NHTSA owner reports · September 18, 2026 snapshot.
Exterior Lighting complaints
68 reportsClear category filterMileage unknown · May 2, 2017
Exterior Lighting
TURN SIGNAL INTERMITTENT AND SAFETY FLASHERS INOPERATIVE AT SAME TIME. DOESN'T MATTER IF IT'S IN MOTION, STATIONARY, ON CITY STREET, HIGHWAY, ETC., HAPPENS APPROX. 5 MINUTES AFTER BEING USED. I TOOK MY CAR TO A LOCAL STATION AND THEY COULDN'T REPAIR IT DUE TO INTERMITTENT PROBLEM AT FIRST. TOOK TO DIFFERENT SERVICE REPAIR AND…
Read full complaint
TURN SIGNAL INTERMITTENT AND SAFETY FLASHERS INOPERATIVE AT SAME TIME. DOESN'T MATTER IF IT'S IN MOTION, STATIONARY, ON CITY STREET, HIGHWAY, ETC., HAPPENS APPROX. 5 MINUTES AFTER BEING USED. I TOOK MY CAR TO A LOCAL STATION AND THEY COULDN'T REPAIR IT DUE TO INTERMITTENT PROBLEM AT FIRST. TOOK TO DIFFERENT SERVICE REPAIR AND THEY KNEW IMMEDIATELY OF THE RECALL AND SAID IT NEEDED A 4 WAY FLASHER SWITCH ASSEMBLY, AND TO TAKE IT TO MY LOCAL GM DEALER FOR REPAIR AND WHEN I DID, THEY DECLINED IT..!! RECALL: NHTSA CAMPAIGN #14V400000. IMMEDIATELY AFTER I BOUGHT THIS CAR FROM THE DEALERSHIP, PROSTROLLO AUTO MALL, MADISON, SD..I HAD THIS PROBLEM...IT CAME WITH THE CAR, SHOULDN'T THIS HAVE BEEN FIXED BY THE DEALERSHIP BEFORE THE SALE..?
NHTSA ODI #10982965
Mileage unknown · Dec 13, 2016
Electrical SystemExterior Lighting
TL* THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE CONTACT STATED THAT THE TURN SIGNALS AND HAZARD LIGHTS INTERMITTENTLY STOPPED WORKING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DETERMINED NOT TO BE INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V327000 (EXTERIOR LIGHTING). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NO…
Read full complaint
TL* THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE CONTACT STATED THAT THE TURN SIGNALS AND HAZARD LIGHTS INTERMITTENTLY STOPPED WORKING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DETERMINED NOT TO BE INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V327000 (EXTERIOR LIGHTING). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10935091
Mileage unknown · Nov 3, 2016
Exterior Lighting
WE HAVE THE SAME PROBLEM AS GM RECALL 03043 FOR 2001 OLDSMOBILE ALERO MODELS, BUT ARE TOLD OUR VIN IS NOT INCLUDED IN THE RECALL. WHY? WE HAVE A 2001 OLDSMOBILE ALERO. TURN SIGNALS ARE INTERMITTENTLY INOPERATIVE. DIRECTLY RELATED TO THE HAZARD WARNING LIGHTS. IF YOU MESS WITH THE HAZARDS, TURNING ON AND OFF, YOU MAYBE MIGHT…
Read full complaint
WE HAVE THE SAME PROBLEM AS GM RECALL 03043 FOR 2001 OLDSMOBILE ALERO MODELS, BUT ARE TOLD OUR VIN IS NOT INCLUDED IN THE RECALL. WHY? WE HAVE A 2001 OLDSMOBILE ALERO. TURN SIGNALS ARE INTERMITTENTLY INOPERATIVE. DIRECTLY RELATED TO THE HAZARD WARNING LIGHTS. IF YOU MESS WITH THE HAZARDS, TURNING ON AND OFF, YOU MAYBE MIGHT GET YOUR TURN SIGNALS TO WORK INTERMITTENTLY. THIS IS WHAT THE RECALL IS DIRECTLY ABOUT, BUT WHEN OUR VIN IS ENTERED INTO RECALL DATA BASE, IT SAYS NO RECALLS FOR THIS VIN. DOESN'T MAKE SENSE TO US. VERY DANGEROUS TO DRIVE WITHOUT TURN SIGNALS. PLEASE ADVISE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10924109
63,680 miles · Dec 3, 2015
Electrical SystemExterior LightingUnknown Or Other
WHEN DRIVING THE TURN SIGNALS WILL WORK AND THEN NOT WORK AT RANDOM AND THIS CONCERNS ME, IT CAN CREATE A SERIOUS AND DANGEROUS SITUATION
NHTSA ODI #10808294
183,000 miles · Mar 3, 2015
Electrical SystemExterior Lighting
SIGNAL TURN DON'T WORK, WORK ON AND OFF CAUSING HAZARD. *TR
NHTSA ODI #10691955
270,000 miles · Dec 16, 2014
Exterior Lighting
TL* THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE CONTACT STATED THAT WHILE DRIVING AT 60 MPH, THE TURN SIGNALS FAILED TO ACTIVATE. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 03V327000 EXTERIOR LIGHTING. THE MANUFACTURER WAS NOTIFIED OF T…
Read full complaint
TL* THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE CONTACT STATED THAT WHILE DRIVING AT 60 MPH, THE TURN SIGNALS FAILED TO ACTIVATE. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 03V327000 EXTERIOR LIGHTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 270,000. ....UPDATED 01/23/15 *BF THE CONSUMER STATED WHILE SITTING AT A TRAFFIC LIGHT OR DRIVING 60 MPH, THE TURN SIGNALS WOULD NOT OPERATE. IT WAS AN INTERMITTENT PROBLEM BUT WHEN IT HAPPENED, PRESSING THE HAZARD BUTTON CAUSED THE TURNED SIGNALS TO WORK. THE VEHICLE WAS TO A LOCAL REPAIR SHOP, BUT THE TURN SIGNALS WORKED AT THE TIME. UPDATED 02/18/15.*JB
NHTSA ODI #10664684
106,285 miles · Nov 10, 2014
Exterior Lighting
TL* THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE TURN SIGNALS AND HAZARD LAMPS MALFUNCTIONED INTERMITTENTLY. THE CONTACT BELIEVED THAT THE FAILURE WAS DIRECTLY RELATED TO NHTSA CAMPAIGN NUMBER: 03V327000 (EXTERIOR LIGHTING). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE.…
Read full complaint
TL* THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE TURN SIGNALS AND HAZARD LAMPS MALFUNCTIONED INTERMITTENTLY. THE CONTACT BELIEVED THAT THE FAILURE WAS DIRECTLY RELATED TO NHTSA CAMPAIGN NUMBER: 03V327000 (EXTERIOR LIGHTING). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 106,285.
NHTSA ODI #10653810
186,000 miles · Oct 1, 2014
Electrical SystemExterior Lighting
THE FIRST TIME IT STOPPED WORKING, I THOUGHT MAYBE I HAD JUST A BURNED OUT SIGNAL LAMP, BUT THEN IT STARTED WORKING AGAIN. IT WAS PRETTY RANDOM AT FIRST, BUT NOW IT WILL NOT WORK AT ALL, OR IT WILL START WORKING BLINK TWICE AND THEN JUST STOP. IT MAY BE "DEAD" FOR A LONG WHILE AND THEN JUST START BACK UP. USUALLY IT JUST DOES…
Read full complaint
THE FIRST TIME IT STOPPED WORKING, I THOUGHT MAYBE I HAD JUST A BURNED OUT SIGNAL LAMP, BUT THEN IT STARTED WORKING AGAIN. IT WAS PRETTY RANDOM AT FIRST, BUT NOW IT WILL NOT WORK AT ALL, OR IT WILL START WORKING BLINK TWICE AND THEN JUST STOP. IT MAY BE "DEAD" FOR A LONG WHILE AND THEN JUST START BACK UP. USUALLY IT JUST DOESN'T WORK AT ALL ANYMORE. I HAVE DRIVEN DOWN THE HIGHWAY WITH IT TURNED ON AND IT WILL BE 5-10 MINUTES LATER AND IT WILL START BLINKING AGAIN. I SEE THERE IS/WAS A RECALL FOR THIS EXACT PROBLEM, FOR MODEL YEARS 2000-2001 AND I HAVE A 2001, BUT THEY CLAIM MY VEHICLE IS NOT PART OF THE RECALL. THE RECALL IS 03V327000, OR GM RECALL 03043A. THE A WAS BECAUSE THEY EXPANDED IT TO INCLUDE THESE TWO MODEL YEARS FROM AN ORIGINAL RECALL. I TALKED TO OLDSMOBILE DIRECTLY AND THEY SAY IT IS NOT PART OF THE RECALL. THAT WAS IN A CALL, AND I SENT GM AN E-MAIL DETAILING THIS PROBLEM, BUT I HAVE NOT HEARD ANYTHING BACK FROM THEM EITHER. I WOULD THINK WITH ALL THE OTHER RECALLS THEY HAVE GOING ON, THEY SHOULD JUST ACCEPT THIS ONE AND NOT MAKE A BIG ISSUE OUT OF IT. MORE NEGATIVE PRESS. AS I WAS LOOKING THROUGH THE POTENTIAL ISSUES/RECALLS I DID SEE A FEW OTHER BULLETINS THEY HAD FOR ISSUES ON THAT MODEL YEAR AND VEHICLE, SOME OF WHICH I AM EXPERIENCING AS WELL. I DO UNDERSTAND THAT THIS IS A 14-15 YEAR OLD CAR, BUT I WOULD LOVE TO DRIVE IT FOR A LONG TIME YET. *TR
NHTSA ODI #10640549
68,000 miles · Sep 27, 2013
Electrical SystemExterior LightingCrash
HAZARD SWITCH FAILED RESULTING IN TURN SIGNALS ALSO NOT WORKING. PART WAS REPLACED IN 2004 UNDER RECALL ID 34013 BUT REPLACEMENT PART HAS FAILED. *TR
NHTSA ODI #10545734
87,000 miles · Aug 2, 2013
Exterior Lighting
TL* THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE VEHICLE WAS REMEDIED FOR RECALL NHTSA CAMPAIGN NUMBER: 03V327000 (EXTERIOR LIGHTING). THE CONTACT STATED BOTH OF THE TURN SIGNALS ON THE VEHICLE COME ON SPORADICALLY. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC BUT THE CAUSE OF FAILURE HAD NOT BEEN DIAGNOSED. THE MANUFAC…
Read full complaint
TL* THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE VEHICLE WAS REMEDIED FOR RECALL NHTSA CAMPAIGN NUMBER: 03V327000 (EXTERIOR LIGHTING). THE CONTACT STATED BOTH OF THE TURN SIGNALS ON THE VEHICLE COME ON SPORADICALLY. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC BUT THE CAUSE OF FAILURE HAD NOT BEEN DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 87,000. THE CURRENT MILEAGE WAS 92,000.
NHTSA ODI #10533230
Official recalls
4Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Nov 13, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSAXLES (RPO M86) FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." WHEN A DRIVER ATTEMPTS TO SHIFT FROM 5TH GEAR TO REVERSE, A SHIFT INHIBITOR CAUSES THE TRANSMISSION TO BE MECHANICALLY IN 4TH GEAR EVEN THOUGH THE SHIFT LEVER INDICATES REVERSE GEAR.
Consequence & remedy
Consequence: IN THIS SITUATION, THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE TRANSMISSION IS IN A FORWARD GEAR, WHICH IS NOT PERMITTED BY THE STANDARD.
Remedy: DEALERS WILL DISABLE THE 5TH/REVERSE INHIBITOR BY REMOVING A RETAINING PIN AND REPLACE THE SHIFTER ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration