NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
42 reportsClear category filter60,000 miles · Nov 19, 2025
EngineEngine And Engine Cooling
The contact owns a 2022 Nissan Rogue. The contact stated that there was an abnormal clicking sound coming from the vehicle. While driving at 30 MPH, the vehicle stalled with several unknown warning lights illuminated. The contact received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling). The vehicle w…
Read full complaint
The contact owns a 2022 Nissan Rogue. The contact stated that there was an abnormal clicking sound coming from the vehicle. While driving at 30 MPH, the vehicle stalled with several unknown warning lights illuminated. The contact received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling). The vehicle was towed to the local dealer, where the engine mounts were replaced. The vehicle was repaired, but the failure recurred. The manufacturer was contacted and opened a case, but declined the buyback request. The failure mileage was approximately 60,000.
NHTSA ODI #11700314
47,600 miles · Nov 14, 2025
Engine And Engine CoolingPower Train
The contact leased a 2022 Nissan Rogue. The contact stated that while driving at 70 MPH, the AWD warning light illuminated, and the vehicle lost power. The driver was able to pull over safely. Upon investigation, the contact became aware of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling) and stated that the dealer h…
Read full complaint
The contact leased a 2022 Nissan Rogue. The contact stated that while driving at 70 MPH, the AWD warning light illuminated, and the vehicle lost power. The driver was able to pull over safely. Upon investigation, the contact became aware of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling) and stated that the dealer had leased the vehicle with an active recall. The vehicle was taken to the local dealer, but was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 47,600.
NHTSA ODI #11699379
62,000 miles · Nov 4, 2025
Engine And Engine Cooling
The contact owns a 2022 Nissan Rogue. The contact received notification of NHTSA Campaign Number: 25V437000 (ENGINE AND ENGINE COOLING). However, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the…
Read full complaint
The contact owns a 2022 Nissan Rogue. The contact received notification of NHTSA Campaign Number: 25V437000 (ENGINE AND ENGINE COOLING). However, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. No warning light was illuminated. The contact was able to move to the side of the road. The contact called Roadside Assistance, and the vehicle was jump-started. However, the failure persisted. The vehicle was towed to a shopping center, where an AutoZone was located. An employee from Auto Zone used a reader and retrieved DTC: P0012, P0196, C10511c, C108086, and C10B344. The vehicle was then towed to the dealer, where it was diagnosed, and it was determined that the water control valve had failed, and the transmission mount needed to be replaced. The dealer replaced the transmission mount and the water control valve; however, the dealer informed the contact that the vehicle was still vibrating. The contact had safety concerns about driving the vehicle since the part was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 62,000.
NHTSA ODI #11697478
Mileage unknown · Oct 30, 2025
Engine And Engine Cooling
See attached document for complaint. I have gotten all your notices about the recall, and we advised our dealer Courtesy Nissan now Cooley Nissan of Richardson, Texas and t hey said they will advise us when they are prepared to correct the faults. Unfortunately, everything you describe in the literature happened to the above ca…
Read full complaint
See attached document for complaint. I have gotten all your notices about the recall, and we advised our dealer Courtesy Nissan now Cooley Nissan of Richardson, Texas and t hey said they will advise us when they are prepared to correct the faults. Unfortunately, everything you describe in the literature happened to the above car before we received your notices and I spent almost $15,000 correcting the problems. We were advised at the time that we did not put oil in the car causing all the warning lights to come on even though we regularly went to an oil change company to change the oil. I was told they could put a new engine in, and the cost would be about $10,000. I reluctantly agreed and realized the man that advised us to do this at Courtesy/Cooley, I believe, was fired the next day or in any event he was no longer there after that. Sometime after that all our warning lights came on again and we were back at Cooley, and they said the alternator needs changing so they changed that charged me around $2000 and were ready to return the car. That day before picking up the car I was in the sales department trying to trade the car for another car and they advised me they could not do the exchange because the red lights are still on! This is the day I am picking up the car from having the alternator changed and I would be penalized because of the mileage on the car also. I explained I have a new engine and should not be penalized for the old engine's mileage. I went back to the man who serviced the alternator change and he said don't worry about the light being on as they can fix that as they found t he motor mounts broken which were re placed when the new engine was put in. I then authorized them to fix the car so the lights would go off, and it was hit with another big bill. I still cannot believe the car was being returned to me with the warning lights on. I have heard Cooley has a very bad reputation in Dallas and if these are examples then I understand where those comments come from. I would like to be reimburse
NHTSA ODI #11696520
51,000 miles · Oct 23, 2025
Engine And Engine Cooling
The contact owns a 2022 Nissan Rogue. The contact stated that upon starting the vehicle, the vehicle was running abnormally rough. The vehicle returned to normal functionality, but the failure became a regular occurrence. The check engine warning light was illuminated. The vehicle was taken to the dealer, who was unable to provi…
Read full complaint
The contact owns a 2022 Nissan Rogue. The contact stated that upon starting the vehicle, the vehicle was running abnormally rough. The vehicle returned to normal functionality, but the failure became a regular occurrence. The check engine warning light was illuminated. The vehicle was taken to the dealer, who was unable to provide a specific diagnosis in relation to the MIL. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling); the VIN was included, but parts were not yet available to repair the vehicle. The manufacturer was not notified of the failure. The failure mileage was 51,000.
NHTSA ODI #11695300
84,000 miles · Oct 22, 2025
Engine And Engine Cooling
The contact owns a 2022 Nissan Rogue. While the contact's husband was driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact's husband noticed that the vehicle was idling rough. The vehicle accelerated abnormally rough while the accelerator pedal w…
Read full complaint
The contact owns a 2022 Nissan Rogue. While the contact's husband was driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact's husband noticed that the vehicle was idling rough. The vehicle accelerated abnormally rough while the accelerator pedal was depressed. No warning lights were illuminated. The vehicle was driven to the shoulder of the road and turned off. While the contact's husband stated was attempting to restart the vehicle, the vehicle failed to restart. The vehicle was towed to the dealer; however, the dealer who was unable to determine the cause of the failure. The dealer requested that a master technician inspect the vehicle. The master technician inspected the vehicle, and the vehicle was diagnosed with a coolant leakage into the cylinder; however, there was no evidence of a coolant leak coming from the coolant reservoir. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact stated that the vehicle had been with the dealer for a month. The contact received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling); however, the parts for the recall repair were not available. The manufacturer was not made aware of the failure. The failure mileage was approximately 84,000.
NHTSA ODI #11695005
34,000 miles · Oct 9, 2025
Engine And Engine Cooling
The contact owns a 2022 Nissan Rogue. The contact stated that while his wife was driving approximately 45-55 MPH, the vehicle shuddered, and there was white smoke coming out of the exhaust pipes, and the vehicle lost motive power. The contact was also seated in the vehicle during the failure. The contact's wife was able to pull …
Read full complaint
The contact owns a 2022 Nissan Rogue. The contact stated that while his wife was driving approximately 45-55 MPH, the vehicle shuddered, and there was white smoke coming out of the exhaust pipes, and the vehicle lost motive power. The contact was also seated in the vehicle during the failure. The contact's wife was able to pull over to the side of the road. The vehicle failed to restart and was towed to the dealer, where it was diagnosed, and it was determined that the engine was blown and needed to be replaced. The contact later received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling), which the contact related to the failure; however, the part to do the recall repair was not yet available. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer notified the manufacturer of the failure, but no assistance was provided. The failure mileage was approximately 34,000.
NHTSA ODI #11692264
45,848 miles · Oct 6, 2025
Engine And Engine Cooling
The contact owns a 2022 Nissan Rogue. The contact received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while…
Read full complaint
The contact owns a 2022 Nissan Rogue. The contact received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving approximately 35 MPH, the contact stopped and then attempted to accelerate, and the engine revved abnormally, and the vehicle hesitated while accelerating. The vehicle began to decelerate unintendedly with the check engine warning light illuminated and the message “Engine Malfunction/Engine Malfunction Power Reduced Service Now” displayed on the instrument panel. The contact continued to drive to the dealer at approximately 30 MPH. The dealer was contacted and confirmed that the repair was not covered under the recall because the remedy was not available. The contact stated that the engine previously overheated, and the 3-way or multiport valve associated with the radiator and overflow had disengaged. The valve was replaced; however, the failure persisted. The dealer diagnosed the vehicle and determined that the engine needed to be replaced. The engine was replaced in March 2024. The manufacturer was not made aware of the issue. The approximate failure mileage was 45,848. The VIN was not available.
NHTSA ODI #11691543
80,544 miles · Sep 30, 2025
Engine And Engine CoolingPower Train
The contact owns a 2022 Nissan Rogue. The contact stated that while his girlfriend was depressing the accelerator pedal, the AWD warning illuminated, and the vehicle started hesitating. The contact pulled over to the right side of the road and waited for tow truck assistance. An independent mechanic was contacted. The vehicle wa…
Read full complaint
The contact owns a 2022 Nissan Rogue. The contact stated that while his girlfriend was depressing the accelerator pedal, the AWD warning illuminated, and the vehicle started hesitating. The contact pulled over to the right side of the road and waited for tow truck assistance. An independent mechanic was contacted. The vehicle was towed to an independent mechanic, where it was diagnosed and determined that the engine needed to be replaced and that the head gasket was damaged. The vehicle was towed to the dealer, where the same diagnostic information was provided. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that there warranty on the engine. The contact related the failure to NHTSA Campaign Number: 25V437000(ENGINE AND ENGINE COOLING). The contact stated that the manufacturer had exceeded as a reasonable amount of time for the recall repair. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 80,544.
NHTSA ODI #11690557
64,670 miles · Sep 29, 2025
Engine And Engine Cooling
The contact owns a 2022 Nissan Rogue. The contact stated that while driving at an undisclosed speed, the check engine and several other unknown warning lights illuminated. The vehicle was taken to the dealer; however, the diagnostic test was not performed. The vehicle was not diagnosed or repaired by an independent mechanic or d…
Read full complaint
The contact owns a 2022 Nissan Rogue. The contact stated that while driving at an undisclosed speed, the check engine and several other unknown warning lights illuminated. The vehicle was taken to the dealer; however, the diagnostic test was not performed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling); however, the parts were not yet available. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 64,670.
NHTSA ODI #11690425
Official recalls
6Jun 27, 2025
Nissan North America, Inc. (Nissan) is recalling certain 2021-2024 Rogue, 2019-2020 Altima, 2019-2022 Infiniti QX50, and 2022 Infiniti QX55 vehicles equipped with 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. The engine bearings may have manufacturing defects that can lead to engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash. A bearing failure may cause a breach in the engine block, allowing hot oil to be discharged, increasing the risk of an engine fire.
Remedy: Dealers will reprogram the engine control module (ECM) software, free of charge. Owner letters were mailed April 8, 2026. Owners may contact Nissan's customer service at 800-647-7261 or Infiniti's customer service at 1-800-662-6200. Nissan's numbers for this recall are R25A8/A9 and R25B1/B2.
Oct 13, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2022 Titan, Titan XD, Frontier, and 2021-2022 Rogue vehicles. The in-vehicle infotainment (IVI) system may continuously reboot when the vehicle is restarted, which can result in an inoperative rearview display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperative rearview camera display reduces the driver's rear visibility, increasing the risk of a crash.
Remedy: The IVI software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters are expected to be mailed November 18, 2022. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's numbers for this recall are R22B8, R22C1, and PC923/25.
Sep 1, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2021-2022 Rogue vehicles. The rear seat belts for the left-hand and right-hand rear seats may not retract properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupant Crash Protection," and 209, "Seatbelt Assemblies."
Consequence & remedy
Consequence: Seat belts that do not retract properly may be difficult to operate, preventing their usage, which can increase the risk of injury in a crash.
Remedy: Dealers will inspect and replace the rear seat belts, as necessary, free of charge. Owner notification letters are expected to be mailed October 27, 2023. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is PC915.
Aug 31, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2022 Rogue vehicles. The fuel tank may have been punctured when vehicle modifications were performed.
Consequence & remedy
Consequence: A hole in the fuel tank could leak, increasing the risk of fire.
