IllustrationWhile driving an alert appeared on the dash stating engine malfunction. Speed was reduced instantly which was dangerous as I was driving at high speeds on the freeway with traffic behind me. The accelerator wouldn’t work and I had to immediately pull over.
2022 Nissan Rogue
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2022 Nissan Rogue do not stand out strongly from the model-year median of 320.
About this comparison →How this year compares
Owner complaints by model year
Compare all Rogue years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 57 of 258 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 137 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports1 fire reports2 injury reports
What owners actually said
258 reportsI have a 2022 Nissan Rogue SV that had an engine replaced due to a faulty head gasket in March of 2024 and my vehicle on 6/15/2026 had a rough idle of the engine and irregular RPM's which then led to the RPM's dropping to zero while in a stationary drivethru lane. The vehicle then showed a caution warning indicating to shift the…
Read full complaint
I have a 2022 Nissan Rogue SV that had an engine replaced due to a faulty head gasket in March of 2024 and my vehicle on 6/15/2026 had a rough idle of the engine and irregular RPM's which then led to the RPM's dropping to zero while in a stationary drivethru lane. The vehicle then showed a caution warning indicating to shift the car into Neutral. After getting the car towed to the dealership for diagnostics it was determined that the vehicle requires a new engine. The likely cause according to the service advisor was a failed head gasket, which was the same reason for the first engine replacement. Despite the fact the engine will be covered under warranty, the possibility of the engine failure occurring on the highway while traveling at a high rate of speed, and potentially stranding me on the highway with no warning is a high cause for concern given the vehicle would have went into limp mode, which limits the vehicle to less than 15 MPH.
June 8th, 2026 I was driving to work when my car began to have problems accelerating. My cars acceleration was inconsistent and would not allow for appropriate throttle response. After realizing this was not a fuel delivery problem I tried to come to a safe area to pull over in which I could not do so rounding a roundabout. Aft…
Read full complaint
June 8th, 2026 I was driving to work when my car began to have problems accelerating. My cars acceleration was inconsistent and would not allow for appropriate throttle response. After realizing this was not a fuel delivery problem I tried to come to a safe area to pull over in which I could not do so rounding a roundabout. After making it through the roundabout my cars acceleration was depleting fast. I pulled over as much as I could before I put the car in park and turned the engine off. After the engine was turned off I attempted to restart it. Upon restarting the vehicle began to shake violently as if the back tires were still in rotation and began making an awful noise. I turned the car off and called someone to come assist me. Moments later a random civilian operating under the name “bulldogs handyman and roadside assistance” pulled up behind me. He attempted to help me restart the car to understand what was going on. The car at this point could not turnover. He then asked me “are you out of gas” because visually my car was perfectly fine. I was indeed at half a tank. The man then plugged a code reader into my car and received the code A11P7. At this time a light finally went off on my dash board showing “check engine” symbol. We called Nissan due to the recent recall on my car and had it towed there. The Nissan dealership claims my EGR cooler failed resulting in coolant to enter my engine and overheat the engine causing it to fail. However, Nissan refuses to check the oil pan because the code specifically installed for the recall did not populate. Their diagnoses is plausible however, I just had a multi point inspection 4 months ago by this exact dealership. My cars mileage is 71,315 miles. All maintenance is up to date and I never had a coolant leak. I have had many people INCLUDING EMPLOYEES tell me about the EGR cooler failing and how it is a known problem for Nissan. The EGR cooler needs to be inspected in these models! They are defective.
I own a 2022 Nissan Rogue with approx 71,139 miles on. While driving on the freeway at 65mph, the vehicle suddenly lost power and became disabled. Prior to the failure, the vehicle did not dispaly an overheating warning, coolant warning, or other indication the engine was overheating or experiencing coolant loss. The vehicle was…
Read full complaint
I own a 2022 Nissan Rogue with approx 71,139 miles on. While driving on the freeway at 65mph, the vehicle suddenly lost power and became disabled. Prior to the failure, the vehicle did not dispaly an overheating warning, coolant warning, or other indication the engine was overheating or experiencing coolant loss. The vehicle was being driven normally and was on the way to routine maintenance and fuel stop when the failure occurred. An independent repair facility diagnosed coolant intrusion into the combustion chamber and determined the engine had overheated and required replacement. The vehicle's sudden loss of propulsion occurred without warning creating a safety hazard for myself and my daughter as I was forced to coast to a stop in the Gore Area of the freeway just as you entered the [XXX] from [XXX] due to the inability to maintain speed on the freeway. This was the safest area for us to park but it was terrifying as cars zoomed past us from both sides. I am concerned that the engine failed without adequate warning to the driver and that similar complaints have been noted by several others describing the same issue with the same year, make and model as my car. Multiple reports have said it occurred while on the freeway, making this a greater concern for safety. I took my car to Nissan who stated they see the coolant intrusion, but that it was not covered under recall. I asked what caused the internal leak, to which they replied that would require them to take apart the engine to examine further at my cost. I advised the issue with the car not indicating it was even out of coolant to cause it to overheat was concerning because even if I replace the engine, if the electrical failure isn't addressed I could run into the same issue and this time actually get into an accident that could cause death or serious injury. My car is still at Nissan Mission Hills Dealership and available for inspection upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I own a 2022 Nissan Rogue that has experienced multiple critical safety defects. The vehicle has repeatedly lost engine power without warning, exhibited delayed acceleration, and failed to engage gears—creating dangerous driving conditions that have put me at risk. Service History and Warranty Disputes: February 20, 2026: I br…
Read full complaint
I own a 2022 Nissan Rogue that has experienced multiple critical safety defects. The vehicle has repeatedly lost engine power without warning, exhibited delayed acceleration, and failed to engage gears—creating dangerous driving conditions that have put me at risk. Service History and Warranty Disputes: February 20, 2026: I brought the vehicle to the dealership after experiencing loss of engine power. Diagnostics revealed that the EGR Pressure Sensor had internally shorted, causing a loss of communication diagnostic trouble code. The service department replaced the exhaust gas pressure sensor assembly. Despite the defect being a manufacturing fault and my purchase of a wraparound warranty, I was charged out of pocket for this repair. When I questioned the warranty coverage, I was transferred to consumer affairs and informed that only the dealership determines what is covered—an unsatisfactory response to a valid warranty claim. May 20, 2026: I returned to the dealership after the vehicle lost engine power again and lurched violently forward with jerking motions. The service department replaced the engine mounts. However, after only one day of driving, the same dangerous symptoms returned. May 29, 2026: I brought the vehicle back to the dealership for recurring loss of engine power, delayed acceleration, and violent lurching. The service department replaced the EGR system, which subsequently caused the spark plugs to warp. I was charged $400 for this additional repair, despite these being recurring manufacturing defects that should be covered under warranty. Conclusion: This vehicle demonstrates a pattern of dangerous, unresolved mechanical failures. The repeated issues—combined with warranty coverage disputes and repeated out-of-pocket charges for factory defects—indicate serious safety and reliability concerns with this 2022 Rogue.
