IllustrationTHE DRIVERS DOOR HANDLE IS COMING OFF..
2011 Nissan Versa
Owner reports · Recalls · Investigations
More warning signs than most Versa years
Owner complaints for the 2011 Nissan Versa are substantially higher than the model-year median of 95.
About this comparison →How this year compares
Owner complaints by model year
Compare all Versa years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
230–25K
2525–50K
4250–75K
2375–100K
22100–150K
11150K+
146 reports with mileage · 123 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 152 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
19 crash reports6 fire reports15 injury reports
What owners actually said
269 reportsTHE HATCH BACK DOOR DOESN'T OPEN EVEN FROM THE INSIDE. I ONLY HEARD THE ELECTRIC MOTOR OR THE ACTUATOR BUT I'M UNABLE TO OPEN THE REAR DOOR.
TL* THE CONTACT OWNS A 2011 NISSAN VERSA. THE CONTACT STATED THAT AT VEHICLE STARTUP, THE PASSENGER AIR BAG WARNING LIGHT ILLUMINATED AND REMAINED ILLUMINATED. THE VEHICLE WAS TOWED TO BILL SEIDLE'S NISSAN 10500 NW 12TH ST, MIAMI, FL 33172 WHERE THE VEHICLE WAS DIAGNOSED WITH AN AIR BAG SENSOR FAILURE. THE CONTACT WAS GIVEN AN E…
Read full complaint
TL* THE CONTACT OWNS A 2011 NISSAN VERSA. THE CONTACT STATED THAT AT VEHICLE STARTUP, THE PASSENGER AIR BAG WARNING LIGHT ILLUMINATED AND REMAINED ILLUMINATED. THE VEHICLE WAS TOWED TO BILL SEIDLE'S NISSAN 10500 NW 12TH ST, MIAMI, FL 33172 WHERE THE VEHICLE WAS DIAGNOSED WITH AN AIR BAG SENSOR FAILURE. THE CONTACT WAS GIVEN AN ESTIMATE OF $450.00 FOR REPAIRS. THE VEHICLE WAS THEN TOWED TO AUTONATION NISSAN MIAMI 3345 SW 8TH ST, MIAMI, FL 33135 WHERE THE VEHICLE WAS DIAGNOSED WITH A DEFECTIVE CLOCK SPRING AND AIR BAG SENSOR. AN ESTIMATE OF $1,155.00 WAS PROVIDED FOR THE REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED HER THAT THEY WOULD COVER 60% OF THE REPAIR. UPON INVESTIGATION, THE CONTACT HAD LINKED NHTSA CAMPAIGN NUMBER: 20V008000(AIR BAGS) WITH HER FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 57,000.
AIRBAG INDICATOR LIGHT ON DASHBOARD. BEGAN FLASHING AT TIME OF FIRST RECALL IN REGARD TO AIR BAGS. WHEN BROUGHT IN TO NISSAN FOR AIRBAG RECALL THEY SAID IT WAS NOT RELATED.
NISSAN VEHICLE WAS ON A MAIN CITY ROAD IN MOTION AND THEN SLOWING DOWN TO TRAFFICS CHANGE IN SPEED WHEN REAR ENDED. AS SOON AS VEHICLE WAS REAR ENDED, BRAKES WERE PRESSED TO PREVENT FURTHER COLLISIONS WITH VEHICLES UP FORWARD. MY VEHICLE SEATBELTS FAILED TO RESTRAIN DRIVER AND ALL PASSENGERS WEARING THEM DURING A COLLISION. SEAT…
Read full complaint
NISSAN VEHICLE WAS ON A MAIN CITY ROAD IN MOTION AND THEN SLOWING DOWN TO TRAFFICS CHANGE IN SPEED WHEN REAR ENDED. AS SOON AS VEHICLE WAS REAR ENDED, BRAKES WERE PRESSED TO PREVENT FURTHER COLLISIONS WITH VEHICLES UP FORWARD. MY VEHICLE SEATBELTS FAILED TO RESTRAIN DRIVER AND ALL PASSENGERS WEARING THEM DURING A COLLISION. SEAT BELTS DIDN'T RETRACT UNLESS BRAKES WERE SLAMMED. TWO PASSENGERS IN THE BACK WERE CHILDREN. ONE CHILD HAD A CONVERTIBLE CAR SEAT, SAVING THEM AND FULLY RESTRAINING THEM TO SEAT. THE SECOND CHILD WAS IN A BOOSTER SEAT AND WHIPLASHED COMPLETELY FORWARD AND BACK NEARLY HITTING HEAD BEHIND DRIVERS SEAT. THE DRIVER LOCKED THEIR ARMS IN PLACE TO PREVENT HITTING THE STEERING WHEEL. THE FRONT PASSENGER, MYSELF, HIT THE AREA OF THE GLOVE COMPARTMENT AND SUFFERED A SMALL BUT DEEP GASH ON THE FOREHEAD. THIS REQUIRED SUTURES TO CLOSE WOMB UP. NO AIR BAGS DEPLOYED WHEN IMPACT TO VEHICLE WAS MADE. AIRBAGS WERE REPLACED WHEN RECALL TO VEHICLE AIRBAGS WERE MADE IN THE PAST, 2017.*DT VEHICLE HAS NOT BEEN REPAIRED. TRACKING NUMBER XXXXXXXX 'PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB
I TOOK MY CAR IN TO NISSAN FOR RECALL THEY SUPOSEIVELY FIXED THE AIRBAG PROBLEM . SINCE THEN I HAS A SMALL FENDER BENDER. AIRBAG DID NOT POP OPEN. LAST WEEK THE CAR WAS IN AN ACCIDENT. THE FRONT WAS SEVERLY DANMAGED AND STILL AIRBAG DID NOT POP OUT. I DONT THINK IT EVER GOT FIXED!!!! MY SON COULD HAVE DIED.WHO IS RESPONSIBLE F…
Read full complaint
I TOOK MY CAR IN TO NISSAN FOR RECALL THEY SUPOSEIVELY FIXED THE AIRBAG PROBLEM . SINCE THEN I HAS A SMALL FENDER BENDER. AIRBAG DID NOT POP OPEN. LAST WEEK THE CAR WAS IN AN ACCIDENT. THE FRONT WAS SEVERLY DANMAGED AND STILL AIRBAG DID NOT POP OUT. I DONT THINK IT EVER GOT FIXED!!!! MY SON COULD HAVE DIED.WHO IS RESPONSIBLE FOR THIS. I'M I COMPLAINING TO THE CORRECT PLACE???
I TOOK MY CAR TO A LOCAL NISSAN DEALERSHIP FOR AN AIRBAG RECALL ON THE DRIVER SIDE AND AFTER THE RECALL WAS SUPPOSEDLY DONE BECAUSE AFTER THIS I'M NOT EVEN POSITIVE THEY WORKED ON MY CAR FOR THAT RECALL. AFTER THE RECALL WAS DONE NOW THE CAR HORN IN MY STEERING WHEEL IS NOT WORKING WHEN IT WAS WORKING BEFORE. THE NISSAN ADVISOR …
Read full complaint
I TOOK MY CAR TO A LOCAL NISSAN DEALERSHIP FOR AN AIRBAG RECALL ON THE DRIVER SIDE AND AFTER THE RECALL WAS SUPPOSEDLY DONE BECAUSE AFTER THIS I'M NOT EVEN POSITIVE THEY WORKED ON MY CAR FOR THAT RECALL. AFTER THE RECALL WAS DONE NOW THE CAR HORN IN MY STEERING WHEEL IS NOT WORKING WHEN IT WAS WORKING BEFORE. THE NISSAN ADVISOR SAID THAT THEY CAN'T FIX IT AND THE REASON IS BECAUSE IS AN OLD CAR. THEY WANT ME TO PAY ALMOST 700 HUNDRED DOLLARS FOR THEM TO FIX WHAT THEY RUINED. NOW I HAVE NO CAR HORN. THIS IS A SAFETY HAZARD FOR ANYONE ON THE ROAD. A CAR HORN WORKS TO ADVICE OTHER DRIVERS OF ANY HAZARD. FROM THIS HAPPENING TO ME I NOW THINK THAT THEY DIDN'T DO ANYTHING IN REGARDS TO AIRBAG RECALLS AND THAT I JUST TOOK MY CAR JUST FOR THEM TO SCAM ME SO I CAN PAY FOR A PART THAT WAS WORKING AND THAT THEY RUINED. THE NISSAN I WENT TOO IS NAPLES NISSAN IN NAPLES, FLORIDA. I ALSO HAVE CALLED NISSAN CONSUMER AFFAIRS AND THEY HAVEN'T DONE ANYTHING IN THIS MATTER I HAVE TWO CLAIM NUMBERS ALREADY I HAVE CALLED TWICE AND THERE NOT DOING ANYTHING ABOUT THIS MATTER.
BALL JOINTS NEED TO BE REPLACED. IS THIS NORMAL AFTER ONLY 9 YEARS AND 85,OOOMILES ?
AFTER 1 YEAR AND 1/2, MUFFLER HAS RATTLING SOUND, HAS A HOLE AND IS BURNT BLACK AT END OF TAIL PIPE. SAME PROBLEM AFTER MUFFLER HAS BEEN CHANGED IN THE SAME AMOUNT OF TIME. MUFFLER SEEMS TO RUST AND OVERHEAT/BURN.
THE VIN FOR MY 2011 NISSAN VERSA [XXX] IS NOT AVAILABLE IN YOUR DATABASE, OR IN THE NISSAN DATABASE YOU REFERRED ME TO. I HAVE CHECKED IT THREE TIMES. IT IS CORRECT. SO I HAVE NO WAY OF IDENTIFYING ANY RECALLS NEEDED. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Official recalls
620V008000 · Air Bags:frontal:passenger Side:inflator Module
Jan 9, 2020
Nissan North America, Inc. (Nissan) is recalling certain 2001-2003 Maxima, 2002-2006 Sentra, 2002-2004 Pathfinder, 2007-2011 Versa Sedan and Versa Hatchback, 2001-2004 Infiniti I30 and I35, 2002-2003 Inifiniti QX4, 2003-2008 Infiniti FX35 and FX45 and 2006-2010 M35 and M45 vehicles. The vehicles are equipped with non-desiccated, frontal passenger air bag inflators containing phase stabilized ammonium nitrate (PSAN) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the front passenger air bag inflators with alternate desiccated inflators, free of charge. The recall began February 12, 2020. Owners may contact Nissan customer service at 888-737-9511 or Infiniti customer service at 888-810-3715.
18V401000 · Air Bags:frontal:passenger Side:inflator Module
Jun 15, 2018
Nissan North America, Inc. (Nissan) is recalling certain 2011 Nissan Versa sedan vehicles and 2011-2012 Nissan Versa hatchback vehicles ever registered in the states of Arizona, Arkansas, Delaware, the District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia. Nissan is also recalling 2010-2011 Nissan Versa sedan vehicles and 2010-2012 Nissan Versa hatchback vehicles ever registered in the states of ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflator may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the front passenger air bag inflator with an alternate inflator, free of charge. The recall began July 5, 2018. Owners may contact Nissan customer service at 1-800-867-7669.
18V044000 · Air Bags:frontal:passenger Side:inflator Module
Jan 10, 2018
Nissan North America, Inc. (Nissan) is recalling certain 2009-2012 Versa Hatchback, and 2009-2011 Versa Sedan vehicles ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Nissan is recalling certain 2009-2010 Versa Hatchback, and Versa Sedan vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Nissan is also recalling certain 2009 Versa Hatchback and Versa Sedan vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflator may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began March 9, 2018. Owners may contact Nissan customer service at 1-800-647-7261.
17V449000 · Air Bags:frontal:driver Side:inflator Module
Jul 17, 2017
Nissan North America, Inc. (Nissan) is recalling certain 2007-2011 Versa Sedan and 2007-2012 Versa Hatchback vehicles. The affected vehicles have a driver frontal air bag inflator that may rupture due to propellant degradation occurring after long-term exposure to moderate absolute humidity, temperatures, and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the subject inflator with a new one manufactured by a different supplier, free of charge. The recall began on March 9, 2018. Owners may contact Nissan customer service at 1-800-647-7261.
16V349000 · Air Bags:frontal:passenger Side:inflator Module
May 24, 2016
Nissan North America, Inc. (Nissan) is recalling certain model year 2003-2008 Infiniti FX35 and FX45, 2003-2004 Infiniti I35, 2006-2010 Infiniti M35 and M45, and 2007-2011 Nissan Versa vehicles, originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Nissan is recalling certain model year 2005-2008 Infiniti FX35 and FX45, 2003-2004 Infiniti I35, 2006-2008 Infiniti M35 and M45, and 2007-2008 Nissan Versa vehicles, originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Nissan is recalling certain model year 2003-2004 Infiniti I35 vehicles originally sold, or registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began December 21, 2017. All owners should receive a second notice by May 15, 2017. Owners may contact Nissan customer service at 1-800-647-7261.
15V573000 · Suspension:front:springs:coil Springs
Sep 14, 2015
Nissan (Nissan North America, Inc.) is recalling certain model year 2007-2012 Nissan Versa vehicles manufactured May 8, 2006, to November 12, 2012, that were sold or ever registered in the District of Columbia, Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky, Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia and Wisconsin. Road salt may corrode the front coil springs, possibly resulting in the coil springs fracturing.
Consequence & remedy
Consequence: If a front coil spring fractures, it may contact the tire, possibly puncturing it, increasing the risk of a crash.
Remedy: Nissan will notify owners, and dealers will replace both front coil springs, free of charge. The recall began on February 2, 2016. Owners may contact Nissan customer service at 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
PE15019 · Front Coil Spring Fracture
Opened May 13, 2015 · Closed Oct 2, 2015
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
In a letter dated September 10,2015, Nissan North America,Inc. (Nissan) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in coil spring fracture in approximately 218,019 model year (MY) 2007 through 2012 Nissan Versa vehiclesproduced from May 8, 2006 through November12, 2012 and originally sold or ever registered in the following 22 states and the District of Columbia: Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington D.C., West Virginia and Wisconsin (NHTSA Recall 15V-573).Nissan indicated that the recalled vehicles may contain front coil springs that received inadequate phosphorous coating, have low residual stress, or a combination of both.Surface imperfections resulting from coil-to-coil contact when the spring is compressed may lead to crack initiation.Exposure of the surface imperfections to road salts, in regions with heavy use of road salts for snow and ice control, may promote crack propagation in the spring that could result in spring fracture.If the coil spring fractures it may puncture the front tire and possibly the brake line while driving, which may increase the risk of a vehicle crash.ODI's analysis of complaints it has received from the public (VOQ's) and Nissan complaint data submitted in response to the information request letter for PE15-019 identified a total of 468 non-duplicative reports alleging coil spring fractures in the subject vehicles, including 142 VOQ's and 367 Nissan complaints (41 of the incidents reported to ODI were also reported to Nissan).While the recall region accounts for approximately 43 percent of vehicle sales, the analysis found that 94 percent of the complaints involved vehicles sold or operated in those states.Approximately 27 percent of the VOQ's reporting coil spring failures in the recalled states indicated that the failure resulted in a punctured tire.ODI also identified one complaint that alleged brake line damage from a failed spring.Nissan's recall will replace both coil springs free of charge.Based on Nissan's safety recall, this investigation is closed.The 142 VOQ's referenced in this resume are: 10236143, 10405369, 10443746, 10452956, 10491553, 10497737, 10503060, 10504557, 10512390, 10512975, 10514582, 10516024, 10516085, 10521216, 10522261, 10526334, 10533856, 10537404, 10537407, 10548678, 10552124, 10559853, 10562485, 10565283, 10572591, 10578519, 10583059, 10583154, 10583496, 10583673, 10584979, 10585327, 10585377, 10585751, 10586397, 10586444, 10587798, 10588347, 10588427, 10592366, 10592498, 10592780, 10593373, 10593621, 10595215, 10596802, 10598404, 10598877, 10606859, 10606998, 10610082, 10618059, 10640845, 10644269, 10645075, 10649515, 10653189, 10659632, 10662158, 10663102, 10667071, 10667845, 10669949, 10670829, 10671894, 10676522, 10680544, 10680740, 10682397, 10691419, 10692629, 10693347, 10694156, 10694420, 10701250, 10702765, 10703126, 10704658, 10705882, 10706351, 10711805, 10712045, 10712922, 10714243, 10715041, 10715175, 10716106, 10717254, 10717320, 10717403, 10717412, 10717489, 10717563, 10720958, 10721782, 10721824, 10722113, 10722459, 10722915, 10723873, 10723972, 10723973, 10724158, 10724899, 10725002, 10725328, 10725377, 10725542, 10726251, 10726736, 10726741, 10730138, 10730154, 10730342, 10731050, 10731692, 10731799, 10731901, 10732054, 10732062, 10733059, 10733144, 10733309, 10733349, 10733607, 10733781, 10733854, 10735347, 10735353, 10735606, 10736199, 10736227, 10743474, 10743634, 10743790, 10744