NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
122 reportsClear category filter122,000 miles · Oct 22, 2025
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. The contact stated that while driving approximately 65 MPH, the engine overheating warning light illuminated. The contact started to drive back to the residence; however, closer to the residence, there was white smoke coming from the exhaust pipes and the vehicle started losing motive power.…
Read full complaint
The contact owns a 2023 Nissan Rogue. The contact stated that while driving approximately 65 MPH, the engine overheating warning light illuminated. The contact started to drive back to the residence; however, closer to the residence, there was white smoke coming from the exhaust pipes and the vehicle started losing motive power. The vehicle was towed to a dealer. The dealer diagnosed the vehicle and determined that there was coolant intrusion in the engine block, causing damage to the head gasket and the engine block. The vehicle was not repaired. The contact was aware that the VIN was included in NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling); and related the failure to the recall. However, the contact called the dealer and was advised that the failure was not covered under the recall. The manufacturer was informed of the failure and confirmed that the failure was not covered under the recall. The failure mileage was approximately 122,000.
NHTSA ODI #11694933
45,000 miles · Oct 20, 2025
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. The contact stated that while driving at an undisclosed speed, the vehicle was vibrating abnormally. No warning lights were illuminated. The contact stated that the vibration occurred especially when the vehicle was idling. The vehicle was taken to the dealer; however, the vehicle was not di…
Read full complaint
The contact owns a 2023 Nissan Rogue. The contact stated that while driving at an undisclosed speed, the vehicle was vibrating abnormally. No warning lights were illuminated. The contact stated that the vibration occurred especially when the vehicle was idling. The vehicle was taken to the dealer; however, the vehicle was not diagnosed. The contact was advised that the failure could possibly be related to an unrepaired recall. The contact had received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling). The manufacturer was not made aware of the failure. The failure mileage was approximately 45,000. The VIN was unavailable.
NHTSA ODI #11694594
35,000 miles · Oct 16, 2025
Engine And Engine Cooling
The contact's friend owns a 2023 Nissan Rogue. The contact stated that while the friend was driving at an undisclosed speed, the vehicle stalled. No warning lights were illuminated. The contact stated that the vehicle stalled several times. The vehicle was driven to the contact's friend's residence. The contact stated that the v…
Read full complaint
The contact's friend owns a 2023 Nissan Rogue. The contact stated that while the friend was driving at an undisclosed speed, the vehicle stalled. No warning lights were illuminated. The contact stated that the vehicle stalled several times. The vehicle was driven to the contact's friend's residence. The contact stated that the vehicle was parked. The vehicle was parked and turned off. The contact stated that while the friend was attempting to restart the vehicle, the vehicle failed to restart. The dealer was made aware of the failure; however, the contact was informed that there were no open recalls on the VIN. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact then received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling); however, the parts were not yet available for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 35,000.
NHTSA ODI #11693909
60,000 miles · Oct 14, 2025
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. The contact received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling). However, the part to do the recall repair was not yet available. The contact stated that while driving at 45 MPH, the vehicle went into LIMP Mode. The message engine malfunction was displayed o…
Read full complaint
The contact owns a 2023 Nissan Rogue. The contact received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling). However, the part to do the recall repair was not yet available. The contact stated that while driving at 45 MPH, the vehicle went into LIMP Mode. The message engine malfunction was displayed on the instrument panel. The contact pulled over to the side of the road. The vehicle was towed to the dealer, who diagnosed that the valve body had failed. The vehicle was repaired. The contact stated that on a separate occasion, while driving at 65 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. In addition, the vehicle stalled. The contact was able to coast to the side of the road. The vehicle was towed to the dealer, where it was diagnosed that the heat oil indicator had overheated. The vehicle was repaired. Most recently, while driving at 25 MPH, the check engine warning light illuminated. The contact drove to the residence. The vehicle was then taken to the dealer, where it was diagnosed with solenoid failure. The vehicle was not repaired due to the cost and parts availability. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 60,000.
NHTSA ODI #11693331
Mileage unknown · Oct 9, 2025
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. The contact received notification of NHTSA Campaign Number: 25V437000(Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. An unknown dealer was co…
Read full complaint
The contact owns a 2023 Nissan Rogue. The contact received notification of NHTSA Campaign Number: 25V437000(Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. An unknown dealer was contacted. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure.
NHTSA ODI #11692445
Mileage unknown · Oct 9, 2025
Engine And Engine Cooling
The contact leased a 2023 Nissan Rogue. The contact received a recall notification of NHTSA Campaign Number: 25V437000(Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that while her daughter was driving at an unknown speed on the highway, the vehicle stalled. The co…
Read full complaint
The contact leased a 2023 Nissan Rogue. The contact received a recall notification of NHTSA Campaign Number: 25V437000(Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that while her daughter was driving at an unknown speed on the highway, the vehicle stalled. The contact stated that the failure occurred on two occasions. There were no warning lights illuminated. The contact was concerned for her daughter's safety because the vehicle was unsafe to drive. The driver called Triple A, and the vehicle was towed to the local dealer, where no Diagnostic Trouble Codes were found. The vehicle was not diagnosed or repaired. The contact called another unknown local dealer, but the dealer was unreachable. The manufacturer was called, but the voicemail message advised calling back in December. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was unknown.
NHTSA ODI #11692391
37,000 miles · Oct 9, 2025
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. The contact received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that occasionally, while driving at various speeds, the ESB warning light illuminated. The local dealer was c…
Read full complaint
The contact owns a 2023 Nissan Rogue. The contact received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that occasionally, while driving at various speeds, the ESB warning light illuminated. The local dealer was contacted; however, the contact was advised that the vehicle did not qualify for a Buy Back and deemed the vehicle safe to drive. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 37,000.
NHTSA ODI #11692359
Mileage unknown · Oct 8, 2025
Engine And Engine Cooling
See attached document for complaint. Please be advised that I received a safety recall notice relative to my leased 2023 Nissan Rogue Platinum involving a manufacturing defect affecting the engine bearings and/or engine components. Bearings and crankshaft are prone to failure, which can result in catastrophic engine damage with…
Read full complaint
See attached document for complaint. Please be advised that I received a safety recall notice relative to my leased 2023 Nissan Rogue Platinum involving a manufacturing defect affecting the engine bearings and/or engine components. Bearings and crankshaft are prone to failure, which can result in catastrophic engine damage with little or no warning. I appreciate that Nissan is going to address this issue, as this issue will increase the risk of a crash . The NHTSA RECALL 25V-437 affects my car. The Vin number is [XXX] . My account number with Nissan is XXXXXXXXXXX·. Since I received this notice, and was scheduled for an oil and filter change, I took my Nissan to Maus Nissan located in Tampa, Florida. I was told that the parts relative to the recall were not in. Since I was going to drive to Miami, Florida and considered the vehicle unsafe to drive from Tampa to Miami I contacted Nissan about a rental vehicle. I was told no, to drive the vehicle and if a problem happened to pull over and take the car to the nearest Nissan Dealer. I rented a vehicle from National Car Rental and have attached a copy of the rental receipt. The amount was $261.66. I respectfully request that Nissan North America reimburse said amount. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11692131
32,000 miles · Oct 8, 2025
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the vehicle. No warning lights were illuminated. In addition, the contact stated that the abnormal sound was persistent and had become louder. The vehicle was taken to the dealer; however, …
Read full complaint
The contact owns a 2023 Nissan Rogue. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the vehicle. No warning lights were illuminated. In addition, the contact stated that the abnormal sound was persistent and had become louder. The vehicle was taken to the dealer; however, the contact was informed to wait until the check engine warning light was illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling); however, the parts for the recall repair were not yet available. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 32,000.
NHTSA ODI #11692126
25,000 miles · Oct 7, 2025
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. The contact received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that while stopped, the vehicle hesitated while the accelerator pedal was depressed. No warning light was ill…
Read full complaint
The contact owns a 2023 Nissan Rogue. The contact received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that while stopped, the vehicle hesitated while the accelerator pedal was depressed. No warning light was illuminated. In addition, the vehicle occasionally experienced a loss of automotive power. The local dealer was contacted; however, the contact was provided with a cost for a diagnostic test. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 25,000.
NHTSA ODI #11691893
Official recalls
6Feb 11, 2026
Nissan North America, Inc. (Nissan) is recalling certain 2023-2025 Rogue vehicles equipped with 3-cylinder 1.5L variable compression turbo (VC-Turbo) engines. Increased temperatures can break down the engine oil, which may cause the engine bearings to seize and become damaged, leading to engine failure.
Consequence & remedy
Consequence: Engine failure can cause a loss of drive power, increasing the risk of a crash. A bearing failure may cause a breach in the engine block, allowing hot oil to be discharged, increasing the risk of an engine fire.
Remedy: Dealers will reprogram the engine control module (ECM) software, inspect for diagnostic trouble codes, and test drive the vehicle, free of charge. The dealer may also inspect the oil pan for metal debris, and replace the engine if necessary. Repairs will be performed free of charge. Owner notification letters were mailed April 8, 2026. Owners may contact Nissan's customer service at 800-647-7261. Nissan's numbers for this recall are R25E2 and R25E3. This recall expands previous NHTSA recall number 25V437. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 27, 2026.
Jun 27, 2025
Nissan North America, Inc. (Nissan) is recalling certain 2021-2024 Rogue, 2019-2020 Altima, 2019-2022 Infiniti QX50, and 2022 Infiniti QX55 vehicles equipped with 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. The engine bearings may have manufacturing defects that can lead to engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash. A bearing failure may cause a breach in the engine block, allowing hot oil to be discharged, increasing the risk of an engine fire.
Remedy: Dealers will reprogram the engine control module (ECM) software, free of charge. Owner letters were mailed April 8, 2026. Owners may contact Nissan's customer service at 800-647-7261 or Infiniti's customer service at 1-800-662-6200. Nissan's numbers for this recall are R25A8/A9 and R25B1/B2.
Feb 28, 2024
Nissan North America, Inc. (Nissan) is recalling certain 2023 Rogue vehicles. The driver and front passenger seat belt pretensioners may have been incorrectly manufactured, which can cause the seat belts to not properly restrain occupants. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection," 209, "Seat Belt Assemblies," and 210 "Seat Belt Assembly Anchorages."
Consequence & remedy
Consequence: Improperly restrained occupants have an increased risk of injury during a crash.
Remedy: Dealers will replace the front seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed April 26, 2024. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PD105.
Feb 27, 2024
Nissan North America, Inc. (Nissan) is recalling certain 2024 Titan, Frontier, Infiniti QX60, Pathfinder, 2023-2024 Sentra, Versa, Kicks, Infiniti QX50, and 2023 Rogue vehicles. Due to a manufacturing issue, the driver's air bag inflator may absorb moisture, and cause the air bag to deploy improperly.
Consequence & remedy
Consequence: An air bag that deploys improperly may not protect the driver as intended during a crash, increasing the risk of injury.
Remedy: Dealers will replace the front driver's air bag assembly, free of charge. Owner notification letters were mailed April 10, 2024. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's numbers for this recall are PD103, PD104, and PMA34.
May 25, 2023
Nissan North America, Inc. (Nissan) is recalling certain 2023 Nissan Rogue vehicles. The fastener in the rear seat belt anchor attachment points may not have been tightened properly and can loosen over time.
Consequence & remedy
Consequence: A loose rear seat belt anchor fastener may not properly restrain an occupant in the event of a crash, increasing the risk of injury.
Remedy: Dealers will inspect and tighten the rear seat belt anchor bolts. Additionally, dealers will apply warning labels to the seat belt attachment points to indicate the bolt size and torque value required for any future seat belt repair. Repairs will be performed free of charge. Owner notification letters are expected to be mailed July 14, 2023. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is PC978, PC979.
Apr 13, 2023
Nissan North America, Inc. (Nissan) is recalling certain 2023 Rogue, Pathfinder, and Infiniti QX60 vehicles. The driver's powered seat may not be fully secured to the seat frame, causing the seat frame welds to detach from the rear inboard seat bracket.
Consequence & remedy
Consequence: An unsecured seat with broken welds may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect the driver's seat rail clearance, and if necessary, replace the driver's seat cushion frame, free of charge. Owner notification letters are expected to be mailed June 10, 2023. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is PC966, PC967.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE24020 · 2021 Nissan Rogue Inner Tie Rod Failures
Opened Aug 5, 2024 · Closed Aug 24, 2026
Status: closed (inferred from source dates) · Steering:linkages:tie Rod Assembly
The Office of Defects Investigation (ODI) opened this investigation to assess allegations of tie rod bending, deformation, or related steering linkage damage in certain 2021 Nissan Rogue vehicles. A bent tie rod can affect wheel alignment and steering geometry, and in some circumstances may result in steering pull, abnormal tire wear, reduced steering precision, difficulty maintaining directional control, or loss of vehicle steering control, increasing the risk of a crash. ODI reviewed Vehicle Owner Questionnaires (VOQs), Early Warning Reporting data, manufacturer field reports, warranty claims, consumer complaints submitted to the manufacturer, and other information provided by Nissan in response to ODI’s information request. ODI also evaluated the reported failure circumstances, vehicle age and mileage, incident severity, and whether the available evidence indicated a defect trend occurring in the absence of external impact or other non-defect causes. Based on the information reviewed, ODI identified a low number of tie rod bending or deformation allegations relative to the subject vehicle population and exposure. The available reports did not indicate a consistent failure pattern, common production period, common mileage, or repeatable failure mode suggestive of a safety-related defect. Many of the reviewed incidents involved circumstances consistent with external loading or impact-related damage, including pothole strikes, curb contact, road debris impacts, prior collision damage, or other abnormal steering/suspension loads. ODI’s analysis did not identify a trend of tie rod bending occurring during normal vehicle operation without evidence of external influence. The complaint and warranty rates were low, and ODI did not identify a pattern of crashes, injuries, or loss-of-control events attributable to a tie rod defect in the subject vehicles. Accordingly, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by new circumstances or additional information. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23023 · Complete Loss Of Motive Power Due To Engine Failure
Opened Dec 13, 2023 · Closed Jul 18, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration