IllustrationMileage unknown · Feb 26, 1999
Engine And Engine Cooling
NO SUMMARY
NHTSA ODI #703773
1994 Nissan Pathfinder
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1994 Nissan Pathfinder do not stand out strongly from the model-year median of 97.
About this comparison →How this year compares
Owner complaints by model year
Compare all Pathfinder years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 18 of 91 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports2 fire reports1 injury reports
What owners actually said
91 reportsNO SUMMARY
EXHAUST MANIFOLD BOLTS FAILED.
THROTTLE STICKS AT HIGH SPEED DRIVING. POTETIAL CAUSE FOR CRASH WITH FATALITIES.
VEHICLE JUST DIE WHEN RUNNING ON THE ROAD.
INTERMITTENTLY WHILE DRIVING THE VEHICLE WILL IDLE HIGH AND LOW. THEN WITHOUT ANY WARNING THE CAR WILL CUT OFF IN THE MIDDLE OF TRAFFIC. DEALER AND MANUFACTURER HAVE BEEN NOTIFIED. *AK
EXHAUST MANIFOLD STUDS ARE BROKEN FROM FATIGUE ON BOTH LEFT AND RIGHT SIDES OF THE ENGINE, POSSIBLE ENGINEERING/DESIGN DEFECT.
PASSENGER SIDE MANIFOLD STUDS FAILED AT 59000 MILES COVERED BY POWERTRAIN WARRANTY. DRIVER SIDE STUDS FAILED AT 63000 MILES WILL NOT BE COVERED BY WARRANTY. NISSAN IS AWARE OF DEFECT AND HAS ISSUED A TSB, YET FAIL TO ADMIT IT IS AN ENGINEERING FLAW AND WILL NOT ISSUE A RECALL.
UNSPECIFIED.
VEHICLE STALLS AND STOPS RUNNING WITHOUT WARNING OR INDICATION, HIGH SPEEDS ON THE HIGHWAY AND SLOW SPEEDS IN NEIGHBORHOOD, DEALER CONTACTED SEVEN TIMES AND CANNOT DUPLICATE THE PROBLEM. *AK
ENGINE RUNS NORMAL WITH A SLIGHT TICKING NOISE ON THE PASSENGER SIDE, ESPECIALLY DURING ACCELERATION. POSSIBLY THE EXHAUST SYSTEM.
Official recalls
202V125000 · Seat Belts:front:buckle Assembly
May 2, 2002
ON CERTAIN LIGHT DUTY PICKUP TRUCKS, THE LATCH PLATE USED IN THE SEAT BELT BUCKLE WAS NOT MANUFACTURED ACCORDING TO DESIGN DIMENSIONS. IF THE SEAT BELT TONGUE IS INSERTED SLOWLY AT AN ANGLE INTO THE BUCKLE, THERE IS A POSSIBILITY OF PARTIAL ENGAGEMENT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE SEAT BELT TONGUE TO COME OUT OF THE BUCKLE IN THE EVENT OF A COLLISION OR HARD BRAKING OF THE VEHICLE INCREASING THE RISK OF PERSONAL INJURY TO AN OCCUPANT OF THE SEAT.
Remedy: DEALERS WILL INSPECT THE BUCKLE AND, IF NECESSARY, REPLACE THE BUCKLE ASSEMBLY WITH A NEW BUCKLE. OWNER NOTIFICATION BEGAN MAY 22, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.
96V170001 · Seat Belts:front:buckle Assembly
Sep 10, 1996
THE LATCH PLATE USED IN THE SEAT BELT BUCKLE WAS NOT MANUFACTURED ACCORDING TO DESIGN DIMENSIONS. IF THE SEAT BELT TONGUE IS INSERTED SLOWLY AT AN ANGLE INTO THE BUCKLE, THERE IS A POSSIBILITY OF PARTIAL ENGAGEMENT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE SEAT BELT TONGUE TO COME OUT OF THE BUCKLE IN THE EVENT OF A COLLISION OR HARD BRAKING OF THE VEHICLE INCREASING THE RISK OF PERSONAL INJURY TO AN OCCUPANT OF THE SEAT.
Remedy: DEALERS WILL INSPECT THE BUCKLE AND, IF NECESSARY, REPLACE THE BUCKLE ASSEMBLY WITH A NEW BUCKLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ02009 · Seat Belt Latch Failures
Opened Apr 11, 2002 · Closed Dec 17, 2002
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front:buckle Assembly
TAKATA/NISSAN/ISUZU HAVE DETERMINED THAT DURING THE INITIAL RECALL CAMPAIGN (96V-170), SOME VEHICLES THAT CONTAIN DEFECTIVE SEAT BELT BUCKLES WERE INADVERTENTLY OMITTED FROM THE CAMPAIGN. NISSAN WILL RECALL 92,500 MY1994 PATHFINDER AND D21 PICKUP TRUCKS (02V-125).ISUZU WILL RECALL 13,831 MY1994/1995 RODEO, AMIGO, TF AND PICKUP TRUCKS (02V-281) .ISUZU IS ALSO RECALLING 618 MY 1994 HONDA PASSPORT VEHICLES UNDER RECALL 02V-281 (THE HONDA PASSPORT IS MANUFACTURED BY ISUZU FOR HONDA AND IS SIMILAR TO THE ISUZU RODEO VEHICLE). THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Seat Belts:front:buckle Assembly
TAKATA/NISSAN/ISUZU HAVE DETERMINED THAT DURING THE INITIAL RECALL CAMPAIGN (96V-170), SOME VEHICLES THAT CONTAIN DEFECTIVE SEAT BELT BUCKLES WERE INADVERTENTLY OMITTED FROM THE CAMPAIGN. NISSAN WILL RECALL 92,500 MY1994 PATHFINDER AND D21 PICKUP TRUCKS (02V-125).ISUZU WILL RECALL 13,831 MY1994/1995 RODEO, AMIGO, TF AND PICKUP TRUCKS (02V-281) .ISUZU IS ALSO RECALLING 618 MY 1994 HONDA PASSPORT VEHICLES UNDER RECALL 02V-281 (THE HONDA PASSPORT IS MANUFACTURED BY ISUZU FOR HONDA AND IS SIMILAR TO THE ISUZU RODEO VEHICLE). THIS INVESTIGATION IS CLOSED.
Seat Belts:front:buckle Assembly
TAKATA/NISSAN/ISUZU HAVE DETERMINED THAT DURING THE INITIAL RECALL CAMPAIGN (96V-170), SOME VEHICLES THAT CONTAIN DEFECTIVE SEAT BELT BUCKLES WERE INADVERTENTLY OMITTED FROM THE CAMPAIGN. NISSAN WILL RECALL 92,500 MY1994 PATHFINDER AND D21 PICKUP TRUCKS (02V-125).ISUZU WILL RECALL 13,831 MY1994/1995 RODEO, AMIGO, TF AND PICKUP TRUCKS (02V-281) .ISUZU IS ALSO RECALLING 618 MY 1994 HONDA PASSPORT VEHICLES UNDER RECALL 02V-281 (THE HONDA PASSPORT IS MANUFACTURED BY ISUZU FOR HONDA AND IS SIMILAR TO THE ISUZU RODEO VEHICLE). THIS INVESTIGATION IS CLOSED.
Seat Belts
TAKATA/NISSAN/ISUZU HAVE DETERMINED THAT DURING THE INITIAL RECALL CAMPAIGN (96V-170), SOME VEHICLES THAT CONTAIN DEFECTIVE SEAT BELT BUCKLES WERE INADVERTENTLY OMITTED FROM THE CAMPAIGN. NISSAN WILL RECALL 92,500 MY1994 PATHFINDER AND D21 PICKUP TRUCKS (02V-125).ISUZU WILL RECALL 13,831 MY1994/1995 RODEO, AMIGO, TF AND PICKUP TRUCKS (02V-281) .ISUZU IS ALSO RECALLING 618 MY 1994 HONDA PASSPORT VEHICLES UNDER RECALL 02V-281 (THE HONDA PASSPORT IS MANUFACTURED BY ISUZU FOR HONDA AND IS SIMILAR TO THE ISUZU RODEO VEHICLE). THIS INVESTIGATION IS CLOSED.
Seat Belts
TAKATA/NISSAN/ISUZU HAVE DETERMINED THAT DURING THE INITIAL RECALL CAMPAIGN (96V-170), SOME VEHICLES THAT CONTAIN DEFECTIVE SEAT BELT BUCKLES WERE INADVERTENTLY OMITTED FROM THE CAMPAIGN. NISSAN WILL RECALL 92,500 MY1994 PATHFINDER AND D21 PICKUP TRUCKS (02V-125).ISUZU WILL RECALL 13,831 MY1994/1995 RODEO, AMIGO, TF AND PICKUP TRUCKS (02V-281) .ISUZU IS ALSO RECALLING 618 MY 1994 HONDA PASSPORT VEHICLES UNDER RECALL 02V-281 (THE HONDA PASSPORT IS MANUFACTURED BY ISUZU FOR HONDA AND IS SIMILAR TO THE ISUZU RODEO VEHICLE). THIS INVESTIGATION IS CLOSED.