Remedy: Dealers will inspect and replace the fuel tank as necessary, free of charge. Owner notification letters are expected to be mailed September 23, 2022. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PC912.
Jul 21, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2021-2022 Rogue, 2022 Frontier, Pathfinder, and Titan rental vehicles. When the Sirius XM subscription is set to "Not Subscribed," it may cause the infotainment head unit to reboot, resulting in an inoperative rearview camera. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperative rearview camera display reduces the driver's rear visibility, increasing the risk of a crash.
Remedy: The Infotainment system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters are expected to be mailed July 29, 2022. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is R22A5 PC901 PC902.
Additional source detail variants (2)
Equipment:electrical:infotainment:software
Nissan North America, Inc. (Nissan) is recalling certain 2021-2022 Rogue, 2022 Frontier, Pathfinder, and Titan rental vehicles. When the Sirius XM subscription is set to "Not Subscribed," it may cause the infotainment head unit to reboot, resulting in an inoperative rearview camera. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An inoperative rearview camera display reduces the driver's rear visibility, increasing the risk of a crash.
Remedy: The Infotainment system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters are expected to be mailed July 29, 2022. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is R22A5 PC901 PC902.
Back Over Prevention: Sensing System: Camera
Nissan North America, Inc. (Nissan) is recalling certain 2021-2022 Rogue, 2022 Frontier, Pathfinder, and Titan rental vehicles. When the Sirius XM subscription is set to "Not Subscribed," it may cause the infotainment head unit to reboot, resulting in an inoperative rearview camera. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An inoperative rearview camera display reduces the driver's rear visibility, increasing the risk of a crash.
Remedy: The Infotainment system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters are expected to be mailed July 29, 2022. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is R22A5 PC901 PC902.
Apr 14, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2022 Rogue vehicles. Due to a manufacturing error, an area on the bottom wall of the fuel tank may be too thin.
Consequence & remedy
Consequence: Road debris may puncture the thin fuel tank wall, causing a gas leak and increasing the risk of a fire. In addition, the fuel tank may not perform as expected during a crash, increasing the risk of injury.
Remedy: Dealers will replace the fuel tank assembly and install a new lock ring, gasket, and o-ring seal, free of charge. Owner notification letters were mailed May 19, 2022. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PC887.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE24020 · 2021 Nissan Rogue Inner Tie Rod Failures
Opened Aug 5, 2024 · Closed Aug 24, 2026
Status: closed (inferred from source dates) · Steering:linkages:tie Rod Assembly
The Office of Defects Investigation (ODI) opened this investigation to assess allegations of tie rod bending, deformation, or related steering linkage damage in certain 2021 Nissan Rogue vehicles. A bent tie rod can affect wheel alignment and steering geometry, and in some circumstances may result in steering pull, abnormal tire wear, reduced steering precision, difficulty maintaining directional control, or loss of vehicle steering control, increasing the risk of a crash. ODI reviewed Vehicle Owner Questionnaires (VOQs), Early Warning Reporting data, manufacturer field reports, warranty claims, consumer complaints submitted to the manufacturer, and other information provided by Nissan in response to ODI’s information request. ODI also evaluated the reported failure circumstances, vehicle age and mileage, incident severity, and whether the available evidence indicated a defect trend occurring in the absence of external impact or other non-defect causes. Based on the information reviewed, ODI identified a low number of tie rod bending or deformation allegations relative to the subject vehicle population and exposure. The available reports did not indicate a consistent failure pattern, common production period, common mileage, or repeatable failure mode suggestive of a safety-related defect. Many of the reviewed incidents involved circumstances consistent with external loading or impact-related damage, including pothole strikes, curb contact, road debris impacts, prior collision damage, or other abnormal steering/suspension loads. ODI’s analysis did not identify a trend of tie rod bending occurring during normal vehicle operation without evidence of external influence. The complaint and warranty rates were low, and ODI did not identify a pattern of crashes, injuries, or loss-of-control events attributable to a tie rod defect in the subject vehicles. Accordingly, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by new circumstances or additional information. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23023 · Complete Loss Of Motive Power Due To Engine Failure
Opened Dec 13, 2023 · Closed Jul 18, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration