SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

1994 Nissan Pathfinder

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 1994 Nissan Pathfinder do not stand out strongly from the model-year median of 97.

About this comparison →
91Owner complaints

Model-year median: 97

2Recall campaigns

View recall details →

1Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
39
199130
199249
199391
1994170
1995159
1996217
1997
Compare all Pathfinder years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Engine And Engine Cooling
35Structure
23Power Train
10Vehicle Speed Control
7Service Brakes, Hydraulic
5
All reported categories
Tires
5Electrical System
4Visibility
3Equipment
2Fuel System, Gasoline
2Suspension
2Unknown Or Other
2Air Bags
1Latches/locks/linkages
1Parking Brake
1Seats
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

Limited mileage data: 18 of 91 reports include usable mileage. There isn’t enough coverage to show a useful chart.

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Engine And Engine Cooling. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Structure. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Power Train. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

8 crash reports2 fire reports1 injury reports

Engine And Engine Cooling complaints

35 reports
Clear category filter
50,000 miles · Dec 8, 2003
Engine And Engine Cooling

AT ANY SPEED VEHICLE WAS VERY LOUD, AND THE EXHAUST SOUNDED AS IF T MARBLES WERE RATTLING AROUND. A RECALL WAS ISSUED FOR VEHICLES OF SAME MAKE/MODEL AND CERTAIN YEARS, BUT THE CONSUMER'S VEHICLE WAS NOT INCLUDED. THE BOLTS TO THE EXHAUST MANIFOLD OVERHEATED AND BROKE OFF INTO THE MANIFOLD COVER. MANUFACTURER AND THE DEALER…

Read full complaint

AT ANY SPEED VEHICLE WAS VERY LOUD, AND THE EXHAUST SOUNDED AS IF T MARBLES WERE RATTLING AROUND. A RECALL WAS ISSUED FOR VEHICLES OF SAME MAKE/MODEL AND CERTAIN YEARS, BUT THE CONSUMER'S VEHICLE WAS NOT INCLUDED. THE BOLTS TO THE EXHAUST MANIFOLD OVERHEATED AND BROKE OFF INTO THE MANIFOLD COVER. MANUFACTURER AND THE DEALER WERE AWARE OF THE PROBLEM.*AK

NHTSA ODI #10050251

99,420 miles · Nov 4, 2003
Engine And Engine Cooling

UPON TAKING IN THE VEHCILE FOR ROUTINE MAINETENCE, OIL CHANGE, TIRE ROTATION, & WINETRISE SPECIAL. WAS INFORMED THAT MY EXAUSHT MANIFOLD BOLTS WERE BROKEN AND NEEDED REPLACING, AFTER THE VEHICLE WENT THROUGH TWO MAJOR INSPECTIONS NOT OVER A YEAR AGO. 1) FOR PURCHASEING A USED VEHICLE AND 2) FOR OUT OF PROVINCE INSPECTION. NISS…

Read full complaint

UPON TAKING IN THE VEHCILE FOR ROUTINE MAINETENCE, OIL CHANGE, TIRE ROTATION, & WINETRISE SPECIAL. WAS INFORMED THAT MY EXAUSHT MANIFOLD BOLTS WERE BROKEN AND NEEDED REPLACING, AFTER THE VEHICLE WENT THROUGH TWO MAJOR INSPECTIONS NOT OVER A YEAR AGO. 1) FOR PURCHASEING A USED VEHICLE AND 2) FOR OUT OF PROVINCE INSPECTION. NISSAN CANADA KNOWS ABOUT THIS PROBLEM BUT REFUSES TO DO ANYTHING ABOUT THIS PROBLEM.*AK

NHTSA ODI #10045435

100,000 miles · Aug 6, 2003
Engine And Engine Cooling

AT ABOUT 100,000 MILES, A BOLT ON THE EXHAUST MANIFOLD FAILED DUE TO THE DEFECTIVE MANIFOLD WARPING AWAY FROM THE ENGINE. BOLT WAS REPLACED, BUT FUTURE PROBLEMS WERE PREDICTED BY THE MECHANIC.

NHTSA ODI #10030908

106,000 miles · Jul 6, 2003
Engine And Engine Cooling

EXHAUST MANIFOLD BOLTS HAVE FAILED. RECALL NEEDED REGARDLESS OF VEHICLE AGE/MILEAGE. TSD HAS BEEN ISSUED SO COMPANY RECOGNIZES PROBLEM BUT IS NOT TAKING FULL RESPONSIBILITY. ALSO, MANY SIMILAR COMPLAINTS ON THIS SITE.*AK IN ADDITION, VEHICLE SOMETIMES "STICKS" IN 1ST GEAR (A/T). FLUID HAS BEEN CHANGED AND PROBLEM IS INTER…

Read full complaint

EXHAUST MANIFOLD BOLTS HAVE FAILED. RECALL NEEDED REGARDLESS OF VEHICLE AGE/MILEAGE. TSD HAS BEEN ISSUED SO COMPANY RECOGNIZES PROBLEM BUT IS NOT TAKING FULL RESPONSIBILITY. ALSO, MANY SIMILAR COMPLAINTS ON THIS SITE.*AK IN ADDITION, VEHICLE SOMETIMES "STICKS" IN 1ST GEAR (A/T). FLUID HAS BEEN CHANGED AND PROBLEM IS INTERMITTANT. SEVERAL OTHER COMPLAINTS ON THIS SITE AS WELL. SOLUTION WOULD BE HELPFUL.

NHTSA ODI #10025501

98,385 miles · Feb 9, 2003
Engine And Engine Cooling

RIGHT AND LEFT EXHAUST MANIFOLD BOLTS FAILED AND NEEDED TO BE REPLACED.

NHTSA ODI #10005560

Mileage unknown · Nov 26, 2002
Engine And Engine CoolingFire

WHILE DRIVING AT 30 MPH SMOKE STARTED COMING FROM THE HOOD AND THROUGH THE AIR CONDITIONER VENTS ALSO, THE CHECK ENGINE LIGHT CAME. THIS RESULTED IN VEHICLE FIRE. PLEASE PROVIDE MORE DETAILS. TS

NHTSA ODI #8023323

Mileage unknown · Sep 26, 2002
Engine And Engine Cooling

CONSUMER STATES THAT THEY WERE UNABLE TO START VEHICLE,HAD VEHICLE SERVICED.THE ENGINE HAD LOCK UP. DEALERSHIP REFUSE TO SPEAK TO CONSUMER.

NHTSA ODI #8019558

Mileage unknown · Sep 19, 2002
Engine And Engine CoolingUnknown Or Other

ENGINE CHECK LIGHT COMES ON, LOSES POWER STEERING AS A RESULT OF ENGINE FAILURE CAUSED BY A DEFECT IN ENGINE INJECTORS. HAD PART REPLACED TWICE.*AK

NHTSA ODI #8019084

Mileage unknown · Jan 7, 2002
Engine And Engine Cooling

THIS IS THE 13TH MANIFOLD STUD THAT WOULD NEED TO BE REPLACED. WHEN TAKEN TO THE DEALER THEY WANT TO REPLACE ALL 6 AGAIN AT A COST OF $636.00. I HAVE ALREADY HAD THE VEHICLE IN THE SHOP OVER THE PAST 2 YEARS TWICE FOR THE SAME ISSUE. THIS IS ALSO AN EMISSIONS ISSUE AS THE EXHAUST MANIFOLD SEPAREATES FROM THE ENGINE. I HAVE ASLO …

Read full complaint

THIS IS THE 13TH MANIFOLD STUD THAT WOULD NEED TO BE REPLACED. WHEN TAKEN TO THE DEALER THEY WANT TO REPLACE ALL 6 AGAIN AT A COST OF $636.00. I HAVE ALREADY HAD THE VEHICLE IN THE SHOP OVER THE PAST 2 YEARS TWICE FOR THE SAME ISSUE. THIS IS ALSO AN EMISSIONS ISSUE AS THE EXHAUST MANIFOLD SEPAREATES FROM THE ENGINE. I HAVE ASLO LOGGED A COMPLAINT WITH THE EPA. THIS IS A CHRONIC PROBLEM ON THESE VEHICLES AS WELL AS SEVERAL OTHER MODEL YEARS.*AK

NHTSA ODI #756519

Mileage unknown · Dec 27, 2001
Engine And Engine Cooling

4 EXHAUST BOLTS HAVE SHEARED ON BOTH SIDES OF THE ENGINE. DEALERSHIP SAID THEY KNEW ABOUT THIS, BUT ONLY COVERED VEHICLES FROM 1995 AND NEWER AND UNDER 100,000 MILES.*AK

NHTSA ODI #756089

Official recalls

2

02V125000 · Seat Belts:front:buckle Assembly

May 2, 2002

ON CERTAIN LIGHT DUTY PICKUP TRUCKS, THE LATCH PLATE USED IN THE SEAT BELT BUCKLE WAS NOT MANUFACTURED ACCORDING TO DESIGN DIMENSIONS. IF THE SEAT BELT TONGUE IS INSERTED SLOWLY AT AN ANGLE INTO THE BUCKLE, THERE IS A POSSIBILITY OF PARTIAL ENGAGEMENT.

Consequence & remedy

Consequence: THIS CONDITION CAN CAUSE THE SEAT BELT TONGUE TO COME OUT OF THE BUCKLE IN THE EVENT OF A COLLISION OR HARD BRAKING OF THE VEHICLE INCREASING THE RISK OF PERSONAL INJURY TO AN OCCUPANT OF THE SEAT.

Remedy: DEALERS WILL INSPECT THE BUCKLE AND, IF NECESSARY, REPLACE THE BUCKLE ASSEMBLY WITH A NEW BUCKLE. OWNER NOTIFICATION BEGAN MAY 22, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.

96V170001 · Seat Belts:front:buckle Assembly

Sep 10, 1996

THE LATCH PLATE USED IN THE SEAT BELT BUCKLE WAS NOT MANUFACTURED ACCORDING TO DESIGN DIMENSIONS. IF THE SEAT BELT TONGUE IS INSERTED SLOWLY AT AN ANGLE INTO THE BUCKLE, THERE IS A POSSIBILITY OF PARTIAL ENGAGEMENT.

Consequence & remedy

Consequence: THIS CONDITION CAN CAUSE THE SEAT BELT TONGUE TO COME OUT OF THE BUCKLE IN THE EVENT OF A COLLISION OR HARD BRAKING OF THE VEHICLE INCREASING THE RISK OF PERSONAL INJURY TO AN OCCUPANT OF THE SEAT.

Remedy: DEALERS WILL INSPECT THE BUCKLE AND, IF NECESSARY, REPLACE THE BUCKLE ASSEMBLY WITH A NEW BUCKLE.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

RQ02009 · Seat Belt Latch Failures

Opened Apr 11, 2002 · Closed Dec 17, 2002

Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front:buckle Assembly

TAKATA/NISSAN/ISUZU HAVE DETERMINED THAT DURING THE INITIAL RECALL CAMPAIGN (96V-170), SOME VEHICLES THAT CONTAIN DEFECTIVE SEAT BELT BUCKLES WERE INADVERTENTLY OMITTED FROM THE CAMPAIGN. NISSAN WILL RECALL 92,500 MY1994 PATHFINDER AND D21 PICKUP TRUCKS (02V-125).ISUZU WILL RECALL 13,831 MY1994/1995 RODEO, AMIGO, TF AND PICKUP TRUCKS (02V-281) .ISUZU IS ALSO RECALLING 618 MY 1994 HONDA PASSPORT VEHICLES UNDER RECALL 02V-281 (THE HONDA PASSPORT IS MANUFACTURED BY ISUZU FOR HONDA AND IS SIMILAR TO THE ISUZU RODEO VEHICLE). THIS INVESTIGATION IS CLOSED.

Additional source detail variants (4)

Seat Belts:front:buckle Assembly

TAKATA/NISSAN/ISUZU HAVE DETERMINED THAT DURING THE INITIAL RECALL CAMPAIGN (96V-170), SOME VEHICLES THAT CONTAIN DEFECTIVE SEAT BELT BUCKLES WERE INADVERTENTLY OMITTED FROM THE CAMPAIGN. NISSAN WILL RECALL 92,500 MY1994 PATHFINDER AND D21 PICKUP TRUCKS (02V-125).ISUZU WILL RECALL 13,831 MY1994/1995 RODEO, AMIGO, TF AND PICKUP TRUCKS (02V-281) .ISUZU IS ALSO RECALLING 618 MY 1994 HONDA PASSPORT VEHICLES UNDER RECALL 02V-281 (THE HONDA PASSPORT IS MANUFACTURED BY ISUZU FOR HONDA AND IS SIMILAR TO THE ISUZU RODEO VEHICLE). THIS INVESTIGATION IS CLOSED.

Seat Belts:front:buckle Assembly

TAKATA/NISSAN/ISUZU HAVE DETERMINED THAT DURING THE INITIAL RECALL CAMPAIGN (96V-170), SOME VEHICLES THAT CONTAIN DEFECTIVE SEAT BELT BUCKLES WERE INADVERTENTLY OMITTED FROM THE CAMPAIGN. NISSAN WILL RECALL 92,500 MY1994 PATHFINDER AND D21 PICKUP TRUCKS (02V-125).ISUZU WILL RECALL 13,831 MY1994/1995 RODEO, AMIGO, TF AND PICKUP TRUCKS (02V-281) .ISUZU IS ALSO RECALLING 618 MY 1994 HONDA PASSPORT VEHICLES UNDER RECALL 02V-281 (THE HONDA PASSPORT IS MANUFACTURED BY ISUZU FOR HONDA AND IS SIMILAR TO THE ISUZU RODEO VEHICLE). THIS INVESTIGATION IS CLOSED.

Seat Belts

TAKATA/NISSAN/ISUZU HAVE DETERMINED THAT DURING THE INITIAL RECALL CAMPAIGN (96V-170), SOME VEHICLES THAT CONTAIN DEFECTIVE SEAT BELT BUCKLES WERE INADVERTENTLY OMITTED FROM THE CAMPAIGN. NISSAN WILL RECALL 92,500 MY1994 PATHFINDER AND D21 PICKUP TRUCKS (02V-125).ISUZU WILL RECALL 13,831 MY1994/1995 RODEO, AMIGO, TF AND PICKUP TRUCKS (02V-281) .ISUZU IS ALSO RECALLING 618 MY 1994 HONDA PASSPORT VEHICLES UNDER RECALL 02V-281 (THE HONDA PASSPORT IS MANUFACTURED BY ISUZU FOR HONDA AND IS SIMILAR TO THE ISUZU RODEO VEHICLE). THIS INVESTIGATION IS CLOSED.

Seat Belts

TAKATA/NISSAN/ISUZU HAVE DETERMINED THAT DURING THE INITIAL RECALL CAMPAIGN (96V-170), SOME VEHICLES THAT CONTAIN DEFECTIVE SEAT BELT BUCKLES WERE INADVERTENTLY OMITTED FROM THE CAMPAIGN. NISSAN WILL RECALL 92,500 MY1994 PATHFINDER AND D21 PICKUP TRUCKS (02V-125).ISUZU WILL RECALL 13,831 MY1994/1995 RODEO, AMIGO, TF AND PICKUP TRUCKS (02V-281) .ISUZU IS ALSO RECALLING 618 MY 1994 HONDA PASSPORT VEHICLES UNDER RECALL 02V-281 (THE HONDA PASSPORT IS MANUFACTURED BY ISUZU FOR HONDA AND IS SIMILAR TO THE ISUZU RODEO VEHICLE). THIS INVESTIGATION IS CLOSED.