NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
89 reportsClear category filter137,000 miles · Oct 7, 2014
Electrical SystemEngine
TL* THE CONTACT OWNS A 2000 OLDSMOBILE ALERO. THE CONTACT STATED THAT THE VEHICLE HESITATED TO START AND FAILED TO TURN TO THE OFF POSITION. ALSO, THE CONTACT MENTIONED THAT THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED A NOTIFICAT…
Read full complaint
TL* THE CONTACT OWNS A 2000 OLDSMOBILE ALERO. THE CONTACT STATED THAT THE VEHICLE HESITATED TO START AND FAILED TO TURN TO THE OFF POSITION. ALSO, THE CONTACT MENTIONED THAT THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED A NOTIFICATION FOR RECALL NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE CONTACT MENTIONED THAT THE VEHICLE WAS EXPERIENCING THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 137,000.
NHTSA ODI #10641937
312,000 miles · Oct 6, 2014
Electrical System
DURING THE EXTREME COLD PERIOD THIS PAST WINTER, THE HORN PAD ON MY VEHICLE DEVELOPED AN ISSUE WHERE THE HORN STUCK ON DURING THE EARLY HOURS OF THE MORNING. CIRCUIT HAD TO BE DISABLED IN ORDER TO SILENCE THE HORN. THIS IS PART OF THE DRIVER SIDE AIR BAG SYSTEM AND CANNOT BE EASILY, OR INEXPENSIVELY REPAIRED, SO THE VEHICLE IS…
Read full complaint
DURING THE EXTREME COLD PERIOD THIS PAST WINTER, THE HORN PAD ON MY VEHICLE DEVELOPED AN ISSUE WHERE THE HORN STUCK ON DURING THE EARLY HOURS OF THE MORNING. CIRCUIT HAD TO BE DISABLED IN ORDER TO SILENCE THE HORN. THIS IS PART OF THE DRIVER SIDE AIR BAG SYSTEM AND CANNOT BE EASILY, OR INEXPENSIVELY REPAIRED, SO THE VEHICLE IS WITHOUT A WORKING HORN. IN CHECKING FEEDBACK SITES ON THE ALERO, THIS SEEMS TO BE AN COMMON ISSUE WITH AGING ALEROS THAT ARE LEFT OUTSIDE OVERNIGHT IN SUB-FREEZING WEATHER CONDITIONS. *TR
NHTSA ODI #10641832
700 miles · Oct 6, 2014
Electrical System
TL* THE CONTACT OWNS A 2000 OLDSMOBILE ALERO. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE FAILED TO ACCELERATE AND THE STEERING WHEEL SEIZED. THE CONTACT MERGED TO THE SHOULDER OF THE ROAD AND THE VEHICLE STALLED. THE VEHICLE RESTARTED, BUT THE FAILURE RECURRED TWICE. THE DEALER STATED THAT THE ANTI-THEFT MODE SWITCH NEEDED …
Read full complaint
TL* THE CONTACT OWNS A 2000 OLDSMOBILE ALERO. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE FAILED TO ACCELERATE AND THE STEERING WHEEL SEIZED. THE CONTACT MERGED TO THE SHOULDER OF THE ROAD AND THE VEHICLE STALLED. THE VEHICLE RESTARTED, BUT THE FAILURE RECURRED TWICE. THE DEALER STATED THAT THE ANTI-THEFT MODE SWITCH NEEDED TO BE REPLACED. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 700.
NHTSA ODI #10641623
50,000 miles · Oct 2, 2014
Electrical System
TL* THE CONTACT OWNS A 2000 OLDSMOBILE ALERO. WHILE DRIVING VARIOUS SPEEDS, ALL THE WARNING INDICATORS ILLUMINATED. THE CONTACT STATED THAT THE WINDSHIELD WIPERS FAILED TO ACTIVATE AND THE AIR BAG WARNING INDICATOR ILLUMINATED. THE FAILURES OCCURRED ON MULTIPLE OCCASIONS. THE CONTACT REPLACED THE IGNITION SWITCH AND THE VEHICLE …
Read full complaint
TL* THE CONTACT OWNS A 2000 OLDSMOBILE ALERO. WHILE DRIVING VARIOUS SPEEDS, ALL THE WARNING INDICATORS ILLUMINATED. THE CONTACT STATED THAT THE WINDSHIELD WIPERS FAILED TO ACTIVATE AND THE AIR BAG WARNING INDICATOR ILLUMINATED. THE FAILURES OCCURRED ON MULTIPLE OCCASIONS. THE CONTACT REPLACED THE IGNITION SWITCH AND THE VEHICLE WAS REPAIRED. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. UPDATED 11/20/14*CN THE CONSUMER STATED AT VARIOUS TIMES, THE INDICATOR WARNING LIGHTS WOULD NOT COME ON WHEN THE VEHICLE WAS STARTED. UPDATED 01/08/15
NHTSA ODI #10640921
Mileage unknown · Sep 29, 2014
Electrical System
TL* THE CONTACT OWNS A 2000 OLDSMOBILE ALERO. THE CONTACT STATED THAT WHEN SHE ATTEMPTED TO START THE IGNITION, AN ABNORMAL NOISE EMITTED FROM THE IGNITION SWITCH. THE FAILURE OCCURRED MULTIPLE TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V400000 (ELECT…
Read full complaint
TL* THE CONTACT OWNS A 2000 OLDSMOBILE ALERO. THE CONTACT STATED THAT WHEN SHE ATTEMPTED TO START THE IGNITION, AN ABNORMAL NOISE EMITTED FROM THE IGNITION SWITCH. THE FAILURE OCCURRED MULTIPLE TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM); HOWEVER, THE PARTS WERE NOT AVAILABLE FOR THE REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS UNAVAILABLE.
NHTSA ODI #10639900
130,000 miles · Sep 29, 2014
Electrical System
TL* THE CONTACT OWNS A 2000 OLDSMOBILE ALERO. WHILE DRIVING VARIOUS SPEEDS, THE ALARM SYSTEM WOULD INDEPENDENTLY ACTIVATE AND SHUT OFF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING AND THE IGNITION SWITCH, KEY CYLINDER, AND HOUSING WERE REPLACED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER…
Read full complaint
TL* THE CONTACT OWNS A 2000 OLDSMOBILE ALERO. WHILE DRIVING VARIOUS SPEEDS, THE ALARM SYSTEM WOULD INDEPENDENTLY ACTIVATE AND SHUT OFF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING AND THE IGNITION SWITCH, KEY CYLINDER, AND HOUSING WERE REPLACED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14V4000 (ELECTRICAL SYSTEM), BUT THE VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
NHTSA ODI #10639766
200,000 miles · Sep 18, 2014
Electrical SystemSteeringFire
TL* THE CONTACT OWNS A 2000 OLDSMOBILE ALERO. WHILE DRIVING AT AN UNKNOWN SPEED, THE STEERING WHEEL BECAME DIFFICULT TO TURN AND SMOKE EMITTED FROM THE FRONT OF THE VEHICLE. ALL OF THE WARNING INDICATORS ON THE INSTRUMENT PANEL ILLUMINATED AND THE FRONT END OF THE VEHICLE CAUGHT FIRE. THE FIRE WAS EXTINGUISHED AND THERE WERE NO …
Read full complaint
TL* THE CONTACT OWNS A 2000 OLDSMOBILE ALERO. WHILE DRIVING AT AN UNKNOWN SPEED, THE STEERING WHEEL BECAME DIFFICULT TO TURN AND SMOKE EMITTED FROM THE FRONT OF THE VEHICLE. ALL OF THE WARNING INDICATORS ON THE INSTRUMENT PANEL ILLUMINATED AND THE FRONT END OF THE VEHICLE CAUGHT FIRE. THE FIRE WAS EXTINGUISHED AND THERE WERE NO INJURIES. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 200,000.
NHTSA ODI #10637367
145,000 miles · May 14, 2014
Electrical SystemSteering
CAR SHUTS OFF WHILE DRIVING AT ALL SPEEDS. ALL POWER IS LOST (INCLUDING STEERING). SOMETIMES (WHILE DRIVING ON THE HIGHWAY) IT TURNS ITSELF BACK ON AFTER A FEW SECONDS - AND I KEEP ON DRIVING, SOMETIMES I CAN SHIFT TO NEUTRAL AND RESTART AND SHIFT BACK TO DRIVE, BUT USUALLY I HAVE TO TURN MY HAZARD LIGHTS ON AND MUSSEL THE STE…
Read full complaint
CAR SHUTS OFF WHILE DRIVING AT ALL SPEEDS. ALL POWER IS LOST (INCLUDING STEERING). SOMETIMES (WHILE DRIVING ON THE HIGHWAY) IT TURNS ITSELF BACK ON AFTER A FEW SECONDS - AND I KEEP ON DRIVING, SOMETIMES I CAN SHIFT TO NEUTRAL AND RESTART AND SHIFT BACK TO DRIVE, BUT USUALLY I HAVE TO TURN MY HAZARD LIGHTS ON AND MUSSEL THE STEERING WHEEL OFF TO THE SHOULDER AND TRY TO RESTART IT. THEN - THE 'SECURITY' LIGHT IS ON AND IT WON'T LET ME START THE CAR. I'VE FOUND COUNTLESS POSTS ONLINE ABOUT THIS PROBLEM. I CAN'T BELIEVE THERE ISN'T A RECALL. ISN'T GM BEING SUED FOR A VERY SIMILAR PROBLEM? *TR
NHTSA ODI #10588450
118,000 miles · May 7, 2013
Electrical SystemElectronic Stability Control (esc)Engine
THE ENTIRE CLUSTER SYSTEM WENT OUT,$2200.00 REPLACEMENT,THE ENTIRE DASH IS COMING DOWN WITH A COST OF $1000.00 DOLLARS FOR REPLACEMENT,VALVE COVER GASKET NEEDS REPLACED WITH COST OF $1200.00 COST TO CONSUMER,THE BRAKES HAVE BEEN REWORKED FOR 300.00 DOLLARS AT A COST TO CONSUMER,ACTUAL MILEAGE 43000- NOW PROBLEMS STARTED AT 90,00…
Read full complaint
THE ENTIRE CLUSTER SYSTEM WENT OUT,$2200.00 REPLACEMENT,THE ENTIRE DASH IS COMING DOWN WITH A COST OF $1000.00 DOLLARS FOR REPLACEMENT,VALVE COVER GASKET NEEDS REPLACED WITH COST OF $1200.00 COST TO CONSUMER,THE BRAKES HAVE BEEN REWORKED FOR 300.00 DOLLARS AT A COST TO CONSUMER,ACTUAL MILEAGE 43000- NOW PROBLEMS STARTED AT 90,000 MILES,THE CAR CONSTANTLY LEAKS IN THE AUTO WHEN IT RAINS,I FEEL AS A CONSUMER THIS VEHICLE SHOULD BE RECALLED BECAUSE I'VE HAD NOTHING BUT PROBLEMS SINCE THE DAY OF PURCHASE,LOST WAGES BEING STUCK ON THE SIDE OF THE ROAD,PAIN AND SUFFERING BECAUSE I ONLY LIVE ON DISABILITY,AND A PART TIME JOB,AND IT TOOK IT ALL FOR REPAIRS!!!!! *TR
NHTSA ODI #10511021
164,000 miles · Apr 5, 2013
Electrical System
VERY COMMON PROBLEM IN ALL GM MAKES AND MODELS WITH THIS TYPE OF SECURITY SYSTEM. *TR
NHTSA ODI #10507298
Official recalls
4Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Nov 13, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSAXLES (RPO M86) FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." WHEN A DRIVER ATTEMPTS TO SHIFT FROM 5TH GEAR TO REVERSE, A SHIFT INHIBITOR CAUSES THE TRANSMISSION TO BE MECHANICALLY IN 4TH GEAR EVEN THOUGH THE SHIFT LEVER INDICATES REVERSE GEAR.
Consequence & remedy
Consequence: IN THIS SITUATION, THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE TRANSMISSION IS IN A FORWARD GEAR, WHICH IS NOT PERMITTED BY THE STANDARD.
Remedy: DEALERS WILL DISABLE THE 5TH/REVERSE INHIBITOR BY REMOVING A RETAINING PIN AND REPLACE THE SHIFTER ASSEMBLY.
May 18, 2000
VEHICLE DESCRIPTION: THESE VEHICLES DO NOT COMPLY WITH THE OCCUPANT PROTECTION REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE CONSOLE COVER ON THESE VEHICLES DOES NOT STAY CLOSED WHEN A SPECIFIED VERTICAL LOAD IS APPLIED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CONSOLE COVER COULD OPEN AND THE COVER OR ITEMS STORED UNDER IT COULD INJURE AN OCCUPANT.
Remedy: DEALERS WILL REPLACE THE CONSOLE LATCH MECHANISM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5RQ04005 · Turn Signal Failures
Opened Jun 18, 2004 · Closed Nov 30, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE02066 · Engine Stall Due To Fuel Starvation
Opened Sep 6, 2002 · Closed Nov 3, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other; Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Gasoline
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration