NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
122 reportsClear category filter62,000 miles · Apr 14, 2026
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. While driving at an undisclosed speed, the vehicle suddenly lost automotive power and failed to accelerate as intended. The vehicle was towed to a dealer where it was diagnosed under NHTSA Campaign Number: 26V080000 (Engine and Engine Cooling) and Nissan ID: P4A47 (Turbo Hose). However, the …
Read full complaint
The contact owns a 2023 Nissan Rogue. While driving at an undisclosed speed, the vehicle suddenly lost automotive power and failed to accelerate as intended. The vehicle was towed to a dealer where it was diagnosed under NHTSA Campaign Number: 26V080000 (Engine and Engine Cooling) and Nissan ID: P4A47 (Turbo Hose). However, the dealer declined to perform the recall repairs because the turbocharger hose had ruptured. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 62,000.
NHTSA ODI #11731077
74,200 miles · Apr 10, 2026
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. The contact stated after the vehicle was repaired under NHTSA Campaign Number: 26V080000 (Engine and Engine Cooling), the vehicle experienced stalling and shuddering failures during acceleration. The contact believed that the recall repair failed to correct the safety issue. The vehicle was …
Read full complaint
The contact owns a 2023 Nissan Rogue. The contact stated after the vehicle was repaired under NHTSA Campaign Number: 26V080000 (Engine and Engine Cooling), the vehicle experienced stalling and shuddering failures during acceleration. The contact believed that the recall repair failed to correct the safety issue. The vehicle was repaired; however, the failure persisted. The manufacturer was not notified of the failure. The failure mileage was 74,200.
NHTSA ODI #11730389
85,000 miles · Apr 7, 2026
Engine And Engine Cooling
The contact's fiancé owns a 2023 Nissan Rogue. The contact stated that after the vehicle was repaired under NHTSA Campaign Number: 26V080000 (Engine and Engine Cooling); the vehicle experienced rough idling, and the vehicle lost motive power while driving with the RPM elevated. The dealer and the manufacturer were notified of th…
Read full complaint
The contact's fiancé owns a 2023 Nissan Rogue. The contact stated that after the vehicle was repaired under NHTSA Campaign Number: 26V080000 (Engine and Engine Cooling); the vehicle experienced rough idling, and the vehicle lost motive power while driving with the RPM elevated. The dealer and the manufacturer were notified of the failure, but no assistance was provided. The contact stated that while driving 50 MPH, the vehicle went into LIMP Mode and started sputtering. There was no warning light illuminated. The contact was able to drive to the residence nearby. There was a significant amount of smoke coming from the tailpipe while driving into the driveway. The manufacturer was notified of the failure and advised the contact to tow the vehicle to the dealer and to obtain rental assistance at the owner’s expense. The dealer was notified of the failure, but the vehicle was not diagnosed or repaired. The contact stated that the recall repair failed to fix the vehicle. The failure mileage was approximately 85,000.
NHTSA ODI #11729606
1,000 miles · Apr 6, 2026
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. The contact stated that while driving at an undisclosed speed, the vehicle stalled while driving. While accelerating, the vehicle stalled. There was an abnormal revving of the engine while accelerating. The driver pulled over and restarted the vehicle. The engine and oil light warning lights…
Read full complaint
The contact owns a 2023 Nissan Rogue. The contact stated that while driving at an undisclosed speed, the vehicle stalled while driving. While accelerating, the vehicle stalled. There was an abnormal revving of the engine while accelerating. The driver pulled over and restarted the vehicle. The engine and oil light warning lights were illuminated. The contact related the failure to NHTSA Campaign Number: 26V080000 (Engine and Engine Cooling); and received the recall notification after the failure. The vehicle was taken to the local dealer to reset the system. The vehicle was taken to another local dealer, Tamaroff Nissan Service & Parts (28585 Telegraph Rd, Southfield, MI 48034). The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The contact filed a complaint with the BBB. The failure mileage was approximately 1,000.
NHTSA ODI #11729351
99,000 miles · Mar 13, 2026
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. The contact stated that the check engine warning light was illuminated on the instrument panel. The vehicle was initially taken to an independent mechanic where the DTC for a failure with the turbo charger was retrieved. The vehicle was then taken to the dealer, where no errors codes were re…
Read full complaint
The contact owns a 2023 Nissan Rogue. The contact stated that the check engine warning light was illuminated on the instrument panel. The vehicle was initially taken to an independent mechanic where the DTC for a failure with the turbo charger was retrieved. The vehicle was then taken to the dealer, where no errors codes were retrieved; however, the check engine warning light returned two weeks later, and the vehicle was returned to the dealer. The dealer then performed an engine cylinder pressure test which determined that the cylinder head had failed, and coolant was moving through the turbo charger assembly and the catalytic converter. Due to the damage, the contact was advised to replace the engine. Upon investigation, the contact discovered that the vehicle was included in NHTSA Campaign Number: 26V080000 (Engine and Engine Cooling) which was associated with the failure. The vehicle was taken back to the dealer and was informed that since the vehicle had not produced DTC: P0424 (Engine Oil Pressure Low) the recall did not apply to the vehicle. The manufacturer was notified of the failure, and the contact was informed that the vehicle had qualified for a Goodwill repair. The contact escalated the issue to a supervisor and was informed that any decision made by the manufacturer was the final decision. The contact was provided a case number. The vehicle was not repaired and remained with the dealer. The failure mileage was approximately 99,000.
NHTSA ODI #11724189
46,000 miles · Mar 12, 2026
Engine And Engine Cooling
The contact owns a 2025 Nissan Rogue. The contact stated that while driving at an undisclosed speed, there was an abnormal banging sound coming from the vehicle. In addition, the vehicle jerked back and forth and was shaking abnormally. The check engine warning light was illuminated. There was white smoke coming from the exhaust…
Read full complaint
The contact owns a 2025 Nissan Rogue. The contact stated that while driving at an undisclosed speed, there was an abnormal banging sound coming from the vehicle. In addition, the vehicle jerked back and forth and was shaking abnormally. The check engine warning light was illuminated. There was white smoke coming from the exhaust. The contact attempted to drive the vehicle to the shoulder of the road, and the engine seized. While attempting to restart the vehicle, the vehicle failed to restart. The contact stated that after several attempts, the vehicle restarted. The vehicle was driven a short distance, and the failure reoccurred. The vehicle was repeatedly restarted and driven short distances until the vehicle was onto the shoulder of the road. The vehicle was towed to the dealer, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact was informed that the recall repair could not be performed because some of the parts were unavailable. The contact stated that the vehicle was used for transporting an elderly Aunt and nephew to medical appointments. The contact had received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling). The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 46,000.
NHTSA ODI #11723939
30,000 miles · Mar 12, 2026
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. The contact stated that while driving at an undisclosed speed, engine oil sprayed all over the engine. The vehicle was towed to the dealer, who replaced the engine under NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling); however, the failure recurred two days later, resulting in a…
Read full complaint
The contact owns a 2023 Nissan Rogue. The contact stated that while driving at an undisclosed speed, engine oil sprayed all over the engine. The vehicle was towed to the dealer, who replaced the engine under NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling); however, the failure recurred two days later, resulting in a loss of drive power while driving. The vehicle was towed back to the dealer, who determined that the spark plugs had failed, causing engine damage and low compression in several cylinders. The contact was informed that the engine needed to be replaced for the second time. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure but refused to replace the engine a second time, free of charge. The failure mileage was approximately 30,000. The VIN was unavailable.
NHTSA ODI #11723884
144,000 miles · Mar 4, 2026
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. The contact stated that while driving at an undisclosed speed downhill, the vehicle lost motive power. No warning light was illuminated. The vehicle was towed to the dealer, who informed the contact that oil had accumulated on the engine bearings; however, the failure was unrelated to NHTSA …
Read full complaint
The contact owns a 2023 Nissan Rogue. The contact stated that while driving at an undisclosed speed downhill, the vehicle lost motive power. No warning light was illuminated. The vehicle was towed to the dealer, who informed the contact that oil had accumulated on the engine bearings; however, the failure was unrelated to NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling); which was associated with the VIN. The vehicle was not repaired. The manufacturer was made aware of the failure, and the recall repair was denied due to the mileage. The failure mileage was approximately 144,000.
NHTSA ODI #11722096
7,000 miles · Feb 26, 2026
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. The vehicle was repaired under NHTSA Campaign Number: 25V437000 (ENGINE AND ENGINE COOLING). The contact stated that there was an abnormal sound coming from the engine. Once the accelerator pedal was depressed, the abnormal sound was heard for a short while before the noise ceased. No warnin…
Read full complaint
The contact owns a 2023 Nissan Rogue. The vehicle was repaired under NHTSA Campaign Number: 25V437000 (ENGINE AND ENGINE COOLING). The contact stated that there was an abnormal sound coming from the engine. Once the accelerator pedal was depressed, the abnormal sound was heard for a short while before the noise ceased. No warning lights were illuminated. The contact stated that while driving at a slower speed, the abnormal sound was more frequent. The vehicle was taken to the dealer. However, no cause for the failure was found. The dealer informed the contact that the sound was normal for the size of the engine. The contact stated that the failure persisted. The contact stated that on a separate occasion, the vehicle was taken to the dealer, where it was diagnosed and determined that the Exhaust Gas Recirculation (EGR) valve had failed. The vehicle was not repaired due to the cost. The manufacturer was not notified of the failure. The failure mileage was approximately 7,000.
NHTSA ODI #11720786
Mileage unknown · Feb 18, 2026
Engine And Engine Cooling
See attached document for complaint. I received a safety recall notice on my 2023 Nissan Rogue back in August 2025. We are in December, 2025 and the dealer sti ll states that Nissan has not provided parts to repair my car. The reason for the recall is quite serious yet Nissan has not responded to the problem. I am looking to yo…
Read full complaint
See attached document for complaint. I received a safety recall notice on my 2023 Nissan Rogue back in August 2025. We are in December, 2025 and the dealer sti ll states that Nissan has not provided parts to repair my car. The reason for the recall is quite serious yet Nissan has not responded to the problem. I am looking to you to take what ever action you can to force Nissan to repair my car to a safe condition. If there is any additional action I can take, please advise what t hat may be. This has gone on long enough. Thank you in advance for any help on getting this problem solved that you can provide.
NHTSA ODI #11718733
Official recalls
6Feb 11, 2026
Nissan North America, Inc. (Nissan) is recalling certain 2023-2025 Rogue vehicles equipped with 3-cylinder 1.5L variable compression turbo (VC-Turbo) engines. Increased temperatures can break down the engine oil, which may cause the engine bearings to seize and become damaged, leading to engine failure.
Consequence & remedy
Consequence: Engine failure can cause a loss of drive power, increasing the risk of a crash. A bearing failure may cause a breach in the engine block, allowing hot oil to be discharged, increasing the risk of an engine fire.
Remedy: Dealers will reprogram the engine control module (ECM) software, inspect for diagnostic trouble codes, and test drive the vehicle, free of charge. The dealer may also inspect the oil pan for metal debris, and replace the engine if necessary. Repairs will be performed free of charge. Owner notification letters were mailed April 8, 2026. Owners may contact Nissan's customer service at 800-647-7261. Nissan's numbers for this recall are R25E2 and R25E3. This recall expands previous NHTSA recall number 25V437. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 27, 2026.
Jun 27, 2025
Nissan North America, Inc. (Nissan) is recalling certain 2021-2024 Rogue, 2019-2020 Altima, 2019-2022 Infiniti QX50, and 2022 Infiniti QX55 vehicles equipped with 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. The engine bearings may have manufacturing defects that can lead to engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash. A bearing failure may cause a breach in the engine block, allowing hot oil to be discharged, increasing the risk of an engine fire.
Remedy: Dealers will reprogram the engine control module (ECM) software, free of charge. Owner letters were mailed April 8, 2026. Owners may contact Nissan's customer service at 800-647-7261 or Infiniti's customer service at 1-800-662-6200. Nissan's numbers for this recall are R25A8/A9 and R25B1/B2.
Feb 28, 2024
Nissan North America, Inc. (Nissan) is recalling certain 2023 Rogue vehicles. The driver and front passenger seat belt pretensioners may have been incorrectly manufactured, which can cause the seat belts to not properly restrain occupants. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection," 209, "Seat Belt Assemblies," and 210 "Seat Belt Assembly Anchorages."
