← New search

2009 Nissan Versa

Owner reports · Recalls · Investigations

More warning signs than most Versa years

Owner complaints for the 2009 Nissan Versa are substantially higher than the model-year median of 95.

About this comparison →

When problems were reported

Mileage at the reported incident

348 reports with mileage · 155 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Suspension. Review the 182 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Air Bags. Review the 179 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Steering. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

27 crash reports2 fire reports15 injury reports

What owners actually said

503 reports
2,800 miles · Nov 18, 2009
Power Train

AT ABOUT 2800 MILES I TOOK THE CAR TO THE NISSAN DEALER FOR THE FIRST OIL CHANGE. THEY INFORMED ME UPON INSPECTION THEY FOUND A CV BOOT WAS NOT SEALED PROPERLY. THEY ADVISED THEY WOULD ORDER AND REPLACE ENTIRE CONSTANT VELOCITY JOINT ASSEMBLY. PART CAME IN 2 DAYS LATER DEALER FIXED-NO PROBLEM. *TR

NHTSA ODI #10292692

7,306 miles · Oct 23, 2009
Fuel System, Other

WHEN I FIRST PURCHASED MY NEW 09 NISSAN VERSA I HAD A START UP ISSUE AND THEN IT WENT AWAY, NOW APPROX ONE YEAR LATER AFTER PURCHASE I HAD START UP ISSUES...TOOK IT TO DEALERSHIP AND THEY PUT IN A FUEL PUMP REGULATOR, FROM WHAT I'M HEARING THIS IS A VERY KNOWN PROBLEM. THOUGHT I WOULD ADVISE YOU SINCE I ALSO HEARD SOME PEOPLE AR…

Read full complaint

WHEN I FIRST PURCHASED MY NEW 09 NISSAN VERSA I HAD A START UP ISSUE AND THEN IT WENT AWAY, NOW APPROX ONE YEAR LATER AFTER PURCHASE I HAD START UP ISSUES...TOOK IT TO DEALERSHIP AND THEY PUT IN A FUEL PUMP REGULATOR, FROM WHAT I'M HEARING THIS IS A VERY KNOWN PROBLEM. THOUGHT I WOULD ADVISE YOU SINCE I ALSO HEARD SOME PEOPLE ARE HAVING TO REPLACE THIS OFTEN AND SOME ARE LOSING POWER WHEN DRIVING THERE CARS ON HIGHWAYS...I HOPE THIS NEVER HAPPENS FOR ME SINCE I HAVE TO KIDS!!!! *TR

NHTSA ODI #10289502

2,536 miles · Oct 18, 2009
Suspension

2009 NISSAN VERSA HATCHBACK LESS THAN A MONTH THE ALIGNMENT NEEDED FIXING THE CAR PULLS TO BOTH SIDES. THE BEGINNING IT GOES TO THE LEFT THEN PUTTING THE CAR BACK STRAIGHT IT GOES TO THE RIGHT. IT GETS WORSE WHEN THE CAR GOES OVER 40 MILES PER HOUR. *TR

NHTSA ODI #10288851

500 miles · Sep 26, 2009
Tires

I JUST BOUGHT A 2009 NISSAN VERSA. WHILE DRIVING ON A WET ROAD AND TAKING A CORNER THE CAR LOST TRACTION FORCING ME TO SLOW DOWN TO ALMOST A HALT. THE STOCK TIRES (185/65R15) SEEM TO BE UNDERSIZED FOR THE HIGH CENTER OF GRAVITY. *TR

NHTSA ODI #10285325

Mileage unknown · Aug 26, 2009
Air BagsCrashInjury

CONSUMER STATES THE RENTAL CAR (2009 NISSAN VERSA) AIR BAG DID NOT FULLY DEPLOY DURING AN ACCIDENT AND THAT SHE RECEIVED A BURN ON HER ARM. *NJ

NHTSA ODI #10282152

Mileage unknown · Jul 31, 2009
Visibility

I OWN A 2009 NISSAN VERSA. THE WINDOW WIPERS ARE DESIGNED SUCH THAT THE DRIVER'S SIDE WIPER BLADE IS '2X' THE PASSENGER BLADE. WHEN USING THE WIPERS (RAIN OR CLEANING THE WINDOWS) THE DRIVER'S SIDE BLADE THROWS WATER ON TO THE PASSENGER SIDE AND AS THE PASSENGER SIDE BLADE HAS ALREADY COMPLETED ITS SWING THUS THE PASSENGER SI…

Read full complaint

I OWN A 2009 NISSAN VERSA. THE WINDOW WIPERS ARE DESIGNED SUCH THAT THE DRIVER'S SIDE WIPER BLADE IS '2X' THE PASSENGER BLADE. WHEN USING THE WIPERS (RAIN OR CLEANING THE WINDOWS) THE DRIVER'S SIDE BLADE THROWS WATER ON TO THE PASSENGER SIDE AND AS THE PASSENGER SIDE BLADE HAS ALREADY COMPLETED ITS SWING THUS THE PASSENGER SIDE WINDOW IN NEVER CLEAR OF WATER, WHEN DRIVING THE WATER BUILDS UP ON THE PASSENGER SIDE FASTER THAN THE WIPER CAN CLEAN IT DUE TO THE EXTRA WATER FROM THE DRIVER'S SIDE WIPER (FOR ME THIS IS RIGHT IN MY FIELD OF VISION). THIS CAUSES A PROBLEM BECAUSE I CAN NOT SEE TRAFFIC COMING OUT OF THE SIDE STREET ON THE RIGHT. WHEN YOU CLEAN THE WINDOW THE ONLY WAY TO CLEAN THE PASSENGER SIDE IS TO RUN THE WIPERS DRY AFTER YOU ARE DONE TO FINISH THE PASSENGER'S SIDE. I BROUGHT THIS UP TO THE DEALER AND THE NISSAN DISTRICT MANAGER CHARLES RICE; HIS COMMENT WAS THIS IS HOW IT IS DESIGNED. TO ME THIS IS AN UNSAFE DESIGN, YOU NEED TO BE ABLE TO SEE OUT THE PASSENGER SIDE OF THE CAR WHEN IT IS RAINING. *TR

NHTSA ODI #10278990

4,000 miles · Jun 18, 2009
Engine And Engine Cooling

THE CAR WONT START HALF OF THE TIME. ITS TAKES TWO TIMES TO START THE CAR. USUALLY THE CAR CRANKS FOR ABOUT 10 SECONDS BEFORE IT WILL START. IT HAS BEEN THIS WAY FOR ABOUT 10 DAYS. *TR

NHTSA ODI #10274223

10,000 miles · May 31, 2009
Engine And Engine Cooling

I HAVE A 2009 NISSAN VERSA THAT HAS A LITTLE OVER 11,000 MILES ON IT. I HAVE STARTED EXPERIENCING A PROBLEM WITH IT NOT WANTING TO START THE FIRST TIME ALONG WITH IT DYING AT RANDOM TIMES WHILE DRIVING. MAJOR SAFETY ISSUE FOR ME AND MY FAMILY. I HAVE ALREADY HAD IT TO VICTORY NISSAN IN KNOXVILLE, TN THREE TIMES AND I'M TAKING B…

Read full complaint

I HAVE A 2009 NISSAN VERSA THAT HAS A LITTLE OVER 11,000 MILES ON IT. I HAVE STARTED EXPERIENCING A PROBLEM WITH IT NOT WANTING TO START THE FIRST TIME ALONG WITH IT DYING AT RANDOM TIMES WHILE DRIVING. MAJOR SAFETY ISSUE FOR ME AND MY FAMILY. I HAVE ALREADY HAD IT TO VICTORY NISSAN IN KNOXVILLE, TN THREE TIMES AND I'M TAKING BACK AGAIN FOR THE FOURTH TOMORROW AND THEY ARE STILL ADVISING NOTHING IS WRONG WITH THE CAR. I HAD THE FUEL PRESSURE REGULATOR REPLACED, BUT THE CAR IS STILL NOT RUNNING PROPERLY. IT RECENTLY DIED IN MY APARTMENT COMPLEX AND WOULD NOT START BACK AND I HAD TO HAVE SOME INDIVIDUALS HELP PUSH IT INTO A PARKING SPOT. I HAVE HAD THE VEHICLE STOP IN TRAFFIC ON THE INTERSTATE AND ALSO ON OTHER STREETS, WHICH POSES A CONCERN FOR ME BEING ON THE HIGHWAY DRIVING THIS VEHICLE. I WOULD LIKE TO KNOW HOW TO RESOLVE THIS ISSUE OR IF NISSAN WILL DO A BUY BACK OF THIS DEFECTIVE VEHICLE I HAVE PURCHASED. *TR

NHTSA ODI #10272455

5,000 miles · Mar 14, 2009
Fuel System, Gasoline

I OWN A 2009 VERSA WITH 5120 MILES. RECENTLY IT HAS DEVELOPED A PROBLEM THAT CAUSES IT TO HAVE A SUBSTANTIAL DELAY IN STARTING. IT IS INTERMITTENT DURING THE DAY BUT HAPPENS AT LEAST ONCE DAILY. I PLAN TO HAVE THE VEHICLE SERVICED FOR THIS PROBLEM SHORTLY, BUT WANTED TO REGISTER THIS PROBLEM AS IT HAS ALREADY HAPPENED TO AT LEA…

Read full complaint

I OWN A 2009 VERSA WITH 5120 MILES. RECENTLY IT HAS DEVELOPED A PROBLEM THAT CAUSES IT TO HAVE A SUBSTANTIAL DELAY IN STARTING. IT IS INTERMITTENT DURING THE DAY BUT HAPPENS AT LEAST ONCE DAILY. I PLAN TO HAVE THE VEHICLE SERVICED FOR THIS PROBLEM SHORTLY, BUT WANTED TO REGISTER THIS PROBLEM AS IT HAS ALREADY HAPPENED TO AT LEAST ONE OTHER COMPLAINANT. *TR

NHTSA ODI #10261826

7,000 miles · Dec 26, 2008
Service Brakes, Hydraulic

THE BRAKES HAVE BEEN NON-RESPONSIVE THREE TIMES ON MY 2009 NISSAN VERSA. WHEN DEPRESSING THE BRAKES - THERE IS NO RESPONSE. FORTUNATELY, WHEN DEPRESSING THE BRAKES A SECOND TIME THEY RESPOND. THE FIRST TWO TIMES WERE AT SPEEDS BELOW 20MPH. TODAY THE 26TH OF DEC. 2008 THE BRAKES WERE NON-RESPONSIVE (FIRST PUSH) AT 50 MPH. ON SEC…

Read full complaint

THE BRAKES HAVE BEEN NON-RESPONSIVE THREE TIMES ON MY 2009 NISSAN VERSA. WHEN DEPRESSING THE BRAKES - THERE IS NO RESPONSE. FORTUNATELY, WHEN DEPRESSING THE BRAKES A SECOND TIME THEY RESPOND. THE FIRST TWO TIMES WERE AT SPEEDS BELOW 20MPH. TODAY THE 26TH OF DEC. 2008 THE BRAKES WERE NON-RESPONSIVE (FIRST PUSH) AT 50 MPH. ON SECOND PUSH THE CAR SWERVED FIRST LEFT THEN RIGHT - I TOOK MY FOOT OFF THE BRAKE AND ON THE THIRD PUSH THE CAR BRAKED AS EXPECTED. HAVING BRAKES BE NON-RESPONSIVE AT ANY TIME IS OBVIOUSLY A PROBLEM. I MADE THE DEALER AWARE OF THE FAILURE WHEN IT OCCURRED THE 2ND TIME ON 12/13/08 - THE DEALER BRUCE BENNETT NISSAN OF WILTON CT 203.544.8371 REVIEWED THE CAR (KEEPING IT OVERNIGHT) ON 12/16/08. THEY DETERMINED THAT NOTHING WAS WRONG WITH THE BRAKES. TODAY ON 12/26/08 I LEFT A MESSAGE ON THE SERVICE LINE AS IT HAS NOW HAPPENED A 3RD TIME - BUT I WAS GOING FASTER AND THE CAR SWERVED SEVERELY WHEN THE BRAKES WERE USED ON THE SECOND PUSH. HOPEFULLY I WILL HERE FROM THEM TOMORROW. I ALSO CALLED NISSAN CUSTOMER SERVICE - HOWEVER THEY APPEAR TO BE CLOSED. *TR

NHTSA ODI #10252862

Official recalls

7

20V008000 · Air Bags:frontal:passenger Side:inflator Module

Jan 9, 2020

Nissan North America, Inc. (Nissan) is recalling certain 2001-2003 Maxima, 2002-2006 Sentra, 2002-2004 Pathfinder, 2007-2011 Versa Sedan and Versa Hatchback, 2001-2004 Infiniti I30 and I35, 2002-2003 Inifiniti QX4, 2003-2008 Infiniti FX35 and FX45 and 2006-2010 M35 and M45 vehicles. The vehicles are equipped with non-desiccated, frontal passenger air bag inflators containing phase stabilized ammonium nitrate (PSAN) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Nissan will notify owners, and dealers will replace the front passenger air bag inflators with alternate desiccated inflators, free of charge. The recall began February 12, 2020. Owners may contact Nissan customer service at 888-737-9511 or Infiniti customer service at 888-810-3715.

18V044000 · Air Bags:frontal:passenger Side:inflator Module

Jan 10, 2018

Nissan North America, Inc. (Nissan) is recalling certain 2009-2012 Versa Hatchback, and 2009-2011 Versa Sedan vehicles ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Nissan is recalling certain 2009-2010 Versa Hatchback, and Versa Sedan vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Nissan is also recalling certain 2009 Versa Hatchback and Versa Sedan vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflator may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Nissan will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began March 9, 2018. Owners may contact Nissan customer service at 1-800-647-7261.

17V449000 · Air Bags:frontal:driver Side:inflator Module

Jul 17, 2017

Nissan North America, Inc. (Nissan) is recalling certain 2007-2011 Versa Sedan and 2007-2012 Versa Hatchback vehicles. The affected vehicles have a driver frontal air bag inflator that may rupture due to propellant degradation occurring after long-term exposure to moderate absolute humidity, temperatures, and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Nissan will notify owners, and dealers will replace the subject inflator with a new one manufactured by a different supplier, free of charge. The recall began on March 9, 2018. Owners may contact Nissan customer service at 1-800-647-7261.

17V028000 · Air Bags:frontal:passenger Side:inflator Module

Jan 10, 2017

Nissan North America, Inc. (Nissan) is recalling certain 2012 Nissan Versa hatchbacks originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan) and the U.S. Virgin Islands, or "Zone A". Additionally, if not included in "Zone A" above, Nissan is recalling certain 2009-2010 Infiniti M35 and M45 and 2009 Nissan Versa sedans and hatchbacks originally sold, or ever registered, in Arizona, Arkansas, Delaware, the District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B". Additionally, if not included in "Zone A" or "Zone B" above, Nissan is recalling certain 2005-2008 Infiniti FX35 and FX45, 2006-2010 Infiniti M35 and M45, and 2007-2008 Nissan Versa vehicles originally sold, or ever registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Nissan will notify owners, and dealers will replace the front passenger air bag inflators, free of charge. The recall began on June 8, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Nissan customer service at 1-800-647-7261.

16V349000 · Air Bags:frontal:passenger Side:inflator Module

May 24, 2016

Nissan North America, Inc. (Nissan) is recalling certain model year 2003-2008 Infiniti FX35 and FX45, 2003-2004 Infiniti I35, 2006-2010 Infiniti M35 and M45, and 2007-2011 Nissan Versa vehicles, originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Nissan is recalling certain model year 2005-2008 Infiniti FX35 and FX45, 2003-2004 Infiniti I35, 2006-2008 Infiniti M35 and M45, and 2007-2008 Nissan Versa vehicles, originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Nissan is recalling certain model year 2003-2004 Infiniti I35 vehicles originally sold, or registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Nissan will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began December 21, 2017. All owners should receive a second notice by May 15, 2017. Owners may contact Nissan customer service at 1-800-647-7261.

15V573000 · Suspension:front:springs:coil Springs

Sep 14, 2015

Nissan (Nissan North America, Inc.) is recalling certain model year 2007-2012 Nissan Versa vehicles manufactured May 8, 2006, to November 12, 2012, that were sold or ever registered in the District of Columbia, Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky, Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia and Wisconsin. Road salt may corrode the front coil springs, possibly resulting in the coil springs fracturing.

Consequence & remedy

Consequence: If a front coil spring fractures, it may contact the tire, possibly puncturing it, increasing the risk of a crash.

Remedy: Nissan will notify owners, and dealers will replace both front coil springs, free of charge. The recall began on February 2, 2016. Owners may contact Nissan customer service at 1-800-647-7261.

10V401000 · Equipment:electrical:navigational System(global Positioning System)

Sep 10, 2010

NISSAN IS RECALLING CERTAIN VEHICLES THAT WERE EQUIPPED WITH A GARMIN NUVI MODEL 750 NAVIGATION SYSTEM. THE BATTERIES CONTAINED IN THE AFFECTED GPS UNITS CAN OVERHEAT.

Consequence & remedy

Consequence: OVERHEATED BATTERIES COULD RESULT IN A FIRE.

Remedy: NISSAN WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY GARMIN TECHNICIANS BY REPLACING THE BATTERY AND INSERTING A SPACER ON TOP OF THE BATTERY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2010. OWNERS MAY CONTACT GARMIN DIRECTLY AT 1-866-957-1981 OR NISSAN AT 1-800-647-7261.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

PE15019 · Front Coil Spring Fracture

Opened May 13, 2015 · Closed Oct 2, 2015

Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs

In a letter dated September 10,2015, Nissan North America,Inc. (Nissan) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in coil spring fracture in approximately 218,019 model year (MY) 2007 through 2012 Nissan Versa vehiclesproduced from May 8, 2006 through November12, 2012 and originally sold or ever registered in the following 22 states and the District of Columbia: Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington D.C., West Virginia and Wisconsin (NHTSA Recall 15V-573).Nissan indicated that the recalled vehicles may contain front coil springs that received inadequate phosphorous coating, have low residual stress, or a combination of both.Surface imperfections resulting from coil-to-coil contact when the spring is compressed may lead to crack initiation.Exposure of the surface imperfections to road salts, in regions with heavy use of road salts for snow and ice control, may promote crack propagation in the spring that could result in spring fracture.If the coil spring fractures it may puncture the front tire and possibly the brake line while driving, which may increase the risk of a vehicle crash.ODI's analysis of complaints it has received from the public (VOQ's) and Nissan complaint data submitted in response to the information request letter for PE15-019 identified a total of 468 non-duplicative reports alleging coil spring fractures in the subject vehicles, including 142 VOQ's and 367 Nissan complaints (41 of the incidents reported to ODI were also reported to Nissan).While the recall region accounts for approximately 43 percent of vehicle sales, the analysis found that 94 percent of the complaints involved vehicles sold or operated in those states.Approximately 27 percent of the VOQ's reporting coil spring failures in the recalled states indicated that the failure resulted in a punctured tire.ODI also identified one complaint that alleged brake line damage from a failed spring.Nissan's recall will replace both coil springs free of charge.Based on Nissan's safety recall, this investigation is closed.The 142 VOQ's referenced in this resume are: 10236143, 10405369, 10443746, 10452956, 10491553, 10497737, 10503060, 10504557, 10512390, 10512975, 10514582, 10516024, 10516085, 10521216, 10522261, 10526334, 10533856, 10537404, 10537407, 10548678, 10552124, 10559853, 10562485, 10565283, 10572591, 10578519, 10583059, 10583154, 10583496, 10583673, 10584979, 10585327, 10585377, 10585751, 10586397, 10586444, 10587798, 10588347, 10588427, 10592366, 10592498, 10592780, 10593373, 10593621, 10595215, 10596802, 10598404, 10598877, 10606859, 10606998, 10610082, 10618059, 10640845, 10644269, 10645075, 10649515, 10653189, 10659632, 10662158, 10663102, 10667071, 10667845, 10669949, 10670829, 10671894, 10676522, 10680544, 10680740, 10682397, 10691419, 10692629, 10693347, 10694156, 10694420, 10701250, 10702765, 10703126, 10704658, 10705882, 10706351, 10711805, 10712045, 10712922, 10714243, 10715041, 10715175, 10716106, 10717254, 10717320, 10717403, 10717412, 10717489, 10717563, 10720958, 10721782, 10721824, 10722113, 10722459, 10722915, 10723873, 10723972, 10723973, 10724158, 10724899, 10725002, 10725328, 10725377, 10725542, 10726251, 10726736, 10726741, 10730138, 10730154, 10730342, 10731050, 10731692, 10731799, 10731901, 10732054, 10732062, 10733059, 10733144, 10733309, 10733349, 10733607, 10733781, 10733854, 10735347, 10735353, 10735606, 10736199, 10736227, 10743474, 10743634, 10743790, 10744