The contact owns a 2022 Nissan Rogue. The contact received notification of NHTSA Campaign Number: 25V437000(Engine and Engine Cooling). The vehicle was taken to the dealer where the contact was informed that the dealer reprogrammed the engine control module (ECM) software and test drove the vehicle and found no failures. Despite…
Read full complaint
The contact owns a 2022 Nissan Rogue. The contact received notification of NHTSA Campaign Number: 25V437000(Engine and Engine Cooling). The vehicle was taken to the dealer where the contact was informed that the dealer reprogrammed the engine control module (ECM) software and test drove the vehicle and found no failures. Despite the dealer's claims that they test drove the vehicle, the contact stated that her mileage had not changed upon picking up the vehicle. The contact then stated that while driving at 55 MPH, an audible ding sound emitted from the vehicle as both an "Engine Malfunction" and "Power Reduced Service Now" warning messages appeared on the instrument panel. The vehicle began to slow down upon depression of the accelerator pedal. While at a stop light, the vehicle failed to accelerate above 5 MPH as the contact coasted the vehicle into a parking lot. Due to the failure, the vehicle was towed to another dealer where after the dealer spoke with the manufacturer; they agreed to repair the vehicle under the initial recall. The contact had yet to notify the manufacturer directly about the failure. The vehicle had yet to be repaired and remained in the possession of the dealer. The failure mileage was approximately 35,000
During acceleration engine makes a strange noise as if marbles were rolling around in the engine, or a knocking noise more noticeable when the engine is cold. Dealership says this is a normal sound on Nissan Rogues with the 1.5 cyl turbo charged engine. When I use 89 octane fuel the knocking sound seems less pronounced but, The …
Read full complaint
During acceleration engine makes a strange noise as if marbles were rolling around in the engine, or a knocking noise more noticeable when the engine is cold. Dealership says this is a normal sound on Nissan Rogues with the 1.5 cyl turbo charged engine. When I use 89 octane fuel the knocking sound seems less pronounced but, The manual on my 2022 Nissan Rogue says to use 87 octane. Is there anything we can do if the dealership refuses to acknowledge there is a problem which needs to be addressed?
There have been a couple recalls for Transmission/Engine Bearing and the Nissan Dealership has serviced the recalls. However, today May 8, 2022 while driving on the highway the check engine light appeared and a notification appeared check oil immediately. Then my engine and Transmission blew on the highway at 65 miles per hour c…
Read full complaint
There have been a couple recalls for Transmission/Engine Bearing and the Nissan Dealership has serviced the recalls. However, today May 8, 2022 while driving on the highway the check engine light appeared and a notification appeared check oil immediately. Then my engine and Transmission blew on the highway at 65 miles per hour causing my Nissan to immediately stop. I was able to quickly put my hazard light on an move the Nissan off the highway and shut the vehicle off. After about 10 minutes I started the Nissan Rogue again and checked for any new messages/notifications. The Engine check light was still on and the check oil/change oil immediately appeared. The vehicle would not drive over 15 miles per hour. There was no power. I contacted the Nissan dealership and explained what happened the dealership has my Nissan Rogue and wants me to come in and trade my car to purchase a new vehicle.
The contact owns2022 Nissan Rogue. The contact stated that the vehicle was taken to the dealer for a recall repair and approximately 2 weeks after the repair was done while driving on the roadway, vehicle went into limp mode and vehicle was driven to safety on the side of the road. The vehicle was able to restart after 5 to …
Read full complaint
The contact owns2022 Nissan Rogue. The contact stated that the vehicle was taken to the dealer for a recall repair and approximately 2 weeks after the repair was done while driving on the roadway, vehicle went into limp mode and vehicle was driven to safety on the side of the road. The vehicle was able to restart after 5 to 10 minutes. An engine failure warning displayed on the instrument panel. The vehicle was taken to the dealer where the issue could not be duplicated. The manufacturer was notified of the failure. The approximate failure mileage was 45,423
Subject: Safety Complaint and Recall Concern – 2022 Nissan Rogue Engine Failure and Resulting Consumer Harm (VIN: [XXX] ) To Whom It May Concern, I am submitting this complaint to report a catastrophic engine failure involving my 2022 Nissan Rogue (VIN: [XXX] ), and to request review of potential safety and recall-related conc…
Read full complaint
Subject: Safety Complaint and Recall Concern – 2022 Nissan Rogue Engine Failure and Resulting Consumer Harm (VIN: [XXX] ) To Whom It May Concern, I am submitting this complaint to report a catastrophic engine failure involving my 2022 Nissan Rogue (VIN: [XXX] ), and to request review of potential safety and recall-related concerns. In November 2025, while I still owned and was actively financing this vehicle, it experienced a sudden and complete engine failure attributed to an engine control module (ECM) / engine-related issue. This failure rendered the vehicle inoperable without warning. At the time of failure, I was not informed by the dealership of any existing or potential recall, defect investigation, or manufacturer responsibility that may have applied to this condition. I was advised that the vehicle was no longer viable and was directed into purchasing a replacement vehicle. As a result, approximately $17,958.15 of remaining debt from the failed Rogue was rolled into the financing of a replacement vehicle, creating significant and ongoing financial harm. I have since become aware of recalls and defect investigations affecting Nissan Rogue vehicles in this model range, including conditions involving engine failure risks that may require inspection, repair, or replacement at no cost to the consumer. My concerns are as follows: 1. Whether the engine failure I experienced is related to known defects or recall conditions involving the Nissan Rogue. 2. Whether adequate notice, disclosure, or remedy information was available or communicated to consumers and dealerships at the time of my vehicle failure. 3. Whether this failure represents a broader safety issue that may affect other drivers. 4. Whether consumers may be incurring avoidable financial harm due to lack of awareness of recall-related remedies. This failure created both a potential safety risk and significant financial consequences that I believe may have been preventable if INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA
Official recalls
625V437000 · Engine And Engine Cooling:engine:hard Parts Internal/mechanical
Jun 27, 2025
Nissan North America, Inc. (Nissan) is recalling certain 2021-2024 Rogue, 2019-2020 Altima, 2019-2022 Infiniti QX50, and 2022 Infiniti QX55 vehicles equipped with 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. The engine bearings may have manufacturing defects that can lead to engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash. A bearing failure may cause a breach in the engine block, allowing hot oil to be discharged, increasing the risk of an engine fire.
Remedy: Dealers will reprogram the engine control module (ECM) software, free of charge. Owner letters were mailed April 8, 2026. Owners may contact Nissan's customer service at 800-647-7261 or Infiniti's customer service at 1-800-662-6200. Nissan's numbers for this recall are R25A8/A9 and R25B1/B2.
22V772000 · Back Over Prevention:display Function
Oct 13, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2022 Titan, Titan XD, Frontier, and 2021-2022 Rogue vehicles. The in-vehicle infotainment (IVI) system may continuously reboot when the vehicle is restarted, which can result in an inoperative rearview display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperative rearview camera display reduces the driver's rear visibility, increasing the risk of a crash.
Remedy: The IVI software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters are expected to be mailed November 18, 2022. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's numbers for this recall are R22B8, R22C1, and PC923/25.
22V666000 · Seat Belts: Rear/other:buckle Assembly
Sep 1, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2021-2022 Rogue vehicles. The rear seat belts for the left-hand and right-hand rear seats may not retract properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupant Crash Protection," and 209, "Seatbelt Assemblies."
Consequence & remedy
Consequence: Seat belts that do not retract properly may be difficult to operate, preventing their usage, which can increase the risk of injury in a crash.
Remedy: Dealers will inspect and replace the rear seat belts, as necessary, free of charge. Owner notification letters are expected to be mailed October 27, 2023. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is PC915.
22V660000 · Fuel System, Gasoline:storage:tank Assembly
Aug 31, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2022 Rogue vehicles. The fuel tank may have been punctured when vehicle modifications were performed.
Consequence & remedy
Consequence: A hole in the fuel tank could leak, increasing the risk of fire.
Remedy: Dealers will inspect and replace the fuel tank as necessary, free of charge. Owner notification letters are expected to be mailed September 23, 2022. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PC912.
22V527000 · Back Over Prevention: Sensing System: Camera; Equipment:electrical:infotainment:software
Jul 21, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2021-2022 Rogue, 2022 Frontier, Pathfinder, and Titan rental vehicles. When the Sirius XM subscription is set to "Not Subscribed," it may cause the infotainment head unit to reboot, resulting in an inoperative rearview camera. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperative rearview camera display reduces the driver's rear visibility, increasing the risk of a crash.
Remedy: The Infotainment system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters are expected to be mailed July 29, 2022. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is R22A5 PC901 PC902.
Additional source detail variants (2)
Equipment:electrical:infotainment:software
Nissan North America, Inc. (Nissan) is recalling certain 2021-2022 Rogue, 2022 Frontier, Pathfinder, and Titan rental vehicles. When the Sirius XM subscription is set to "Not Subscribed," it may cause the infotainment head unit to reboot, resulting in an inoperative rearview camera. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An inoperative rearview camera display reduces the driver's rear visibility, increasing the risk of a crash.
Remedy: The Infotainment system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters are expected to be mailed July 29, 2022. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is R22A5 PC901 PC902.
Back Over Prevention: Sensing System: Camera
Nissan North America, Inc. (Nissan) is recalling certain 2021-2022 Rogue, 2022 Frontier, Pathfinder, and Titan rental vehicles. When the Sirius XM subscription is set to "Not Subscribed," it may cause the infotainment head unit to reboot, resulting in an inoperative rearview camera. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An inoperative rearview camera display reduces the driver's rear visibility, increasing the risk of a crash.
Remedy: The Infotainment system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters are expected to be mailed July 29, 2022. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is R22A5 PC901 PC902.
22V259000 · Fuel System, Gasoline:storage:tank Assembly
Apr 14, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2022 Rogue vehicles. Due to a manufacturing error, an area on the bottom wall of the fuel tank may be too thin.
Consequence & remedy
Consequence: Road debris may puncture the thin fuel tank wall, causing a gas leak and increasing the risk of a fire. In addition, the fuel tank may not perform as expected during a crash, increasing the risk of injury.
Remedy: Dealers will replace the fuel tank assembly and install a new lock ring, gasket, and o-ring seal, free of charge. Owner notification letters were mailed May 19, 2022. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PC887.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE24020 · 2021 Nissan Rogue Inner Tie Rod Failures
Opened Aug 5, 2024 · Closed Aug 24, 2026
Status: closed (inferred from source dates) · Steering:linkages:tie Rod Assembly
The Office of Defects Investigation (ODI) opened this investigation to assess allegations of tie rod bending, deformation, or related steering linkage damage in certain 2021 Nissan Rogue vehicles. A bent tie rod can affect wheel alignment and steering geometry, and in some circumstances may result in steering pull, abnormal tire wear, reduced steering precision, difficulty maintaining directional control, or loss of vehicle steering control, increasing the risk of a crash. ODI reviewed Vehicle Owner Questionnaires (VOQs), Early Warning Reporting data, manufacturer field reports, warranty claims, consumer complaints submitted to the manufacturer, and other information provided by Nissan in response to ODI’s information request. ODI also evaluated the reported failure circumstances, vehicle age and mileage, incident severity, and whether the available evidence indicated a defect trend occurring in the absence of external impact or other non-defect causes. Based on the information reviewed, ODI identified a low number of tie rod bending or deformation allegations relative to the subject vehicle population and exposure. The available reports did not indicate a consistent failure pattern, common production period, common mileage, or repeatable failure mode suggestive of a safety-related defect. Many of the reviewed incidents involved circumstances consistent with external loading or impact-related damage, including pothole strikes, curb contact, road debris impacts, prior collision damage, or other abnormal steering/suspension loads. ODI’s analysis did not identify a trend of tie rod bending occurring during normal vehicle operation without evidence of external influence. The complaint and warranty rates were low, and ODI did not identify a pattern of crashes, injuries, or loss-of-control events attributable to a tie rod defect in the subject vehicles. Accordingly, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by new circumstances or additional information. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23023 · Complete Loss Of Motive Power Due To Engine Failure
Opened Dec 13, 2023 · Closed Jul 18, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.