Illustration2007 NISSAN VERSA LOST POWER TO ENGINE WHILE DRIVING. THEN STARTED HAVING PROBLEMS CRANKING. STARTER TURNS OVER BUT ENGINE WILL ONLY SPUTTER, FAILS TO FULLY START. *TR
2007 Nissan Versa
Owner reports · Recalls · Investigations
More warning signs than most Versa years
Owner complaints for the 2007 Nissan Versa are substantially higher than the model-year median of 95.
About this comparison →How this year compares
Owner complaints by model year
Compare all Versa years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
470–25K
4225–50K
4350–75K
2875–100K
32100–150K
10150K+
202 reports with mileage · 152 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 150 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 54 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports8 fire reports11 injury reports
What owners actually said
354 reportsIN 2008, WE BEGAN TO NOTICE INTERMITTENT STARTING PROBLEMS WITH OUR 2007 NISSAN VERSA; THE CAR WOULD NOT START AFTER PROLONGED CRANKING OF THE STARTER. IN MAY 2009, WE TOOK THE CAR TO THE DEALERSHIP TO UNDERGO DIAGNOSTICS AND REPAIR. THEY FOUND THE PROBLEM TO BE A FAULTY FUEL PRESSURE REGULATOR AND REPLACED THE PART UNDER WARRAN…
Read full complaint
IN 2008, WE BEGAN TO NOTICE INTERMITTENT STARTING PROBLEMS WITH OUR 2007 NISSAN VERSA; THE CAR WOULD NOT START AFTER PROLONGED CRANKING OF THE STARTER. IN MAY 2009, WE TOOK THE CAR TO THE DEALERSHIP TO UNDERGO DIAGNOSTICS AND REPAIR. THEY FOUND THE PROBLEM TO BE A FAULTY FUEL PRESSURE REGULATOR AND REPLACED THE PART UNDER WARRANTY. FIVE MONTHS LATER, THE PROBLEM REAPPEARED. THE VERSA WENT BACK TO THE DEALER FOR THE SAME REPAIR, IN NOVEMBER 2009, AND AGAIN REPLACED THE PART UNDER WARRANTY. SINCE THE LAST REPAIR, THE VERSA WAS DRIVEN INFREQUENTLY DURING THE FIRST HALF OF 2010, AND THEREFORE, DIDN?T ACCUMULATE SIGNIFICANT MILEAGE. IN THE SUMMER OF 2010, THE CAR WAS DRIVEN REGULARLY AGAIN, WITH THE STARTING PROBLEM REAPPEARING IN OCTOBER 2010. WE HAVE NOT BEEN ABLE TO TAKE THE CAR IN FOR SERVICE UNTIL JANUARY 2011. THIS MARKS THE THIRD REPAIR FOR THE SAME PROBLEM. UNFORTUNATELY, THE VERSA HAS EXCEEDED THE FACTORY WARRANTY (38K MILES) AND WE ARE PAYING OUT OF POCKET FOR THIS REPAIR. THIS PROBLEM IS NOT ISOLATED TO US. I HAVE DONE SOME RESEARCH ON THIS ISSUE AND THE SAME PROBLEM IS SHARED MY MANY OTHER NORTH AMERICAN VERSA OWNERS ACROSS MANY ENTHUSIAST INTERNET FORUMS, CAR SITES, BLOGS AND OTHER LOCATIONS. WITH THAT IN MIND, I CALLED NISSAN CONSUMER AFFAIRS AND STATED MY CASE. THE REPLY WAS SIMPLY THAT NISSAN HAS NOT RECOGNIZED THIS PROBLEM AS A RECALL OR CAMPAIGN. WE MADE THE DECISION TO PURCHASE A NEW VEHICLE BASED ON SAFETY AND RELIABILITY. WE HAVE LOST CONFIDENCE IN OUR NISSAN VERSA, AS EVERY TIME WE TAKE THE WHEEL WE?RE LEFT WONDERING WHETHER IT WILL OR WILL NOT START. I CANNOT ACCEPT THE FACT THAT A MODERN, LOW-MILEAGE, THREE-YEAR-OLD VEHICLE WILL OCCASIONALLY NOT START, THEREBY, CREATING A SITUATION OF POTENTIAL DANGER TO FAMILY. WHILE THIS PROBLEM DOES NOT CONSTITUTE AN IMMINENT THREAT SUCH AS A BRAKE FAILURE OR TIRE DEFECT, HAVING YOUR CAR BECOME INOPERABLE CAN LEAD TO DANGEROUS OUTCOMES AS WELL. NISSAN IS NOT ADDRESSING A SIGNIFICANT PROBLEM. *TR
