TL*THE CONTACT OWNS A 1996 NISSAN QUEST. WHILE DRIVING TO A STOP. THE CONTACT NOTICED A PUFF OF SMOKE NEAR THE FRONT END OF HER VEHICLE. SHE STOPPED AND EXITED THE VEHICLE TO LOOK UNDER THE HOOD AND NOTICED FLAMES. SHE IMMEDIATELY SLAMMED THE HOOD DOWN AND REMOVED HER CHILDREN FROM THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISH…
Read full complaint
TL*THE CONTACT OWNS A 1996 NISSAN QUEST. WHILE DRIVING TO A STOP. THE CONTACT NOTICED A PUFF OF SMOKE NEAR THE FRONT END OF HER VEHICLE. SHE STOPPED AND EXITED THE VEHICLE TO LOOK UNDER THE HOOD AND NOTICED FLAMES. SHE IMMEDIATELY SLAMMED THE HOOD DOWN AND REMOVED HER CHILDREN FROM THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND STATED THAT A FUEL LEAK WAS THE CAUSE OF THE FAILURE. THERE WERE NO WARNING INDICATORS PRIOR TO THE FIRE. A POLICE REPORT WAS FILED. THE FAILURE MILEAGE WAS 80,000. UPDATED 09/10/08. *LJ UPDATED 09/12/08 *JB
NHTSA ODI #10231389
68,000 miles · May 13, 2003
Electrical SystemEngine And Engine CoolingEquipment
ENGINE KNOCK,ENGINE FAILURE, REPLACE CORRODED THROTTLE BODY, GAS SMELL LEAKS INTO INTERIOR, FAULTY FRONT PASSENGER SEAT BELT RESTRAINT,VEHICLE NOW HAS 110,000 MILES ON IT AND IS IN THE SHOP FOR A NEW FUEL PUMP. EXCESSIVE NOISE POLLUTION WHEN DRIVING, FAULTY REAR HATCH LOCK(ELECTRICAL), FAULTY ELECT. PWR. DOOR LOCKS, LOCKS WHEN N…
Read full complaint
ENGINE KNOCK,ENGINE FAILURE, REPLACE CORRODED THROTTLE BODY, GAS SMELL LEAKS INTO INTERIOR, FAULTY FRONT PASSENGER SEAT BELT RESTRAINT,VEHICLE NOW HAS 110,000 MILES ON IT AND IS IN THE SHOP FOR A NEW FUEL PUMP. EXCESSIVE NOISE POLLUTION WHEN DRIVING, FAULTY REAR HATCH LOCK(ELECTRICAL), FAULTY ELECT. PWR. DOOR LOCKS, LOCKS WHEN NOT TOUCHED. THIS VEHICLE IS WHAT LEMON LAWS WERE INTENDED FOR YET NISSAN IS IN DENIAL ABOUT ALL THE PROBLEMS OWNERS HAVE ENDURED WITH NO COMPENSATION. *JB
NHTSA ODI #10018632
Mileage unknown · Aug 9, 2001
Electrical System
WHEN STARTING VEHICLE BATTERY BLEW UP. CONSUMER REPLACED BATTERY, BUT VEHICLE WAS NOT TAKEN TO DEALER OR MECHANIC TO DETERMINE CAUSE. PLEASE PROVIDE FURTHER INFORMATION.*AK
NHTSA ODI #893909
Mileage unknown · Apr 24, 2001
Electrical System
ON 4/18/01, NOTICED ONE HEADLAMP NOT LIT. ON OPENING THE HOOD, DISCOVERED BOTH MAIN GROUNDING WIRES WERE "EXPLODED" FROM INSIDE THEIR CASINGS. INDIVIDUAL STRANDS WERE IN SOME CASES STILL INTACT WHILE OTHERS WERE COMPLETELY SEPARATED. WIRES NEARBY WERE ALSO SEVERED BY WHAT APPEARS TO BE A MAJOR ELECTRICAL SURGE. AN ADDITIONAL SM…
Read full complaint
ON 4/18/01, NOTICED ONE HEADLAMP NOT LIT. ON OPENING THE HOOD, DISCOVERED BOTH MAIN GROUNDING WIRES WERE "EXPLODED" FROM INSIDE THEIR CASINGS. INDIVIDUAL STRANDS WERE IN SOME CASES STILL INTACT WHILE OTHERS WERE COMPLETELY SEPARATED. WIRES NEARBY WERE ALSO SEVERED BY WHAT APPEARS TO BE A MAJOR ELECTRICAL SURGE. AN ADDITIONAL SMALL SECONDARY GROUNDING WIRE WAS SEPARATED FROM ITS MOUNT. RECONNECTING THAT WIRE "FIXED" THE NONFUNCTIONING HEADLIGHT. NEXT DAY, BOTH HEADLIGHTS WERE OUT. ON OPENING THE HOOD, DISCOVERED BOTH MAIN GROUNDING WIRES COMPLETELY SEPARATED, SECONDARY GROUNDING WIRE SEPARATED, HEADLAMP WIRING CONNECTORS "BURNED" AND ALL CONNECTING WIRES (3 PER) SEPARATED. ELECTRICAL "SCARRING" EVIDENT ON NEARBY METAL AND PLASTIC INSIDE THE ENGINE COMPARTMENT. WIRE AND PLASTIC FRAGMENTS FOUND UNDER AND AROUND AFFECTED AREAS. WINDSHIELD WASHER FILLER CAP AND FUNNEL "SCARRED". ALL OTHER MECHANICAL AND ELECTRICAL FUNCTIONS APPEAR TO OPERATE NORMALLY, INCLUDING TURN INDICATORS AND PARKING LIGHTS. HAS THIS TYPE OF PROBLEM OCCURRED ELSEWHERE? IS THERE REMEDY THROUGH NISSAN EVEN AFTER WARRANTY IS EXPIRED? COPYING TO NISSAN AFTER SUBMITTING TO NHTSA. THANK YOU IN ADVANCE FOR LISTENING AND INVESTIGATING. SINCERELY, [XXX]. *AK PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA ODI #744447
