Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1090–25K
11025–50K
13650–75K
15975–100K
149100–150K
28150K+
691 reports with mileage · 109 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Power Train. Review the 265 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 187 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Seats. Review the 111 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports5 fire reports6 injury reports
What owners actually said
800 reports
88,000 miles · Feb 15, 2009
Power Train
AFTER BEING IN STOP AND GO TRAFFIC, MY 2003 NISSAN MURANO SE 2WD DOES NOT ACCELERATE PROPERLY. ONCE THE GAS PEDAL IS PRESSED, THE CAR BARELY STARTS TO MOVE, BUT THE TACHOMETER CONTINUES TO INCREASE. AT ABOUT 3000 RPM, OR ROUGHLY 1-2 SECONDS UNDER NORMAL ACCELERATION FROM A COMPLETE STOP, THE MURANO THEN LURCHES FORWARD. THIS …
Read full complaint
AFTER BEING IN STOP AND GO TRAFFIC, MY 2003 NISSAN MURANO SE 2WD DOES NOT ACCELERATE PROPERLY. ONCE THE GAS PEDAL IS PRESSED, THE CAR BARELY STARTS TO MOVE, BUT THE TACHOMETER CONTINUES TO INCREASE. AT ABOUT 3000 RPM, OR ROUGHLY 1-2 SECONDS UNDER NORMAL ACCELERATION FROM A COMPLETE STOP, THE MURANO THEN LURCHES FORWARD. THIS IS VERY DANGEROUS AND HAPPENS WHEN THE CAR HAS EXPERIENCED LONG PERIODS OF STOP AND GO TRAFFIC OR BEING IDLE. I TOOK IT TO NISSAN AND THEY CLAIMED TO HAVE FIXED THE PROBLEM BY CHANGING THE THROTTLE BODY CHAMBER. THE MURANO DID NOT HAVE ANY MORE PROBLEMS UNTIL ABOUT 4 MONTHS AFTER THE REPAIR. SINCE THEN, IT HAS BEEN ACTING UP AS TRAFFIC CONDITIONS WARRANT. I CAN "RESET" OR STOP THE LURCHING FROM OCCURRING BY TURNING OFF THE IGNITION AND THEN TURNING IT BACK ON. THE PROBLEM IS, I'M USUALLY IN TRAFFIC WHEN I DO THIS, AND THE PROBLEM RESUMES ABOUT 5-10 MINUTES LATER. IF I GET AWAY FROM THE TRAFFIC, STOP AND LET THE CAR SIT FOR A BIT, THEN TURN THE ENGINE BACK ON AND DRIVE IN NORMAL TRAFFIC, THEN THE PROBLEM DOES NOT OCCUR. *TR
NHTSA ODI #10258684
84,186 miles · Feb 14, 2009
Fuel System, Gasoline
FUEL TANK FILLER DOOR WOULD NOT OPEN. DEALER REPLACED RELAY FOR $209.46 ON 7/8/2008. FUEL TANK FILLER DOOR BECAME STUCK CLOSED AGAIN ON 9/23/2008. DEALER RECOMMENDED ADDITIONAL PARTS/LABOR (OPENER MECHANISM) FOR SEVERAL HUNDRED MORE DOLLARS. I HAD THE MECHANIC ADJUST THE LATCH. AS OF 2/14/2009 THERE HAS NOT BEEN A RECURRENCE. *…
Read full complaint