CAR WAS AT A DEAD STOP IN MY DRIVEWAY. I WENT TO BACK OUT OF MY DRIVEWAY...AND AS ALWAYS I STARTED THE CAR WITH MY FOOT ON THE BRAKE...PUT THE CAR IN REVERSE...BEGAN TO LIFT MY FOOT OFF THE BRAKE TO COAST BACK AGAIN AS USUAL...WITHOUT EVER TOUCHING THE GAS PEDAL. THE CAR SHOT BACK LIKE A BULLET...TRAVELED ABOUT 45 TO 50 FEET AND…
Read full complaint
CAR WAS AT A DEAD STOP IN MY DRIVEWAY. I WENT TO BACK OUT OF MY DRIVEWAY...AND AS ALWAYS I STARTED THE CAR WITH MY FOOT ON THE BRAKE...PUT THE CAR IN REVERSE...BEGAN TO LIFT MY FOOT OFF THE BRAKE TO COAST BACK AGAIN AS USUAL...WITHOUT EVER TOUCHING THE GAS PEDAL. THE CAR SHOT BACK LIKE A BULLET...TRAVELED ABOUT 45 TO 50 FEET AND SLAMMED INTO THE DRIVER SIDE DOOR OF A PARKED PANEL TRUCK. THE CAR THEN SHOT FORWARD AGAIN LIKE A BULLET AND SLAMMED INTO A FENCE POLE THAT WAS SET IN CEMENT. I GOT OUT OF THE CAR IN SHOCK....A NEIGHBOR CAME RUNNING OVER...I TOLD HIM THAT ALL I DID WAS PUT THE CAR IN REVERSE AND THEN LOST COMPLETE CONTROL. THE CAR WAS STILL RUNNING...MY NEIGHBOR WENT TO TURN OFF THE ENGINE...AND SAID..."THE CAR IS STILL IN REVERSE." HE PUT THE CAR IN PARK AND TURNED OFF THE ENGINE. A POLICE REPOPRT WAS FILED. THE CAR WAS REMOVED TO A LOT FOR INSPECTION. THE INSPECTION DID NOT REVEAL ANY PROBLEMS WITH THE CAR. AS FAR AS NISSAN WAS CONCERNED THE CASE ENDED THERE. THEY NEVER INTERVIEWED ANY WITNESSES. THE PANEL TRUCK OWNER WAS JUST ABOUT TO GO TO HIS TRUCK...HE HEARD THE LOUD RACING SOUND OF THE ENGINE...AS DID MY DAUGHTER WHO SAW THE WHOLE THING... SHE WAS SITTING AT THE DINING ROOM TABLE WITH FULL VIEW FROM A WINDOW...SHE THOUGHT I HAD A HEART ATTACK. AND THE NEIGHBOR WHO WINESSED THE GEAR IN REVERSE WAS NEVER CONTACTED. IN LIGHT OF THE CASES OF "UNEXPLAINED" SUDDEN ACCELERATION I FIND IT HARD TO BELIEVE THAT NISSAN IS SATISFIED WITH THE RESULTS IN THIS CASE. I CANNOT IN GOOD CONSCIOUS LET THIS STAND WITHOUT AT LEAST MAKING A RECORD OF THE INCIDENT. BY THE WAY THE CAR WAS TOTALED. I WOULD BE CURIOUS TO SEE A REPORT FROM AN ACCIDENT RECONSTRUCTION EXPERT AS TO THE SPEED THE CAR REACHED FROM A DEAD STOP....TRAVELEING ABOUT 45 FEET..... THAT WOULD CAUSE THE AMOUNT OF DAMGE DONE TO THAT CAR. I WOULD HAVE TO BE STANDING ON THE GAS PEDAL...COMMON SENSE SAYS THAT DID NOT HAPPEN. THE AIRBAGS NEVER DEPLOYED. THANK YOU. *TR
TL* THE CONTACT OWNS A 2007 NISSAN VERSA. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT BELIEVED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE DEALER WAS NOTIFIED WHO ADVISED THE CONTACT TO CALL THE MANUFACTURER. THE CONTACT ATTEMPTED TO CONTACT THE MANUFACTURER BUT TO NO AVAIL. THE VE…
Read full complaint
TL* THE CONTACT OWNS A 2007 NISSAN VERSA. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT BELIEVED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE DEALER WAS NOTIFIED WHO ADVISED THE CONTACT TO CALL THE MANUFACTURER. THE CONTACT ATTEMPTED TO CONTACT THE MANUFACTURER BUT TO NO AVAIL. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 80,000.
WHILE DRIVING ON MY ROAD I HEARD A LOUDER THAN USUAL EXHAUST NOISE. INSPECTION AT MY HOME REVEALED THE FLANGE ON THE EXHAUST PIPE RIGHT BEFORE THE MUFFLER HAS RUSTED AND COMPLETELY SEPARATED. TAKING IT TO MUFFLER SHOP TO HAVE A NEW PIPE WELDED ON WHERE SEPARATION OCCURRED. APPROXIMATE COST WAS QUOTED AT $100.00. I HAVE READ …
Read full complaint
WHILE DRIVING ON MY ROAD I HEARD A LOUDER THAN USUAL EXHAUST NOISE. INSPECTION AT MY HOME REVEALED THE FLANGE ON THE EXHAUST PIPE RIGHT BEFORE THE MUFFLER HAS RUSTED AND COMPLETELY SEPARATED. TAKING IT TO MUFFLER SHOP TO HAVE A NEW PIPE WELDED ON WHERE SEPARATION OCCURRED. APPROXIMATE COST WAS QUOTED AT $100.00. I HAVE READ OF NUMEROUS NISSAN VERSA AND NISSAN MURANO OWNERS WITH THE SAME ISSUE. *TR
2007 NISSAN VERSA ALWAYS PULLS TO THE LEFT, ALIGNMENT PROBLEM. *TR
UNABLE TO OBTAIN A MUFFLER FOR 2007 NISSAN VERSA HATCHBACK. THESE HAVE BEEN UNAVAILABLE FOR 5 WEEKS WITH ANTICIPATED 2 MORE WEEK DELAY. NISSANUSA HAS PROVIDED CUSTOMER SERVICE PHONE NUMBERS WHICH, WHEN CALLED, ARE NOT RESPONDED TO OR DISCONNECT. IS THERE A PROBLEM WITH THIS VEHICLE/PART WHICH MAY NECESSITATE A RECALL/INVESTIG…
Read full complaint
UNABLE TO OBTAIN A MUFFLER FOR 2007 NISSAN VERSA HATCHBACK. THESE HAVE BEEN UNAVAILABLE FOR 5 WEEKS WITH ANTICIPATED 2 MORE WEEK DELAY. NISSANUSA HAS PROVIDED CUSTOMER SERVICE PHONE NUMBERS WHICH, WHEN CALLED, ARE NOT RESPONDED TO OR DISCONNECT. IS THERE A PROBLEM WITH THIS VEHICLE/PART WHICH MAY NECESSITATE A RECALL/INVESTIGATION SINCE NONE ARE AVAILABLE IN THE US? FILE# WITH NISSANUSA IS [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
HAVING ISSUE WITH HARD START WITH VEHICLE TAKING A LONG TIME CRANKING IN ORDER TO CATCH. WHILE READING OTHER CONSUMERS ISSUES WITH THEIR VERSA DYING OUT IN TRAFFIC I WOULD LIKE TO AVOID THAT AS I HAVE A BABY ON THE WAY. *TR
TL* THE CONTACT OWNS A 2007 NISSAN VERSA. THE CONTACT STATED SINCE THE DATE OF PURCHASING THE VEHICLE (SEPTEMBER 25, 2007), THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER NUMEROUS TIME TO DETERMINE THE CAUSE OF THE WARNING LIGHT BEING ACTIVATED. THE DEALER REPLACED THE GAS CAP TWICE, THE FIL…
Read full complaint
TL* THE CONTACT OWNS A 2007 NISSAN VERSA. THE CONTACT STATED SINCE THE DATE OF PURCHASING THE VEHICLE (SEPTEMBER 25, 2007), THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER NUMEROUS TIME TO DETERMINE THE CAUSE OF THE WARNING LIGHT BEING ACTIVATED. THE DEALER REPLACED THE GAS CAP TWICE, THE FILTER AND THE VALVE. THE FAILURE WAS CORRECTED FOR A FEW MONTHS UNTIL RECURRING. THE MANUFACTURER ADVISED THE CONTACT THAT A REGIONAL DIRECTORY WOULD CONTACT HER. THE CONTACT STATED THAT THE VEHICLE WOULD BE TAKEN BACK TO THE DEALER FOR FURTHER DIAGNOSIS. THE FAILURE MILEAGE WAS 700 AND THE CURRENT MILEAGE WAS 14,000.
TL* THE CONTACT OWNS A 2007 NISSAN VERSA. THE CONTACT STATED THAT WHEN BRAKING ABRUPTLY, THE SEAT BELT WOULD NOT CATCH OR HOLD FIRMLY. THE CONTACT WOULD BE PUSHED FORWARD INTO THE STEERING WHEEL. THE FAILURE WOULD NOT INJURE THE CONTACT YET SHE WAS CONCERNED WITH THE SEAT BELT RESTRAINING HER IN THE POTENTIAL EVENT OF A CRASH. T…
Read full complaint
TL* THE CONTACT OWNS A 2007 NISSAN VERSA. THE CONTACT STATED THAT WHEN BRAKING ABRUPTLY, THE SEAT BELT WOULD NOT CATCH OR HOLD FIRMLY. THE CONTACT WOULD BE PUSHED FORWARD INTO THE STEERING WHEEL. THE FAILURE WOULD NOT INJURE THE CONTACT YET SHE WAS CONCERNED WITH THE SEAT BELT RESTRAINING HER IN THE POTENTIAL EVENT OF A CRASH. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION NOR WAS THE MANUFACTURER CONTACTED TO REPORT THE FAILURE. THE FAILURE MILEAGE WAS 52,000.
Official recalls
820V008000 · Air Bags:frontal:passenger Side:inflator Module
Jan 9, 2020
Nissan North America, Inc. (Nissan) is recalling certain 2001-2003 Maxima, 2002-2006 Sentra, 2002-2004 Pathfinder, 2007-2011 Versa Sedan and Versa Hatchback, 2001-2004 Infiniti I30 and I35, 2002-2003 Inifiniti QX4, 2003-2008 Infiniti FX35 and FX45 and 2006-2010 M35 and M45 vehicles. The vehicles are equipped with non-desiccated, frontal passenger air bag inflators containing phase stabilized ammonium nitrate (PSAN) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the front passenger air bag inflators with alternate desiccated inflators, free of charge. The recall began February 12, 2020. Owners may contact Nissan customer service at 888-737-9511 or Infiniti customer service at 888-810-3715.
18V452000 · Air Bags:frontal:passenger Side:inflator Module
Jul 6, 2018
Nissan North America, Inc. (Nissan) is recalling certain 2007-2008 Nissan Versa sedan and Versa hatchback vehicles originally sold, or ever registered, in Alabama, Arizona, Arkansas, California, Delaware, District of Columbia, Florida, Georgia, Hawaii, Illinois, Indiana, Kansas, Kentucky, Louisiana, Maryland, Mississippi, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, South Carolina, Tennessee, Texas, Virginia, West Virginia, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. The passenger air bag inflators may explode due to propellant degradation due to exposure to humidity and temperature cycling.
Consequence & remedy
Consequence: If an inflator were to explode it may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began July 25, 2018. Owners may contact Nissan customer service at 1-800-867-7669. Note: The vehicles covered by this recall are in addition to those covered by recall 16V-349.
17V449000 · Air Bags:frontal:driver Side:inflator Module
Jul 17, 2017
Nissan North America, Inc. (Nissan) is recalling certain 2007-2011 Versa Sedan and 2007-2012 Versa Hatchback vehicles. The affected vehicles have a driver frontal air bag inflator that may rupture due to propellant degradation occurring after long-term exposure to moderate absolute humidity, temperatures, and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the subject inflator with a new one manufactured by a different supplier, free of charge. The recall began on March 9, 2018. Owners may contact Nissan customer service at 1-800-647-7261.
17V028000 · Air Bags:frontal:passenger Side:inflator Module
Jan 10, 2017
Nissan North America, Inc. (Nissan) is recalling certain 2012 Nissan Versa hatchbacks originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan) and the U.S. Virgin Islands, or "Zone A". Additionally, if not included in "Zone A" above, Nissan is recalling certain 2009-2010 Infiniti M35 and M45 and 2009 Nissan Versa sedans and hatchbacks originally sold, or ever registered, in Arizona, Arkansas, Delaware, the District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B". Additionally, if not included in "Zone A" or "Zone B" above, Nissan is recalling certain 2005-2008 Infiniti FX35 and FX45, 2006-2010 Infiniti M35 and M45, and 2007-2008 Nissan Versa vehicles originally sold, or ever registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the front passenger air bag inflators, free of charge. The recall began on June 8, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Nissan customer service at 1-800-647-7261.
16V349000 · Air Bags:frontal:passenger Side:inflator Module
May 24, 2016
Nissan North America, Inc. (Nissan) is recalling certain model year 2003-2008 Infiniti FX35 and FX45, 2003-2004 Infiniti I35, 2006-2010 Infiniti M35 and M45, and 2007-2011 Nissan Versa vehicles, originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Nissan is recalling certain model year 2005-2008 Infiniti FX35 and FX45, 2003-2004 Infiniti I35, 2006-2008 Infiniti M35 and M45, and 2007-2008 Nissan Versa vehicles, originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Nissan is recalling certain model year 2003-2004 Infiniti I35 vehicles originally sold, or registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began December 21, 2017. All owners should receive a second notice by May 15, 2017. Owners may contact Nissan customer service at 1-800-647-7261.
15V573000 · Suspension:front:springs:coil Springs
Sep 14, 2015
Nissan (Nissan North America, Inc.) is recalling certain model year 2007-2012 Nissan Versa vehicles manufactured May 8, 2006, to November 12, 2012, that were sold or ever registered in the District of Columbia, Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky, Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia and Wisconsin. Road salt may corrode the front coil springs, possibly resulting in the coil springs fracturing.
Consequence & remedy
Consequence: If a front coil spring fractures, it may contact the tire, possibly puncturing it, increasing the risk of a crash.
Remedy: Nissan will notify owners, and dealers will replace both front coil springs, free of charge. The recall began on February 2, 2016. Owners may contact Nissan customer service at 1-800-647-7261.
07V094000 · Seat Belts
Mar 12, 2007
ON CERTAIN HATCHBACK VEHICLES, THE TERMINALS FOR THE PASSENGER SIDE SEAT BELT TENSION SENSOR HARNESS CONNECTOR MAY HAVE BEEN DAMAGED DURING THE MANUFACTURING PROCESS. THIS COULD RESULT IN A LOSS OF ELECTRICAL CONTINUITY CAUSING THE OCCUPANT DETECTION SYSTEM TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE AIR BAG WARNING LIGHT WILL COME ON AND THE PASSENGER SIDE FRONTAL AIR BAG WILL BE SUPPRESSED.
Remedy: DEALERS WILL REPLACE THE CONNECTOR FOR THE SEAT BELT TENSION SENSOR HARNESS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 18, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
06V348000 · Service Brakes, Hydraulic
Sep 12, 2006
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THE BRAKE FLUID RESERVOIR CAP IS MISSING PART OF THE REQUIRED BRAKE FLUID WARNING.
Consequence & remedy
Consequence: THE PURPOSE OF THIS STANDARD IS TO ENSURE SAFE BRAKING PERFORMANCE UNDER NORMAL AND EMERGENCY DRIVING CONDITIONS.
Remedy: NEW BRAKE FLUID RESERVOIR CAPS WILL BE MAILED TO VEHICLE OWNERS ALONG WITH INSTRUCTIONS FOR INSTALLATION. THE LETTERS WILL INSTRUCT OWNERS WHO DO NOT WANT TO REPLACE THEIR OWN BRAKE FLUID RESERVOIR CAP TO TAKE THE CAR TO A DEALER FOR THE REPAIR. THE RECALL BEGAN ON NOVEMBER 10, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
PE15019 · Front Coil Spring Fracture
Opened May 13, 2015 · Closed Oct 2, 2015
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
In a letter dated September 10,2015, Nissan North America,Inc. (Nissan) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in coil spring fracture in approximately 218,019 model year (MY) 2007 through 2012 Nissan Versa vehiclesproduced from May 8, 2006 through November12, 2012 and originally sold or ever registered in the following 22 states and the District of Columbia: Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington D.C., West Virginia and Wisconsin (NHTSA Recall 15V-573).Nissan indicated that the recalled vehicles may contain front coil springs that received inadequate phosphorous coating, have low residual stress, or a combination of both.Surface imperfections resulting from coil-to-coil contact when the spring is compressed may lead to crack initiation.Exposure of the surface imperfections to road salts, in regions with heavy use of road salts for snow and ice control, may promote crack propagation in the spring that could result in spring fracture.If the coil spring fractures it may puncture the front tire and possibly the brake line while driving, which may increase the risk of a vehicle crash.ODI's analysis of complaints it has received from the public (VOQ's) and Nissan complaint data submitted in response to the information request letter for PE15-019 identified a total of 468 non-duplicative reports alleging coil spring fractures in the subject vehicles, including 142 VOQ's and 367 Nissan complaints (41 of the incidents reported to ODI were also reported to Nissan).While the recall region accounts for approximately 43 percent of vehicle sales, the analysis found that 94 percent of the complaints involved vehicles sold or operated in those states.Approximately 27 percent of the VOQ's reporting coil spring failures in the recalled states indicated that the failure resulted in a punctured tire.ODI also identified one complaint that alleged brake line damage from a failed spring.Nissan's recall will replace both coil springs free of charge.Based on Nissan's safety recall, this investigation is closed.The 142 VOQ's referenced in this resume are: 10236143, 10405369, 10443746, 10452956, 10491553, 10497737, 10503060, 10504557, 10512390, 10512975, 10514582, 10516024, 10516085, 10521216, 10522261, 10526334, 10533856, 10537404, 10537407, 10548678, 10552124, 10559853, 10562485, 10565283, 10572591, 10578519, 10583059, 10583154, 10583496, 10583673, 10584979, 10585327, 10585377, 10585751, 10586397, 10586444, 10587798, 10588347, 10588427, 10592366, 10592498, 10592780, 10593373, 10593621, 10595215, 10596802, 10598404, 10598877, 10606859, 10606998, 10610082, 10618059, 10640845, 10644269, 10645075, 10649515, 10653189, 10659632, 10662158, 10663102, 10667071, 10667845, 10669949, 10670829, 10671894, 10676522, 10680544, 10680740, 10682397, 10691419, 10692629, 10693347, 10694156, 10694420, 10701250, 10702765, 10703126, 10704658, 10705882, 10706351, 10711805, 10712045, 10712922, 10714243, 10715041, 10715175, 10716106, 10717254, 10717320, 10717403, 10717412, 10717489, 10717563, 10720958, 10721782, 10721824, 10722113, 10722459, 10722915, 10723873, 10723972, 10723973, 10724158, 10724899, 10725002, 10725328, 10725377, 10725542, 10726251, 10726736, 10726741, 10730138, 10730154, 10730342, 10731050, 10731692, 10731799, 10731901, 10732054, 10732062, 10733059, 10733144, 10733309, 10733349, 10733607, 10733781, 10733854, 10735347, 10735353, 10735606, 10736199, 10736227, 10743474, 10743634, 10743790, 10744