2004 Nissan Titan

ON MAY 3, 2012, I SAW MY SIDE MIRROR LIGHTS WERE NOT TURNING OFF, EVEN WHILE DRIVING. I SCHEDULED WORK FOR MY TRUCK FOR MAY 5, 2012. MY TRUCK WAS PARKED AT MY PLACE OF EMPLOYMENT FROM AROUND 6 AM TO 2 PM ON MAY 3, 2012. WHEN TRYING TO LEAVE WORK I TRIED TO START MY TRUCK AND IT WOULD NOT TURN OVER, TRIED TO JUMP START WITH NO SUCCESS AND EVEN HAD A TOW TRUCK COMPANY ATTEMPT TO START THE TRUCK. AFTER THE TRUCK WAS TOWED TO LOCAL SHOP THE TRUCK STARTED UP WITH NO PROBLEM AND THE MECHANIC SAID SINCE ITS NOT SHOWING ANY ISSUES THAT IT DID BEFORE THERE WAS NOTHING THEY COULD DO. ON MAY 5, 2012 I TOOK MY TRUCK IN FOR THE ELECTRICAL PROBLEM AND THEY ALSO FIXED A RECALL WITH THE ECM RELAY. ON THE SAME DAY AROUND 6 PM IN THE AFTERNOON THE TRUCK WOULD NOT START AGAIN. THE TRUCK WAS TOWED BACK TO THE NISSAN DEALERSHIP ON MAY 6, 2012 AND ON MAY 7, 2012 THE TECHNICIANS AT NISSAN CONTACTED ME STATING IT WAS MY BCM WHICH WAS IN THE SAME AREA AS THE ECM. I HAD TO PAY ABOUT 600 DOLLARS FOR A NEW BCM. I BELIEVE THE BCM WENT OUT DUE TO THE RECALL WORK THAT WAS PERFORMED EARLIER. *TR

TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED THAT WHILE THE VEHICLE WAS AT THE LOCAL MECHANIC FOR ROUTINE INSPECTION THE CONTACT WAS INFORMED THAT THE ENGINE EXHAUST MANIFOLD WAS LEAKING DUE TO A DEFECTIVE DESIGN. IN ADDITION, THE STEERING FAILED WHILE DRIVING. THE STEERING COLUMN WAS REPLACED; HOWEVER THE EXHAUST MANIFOLD WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 136,000.

THE WIRING HARNESS, IN THE BACK DOOR HAS BROKEN, BECAUSE OF A NISSAN ENGINEERING PROBLEM, BOTH THE HARNESS AND WIRES HAVE BROKEN, WHICH ACCORDING TO NHTSA THE FRONT PASSENGER SIDE AIRBAG WILL NOT DEPLOY, RESULTING IN MY HAVING AN UNSAFE TRUCK ACCORDING TO NHTSA, I CONTACTED NISSAN AND WAS TOLD THAT THE CAMPAIGN HAD ENDED, SO THEY REFUSE TO REPAIR MY TRUCK ACCORDING TO THE GUIDELINES SET BY NHTSA. AT WHAT POINT DOES NISSAN DECIDE THAT THEY CAN DECIDE WHICH TRUCKS TO REPAIR, I HAVE TO WONDER HOW MANY OTHER UNSAFE NISSAN TRUCKS ARE ON THE HIGHWAYS. *TR

THE VEHICLE DISPLAYED INTERMITTENT CHEMICAL TYPE ODOR THROUGH HVAC SYSTEM, 3 DEALERSHIPS UNABLE/UNWILLING TO CONFIRM, OR SEEK DIRECTION FROM CORPORATE AS TO METHOD FOR RESOLUTION AT MY SUGGESTION/REQUEST. I WAITED ONE YEAR TO ALLOW FOR VEHICLE TO "OFF-GAS" INTERIOR ODORS FROM MATERIALS USED IN MANUFACTURE, HAD TO INSIST THAT DEALER STAFF DOCUMENT THE CONCERN WHICH IS YET UNRESOLVED AND DENIED ASSISTANCE FROM CONSUMER AFFAIRS DEPARTMENT TO SATISFY HEALTH AND SAFETY CONCERNS. INCURRED SIGNIFICANT ADDITIONAL EXPENSES TO ALLEVIATE ISSUE SUCH AS IN CABIN AIR FILTER AND PURCHASE OF IONIZING UNIT; PLUS MISSED WORKDAYS, TRANSPORTATION, FUEL AND SERVICE AND DIAGNOSTIC FEES AT DEALERSHIPS. *TR

TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED THAT WHILE PARKED, HE NOTICED THAT THE EXHAUST WAS LOUDER THAN NORMAL. THE CONTACT WAS A CERTIFIED MECHANIC AND DIAGNOSED THE FAILURE AS A CRACKED EXHAUST MANIFOLD, WHICH HE WAS CONCERNED WOULD LEAK HARMFUL FUMES INTO THE INTERIOR CABIN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE AND CURRENT MILEAGE WAS 125,000.

TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, HE DEPRESSED THE BRAKE PEDAL WHICH WAS HESITANT TO RESPOND. THE CONTACT HAD TO APPLY EXTREME PRESSURE TO THE BRAKE PEDAL IN ORDER TO STOP THE VEHICLE. ALSO, THE EMERGENCY BRAKE ENGAGED ON ITS OWN INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THERE WAS AN AXLE FAILURE. THE CONTACT MENTIONED THAT THERE WAS A MANUFACTURE RECALL FOR A BRAKE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 93,000.

WHILE REPLACING LIFETIME WARRANTIED SUSPENSION WHICH WAS NOT HONORED BY NISSAN OR TENNECO, I FOUND THE REAR PINION SEAL TO BE LEAKING SEVERELY, AND REAR AXLE SEAL LEAKING IN WHEEL ASSEMBLY. POSSIBLE SOURCE OF "TICKING" NOISE FROM DIFFERENTIAL, WHICH UNTIL THEN I THOUGHT WERE EXHAUST HEAT SHIELDS. THIS CONDITION COULD CAUSE CATASTROPHIC DRIVETRAIN FAILURE WHILE VEHICLE IS IN MOTION. THE FLUID LEAKING FROM AXLE SEAL CAN REDUCE EFFECTIVENESS OF BRAKING COMPONENTS. OTHER OWNERS HAVE DESCRIBED INADEQUATE ENGINEERING & POSSIBLE USE OF SUBSTANDARD DIFFERENTIAL MATERIALS & COMPONENTS ALONG WITH AXLE VENT ASSEMBLIES WHICH COULD CREATE INTERNAL PRESSURE CONDITIONS THAT COULD CAUSE SEALS TO FAIL. *TR

DON'T KNOW IF IT'S BEEN REPORTED, BUT ALOT OF PEOPLE ARE HAVING ISSUES WITH THE NISSAN TITANS (MANY YEARS) WITH THE EXHAUST MANIFOLDS CRACKING. I HAVE A 2004 AND BOTH OF THEM HAVE BEEN CRACKED FOR ALMOST 4 YEARS NOW. I CONTACTED NISSAN, THEY SUGGESTED TO CONTACT NISSAN CORPORATE, AND PRETTY MUCH TOLD ME I WAS OUT OF LUCK. THE MANIFOLDS ARE OVER $850 EACH, AND BOTH OF MINE ARE SEVERELY CRACKED, CAUSING ENGINE, EMISSION, AND SAFETY/HEALTH PROBLEMS. I HAVE HAD TO REPLACE MANY O2 SENSORS, CAT'S, AND MUFFLERS, DUE TO BURNING UP, AND HAVE TO DRIVE WITH ALL MY WINDOWS DOWN AND SHORT TRIPS DUE TO THE EXHAUST FILLING THE CAB OF THE TRUCK. SOMETHING NEEDS TO BE DONE, AS THIS IS NOT ONLY AN ISSUE, BUT A MAJOR FLAW IN THE DESIGN OF THE TRUCK. I HAVE HAD CHECKED OUT AT A LOCAL SHOP, AND THEIR EXACT WORDS WERE "THERE IS ABSOLUTELY NO FLEX IN THE EXHAUST, SO WHEN THE ENGINE SHIFTS FROM DRIVING AND REVVING, THE MANIFOLDS ARE THE WEAKEST POINT AND THEREFORE CRACK". SOMETHING SERIOUSLY NEEDS TO BE DONE OR LOOKED INTO. MANY NISSAN TITAN FORUMS HUNDREDS OF PEOPLE ARE COMPLAINING ABOUT THE SAME ISSUE. USUALLY ONLY ONE IS CRACKED, BUT I HAVE BOTH CRACKED. IF YOU NEED A VEHICLE TO INSPECT, YOU CAN LOOK AT MINE. I EVEN HAD THE EXHAUST UPGRADED TO BIGGER EXHAUST IN HOPES OF RELIEVING SOME OF THE PRESSURE, SO IT DOESN'T LEAK ALL OUT UNDER THE HOOD, AND THAT HAS HELPED SOME, BUT THIS IS SERIOUSLY AN ISSUE WITH THE DESIGN AND USABILITY OF THESE NISSAN TITAN TRUCKS. AND, I DON'T KNOW ABOUT ALOT OF PEOPLE, BUT I CAN'T AFFORD TO SPEND OVER $1600 IN JUST 2 PARTS, PLUS ALL THE OTHER REQUIRED PARTS, WHEN I CAN BARELY AFFORD TO PAY THE BANK ON THE TRUCK. *TR *BF *TR

THE REAR AXLE HUB SEALS LEAKED AFTER THE 1ST AND ONLY PULLING EVER DONE WITH MY 2004 (4 X 2) SE TITAN P/P. MY VEHICLE IS EQUIPPED WITH " BIG TOW PKG." DEALER REPLACED THE ENTIRE REAR AXLE. " NO" PULLING OR TOWING DONE SINCE REPLACEMENT BY DEALER SVC. DONE 12/24/2008 AT 85,417 MILES. HOWEVER, A RIGHT/PASSENGER SEAL LEAK NOTICED ON 08/29/2012 AT 152,247 MILES. I WAS TOLD BY THE REGIONAL WARRANTY SERVICE MANAGER THAT THE ISSUE HAD BEEN RESOLVED WITH AN " UPGRADED BETTER AXLE SYSTEM " WHICH WOULD RESOLVE THE PROBLEM WHEN THE REAR END WAS REPLACED. THE REAR AXLE DIFF. FLUID LEAK IS CAUSING PERIODIC BRAKING ISSUES AND NOISES. I AM VERY CONCERNED ABOUT SAFE BRAKING, ESPECIALLY WHEN DRIVING THE VEHICLE IN WET WEATHER. NEEDS TO BE ADDRESSED AS A SAFETY ISSUE. *TR