FUEL TANK FILLER DOOR WOULD NOT OPEN. DEALER REPLACED RELAY FOR $209.46 ON 7/8/2008. FUEL TANK FILLER DOOR BECAME STUCK CLOSED AGAIN ON 9/23/2008. DEALER RECOMMENDED ADDITIONAL PARTS/LABOR (OPENER MECHANISM) FOR SEVERAL HUNDRED MORE DOLLARS. I HAD THE MECHANIC ADJUST THE LATCH. AS OF 2/14/2009 THERE HAS NOT BEEN A RECURRENCE. *TR
NHTSA ODI #10258673
52,000 miles · Feb 8, 2009
Seats
I HAVE A 2003 NISSAN MURANO WITHIN THE FIRST THREE YEAR OF OWNERSHIP THE DRIVERS SEAT HAS BROKEN WHILE DRIVING NORMALLY WHEN MAKING A RIGHT HAND TURN. I'VE OWNED THE CAR NOW FOR 5 YEARS HAVE 52K MILES ON IT AND THIS HAS NOW HAPPENED THREE TIMES. THE FIRST TIME IT WAS FIXED ANDUNDER WARRANTY THE SECOND TIME IT WAS FIXED BUT I W…
Read full complaint
I HAVE A 2003 NISSAN MURANO WITHIN THE FIRST THREE YEAR OF OWNERSHIP THE DRIVERS SEAT HAS BROKEN WHILE DRIVING NORMALLY WHEN MAKING A RIGHT HAND TURN. I'VE OWNED THE CAR NOW FOR 5 YEARS HAVE 52K MILES ON IT AND THIS HAS NOW HAPPENED THREE TIMES. THE FIRST TIME IT WAS FIXED ANDUNDER WARRANTY THE SECOND TIME IT WAS FIXED BUT I WAS CHARGED AND THE THIRD TIME JUST HAPPENED ON FEB 7 2009 THE SECOND FIX LAST EDONLY 1 WEEK OVER 1 YEAR. WHICH NEGATES THE REPAIR WARRANTY. I AM UNSURE HOW THIS WILL BE FIXED BUT A DRIVER CAN AND I HAVE LOST CONTROL F THE VEHICLE AS THE SEAT DROPS BACK AND YOU FALL BACKWARD. THIS COUL;D CAUSE AN ACCIDENT AND A POTENTIAL FATAL SITUATION. A SEAT IN A CAR SHOULD NOT REEK ONCE A YEAR. *TR
NHTSA ODI #10257991
76,000 miles · Feb 6, 2009
Power Train
I HAVE A NISSAN 2003 MURANO, WHEN IN A STOPPED POSITION, THE CAR WILL FAIL TO ACCELERATE UNTIL A FEW SECONDS LATER, WHICH CAN CAUSE A SAFETY HAZARD WHEN IN TRAFFIC. I AM NOT THE ONLY OWNER OF THIS TYPE OF VEHICLE THAT HAS THIS ISSUE, THERE ARE MANY OF US. I HAD IT CHECK AND TOLD I NEEDED TO HAVE THE CVT REPLACED. *TR
NHTSA ODI #10257673
52,000 miles · Feb 3, 2009
Power Train
TRANSMISSION FAILURE AT 52,000 MILES. 2003 NISSAN MURANO. *TR
NHTSA ODI #10257328
49,000 miles · Jan 28, 2009
Fuel System, Other
FUEL DOOR LOCKS AND DOES NOT OPEN,ACTUATORS DEFECTIVE 2003 NISSAN MURANO. *TR
NHTSA ODI #10256590
Mileage unknown · Jan 25, 2009
EquipmentFuel System, Gasoline
I OWN A 2003 NISSAN MURANO SL AWD. THE FUEL TANK SHROUD WAS INSTALLED IN COMPLIANCE WITH RECALL CAMPAIGN 06V003000. THE SHROUD IS OF SUCH A BAD DESIGN THAT IT HAS BROKEN IN NORMAL WINTER DRIVING. THE MATERIALS USED ARE TOO WEAK AND THE DESIGN DOES NOT PROVIDE SUFFICIENT PROTECTION FOR THE TANK. OVERALL, THIS DESIGN IS TERRIB…
Read full complaint
I OWN A 2003 NISSAN MURANO SL AWD. THE FUEL TANK SHROUD WAS INSTALLED IN COMPLIANCE WITH RECALL CAMPAIGN 06V003000. THE SHROUD IS OF SUCH A BAD DESIGN THAT IT HAS BROKEN IN NORMAL WINTER DRIVING. THE MATERIALS USED ARE TOO WEAK AND THE DESIGN DOES NOT PROVIDE SUFFICIENT PROTECTION FOR THE TANK. OVERALL, THIS DESIGN IS TERRIBLE, AND DOES NOT SOLVE THE REQUIREMENT OF PROTECTING THE FUEL TANK. NISSAN NEED TO COME UP WITH A BETTER DESIGN THAT BETTER CONFORMS TO THE PROFILE OF THE FUEL TANK--THE CURRENT DESIGN PROTRUDES DOWN TOO FAR AND IS TOO EASILY DAMAGED. *TR
NHTSA ODI #10256292
93,000 miles · Jan 14, 2009
Seats
SEAT RAIL BROKE WHILE GETTING INTO VEHICLE. SECOND TIME THIS HAS HAPPENED FIRST TIME WAS REPAIRED BY DEALERSHIP 15 MONTHS EARLIER. SEAT IS NOW LOOSE AND CAN BE MOVED UP AND DOWN. *TR
NHTSA ODI #10255065
61,000 miles · Jan 14, 2009
Power Train
AT 61000 MILES MY MURANO RIGHT AFTER I BOUGHT IT STARTED TO HAVE A PROBLEM WITH ACCELERATION AT STOP-N-GO TRAFFIC. ALSO IT HAS A BURNING RUBBER SMELL. THE REPLACEMENT OF THE TRANSMISSION IS VERY EXPENSIVE. PLUS THE CAR ONLY HAS 61,000 MILES. *TR
NISSAN IS RECALLING 362,891 MY 2003-2007 MURANO VEHICLES. THE INTAKE AIR DUCTS, WHICH ARE CONNECTED TO THE INTERMEDIATE RESONATOR IN THE AIR INTAKE SYSTEM OF THE ENGINE, MAY SEPARATE FROM THE RESONATOR WITH ENGINE MOVEMENT. THIS SEPARATION OCCURS DUE TO THE PREMATURE AGING OF THE MATERIAL USED IN THE INTAKE AIR DUCTS WHICH CAUSES EXCESSIVE SHRINKING.
Consequence & remedy
Consequence: ENGINE MAY STALL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE/REPAIR THE APPROPRIATE COMPONENTS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 24, 2009. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
ON SOME SPORT UTILITY VEHICLES, IN CERTAIN HIGH SPEED FRONTAL CRASHES, THE WEBBING OF A REAR OUTBOARD SEAT BELT MAY CONTACT THE REAR SEAT BACK HINGE WHERE IT CAN BE CUT BY THE SHARP EDGE OF THE METAL PORTION OF THE HINGE.
Consequence & remedy
Consequence: IF THE WEBBING IS COMPLETELY SEPARATED, IT CAN INCREASE THE RISK OF INJURY TO AN OCCUPANT IN A CRASH.
Remedy: DEALERS WILL INSTALL PROTECTORS OVER THE WEBBING OF THE REAR SEAT BELTS. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO THE LOCATION OF THE FORWARD EDGE OF THE FUEL TANK, IN THE EVENT THAT A VEHICLE FRONT TIRE RUNS OVER A SMALL, SHARP OBJECT IN THE ROAD, CATCHES IT AND PROPELS IT TOWARDS THE REAR OF THE VEHICLE, IT MAY STRIKE AND PUNCTURE THE FUEL TANK.
Consequence & remedy
Consequence: A PUNCTURED TANK COULD INCREASE THE RISK OF A FIRE.
Remedy: DEALERS WILL INSTALL PROTECTORS IN FRONT OF THE TANK FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
ON CERTAIN SPORT UTILITY VEHICLES, THERE IS A POSSIBILITY THAT A WIRE BREAKING INSIDE THE ALTERNATOR COULD STOP THE BATTERY FROM CHARGING.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE CHARGER WARNING AND BRAKE WARNING LAMPS WILL IMMEDIATELY COME ON AND THE BATTERY WILL BEGIN TO DISCHARGE. AFTER A SHORT TIME, THE ENGINE WILL GO INTO A "FALL SAFE" CONDITION WHICH WILL LIMIT VEHICLE SPEED. THE ENGINE WILL STOP RUNNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE ALTERNATOR WITH A NEW VERSION WHICH HAS BEEN MODIFIED TO PREVENT MOVEMENT OF THE COIL. THE RECALL BEGAN ON AUGUST 1, 2005. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
ON CERTAIN PASSENGER VEHICLES, THE CIRCUIT BOARD FOR THE CRANK POSITION SENSOR OR CAM POSITION SENSOR MAY HAVE AN IMPROPER SOLDER JOINT DUE TO SOLDER DEFORMATION CAUSED BY HEAT STRESS ACCELERATED BY THE EXISTENCE OF FLUX RESIDUE DURING THE SOLDERING PROCESS.
Consequence & remedy
Consequence: THIS COULD CAUSE THE "SERVICE ENGINE SOON" WARNING LIGHT TO COME ON, CREATE A NO START CONDITION, CAUSE REDUCED ENGINE POWER, OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING DURING VEHICLE OPERATION, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CRANK POSITION SENSORS. CAMSHAFT POSITION SENSOR(S), AND IN SOME CASES, THE VARIABLE TIMING CONTROL SENSOR(S). VEHICLES INVOLVED IN A PREVIOUS RECALL CAMPAIGN, 01V357, ARE ALSO INCLUDED IN THIS NEW CAMPAIGN. THE REPLACEMENT SENSORS USED IN THAT CAMPAIGN ARE ALSO AFFECTED. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261 OR INFINITI AT 1-800-662-6200.
ON CERTAIN SPORT UTILITY VEHICLES, THE NUT THAT ATTACHES THE TRANSMISSION GEAR SELECTOR SHAFT TO THE CONTROL VALVE LEVER IN THE TRANSMISSION MAY NOT BE ADEQUATELY TIGHTENED. THIS COULD RESULT IN THE TRANSMISSION NOT ACTUALLY BEING IN THE GEAR INDICATED BY THE GEAR SELECTOR LEVER. IN ADDITION, THE TRANSMISSION POSITION DISPLAY IN THE INSTRUMENT PANEL MAY NOT BE ON OR MAY BE INCORRECT.
Consequence & remedy
Consequence: IF THE GEAR DISPLAYED IS DIFFERENT FROM THE GEAR ENGAGED, THIS COULD RESULT IN UNEXPECTED VEHICLE MOVEMENT AND A CRASH.
Remedy: DEALERS WILL CHECK THE AFFECTED NUT IN THE TRANSMISSION SHIFT LEVER LINKAGE, AND TIGHTEN IT IF NECESSARY. OWNER NOTIFICATION BEGAN APRIL 15, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
PE08065 · Driver Seat Anchor Failure
Opened Nov 18, 2008 · Closed Jul 2, 2009
Status: closed (inferred from source dates) · Seats
THIS INVESTIGATION CONCERNS STRUCTURAL FAILURE OF THE ANCHOR/BRACKET ON THE LEFT REAR SIDE OF THE DRIVER'S SEAT.THE CONCERN IS THAT SUCH FAILURES MAY ALTER THE DRIVER'S SEATED POSITION SO AS TO REDUCE EFFECTIVENESS OF THE OCCUPANT PROTECTION SYSTEM OR POTENTIALLY COMPROMISE VEHICLE CONTROL.FAILURE OF THE SUBJECT ANCHOR BRACKET RESULTS FROM METAL FATIGUE AND CAUSES REARWARD TILTING OF THE DRIVER'S SEAT.THESE FAILURES USUALLY OCCUR DURING DRIVER INGRESS BUT MAY ALSO OCCUR WHILE THE VEHICLE IS BEING OPERATED.THE SAFETY RELATED CONCERNS DURING ACTUAL VEHICLE USE WERE NOT VALIDATED BY THIS INVESTIGATION.WHILE THE NUMBER OF COMPLAINTS OF THIS PROBLEM IS RELATIVELY HIGH, ONLY THREE VERY MINOR, UNDOCUMENTED INJURIES WERE REPORTED.THE REPORTED INJURIES OCCURRED DURING DRIVER INGRESS, NOT WHILE THE VEHICLE WAS IN MOTION.INVESTIGATION DISCLOSED THAT THE APPARENT RISK OF COMPROMISE TO VEHICLE CONTROL HAS NOT BEEN DEMONSTRATED.INVESTIGATION ALSO DISCLOSED THAT THE APPARENT RISK OF COLLAPSE OF THE DRIVER'S SEAT BACK HAS NOT BEEN DEMONSTRATEDA SAFETY RELATED DEFECT TREND WAS NOT IDENTIFIED AND THIS INVESTIGATION HAS BEEN CLOSED.
ODI OPENED A PRELIMINARY EVALUATION BASED ON FOUR VEHICLE OWNER QUESTIONNAIRES (VOQ'S) INDICATING THAT THE FUEL TANKS WEREPUNCTURED BY ROAD DEBRIS UNDER NORMAL, NON OFF-ROAD DRIVING CONDITIONS.AS OF NOVEMBER 30, 2005, THE COMPLAINT TOTAL INCREASED TO 12.NISSAN SUPPLIED ODI WITH 31 COMPLAINTS OF FUEL TANK PUNCTURES, INCLUDING 26 NOT PREVIOUSLY KNOWN TO ODI FROM THE VOQ RECORDS. IN A LETTER DATED JANUARY 9, 2006, NISSAN NORTH AMERICA, INC. NOTIFIED ODI OF ITS PLAN TO RECALL APPROXIMATELY 209,000 MODEL YEAR 2003 - 2006 NISSAN MURANO VEHICLES BUILT FROM APRIL 24, 2002 (START OF PRODUCTION OF MY 2003) THROUGH NOVEMBER 24, 2005 (INCLUDING A PORTION OF MY 2006 VEHICLES) TO CORRECT A DEFICIENCY IN FUEL TANK SHIELDING FROM ROAD DEBRIS.THIS RECALL HAS BEEN DESIGNATED NHTSA NO. 06V-003.RECALLED VEHICLES WILL BE FITTED WITH PROTECTIVE SHIELDING FOR THE FRONTAL PORTION OF THE FUEL TANK TO REDUCE THE POSSIBILITY OF PUNCTURE BY PROJECTILES FROM THE FRONT WHEELS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.
Additional source detail variants (2)
Fuel System, Gasoline:storage:tank Assembly
ODI OPENED A PRELIMINARY EVALUATION BASED ON FOUR VEHICLE OWNER QUESTIONNAIRES (VOQ'S) INDICATING THAT THE FUEL TANKS WEREPUNCTURED BY ROAD DEBRIS UNDER NORMAL, NON OFF-ROAD DRIVING CONDITIONS.AS OF NOVEMBER 30, 2005, THE COMPLAINT TOTAL INCREASED TO 12.NISSAN SUPPLIED ODI WITH 31 COMPLAINTS OF FUEL TANK PUNCTURES, INCLUDING 26 NOT PREVIOUSLY KNOWN TO ODI FROM THE VOQ RECORDS. IN A LETTER DATED JANUARY 9, 2006, NISSAN NORTH AMERICA, INC. NOTIFIED ODI OF ITS PLAN TO RECALL APPROXIMATELY 209,000 MODEL YEAR 2003 - 2006 NISSAN MURANO VEHICLES BUILT FROM APRIL 24, 2002 (START OF PRODUCTION OF MY 2003) THROUGH NOVEMBER 24, 2005 (INCLUDING A PORTION OF MY 2006 VEHICLES) TO CORRECT A DEFICIENCY IN FUEL TANK SHIELDING FROM ROAD DEBRIS.THIS RECALL HAS BEEN DESIGNATED NHTSA NO. 06V-003.RECALLED VEHICLES WILL BE FITTED WITH PROTECTIVE SHIELDING FOR THE FRONTAL PORTION OF THE FUEL TANK TO REDUCE THE POSSIBILITY OF PUNCTURE BY PROJECTILES FROM THE FRONT WHEELS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.
Fuel System, Other:storage:tank Assembly
ODI OPENED A PRELIMINARY EVALUATION BASED ON FOUR VEHICLE OWNER QUESTIONNAIRES (VOQ'S) INDICATING THAT THE FUEL TANKS WEREPUNCTURED BY ROAD DEBRIS UNDER NORMAL, NON OFF-ROAD DRIVING CONDITIONS.AS OF NOVEMBER 30, 2005, THE COMPLAINT TOTAL INCREASED TO 12.NISSAN SUPPLIED ODI WITH 31 COMPLAINTS OF FUEL TANK PUNCTURES, INCLUDING 26 NOT PREVIOUSLY KNOWN TO ODI FROM THE VOQ RECORDS. IN A LETTER DATED JANUARY 9, 2006, NISSAN NORTH AMERICA, INC. NOTIFIED ODI OF ITS PLAN TO RECALL APPROXIMATELY 209,000 MODEL YEAR 2003 - 2006 NISSAN MURANO VEHICLES BUILT FROM APRIL 24, 2002 (START OF PRODUCTION OF MY 2003) THROUGH NOVEMBER 24, 2005 (INCLUDING A PORTION OF MY 2006 VEHICLES) TO CORRECT A DEFICIENCY IN FUEL TANK SHIELDING FROM ROAD DEBRIS.THIS RECALL HAS BEEN DESIGNATED NHTSA NO. 06V-003.RECALLED VEHICLES WILL BE FITTED WITH PROTECTIVE SHIELDING FOR THE FRONTAL PORTION OF THE FUEL TANK TO REDUCE THE POSSIBILITY OF PUNCTURE BY PROJECTILES FROM THE FRONT WHEELS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.
ODI RECEIVED 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE ON MY 2003-2004 MURANO (SUBJECT) VEHICLES.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.BASED ON THESE COMPLAINTS, ODI OPENED PE04-077 AND LATER UPGRADED TO EA05-006 FOR THE SUBJECT VEHICLES.DURING EA05-006, ADDITIONAL FAILURE DATA WERE IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.ON JULY 12, 2005, NISSAN NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2003-2005 MURANO VEHICLES PRODUCED FROM APRIL 8, 2002 AND SEPTEMBER 24, 2004 (RECALL 05V-319).THE NOTIFICATION STATED THAT AN OPEN CIRCUIT IN THE ALTERNATOR CAN OCCUR DUE TO WIRE FATIGUE CAUSED BY MOVEMENT OF THE ROTOR COIL DURING RAPID CHANGES IN ENGINE SPEED IN VEHICLES EQUIPPED WITH A CONTINUOUSLY VARIABLE TRANSMISSION (CVT).HIGHER ENGINE COMPARTMENT TEMPERATURE IN THE MURANO COMPARED TO OTHER NISSAN MODELS MAY ALSO BE A CONTRIBUTING FACTOR TO THE WIRE FATIGUE.NISSAN ALSO REPORTED THAT WHEN THIS HAPPENS, THE CHARGE WARNING AND BRAKE WARNING LAMPS WILL ILLUMINATE AND THE BATTERY WILL BEGIN TO DISCHARGE.AFTER A SHORT TIME, THE ENGINE WILL THEN ENTER A FAIL SAFE MODE THAT LIMITS VEHICLE SPEED.VERY SHORTLY AFTER REACHING THIS CONDITION, THE ENGINE WILL STOP.NHTSA'S TESTING, HOWEVER, SHOWED THAT ALTHOUGH THE WARNING LAMPS ILLUMINATE, THE VEHICLE SPEED IS LIMITED TO ONLY 4-7 MPH RATHER THAN WHAT NHTSA CONSIDERS A FAIL SAFE MODE. NISSAN WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY NISSAN DEALER FOR AN ALTERNATOR INSPECTION AND REPLACEMENT, IF REQUIRED.NOTE:SOME VEHICLES MAY HAVE HAD THE NEWLY DESIGNED ALTERNATOR PREVIOUSLY INSTALLED UNDER WARRANTY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (2)
Electrical System:alternator/generator/regulator
ODI RECEIVED 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE ON MY 2003-2004 MURANO (SUBJECT) VEHICLES.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.BASED ON THESE COMPLAINTS, ODI OPENED PE04-077 AND LATER UPGRADED TO EA05-006 FOR THE SUBJECT VEHICLES.DURING EA05-006, ADDITIONAL FAILURE DATA WERE IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.ON JULY 12, 2005, NISSAN NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2003-2005 MURANO VEHICLES PRODUCED FROM APRIL 8, 2002 AND SEPTEMBER 24, 2004 (RECALL 05V-319).THE NOTIFICATION STATED THAT AN OPEN CIRCUIT IN THE ALTERNATOR CAN OCCUR DUE TO WIRE FATIGUE CAUSED BY MOVEMENT OF THE ROTOR COIL DURING RAPID CHANGES IN ENGINE SPEED IN VEHICLES EQUIPPED WITH A CONTINUOUSLY VARIABLE TRANSMISSION (CVT).HIGHER ENGINE COMPARTMENT TEMPERATURE IN THE MURANO COMPARED TO OTHER NISSAN MODELS MAY ALSO BE A CONTRIBUTING FACTOR TO THE WIRE FATIGUE.NISSAN ALSO REPORTED THAT WHEN THIS HAPPENS, THE CHARGE WARNING AND BRAKE WARNING LAMPS WILL ILLUMINATE AND THE BATTERY WILL BEGIN TO DISCHARGE.AFTER A SHORT TIME, THE ENGINE WILL THEN ENTER A FAIL SAFE MODE THAT LIMITS VEHICLE SPEED.VERY SHORTLY AFTER REACHING THIS CONDITION, THE ENGINE WILL STOP.NHTSA'S TESTING, HOWEVER, SHOWED THAT ALTHOUGH THE WARNING LAMPS ILLUMINATE, THE VEHICLE SPEED IS LIMITED TO ONLY 4-7 MPH RATHER THAN WHAT NHTSA CONSIDERS A FAIL SAFE MODE. NISSAN WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY NISSAN DEALER FOR AN ALTERNATOR INSPECTION AND REPLACEMENT, IF REQUIRED.NOTE:SOME VEHICLES MAY HAVE HAD THE NEWLY DESIGNED ALTERNATOR PREVIOUSLY INSTALLED UNDER WARRANTY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Electrical System
ODI RECEIVED 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE ON MY 2003-2004 MURANO (SUBJECT) VEHICLES.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.BASED ON THESE COMPLAINTS, ODI OPENED PE04-077 AND LATER UPGRADED TO EA05-006 FOR THE SUBJECT VEHICLES.DURING EA05-006, ADDITIONAL FAILURE DATA WERE IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.ON JULY 12, 2005, NISSAN NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2003-2005 MURANO VEHICLES PRODUCED FROM APRIL 8, 2002 AND SEPTEMBER 24, 2004 (RECALL 05V-319).THE NOTIFICATION STATED THAT AN OPEN CIRCUIT IN THE ALTERNATOR CAN OCCUR DUE TO WIRE FATIGUE CAUSED BY MOVEMENT OF THE ROTOR COIL DURING RAPID CHANGES IN ENGINE SPEED IN VEHICLES EQUIPPED WITH A CONTINUOUSLY VARIABLE TRANSMISSION (CVT).HIGHER ENGINE COMPARTMENT TEMPERATURE IN THE MURANO COMPARED TO OTHER NISSAN MODELS MAY ALSO BE A CONTRIBUTING FACTOR TO THE WIRE FATIGUE.NISSAN ALSO REPORTED THAT WHEN THIS HAPPENS, THE CHARGE WARNING AND BRAKE WARNING LAMPS WILL ILLUMINATE AND THE BATTERY WILL BEGIN TO DISCHARGE.AFTER A SHORT TIME, THE ENGINE WILL THEN ENTER A FAIL SAFE MODE THAT LIMITS VEHICLE SPEED.VERY SHORTLY AFTER REACHING THIS CONDITION, THE ENGINE WILL STOP.NHTSA'S TESTING, HOWEVER, SHOWED THAT ALTHOUGH THE WARNING LAMPS ILLUMINATE, THE VEHICLE SPEED IS LIMITED TO ONLY 4-7 MPH RATHER THAN WHAT NHTSA CONSIDERS A FAIL SAFE MODE. NISSAN WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY NISSAN DEALER FOR AN ALTERNATOR INSPECTION AND REPLACEMENT, IF REQUIRED.NOTE:SOME VEHICLES MAY HAVE HAD THE NEWLY DESIGNED ALTERNATOR PREVIOUSLY INSTALLED UNDER WARRANTY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
ODI OPENED PE04-077 BASED ON 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.DURING PE04-077, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE . DURING THE INVESTIGATION, NISSAN IDENTIFIED THAT THERE HAD BEEN ALTERNATOR WARRANTY REPLACEMENTS DUE TO AN OPEN CIRCUIT IN THE ROTOR COIL CAUSED BY WIRE FATIGUE. ODI?S ANALYSIS SHOWS FAILURE RATES THAT ARE OF CONCERN TO ODI AND INDICATES THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES.ODI'S ANALYSIS ALSO SHOWS THAT NEARLY ALL OF THE ALTERNATOR WARRANTY CLAIMS SUBMITTED RESULTED IN ENGINE STALLS AND AT LEAST 25% OF THE ENGINE STALLS RESULTED IN A NO RESTART CONDITION.HOWEVER, IN 71% OF THE WARRANTY DATA SUBMITTED, ODI HAS NOT BEEN ABLE TO DETERMINE IF THE CONSUMER COULD RESTART THE VEHICLE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Additional source detail variants (2)
Electrical System:alternator/generator/regulator
ODI OPENED PE04-077 BASED ON 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.DURING PE04-077, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE . DURING THE INVESTIGATION, NISSAN IDENTIFIED THAT THERE HAD BEEN ALTERNATOR WARRANTY REPLACEMENTS DUE TO AN OPEN CIRCUIT IN THE ROTOR COIL CAUSED BY WIRE FATIGUE. ODI?S ANALYSIS SHOWS FAILURE RATES THAT ARE OF CONCERN TO ODI AND INDICATES THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES.ODI'S ANALYSIS ALSO SHOWS THAT NEARLY ALL OF THE ALTERNATOR WARRANTY CLAIMS SUBMITTED RESULTED IN ENGINE STALLS AND AT LEAST 25% OF THE ENGINE STALLS RESULTED IN A NO RESTART CONDITION.HOWEVER, IN 71% OF THE WARRANTY DATA SUBMITTED, ODI HAS NOT BEEN ABLE TO DETERMINE IF THE CONSUMER COULD RESTART THE VEHICLE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Electrical System
ODI OPENED PE04-077 BASED ON 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.DURING PE04-077, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE . DURING THE INVESTIGATION, NISSAN IDENTIFIED THAT THERE HAD BEEN ALTERNATOR WARRANTY REPLACEMENTS DUE TO AN OPEN CIRCUIT IN THE ROTOR COIL CAUSED BY WIRE FATIGUE. ODI?S ANALYSIS SHOWS FAILURE RATES THAT ARE OF CONCERN TO ODI AND INDICATES THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES.ODI'S ANALYSIS ALSO SHOWS THAT NEARLY ALL OF THE ALTERNATOR WARRANTY CLAIMS SUBMITTED RESULTED IN ENGINE STALLS AND AT LEAST 25% OF THE ENGINE STALLS RESULTED IN A NO RESTART CONDITION.HOWEVER, IN 71% OF THE WARRANTY DATA SUBMITTED, ODI HAS NOT BEEN ABLE TO DETERMINE IF THE CONSUMER COULD RESTART THE VEHICLE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
2003 Nissan Murano Problems, Complaints & Recalls | Skip That Year
Illustration