Mileage unknown · Nov 29, 1999
Electrical SystemFire
POSSIBLE WIRING HARNESS FAILURE UNDERHOOD, RESULTED IN FIRE. YH
NHTSA ODI #549752
Mileage unknown · Nov 26, 1999
Electrical System
STEERING WHEEL ELECTRONIC CONTROLS DON'T WORK, DEALER ATTEMPT TO FIX THE PROBLEM BUT IT REOCCURRED. *ET
NHTSA ODI #784326
Mileage unknown · Nov 26, 1999
Electrical System
THE HORN CHIRPS/BEEPS INTERMITTENTLY ALL THE TIME. *ET
NHTSA ODI #784325
Mileage unknown · Sep 22, 1999
Electrical System
DISTRIBUTOR SHAFT SNAPPED. DEALER AGREED IT WAS DEFECTIVE, BUT REFUSED WARRANTY REPAIR OR ADJUSTMENT.
VEHICLE DESCRIPTION: MINIVANS. THE FUEL TANK VENT HOSE ALLOWS AIR TO VENT FROM THE FUEL TANK DURING REFUELING. CRACKS HAVE DEVELOPED IN THE VENT HOSE. IF (1) THE FUEL TANK IS OVERFILLED, NOT ALLOWING EXCESS FUEL IN THE VENT HOSE TO FLOW BACK INTO THE TANK, (2) THE VEHICLE IS DRIVEN ONLY A SHORT DISTANCE AFTER REFUELING AND, (3) THERE IS SUBSEQUENTLY SIGNIFICANT HEATING OF THE FUEL TANK, THE FUEL IN THE TANK CAN EXPAND INTO THE VENT HOSE AND LEAK FUEL.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH POWER WINDOWS THAT CAN BE CLOSED AFTER THE IGNITION KEY IS TURNED TO THE "OFF" POSITION AND THE RIGHT FRONT (PASSENGER) DOOR IS OPENED. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS 118, "POWER-OPERATED WINDOW SYSTEMS."
Consequence & remedy
Consequence: THERE IS THE POTENTIAL FOR UNSUPERVISED CHILDREN TO OPERATE THE POWER WINDOWS, INCREASING THE RISK OF PERSONAL INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH A LABEL REMINDING OWNERS NOT TO LEAVE CHILDREN UNATTENDED BECAUSE THE POWER WINDOWS CAN OPERATE FOR 15 MINUTES AFTER THE VEHICLE IGNITION HAS BEEN TURNED OFF UNLESS THE DRIVER'S DOOR IS OPENED. ALSO INCLUDED ARE INSTRUCTIONS DESCRIBING HOW AND WHERE THIS LABEL IS TO BE INSTALLED. IF AN OWNER PREFERS, THEIR DEALER CAN INSTALL THIS LABEL FOR THEM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA00015 · Fuel Tank Vent Hose Leakage
Opened May 22, 2000 · Closed Jan 4, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
PERIODIC EXPOSURE TO LIQUID GASOLINE MAY RESULT IN EXTRACTION OF ANTIDEGRADANTS FROM THE SUBJECT FUEL TANK VENT HOSE.HOSES WHICH HAVE SUFFERED LOSS OF ANTIDEGRADANT CAN DEVELOP CRACKS IN AREAS OF HIGH STRAIN.FUEL MAY SPRAY OR DRIP FROM CRACKED VENT HOSES FOLLOWING TANK FILL.STARTING AT JOB#1 1998 MY (CALIFORNIA EMISSIONS VEHICLES) AND JOB#1 1999 MY (FEDERAL EMISSIONS VEHICLES), THE SUBJECT VENT HOSE COMPOSITION CHANGED FROM NITRILE RUBBER HOSES WITH CHLOROPRENE RUBBER COVERS (NBR/CR) TO FLUORACBON RUBBER HOSES WHICH AN OUTER LAYER BLEND OF NBR/PVC.THE CHANGES WER MADE TO IMPROVE HYDRACARBON RESISTANCE FOR COMPLAINCE WITH NEW EVAPORATIVE EMISSIONS REGULATIONS.THE MODIFIED HOSES ARE ALSO SIGNIFICANTLY MORE RESISTANT OT DEGRADATION AND CRACIKING. IN A LETTER DATED DECEMBER 14, 2000, NISSAN NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL CAMPAIGN TO REPLACE THE SUBJECT VENT HOSE IN AFFECTD VEHICLES WITH THE REDESIGNED HOSE.NISSAN WILL BEGIN NOTIFYING OWNERS OF THE AFFECTED VEHICLES ON FEBRUARY 5, 2001.NISSAN WILL FINISH ITS OWNER MAILINGS ON SEPTEMBER 10, 2001.OWNERS WILL BE NOTIFIED IN REVERSE ORDER OF VEHICLE AGE.
Additional source detail variants (2)
Vehicle Speed Control:linkages
PERIODIC EXPOSURE TO LIQUID GASOLINE MAY RESULT IN EXTRACTION OF ANTIDEGRADANTS FROM THE SUBJECT FUEL TANK VENT HOSE.HOSES WHICH HAVE SUFFERED LOSS OF ANTIDEGRADANT CAN DEVELOP CRACKS IN AREAS OF HIGH STRAIN.FUEL MAY SPRAY OR DRIP FROM CRACKED VENT HOSES FOLLOWING TANK FILL.STARTING AT JOB#1 1998 MY (CALIFORNIA EMISSIONS VEHICLES) AND JOB#1 1999 MY (FEDERAL EMISSIONS VEHICLES), THE SUBJECT VENT HOSE COMPOSITION CHANGED FROM NITRILE RUBBER HOSES WITH CHLOROPRENE RUBBER COVERS (NBR/CR) TO FLUORACBON RUBBER HOSES WHICH AN OUTER LAYER BLEND OF NBR/PVC.THE CHANGES WER MADE TO IMPROVE HYDRACARBON RESISTANCE FOR COMPLAINCE WITH NEW EVAPORATIVE EMISSIONS REGULATIONS.THE MODIFIED HOSES ARE ALSO SIGNIFICANTLY MORE RESISTANT OT DEGRADATION AND CRACIKING. IN A LETTER DATED DECEMBER 14, 2000, NISSAN NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL CAMPAIGN TO REPLACE THE SUBJECT VENT HOSE IN AFFECTD VEHICLES WITH THE REDESIGNED HOSE.NISSAN WILL BEGIN NOTIFYING OWNERS OF THE AFFECTED VEHICLES ON FEBRUARY 5, 2001.NISSAN WILL FINISH ITS OWNER MAILINGS ON SEPTEMBER 10, 2001.OWNERS WILL BE NOTIFIED IN REVERSE ORDER OF VEHICLE AGE.
Vehicle Speed Control:linkages
PERIODIC EXPOSURE TO LIQUID GASOLINE MAY RESULT IN EXTRACTION OF ANTIDEGRADANTS FROM THE SUBJECT FUEL TANK VENT HOSE.HOSES WHICH HAVE SUFFERED LOSS OF ANTIDEGRADANT CAN DEVELOP CRACKS IN AREAS OF HIGH STRAIN.FUEL MAY SPRAY OR DRIP FROM CRACKED VENT HOSES FOLLOWING TANK FILL.STARTING AT JOB#1 1998 MY (CALIFORNIA EMISSIONS VEHICLES) AND JOB#1 1999 MY (FEDERAL EMISSIONS VEHICLES), THE SUBJECT VENT HOSE COMPOSITION CHANGED FROM NITRILE RUBBER HOSES WITH CHLOROPRENE RUBBER COVERS (NBR/CR) TO FLUORACBON RUBBER HOSES WHICH AN OUTER LAYER BLEND OF NBR/PVC.THE CHANGES WER MADE TO IMPROVE HYDRACARBON RESISTANCE FOR COMPLAINCE WITH NEW EVAPORATIVE EMISSIONS REGULATIONS.THE MODIFIED HOSES ARE ALSO SIGNIFICANTLY MORE RESISTANT OT DEGRADATION AND CRACIKING. IN A LETTER DATED DECEMBER 14, 2000, NISSAN NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL CAMPAIGN TO REPLACE THE SUBJECT VENT HOSE IN AFFECTD VEHICLES WITH THE REDESIGNED HOSE.NISSAN WILL BEGIN NOTIFYING OWNERS OF THE AFFECTED VEHICLES ON FEBRUARY 5, 2001.NISSAN WILL FINISH ITS OWNER MAILINGS ON SEPTEMBER 10, 2001.OWNERS WILL BE NOTIFIED IN REVERSE ORDER OF VEHICLE AGE.
SQ00008 · Unexpected Opening On Sliding Door
Opened May 12, 2000 · Closed Apr 1, 2002
Status: closed (inferred from source dates) · Structure
There is no summary currently available
1996 Nissan Quest Problems, Complaints & Recalls | Skip That Year
Illustration