint
SERVICE VEHICLE SOON, TRAC OFF LIGHT, AND ABS LIGHT TOOK TO DEALER, OUT OF WARRANTY, PRIVATE REPAIR SHOP, COST-$500, GRINDING NOISE BEFORE LIGHTS TURNED ON, DINGING,LIGHTS WENT ON, IT WAS SENSOR IN LEFT FRONT WHEEL BEARING. ALSO HAVE REPLACED FRONT ROTORS, ALTERNATOR AT 65,000 MILES. KEY FOB DOESN''T LOCK DRIVERS DOOR. HOOD ON CAR REPLACED IN 2006 UNDER WARRANTY BECAUSE OF BLISTERING 2002-WATER LEAK ONTO DRIVERS FLOOR, 5 TIMES TO DEALER, REPLACED SIDE DOOR GASKET, PROBLEM HAD TO BE SOLVED BY REPLACING WINDSHIELD GASKET. I'M AFRAID OF ALL THESE COMPLAINTS ABOUT TURN SIGNAL FAILURE AND HAZARD LIGHT FAILURE AND THE CAR JUST QUITTING. TRADING IN THIS PIECE OF **** AS SOON AS PAID OFF. *JB
NHTSA ODI #10182402
60,400 miles · Jan 30, 2007
Exterior Lighting
I WAS SWITCHING LANES AND FLASHED MY TURN SIGNAL TO SWITCH LANE. WHEN I LET GO OF THE TURN SIGNAL, THE RELAY BEHIND THE HAZARD LIGHT BUTTON STARTED TO CLICK LIKE THE TURN SIGNAL WAS STILL ON. THIS IS AN INTERMITTENT CLICK AND IS NOT CONSISTENT. SOMETIMES IT CLICKS FAST AND SOMETIMES IT CLICKS SLOW. I FOUND RECALL 03V327000 A…
Read full complaint
I WAS SWITCHING LANES AND FLASHED MY TURN SIGNAL TO SWITCH LANE. WHEN I LET GO OF THE TURN SIGNAL, THE RELAY BEHIND THE HAZARD LIGHT BUTTON STARTED TO CLICK LIKE THE TURN SIGNAL WAS STILL ON. THIS IS AN INTERMITTENT CLICK AND IS NOT CONSISTENT. SOMETIMES IT CLICKS FAST AND SOMETIMES IT CLICKS SLOW. I FOUND RECALL 03V327000 AND THOUGHT THIS WAS THE PROBLEM. THE DEALERSHIP PERFORMED THIS RECALL AND THE CLICK IS STILL OCCURRING. I HAVE READ THAT THERE HAS BEEN ISSUES WITH MULTI-FUNCTION SWITCHES IN OTHER GM VEHICLES WHICH CAUSES A CLICKING OF THE HAZARD LIGHT BUTTON. ALSO, THE KEY IS GETTING WARM WHEN IT IS IN THE IGNITION. I AM AFRAID THIS CONSTANT CLICKING OF THE RELAY WILL CAUSE THE TURN SIGNALS FROM WORKING WHICH COULD RESULT IN AN ACCIDENT.
NHTSA ODI #10181104
Mileage unknown · Dec 23, 2006
Electrical SystemExterior LightingFuel System, Gasoline
CAR TURNS OVER BUT WILL NOT START. IT HAS LEFT ME STRANDED 3 TIMES SO FAR. I HAVE SPEND OVER A THOUSAND DOLLARS ON PARTS ALONE, AND NOW IT IS IN THE SHOP FOR I NEW FUEL PUMP.(ANOTHER $450) I HAVE READ MANY REPORTS OF THE SOMETHING HAPPENING TO OTHER PEOPLE AND NO RECALL. IT WOULD REALLY HELP TO HAVE A RECALL TO SAVE PEOPLE THEIR…
Read full complaint
CAR TURNS OVER BUT WILL NOT START. IT HAS LEFT ME STRANDED 3 TIMES SO FAR. I HAVE SPEND OVER A THOUSAND DOLLARS ON PARTS ALONE, AND NOW IT IS IN THE SHOP FOR I NEW FUEL PUMP.(ANOTHER $450) I HAVE READ MANY REPORTS OF THE SOMETHING HAPPENING TO OTHER PEOPLE AND NO RECALL. IT WOULD REALLY HELP TO HAVE A RECALL TO SAVE PEOPLE THEIR HARD EARN MONEY ON A PROBLEM THAT SHOULD HAVE BEEN FIXED BEFORE THE CAR WAS SOLD. I HAVE BEEN LATE TO WORK MANY TIMES, HAD TO CATCH BUSES, AND WALK MANY MILES BECAUSE OF THIS CAR. I HAVE PAID OVER $300 ON RIDES TO AND FROM WORK JUST SO I CAN PAY FOR PARTS FOR THE CAR TO ONLY RUN FOR A WEEK. SO PLEASE CAN YOU HAVE A RECALL ISSUED SO ME AND COUNTLESS OTHER CAN HAVE THE GOOD RUNNING CAR WE ALL PAY FOR IN THE FIRST PLACE. THANK YOU JARVIS JOYNER. *NM
NHTSA ODI #10176861
Official recalls
4Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Nov 13, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSAXLES (RPO M86) FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." WHEN A DRIVER ATTEMPTS TO SHIFT FROM 5TH GEAR TO REVERSE, A SHIFT INHIBITOR CAUSES THE TRANSMISSION TO BE MECHANICALLY IN 4TH GEAR EVEN THOUGH THE SHIFT LEVER INDICATES REVERSE GEAR.
Consequence & remedy
Consequence: IN THIS SITUATION, THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE TRANSMISSION IS IN A FORWARD GEAR, WHICH IS NOT PERMITTED BY THE STANDARD.
Remedy: DEALERS WILL DISABLE THE 5TH/REVERSE INHIBITOR BY REMOVING A RETAINING PIN AND REPLACE THE SHIFTER ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration