NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
89 reportsClear category filter85,000 miles · Nov 26, 2006
Electrical System
THE SECURITY LIGHT ON MY DASH WILL COME ONE ABOUT 3 TO 5 TIMES PER MONTH. THIS RESULTS IN MY CAR NOT STARTING. THE FIRST TIME I WAS ALONE AND HAD TO PHONE FOR SOMEONE TO HELP ME. WHEN THEY ARRIVED THE CAR STARTED. AFTER THIS, I REALIZED THE CAR WOULD START AFTER ABOUT TEN MINUTES. I WORK WITH ANOTHER ALERO OWNER AND SHE…
Read full complaint
THE SECURITY LIGHT ON MY DASH WILL COME ONE ABOUT 3 TO 5 TIMES PER MONTH. THIS RESULTS IN MY CAR NOT STARTING. THE FIRST TIME I WAS ALONE AND HAD TO PHONE FOR SOMEONE TO HELP ME. WHEN THEY ARRIVED THE CAR STARTED. AFTER THIS, I REALIZED THE CAR WOULD START AFTER ABOUT TEN MINUTES. I WORK WITH ANOTHER ALERO OWNER AND SHE HAD THE SAME PROBLEM AND HAD TO PAY A VERY LARGE AMOUNT OF MONEY TO FIX THE PROBLEM. SHE ALSO SAID THAT EVERY ALERO OWNER SHE KNOWS HAS HAD THE SAME PROBLEM. I HAVE NOT VISITED A DEALERSHIP DUE TO THE COST, AND I FEEL A RECALL SHOULD BE MADE. *NM
NHTSA ODI #10174289
Mileage unknown · Jun 24, 2006
Electrical SystemEngine And Engine CoolingPower Train
I PURCHASED A 2000 OLDSMOBILE ALERO IN JUNE OF 2002, SINCE THE PURCHASE I HAVE HAD NOTHING BUT MECHANICAL ISSUES. THE FIRST BEING BRAKES/ROTORS BEING REPLACED TWICE A YEAR, THEN MY HEAD GASKET WENT, TIRES WEAR TOO QUICKLY, AND NOW MY SERVICE ENGINE LIGHT, ABS LIGHT, NO TRACTION LIGHT (WHICH DOES NOT WORK), CHANGE OIL LIGHT IS …
Read full complaint
I PURCHASED A 2000 OLDSMOBILE ALERO IN JUNE OF 2002, SINCE THE PURCHASE I HAVE HAD NOTHING BUT MECHANICAL ISSUES. THE FIRST BEING BRAKES/ROTORS BEING REPLACED TWICE A YEAR, THEN MY HEAD GASKET WENT, TIRES WEAR TOO QUICKLY, AND NOW MY SERVICE ENGINE LIGHT, ABS LIGHT, NO TRACTION LIGHT (WHICH DOES NOT WORK), CHANGE OIL LIGHT IS ON, AND NOW I AM HAVING PROBLEMS WITH MY WHEEL BEARINGS, AND CV JOINTS, THE CAR ACTUALLY MAKES GRINDING NOISES WHEN TURNING TO THE LEFT AND OFTEN SOUNDS AND FEELS AS IF I HAVE A FLAT TIRE. I HAVE HAD ALL OF THESE REPAIRS DONE AND THE CAR WAS FINE FOR 1 WEEK AND NOW ALL OF THE PROBLEMS ARE BACK EXCEPT FOR THE HEAD GASKET. DID I MENTION I ALSO HAD TO HAVE THE POWER STEERING PUMP REPLACED AS WELL, I FEEL THAT FOR THE PRICE I PAID AND THE RESEARCH I HAVE DONE, THERE ARE MANY OTHERS THAT ARE HAVING THE SAME DIFFICULTY AS ME, WHEN I READ OTHERS PROBLEMS, I FEEL LIKE I AM READING ABOUT MY CAR. THIS WAS MY FIRST CAR I HAD EVER PURCHASED AND FEEL THAT MINE AND MY FAMILY'S SAFETY IS AT RISK BECAUSE YOU NEVER KNOW WHEN SOMETHING IS GOING TO HAPPEN AND I AM ABOUT OUT OF MONEY REPLACING PARTS. PLEASE LOOK INTO ANYONE WHO OWNS A OLDSMOBILE ALERO AND GIVE ME SOME ADVICE. THANK YOU. *NM
NHTSA ODI #10160672
63,000 miles · Jun 1, 2006
Electrical System
DT*: THE CONTACT STATED THE SECURITY LIGHT ON THE VEHICLE INTERMITTENTLY ILLUMINATES AT LEAST ONCE A WEEK. WHEN THE SECURITY LIGHT ILLUMINATES THE VEHICLE WILL NOT START. THE LIGHT GOES OFF IN ABOUT TEN MINUTES ALLOWING THE VEHICLE TO START. THE DEALERSHIP HAS NOT BEEN ALERTED.
NHTSA ODI #10158741
Mileage unknown · May 3, 2006
Electrical System
FOR THE PAST 4 YEARS MY OLDS ALERO HAS REFUSED TO START DUE TO A MALFUNCTION WITH THE BUILT IN SECURITY SYSTEM. THIS HAPPENS ONE A WEEK AND YOU HAVE TO WAIT FOR 15 MINUTES TO TRY AND START THE CAR AGAIN. THE DEALER WANTED A COUPLE HUNDRED DOLLARS TO FIX IT. I HAVE CHECKED FORUMS AND THIS IS A COMMON PROBLEM. WHY DOESN'T GM ACKNO…
Read full complaint
FOR THE PAST 4 YEARS MY OLDS ALERO HAS REFUSED TO START DUE TO A MALFUNCTION WITH THE BUILT IN SECURITY SYSTEM. THIS HAPPENS ONE A WEEK AND YOU HAVE TO WAIT FOR 15 MINUTES TO TRY AND START THE CAR AGAIN. THE DEALER WANTED A COUPLE HUNDRED DOLLARS TO FIX IT. I HAVE CHECKED FORUMS AND THIS IS A COMMON PROBLEM. WHY DOESN'T GM ACKNOWLEDGE THE PROBLEM AND FIX IT FOR US. I GUESS THEY WANT US TO BUY A DEPENDABLE CAR FROM SOMEONE ELSE. *JB
NHTSA ODI #10156745
Mileage unknown · Apr 19, 2006
Electrical SystemEngine And Engine Cooling
I BOUGHT MY OLDS, ALERO USED IN JULY OF 2002 AND NOTHING BUT PROBLEMS, IT STALLED ON ME ON THE INTERSTATE JUST A FEW MONTHS AFTER I BOUGHT IT. THE MECHANIC SAID HE FIXED IT ONLY TO GET IT BACK AND STALL AGAIN AND AGAIN. I SPENT SO MUCH MONEY ON IT TRYING TO FIND OUT WHAT WAS WRONG. THE MECHANIC DIDN'T KNOW AND DID NOT REFUND M…
Read full complaint
I BOUGHT MY OLDS, ALERO USED IN JULY OF 2002 AND NOTHING BUT PROBLEMS, IT STALLED ON ME ON THE INTERSTATE JUST A FEW MONTHS AFTER I BOUGHT IT. THE MECHANIC SAID HE FIXED IT ONLY TO GET IT BACK AND STALL AGAIN AND AGAIN. I SPENT SO MUCH MONEY ON IT TRYING TO FIND OUT WHAT WAS WRONG. THE MECHANIC DIDN'T KNOW AND DID NOT REFUND ME MY MONEY. MY LIGHTS ON THE DASH STAY ON, THE CHECK ENGINE LIGHT AND THE TRAC AND WATER AND OIL CHANGE LIGHT. MY CIGARETTE LIGHTER DOES NOT WORK AGAIN AND THE BUTTON YOU PUSH IN TO PUT THE STICK SHIFT IN REVERSE HAS FALLEN OFF. THE DASH UPHOLSTERY IS MESSED UP. THE RADIO NEVER CAME IN RIGHT. I BOUGHT A LEMON. JUST THE OTHER DAY MY CAR STALLED AGAIN ON THE BRIDGE AND I WAS ALMOST KILLED, MY 13 YEAR OLD DAUGHTER AND MY 13 YEAR OLD NIECE WERE WITH ME AND THEY WERE CRYING SCARED , WE WERE ALMOST REAR ENDED. I FINALLY GOT IT TO START AND MADE IT TO MY HOUSE, MY CAR WAS MISSING AND MAKING A POPPING NOISE. I STARTED MY CAR AN HOUR LATER AND IT WAS FINE. I NEED SOME HELP. WHAT CAN I DO? PLEASE EMAIL ME BACK AT SWEETKALLEN@AOL.COM OR CALL ME ON MY CELL#(225)802-0394. *JB
NHTSA ODI #10155732
64,682 miles · Feb 16, 2006
Electrical SystemInjury
IGNITION/ANTI-THEFT SECURITY SYSTEM FAILS. CAR WON'T START. "SECURITY" LIGHT FLASHES RED WHEN I TRY TO TURN THE KEY. MUST WAIT ABOUT 10 MINUTES FOR LIGHT TO GO OFF. ALSO, SECURITY LIGHT COMES ON AS I AM DRIVING AND REMAINS THAT WAY UNTIL I TURN THE CAR OFF. ON ONE OCCASION, CAR STALLED WHILE DRIVING WITH LIGHT ON. THIS PROBLEM…
Read full complaint
IGNITION/ANTI-THEFT SECURITY SYSTEM FAILS. CAR WON'T START. "SECURITY" LIGHT FLASHES RED WHEN I TRY TO TURN THE KEY. MUST WAIT ABOUT 10 MINUTES FOR LIGHT TO GO OFF. ALSO, SECURITY LIGHT COMES ON AS I AM DRIVING AND REMAINS THAT WAY UNTIL I TURN THE CAR OFF. ON ONE OCCASION, CAR STALLED WHILE DRIVING WITH LIGHT ON. THIS PROBLEM BEGAN LAST YEAR. I TOOK THE CAR TO A GM DEALER AND HAD THE ANTI-THEFT AND IGNITION SYSTEM REPLACED. IT COST MORE THAN $500.00. TODAY, EXACTLY ONE YEAR AFTER, THE PROBLEM STARTED AGAIN. SAME EVERYTHING ALL OVER AGAIN. *JB
NHTSA ODI #10150479
45,000 miles · Jan 5, 2006
Electrical System
RE: OLDSMOBILE ALERO 2000 THE SECURITY SYSTEM ENGAGES CAUSING THE VEHICLE TO REMAIN INOPERATIVE FOR A PERIOD OF TEN MINUTES. IF THE LIGHT ENGAGES WHILE IN MOTION, THE CAR STALLS. MECHANICS FROM THE DEALERSHIP AND INDEPENDENT MECHANICS CAN NOT ADDRESS THE FAILURE. SECONDLY THE BLINKERS WORK AT TIMES;HOWEVER, THE DRIVER'S SIDE D…
Read full complaint
RE: OLDSMOBILE ALERO 2000 THE SECURITY SYSTEM ENGAGES CAUSING THE VEHICLE TO REMAIN INOPERATIVE FOR A PERIOD OF TEN MINUTES. IF THE LIGHT ENGAGES WHILE IN MOTION, THE CAR STALLS. MECHANICS FROM THE DEALERSHIP AND INDEPENDENT MECHANICS CAN NOT ADDRESS THE FAILURE. SECONDLY THE BLINKERS WORK AT TIMES;HOWEVER, THE DRIVER'S SIDE DOOR MOTOR DOES NOT WORK WHEN THE BLINKERS RESPOND. *JB
NHTSA ODI #10146970
60,000 miles · Nov 10, 2005
Electrical SystemSuspension
FRONT TIRE AREA WAS MAKING LOTS OF NOISE. TOOK IT TO DEALER FOR SERVICE TO CHECK IT OUT - THOUGHT IT MIGHT BE POWER STEERING PROBLEM. THEY TOLD ME IT WAS THE BRAKES. I DID NOT BELIEVE THIS WAS THE PROBLEM. TOOK THE CAR TO A TRANSMISSION SHOP TO CHECK THAT. HE HEARD THE NOISE AND THOUGHT IT MIGHT BE THE WHEEL BEARINGS. WE T…
Read full complaint
FRONT TIRE AREA WAS MAKING LOTS OF NOISE. TOOK IT TO DEALER FOR SERVICE TO CHECK IT OUT - THOUGHT IT MIGHT BE POWER STEERING PROBLEM. THEY TOLD ME IT WAS THE BRAKES. I DID NOT BELIEVE THIS WAS THE PROBLEM. TOOK THE CAR TO A TRANSMISSION SHOP TO CHECK THAT. HE HEARD THE NOISE AND THOUGHT IT MIGHT BE THE WHEEL BEARINGS. WE TOOK IT TO ANOTHER MECHANIC AND HE FOUND THAT IT WAS THE WHEEL BEARINGS AND SAID THAT IT SHOULD NOT HAVE NEEDED TO BE REPLACED - THAT THEY USUALLY LAST OVER 100,000 MILES (I ONLY HAD AROUND 60,000 MILES ON THE CAR). THE OTHER PROBLEM IS THAT THE HEATER/AIR CONDITIONING FAN SWITCH DOES NOT WORK ON THE FIRST TWO SPEEDS - ONLY ON THE MIDDLE AND HIGHER SPEEDS. I WORK WITH A MAN WHO HAS THE SAME PROBLEM ON THE SAME MAKE/MODEL/YEAR AS MY CAR. *NM
NHTSA ODI #10142355
75,000 miles · Jul 9, 2005
Electrical System
MY 2000 OLDSMOBILE ALERO HAS PROBLEMS STARTING DUE TO A DEFECT IN THE PASSLOCK SYSTEM. THE SECURITY LIGHT WILL ILLUMINATE WHILE DRIVING AND I HAVE HAD 5 INSTANCES WHERE THE VEHICLE WILL NOT START AT ALL. I READ THE OWNERS MANUAL AND FOLLOWED ALL THE INSTRUCTIONS PROVIDED. THERE IS NO REASON FOR SUCH A FLAW, I HAVE TAKEN EXCELLEN…
Read full complaint
MY 2000 OLDSMOBILE ALERO HAS PROBLEMS STARTING DUE TO A DEFECT IN THE PASSLOCK SYSTEM. THE SECURITY LIGHT WILL ILLUMINATE WHILE DRIVING AND I HAVE HAD 5 INSTANCES WHERE THE VEHICLE WILL NOT START AT ALL. I READ THE OWNERS MANUAL AND FOLLOWED ALL THE INSTRUCTIONS PROVIDED. THERE IS NO REASON FOR SUCH A FLAW, I HAVE TAKEN EXCELLENT CARE OF MY VEHICLE.
NHTSA ODI #10128171
Mileage unknown · Apr 14, 2005
Electrical SystemEngine And Engine Cooling
ENGINE BLEW. ALL THE WARNINGS LIGHTS ARE ON ACROSS THE DASHBOARD. WE BOUGHT THIS CAR USED FOR OUR SON AND AFTER HAVING IT FOR ABOUT A 18 MONTHS THE ENGINE BLEW. THE DEALER THAT FIXED IT SAID HE SHOULD HAVE PAID ATTENTION TO THE WARNING LIGHT. MY SON CHANGED THE OIL ON TIME ALWAYS AND THE LIGHTS NEVER WENT OUT. TRIED TO GET TH…
Read full complaint
ENGINE BLEW. ALL THE WARNINGS LIGHTS ARE ON ACROSS THE DASHBOARD. WE BOUGHT THIS CAR USED FOR OUR SON AND AFTER HAVING IT FOR ABOUT A 18 MONTHS THE ENGINE BLEW. THE DEALER THAT FIXED IT SAID HE SHOULD HAVE PAID ATTENTION TO THE WARNING LIGHT. MY SON CHANGED THE OIL ON TIME ALWAYS AND THE LIGHTS NEVER WENT OUT. TRIED TO GET THE LIGHTS OUT TO NO AVAIL. PAID 2800.00 TO HAVE USED ENGINE PUT IN BY THE DEALER AND THE DASH LIGHTS ARE STILL ON. SOME SORT OF ELECTRICAL PROBLEM BECAUSE HEAT/DEFROSTER ONLY WORK ON HIGH EVEN AFTER REPLACED ENGINE INSTALLED. THIS HAS BEEN A NIGHTMARE FOR A YOUNG MAN WITH HIS FIRST CAR.*AK
NHTSA ODI #10116911
Official recalls
4Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Nov 13, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSAXLES (RPO M86) FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." WHEN A DRIVER ATTEMPTS TO SHIFT FROM 5TH GEAR TO REVERSE, A SHIFT INHIBITOR CAUSES THE TRANSMISSION TO BE MECHANICALLY IN 4TH GEAR EVEN THOUGH THE SHIFT LEVER INDICATES REVERSE GEAR.
Consequence & remedy
Consequence: IN THIS SITUATION, THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE TRANSMISSION IS IN A FORWARD GEAR, WHICH IS NOT PERMITTED BY THE STANDARD.
Remedy: DEALERS WILL DISABLE THE 5TH/REVERSE INHIBITOR BY REMOVING A RETAINING PIN AND REPLACE THE SHIFTER ASSEMBLY.
May 18, 2000
VEHICLE DESCRIPTION: THESE VEHICLES DO NOT COMPLY WITH THE OCCUPANT PROTECTION REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE CONSOLE COVER ON THESE VEHICLES DOES NOT STAY CLOSED WHEN A SPECIFIED VERTICAL LOAD IS APPLIED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CONSOLE COVER COULD OPEN AND THE COVER OR ITEMS STORED UNDER IT COULD INJURE AN OCCUPANT.
Remedy: DEALERS WILL REPLACE THE CONSOLE LATCH MECHANISM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5RQ04005 · Turn Signal Failures
Opened Jun 18, 2004 · Closed Nov 30, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE02066 · Engine Stall Due To Fuel Starvation
Opened Sep 6, 2002 · Closed Nov 3, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other; Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Gasoline
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration