2004 Nissan Titan

PASS REAR AXLE SEAL BLEW OUT AND LEAKED DIFFERENTIAL FLUID. DIFFERENTIAL FLUID LEAKING ON REAR BRAKE ROTORS WHICH COULD CAUSE BRAKE FAILURE, WHICH WAS A MAJOR SAFETY CONCERN TO ME. AT TIME OF FAILURE NO SUSPENSION MODIFICATIONS HAD BEEN DONE TO VEHICLE. ALSO, THE REAR DIFFERENTIAL OIL WILL SLOWLY LEAK AND CAUSE THE REAR DIFFERENTIAL TO LOSE FLUID AND FAIL. AS THIS SEEMED TO BE A VERY COMMON PROBLEM WITH THE NISSAN TITAN, NISSAN SHOULD ADDRESS THIS ISSUE AND OFFER A PERMANENT FIX SO WE WOULD NOT BE FACED WITH THE SAFETY ISSUE IN THE FUTURE. *TR

WHEN MY 2004 NISSAN TITAN LE 4X4 PICKUP (66420 MILES) FAILED AT ATTEMPTING TO CLIMB THE HILL TO MY HOUSE, I DISCOVERED THAT ALTHOUGH 4WD WAS SELECTED, IT WAS APPARENTLY NOT ENGAGED. UPON INVESTIGATION IT WAS DISCOVERED THAT THE DRIVER'S SIDE HALF AXLE CAME OUT OF THE FRONT DIFFERENTIAL. UPON RESEARCH I DISCOVERED THIS IS APPARENTLY A RECURRING PROBLEM WITH NISSAN TITAN 4X4S. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO REPAIRED THE PROBLEM BY RE-INSERTING THE HALF SHAFT INTO THE FRONT DIFFERENTIAL. *TR

WHILE DRIVING IN SLICK CONDITIONS I PLACED MY 2004 TITAN IN 4 HI, DIDN'T NOTICE ANY IMPROVEMENT IN TRACTION, SLIP INDICATOR CONTINUED TO LIGHT ON ACCELERATION. 4 HI INDICATOR SHOWED ENGAGEMENT BUT THE TRUCK WAS NOT ENGAGING IN EITHER 4 HI OR 4 LO. TOOK THE TRUCK TO AN AUTO REPAIR SHOP. THE "C" CLIPS ON THE SHAFT HAD FAILED AND ALLOWED THE SHAFTS TO COME OUT OF THE SPLINES. DUE TO THAT THE SHAFTS NOT BEING IN PLACE THEY OVALED THE SOCKETS, THE DIFFERENTIAL OIL LEAKED OUT, THE BEARINGS WENT OUT WHICH IN TURN CASED BOTH THE FRONT DIFFERENTIAL AND THE TRANSFER CASE TO FAIL. I GOT THE TRUCK REPAIRED, REPLACED BOTH THE TRANSFER CASE AND FRONT DIFFERENTIAL, AT THE COST OF $2500. A WEEK LATER IT SNOWED ALMOST 12 INCHES. ENGAGED 4 HI WHILE LEAVING THE DRIVE WAY, DROVE APPROXIMATELY 4 MILES AND THE TRUCK LOST 4 HI AGAIN AND WAS MAKING A GRINDING NOISE I PUT THE TRUCK BACK INTO 2 HI NOISE STOPPED. TOOK IT BACK TO THE SHOP AND THE SHAFT HAS COME OUT AGAIN, EVEN THOUGH THIS WAS A NEW FRONT DIFFERENTIAL AND WAS TOLD THAT THERE IS NO FIX FOR THIS PROBLEM. IT HAPPENS AND WILL CONTINUE TO HAPPEN WHEN EVER 4 WHEEL DRIVE IS USED OR IS TO BE ENGAGED.

I HAVE A 2004 NISSAN TITAN,IT HAS BLOWN OUT 2 REAR DIFFERENTIALS. ONE WAS AT 93,000 MILES REPAIR COST 2,900 DOLLARS,AND THE OTHER AT 148,00 MILES REPAIR COSTS 2,600 DOLLARS. THE TRUCK GOES QUICKLY FROM DRIVABLE TO DANGEROUS TO DRIVE. FROM RESEARCH THERE IS A DEFECT IN THE DIFFERENTIAL VENTING DESIGN. YOU WOULD THINK THEY SHOULD BE RESPONSIBLE FOR AT LEAST THE 2ND ONE. *LN

PROBLEM: NOISE IN THE FRONT AXLE AND WOULD NOT SHIFT INTO 4-WHEEL DRIVE WHILE MOVING. DURING AN OIL CHANGE, THE DEALER NOTICED THAT THE FRONT AXLE WAS LEAKING. RECOMMENDED REPLACEMENT AND MENTIONED THE ORIGINAL EQUIPMENT WAS INFERIOR TO THE REPLACEMENT. SEVERAL MONTHS EARLIER THE REAR AXLE WAS LEAKING AND THE DEALER REPLACE THAT SEAL AS WELL. COST: FRONT DIFFERENTIAL AXLE $1,700 & REAR DIFFERENTIAL $900. TOTAL OF $2,600 IN TWO MONTHS. MY CONCERN IS WHY DOES A VEHICLE (2004 & 47K) NEED A COMPLETE FRONT END REPLACEMENT? COME ON NISSAN, PLEASE RECOGNIZE YOU HAVE A MANUFACTURER DEFECT OR AN ENGINEERING ISSUE AND TAKE RESPONSIBILITY FOR THIS! *TR

2004 NISSAN TITAN: PULLING AWAY FROM A STOP SIGN A LOUD BANG WAS HEARD AND FORWARD MOTION CEASED. ONCE ABLE TO GET BACK UNDERWAY LOUD BANGING WAS HEARD. VEHICLE LURCHED BADLY AROUND CORNERS. TOWED TO DEALER. INSPECTION FOUND REAR DIFFERENTIAL HAD FAILED REQUIRING REPLACEMENT. REPAIR WAS ESTIMATED AT 3771.00 + TAX. VEHICLE HAD 131K MILES. VEHICLE WAS TRADED IN ON PURCHASE OF NEW VEHICLE AT A DISCOUNTED VALUE OF 4000.00 DUE TO REPAIRS REQUIRED. *TR