WITH NO WARNING, THE TIMING CHAIN SKIPPED SPROCKETS ON STARTUP, CAUSING VALVE, CYLINDER, AND CRANKSHAFT DAMAGE. THIS NECCESSITATED REPLACEMENT OF THE ENGINE AT A TOTAL COST OF $3902.21. NISSAN WOULD DO NOTHING ABOUT REIMBURSING ANY OF THE EXPENSE DUE TO A TENSIONER DESIGN DEFECT, SINCE THE AUTO WAS OUT OF WARRANTEE. SINCE INTERN…
Read full complaint
WITH NO WARNING, THE TIMING CHAIN SKIPPED SPROCKETS ON STARTUP, CAUSING VALVE, CYLINDER, AND CRANKSHAFT DAMAGE. THIS NECCESSITATED REPLACEMENT OF THE ENGINE AT A TOTAL COST OF $3902.21. NISSAN WOULD DO NOTHING ABOUT REIMBURSING ANY OF THE EXPENSE DUE TO A TENSIONER DESIGN DEFECT, SINCE THE AUTO WAS OUT OF WARRANTEE. SINCE INTERNAL TIMING CHAINS USUALLY LAST THE USEFUL LIFE OF AN ENGINE, ABOUT 120-140K MILES, THIS WAS VERY PREMATURE. WHILE, THE INCIDENT HAPPENED WHILE THE AUTO WAS STATIONARY, IT COULD VERY WELL HAVE HAPPENED ON A HIGHWAY WHILE TRAVELING AT 70 MPH. THE ENGINE WOULD POSSIBLY SEIZE, WITH AN INSTANT DECELERATION WITH A MANUAL SHIFT CAR.
NHTSA ODI #734785
Mileage unknown · Sep 30, 2000
Engine And Engine CoolingFuel System, Gasoline
VEHICLE BROUGHT TO STAR NISSAN FOR 9/29/00 INSPECTION OF GAS SMELL. MR. JOHN CHOE GAVE WRITTEN REPAIR ESTIMATE. INFORMED BY MR. CHOE THAT GAS LEAK WAS DANGEROUS, AND ALL (4) INJECTORS AND SEALS MUST BE REPLACED AT OWNER'S EXPENSE. SAME FOR REAR ENGINE MOUNT. *AK
NHTSA ODI #732981
Mileage unknown · Oct 7, 1998
Engine And Engine Cooling
ENGINE HEAD GASKET BLEW OUT WHILE DRIVING, CAUSING VEHICLE TO LOSE POWER/STALL. *AK
NHTSA ODI #780962
Mileage unknown · Aug 27, 1998
Engine And Engine Cooling
WHILE DRIVING AT 55 MPH THE CATALYTIC CONVERTER CAME OFF ON THE HIGHWAY, CAUSING THE VEHICLE TO CUT OFF. CONSUMER CONTACTED THE DEALER. THE DEALER TOOK OFF THE OTHER PART OF THE CONVERTER. ALSO THREE OTHER PARTS, INCLUDING THE PARTS FROM THE HEAT SHIELD WERE REPLACED. PLEASE PROVIDE ANY FURTHER DETAILS. *AK
NHTSA ODI #827271
Mileage unknown · Aug 27, 1998
Engine And Engine Cooling
CHAIN ASSEMBLY FAILED.
NHTSA ODI #540510
Mileage unknown · Jul 29, 1998
Engine And Engine Cooling
TIMING CHAIN BRACKET BROKE AND THE VALVES WERE RUINED. DEALER AWARE OF THE PROBLEM, AND STATED THE BRACKET WAS REDESIGNED. NO TSB, NO INDICATION OR WARNING OF INCIDENT WHEN DRIVING. DEALER CANNOT DUPLICATE THE PROBLEM. *AK
NHTSA ODI #826016
Mileage unknown · Jul 5, 1998
Engine And Engine Cooling
TECHNICAL BULLETIN #NTB95-027, ADVISED MECHANICS TO REPLACE PLASTIC SIDE TIMING CHAIN GUIDE WITH A STEEL-BACKED GUIDE AFTER THE PLASTIC ONE BREAKS. FOR THIS VEHICLE THE GUIDE BROKE AND CAUSED THE TIMING CHAIN TO STRIKE THE ENGINE COMPONENTS, RUINING THE ENGINE. THIS RESULTED IN ENGINE SUDDENLY WOULD NOT START, WITH NO PRIOR PR…
Read full complaint
TECHNICAL BULLETIN #NTB95-027, ADVISED MECHANICS TO REPLACE PLASTIC SIDE TIMING CHAIN GUIDE WITH A STEEL-BACKED GUIDE AFTER THE PLASTIC ONE BREAKS. FOR THIS VEHICLE THE GUIDE BROKE AND CAUSED THE TIMING CHAIN TO STRIKE THE ENGINE COMPONENTS, RUINING THE ENGINE. THIS RESULTED IN ENGINE SUDDENLY WOULD NOT START, WITH NO PRIOR PROBLEMS.
NHTSA ODI #537746
Mileage unknown · Aug 15, 1996
Electrical SystemEngine And Engine Cooling
WHILE DRIVING, THE VEHICLE ENGINE SHUTS DOWN AND HAD TO BE STARTED AGAIN. PLEASE DESCRIBE.*AK
NHTSA ODI #800893
Mileage unknown · Aug 15, 1995
Engine And Engine Cooling
TIMING CHAIN FAILED, CAUSING VEHICLE TO STALL/STARTING PROBLEMS. *AK
IT IS POSSIBLE FOR A MIXTURE OF MUD AND SALT TO GET TRAPPED BETWEEN THE FUEL FILLER TUBE AND WHEEL HOUSING. THE TRAPPED MUD AND SALT CAN RESULT IN CORROSION OF THE FUEL FILLER TUBE AND THE WHEEL HOUSING.
Consequence & remedy
Consequence: SIGNIFICANT CORROSION OF THE FUEL FILLER TUBE MAY RESULT IN FUEL LEAKS WHICH IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE. IN ADDITION, THE LEFT REAR SEAT BELT RETRACTOR IS MOUNTED TO THE WHEEL HOUSING AND IN THE EVENT OF SIGNIFICANT CORROSION, AND THE MOUNTING COULD FAIL IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THESE VEHICLES AND CORRECTIVE ACTION WILL BE TAKEN DEPENDING UPON THE EXTENT OF THE CORROSION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
RQ99021 · Fuel Leaks From Fuel Injectors
Opened Nov 2, 1999 · Closed May 22, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
In October of 1995, Nisan conducted a safety improvement campaign, 95I-006.The campaign recalled Maximas (1985-88), 200SX (1987-88), 300ZX (1984-88, and Infinity M30 (1990-92), for fuel leaking from the fuel injectors.The remedy called for a replacement of the fuel injectors and related hoses on the affected vehicles.The recall was influenced by EA94-018, involving over 680,000 1984-89 Maxima and 300ZX vehicles, and was originally initiated as PE94-018 with 25 complaints, for a complaint rate of 4 per 100K.ODI has received 34 complaints for the 1990-92 Stanzas and 240SXs, for fuel leaking in the engine compartment from the fuel injectors, for a complaint rate of 10 per 100K.Fuel in the presence of an ignition source can lead to a vehicle fire.The purpose of this investigation is to evaluate whether the 1990-92 Stanzas and 240SXs should be recalled.
1992 Nissan Stanza Problems, Complaints & Recalls | Skip That Year
Illustration