Consequence & remedy
Consequence: Improperly restrained occupants have an increased risk of injury during a crash.
Remedy: Dealers will replace the front seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed April 26, 2024. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PD105.
Feb 27, 2024
Nissan North America, Inc. (Nissan) is recalling certain 2024 Titan, Frontier, Infiniti QX60, Pathfinder, 2023-2024 Sentra, Versa, Kicks, Infiniti QX50, and 2023 Rogue vehicles. Due to a manufacturing issue, the driver's air bag inflator may absorb moisture, and cause the air bag to deploy improperly.
Consequence & remedy
Consequence: An air bag that deploys improperly may not protect the driver as intended during a crash, increasing the risk of injury.
Remedy: Dealers will replace the front driver's air bag assembly, free of charge. Owner notification letters were mailed April 10, 2024. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's numbers for this recall are PD103, PD104, and PMA34.
May 25, 2023
Nissan North America, Inc. (Nissan) is recalling certain 2023 Nissan Rogue vehicles. The fastener in the rear seat belt anchor attachment points may not have been tightened properly and can loosen over time.
Consequence & remedy
Consequence: A loose rear seat belt anchor fastener may not properly restrain an occupant in the event of a crash, increasing the risk of injury.
Remedy: Dealers will inspect and tighten the rear seat belt anchor bolts. Additionally, dealers will apply warning labels to the seat belt attachment points to indicate the bolt size and torque value required for any future seat belt repair. Repairs will be performed free of charge. Owner notification letters are expected to be mailed July 14, 2023. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is PC978, PC979.
Apr 13, 2023
Nissan North America, Inc. (Nissan) is recalling certain 2023 Rogue, Pathfinder, and Infiniti QX60 vehicles. The driver's powered seat may not be fully secured to the seat frame, causing the seat frame welds to detach from the rear inboard seat bracket.
Consequence & remedy
Consequence: An unsecured seat with broken welds may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect the driver's seat rail clearance, and if necessary, replace the driver's seat cushion frame, free of charge. Owner notification letters are expected to be mailed June 10, 2023. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is PC966, PC967.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE24020 · 2021 Nissan Rogue Inner Tie Rod Failures
Opened Aug 5, 2024 · Closed Aug 24, 2026
Status: closed (inferred from source dates) · Steering:linkages:tie Rod Assembly
The Office of Defects Investigation (ODI) opened this investigation to assess allegations of tie rod bending, deformation, or related steering linkage damage in certain 2021 Nissan Rogue vehicles. A bent tie rod can affect wheel alignment and steering geometry, and in some circumstances may result in steering pull, abnormal tire wear, reduced steering precision, difficulty maintaining directional control, or loss of vehicle steering control, increasing the risk of a crash. ODI reviewed Vehicle Owner Questionnaires (VOQs), Early Warning Reporting data, manufacturer field reports, warranty claims, consumer complaints submitted to the manufacturer, and other information provided by Nissan in response to ODI’s information request. ODI also evaluated the reported failure circumstances, vehicle age and mileage, incident severity, and whether the available evidence indicated a defect trend occurring in the absence of external impact or other non-defect causes. Based on the information reviewed, ODI identified a low number of tie rod bending or deformation allegations relative to the subject vehicle population and exposure. The available reports did not indicate a consistent failure pattern, common production period, common mileage, or repeatable failure mode suggestive of a safety-related defect. Many of the reviewed incidents involved circumstances consistent with external loading or impact-related damage, including pothole strikes, curb contact, road debris impacts, prior collision damage, or other abnormal steering/suspension loads. ODI’s analysis did not identify a trend of tie rod bending occurring during normal vehicle operation without evidence of external influence. The complaint and warranty rates were low, and ODI did not identify a pattern of crashes, injuries, or loss-of-control events attributable to a tie rod defect in the subject vehicles. Accordingly, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by new circumstances or additional information. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23023 · Complete Loss Of Motive Power Due To Engine Failure
Opened Dec 13, 2023 · Closed Jul 18, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration