NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
800 reports100,000 miles · May 12, 2009
Power Train
THE POWER ON MY 2003 NISSAN MURANO PERIODICALLY CUTS OUT DURING STOP AND START TRAFFIC, OR HOT CONDITIONS. NOTHING HAPPENS FOR A FEW SECONDS AND THEN THE VEHICLE LURCHES FORWARDS SUDDENLY. THIS HAPPENED TWICE LAST YEAR (AROUND 100K MILES), AND HAS HAPPENED 4 TIMES IN THE LAST MONTH (116K MILES). THIS LACK OF POWER HAS LED TO NUM…
Read full complaint
THE POWER ON MY 2003 NISSAN MURANO PERIODICALLY CUTS OUT DURING STOP AND START TRAFFIC, OR HOT CONDITIONS. NOTHING HAPPENS FOR A FEW SECONDS AND THEN THE VEHICLE LURCHES FORWARDS SUDDENLY. THIS HAPPENED TWICE LAST YEAR (AROUND 100K MILES), AND HAS HAPPENED 4 TIMES IN THE LAST MONTH (116K MILES). THIS LACK OF POWER HAS LED TO NUMEROUS DANGEROUS SITUATIONS WHERE I HAVE BEEN STRANDED IN FRONT OF ONCOMING TRAFFIC, OR SLIPPING DOWN A HILL, AND THE UNPREDICTABLE SURGE OF ACCELERATION IS ALSO A MAJOR PROBLEM. *TR
NHTSA ODI #10268520
40,000 miles · May 12, 2009
Visibility
DRIVER'S SIDE SUN VISOR SUDDENLY FALLS OUT OF POSITION. THIS IS BOTH STARTLING TO THE DRIVER AND BLOCKS HIS/HER VIEW OF THE ROAD. *TR
NHTSA ODI #10268519
93,000 miles · May 11, 2009
Power Train
WHEN CAR IS DRIVEN IN STOP&GO TRAFFIC ON A 70F WARM DAY THE ACCELERATION STOPS WORKING. THE ACCELERATION BECOMES DELAYED AND THEN THE CAR SURGES FORWARD AFTER A 3 SECOND DELAY. VERY DANGEROUS. VERY COMMON PROBLEM WITH THIS CAR & YEAR. NISSAN RECOMMENDS AN EXPENSIVE TRANSMISSION REPAIR - $5K. *TR
NHTSA ODI #10268356
43,000 miles · May 10, 2009
Seats
THE DRIVER SEAT HAS BECOME LOOSE AND "ROCKS" FORWARD AND BACK. THE DRIVER SEAT "ROCKS" ON THE PIVOT OF THE FRONT-LEFT AND REAR-RIGHT. THE ROCKING MOTION OCCURS DURING VEHICLE ACCELERATION AND BRAKING. THE SEAT FAILED ABOUT 1 MONTH AFTER EXTENDED WARRANTY EXPIRED. I CANNOT AFFORD THE $1200 REPAIR AT THIS TIME. THE UNSECURED SEAT …
Read full complaint
THE DRIVER SEAT HAS BECOME LOOSE AND "ROCKS" FORWARD AND BACK. THE DRIVER SEAT "ROCKS" ON THE PIVOT OF THE FRONT-LEFT AND REAR-RIGHT. THE ROCKING MOTION OCCURS DURING VEHICLE ACCELERATION AND BRAKING. THE SEAT FAILED ABOUT 1 MONTH AFTER EXTENDED WARRANTY EXPIRED. I CANNOT AFFORD THE $1200 REPAIR AT THIS TIME. THE UNSECURED SEAT IS DANGEROUS AND THE OPERATOR IS SUBJECT TO INJURY OR DEATH IN THE EVENT OF A CRASH. THE SEAT IS ALSO A DISTRACTION WHILE OPERATING THE VEHICLE, AS AN AUDIBLE SNAP IS HEARD ALONG WITH A JOLTING FORCE CAUSING A SLIGHT REPOSITION OF MY BODY. *TR
NHTSA ODI #10268332
88,000 miles · May 6, 2009
Power Train
TL*THE CONTACT OWNS A 2003 NISSAN MURANO. ON APRIL 15, 2009, THE CONTACT ATTEMPTED TO ACCELERATE PAST 65 MPH, BUT THE VEHICLE WOULD NOT MOVE ANY FASTER. THE VEHICLE THEN BEGAN TO IDLE AND SLOW DOWN ON ITS OWN, AS IF IT SLIPPED INTO NEUTRAL. THE MOTOR CONTINUED TO RUN AND THE CONTACT MANAGED TO PULL THE VEHICLE OVER TO THE SID…
Read full complaint
TL*THE CONTACT OWNS A 2003 NISSAN MURANO. ON APRIL 15, 2009, THE CONTACT ATTEMPTED TO ACCELERATE PAST 65 MPH, BUT THE VEHICLE WOULD NOT MOVE ANY FASTER. THE VEHICLE THEN BEGAN TO IDLE AND SLOW DOWN ON ITS OWN, AS IF IT SLIPPED INTO NEUTRAL. THE MOTOR CONTINUED TO RUN AND THE CONTACT MANAGED TO PULL THE VEHICLE OVER TO THE SIDE OF THE ROAD. HE TURNED OFF AND RESTARTED THE VEHICLE WITHOUT DIFFICULTY. THERE HAD BEEN NO FAILURES WITH THE VEHICLE PRIOR TO THIS INCIDENT. THE DEALER STATED THAT A NEW TRANSMISSION WAS NEEDED. THE FAILURE MILEAGE WAS 88,000.
NHTSA ODI #10267897
92,356 miles · May 6, 2009
Power Train
NISSAN MURANO 2003 STALLS PERIODICALLY DURING STOP AND GO IN TRAFFIC. STOPPED ACCELERATING WHILE DRIVING ON THE HIGHWAY. DEALERSHIP INSISTED THERE WAS NOTHING WRONG FOR SEVERAL MONTHS AND KEPT MAKING REPAIRS TO OTHER COMPONENTS OF THE CAR. HAPPENED AGAIN YESTERDAY AND NOW THEY SAY THE TRANSMISSION NEEDS TO BE REPLACED AT A CO…
Read full complaint
NISSAN MURANO 2003 STALLS PERIODICALLY DURING STOP AND GO IN TRAFFIC. STOPPED ACCELERATING WHILE DRIVING ON THE HIGHWAY. DEALERSHIP INSISTED THERE WAS NOTHING WRONG FOR SEVERAL MONTHS AND KEPT MAKING REPAIRS TO OTHER COMPONENTS OF THE CAR. HAPPENED AGAIN YESTERDAY AND NOW THEY SAY THE TRANSMISSION NEEDS TO BE REPLACED AT A COST OF ALMOST $6,000.00. VEHICLE HAS CVT TRANSMISSION AND HAS 94,000 MILES ON IT.
NHTSA ODI #10267838
88,316 miles · May 2, 2009
Power Train
MY 2003 NISSAN MURANO AWD HAD 88,300 MILES ON IT, AND BEGAN VIBRATING WHILE I WAS ON A 4-LANE ROAD. AS I TRIED TO PULL IT OFF INTO A PARKING LOT ON THE LEFT, IT CAME OUT OF GEAR, AND STOPPED IN THE CENTER OF A BUSY INTERSECTION. IT WOULD NOT GO BACK INTO GEAR, AND WOULD NOT REV, BUT IT WAS IDLING. THE CHECK ENGINE LIGHT NEVER…
Read full complaint
MY 2003 NISSAN MURANO AWD HAD 88,300 MILES ON IT, AND BEGAN VIBRATING WHILE I WAS ON A 4-LANE ROAD. AS I TRIED TO PULL IT OFF INTO A PARKING LOT ON THE LEFT, IT CAME OUT OF GEAR, AND STOPPED IN THE CENTER OF A BUSY INTERSECTION. IT WOULD NOT GO BACK INTO GEAR, AND WOULD NOT REV, BUT IT WAS IDLING. THE CHECK ENGINE LIGHT NEVER CAME ON. IT WAS A DANGEROUS SITUATION, AND I CALLED 911, BECAUSE I WAS AFRAID THAT MY STALLED CAR WOULD CAUSE AN ACCIDENT. THEN 2 MEN OFFERED TO HELP PUSH THE CAR INTO THE PARKING LOT. THEY DID, BUT THEY PUT THEMSELVES IN HARM'S WAY IN THE STILL BUSY INTERSECTION. TWO NISSAN DEALERSHIPS DIAGNOSED THE CAR AS NEEDING A NEW TRANSMISSION, AND I HAVE HAD TO REPLACE IT AT A COST OF $6000. *TR
NHTSA ODI #10267546
Mileage unknown · Apr 30, 2009
Seats
2003 NISSAN MURANO. DRIVERS SEAT MOUNT, LEFT REAR, BROKE IN 2006 (OUT OF WARRANTY, NORMAL WEIGHT DRIVERS). AFTER MANY CALLS TO NISSAN CUSTOMER SERVICE, THEY COVERED THE REPAIR ($900). NOW, APRIL 2009, SAME SEAT MOUNT BROKE. THIS IS AN ISSUE THAT NEEDS TO HAVE A RECALL. MANY COMPLAINTS FOUND ONLINE OF THIS ISSUE NOT ONLY IN …
Read full complaint
2003 NISSAN MURANO. DRIVERS SEAT MOUNT, LEFT REAR, BROKE IN 2006 (OUT OF WARRANTY, NORMAL WEIGHT DRIVERS). AFTER MANY CALLS TO NISSAN CUSTOMER SERVICE, THEY COVERED THE REPAIR ($900). NOW, APRIL 2009, SAME SEAT MOUNT BROKE. THIS IS AN ISSUE THAT NEEDS TO HAVE A RECALL. MANY COMPLAINTS FOUND ONLINE OF THIS ISSUE NOT ONLY IN 2003 MODEL, BUT ALSO 2004 AND 2005. THIS IS A SAFETY ISSUE! A $900 REPAIR IS NOT SOMETHING EVERYONE CAN AFFORD AND DRIVING WITH A BROKEN SEAT MOUNT IS EXTREMELY DANGEROUS! *TR
NHTSA ODI #10267403
67,100 miles · Apr 17, 2009
Engine And Engine Cooling
VEHICLE "SERVICE ENGINE SOON" LIGHT HAS COME ON, VEHICLE HAS VARYING PAUSES BETWEEN PRESSING GAS AND VEHICLE REACTION, VEHICLE STOPPED RUNNING WHILE DRIVING (WITH MY PREGNANT WIFE DRIVING AND 18 MONTH OLD SON IN VEHICLE), AND RESTART HAS LONG CRANK DURATION. ON APRIL 17TH, VEHICLE TURNED OFF AT STOP LIGHT WHILE I WAS DRIVING AN…
Read full complaint
VEHICLE "SERVICE ENGINE SOON" LIGHT HAS COME ON, VEHICLE HAS VARYING PAUSES BETWEEN PRESSING GAS AND VEHICLE REACTION, VEHICLE STOPPED RUNNING WHILE DRIVING (WITH MY PREGNANT WIFE DRIVING AND 18 MONTH OLD SON IN VEHICLE), AND RESTART HAS LONG CRANK DURATION. ON APRIL 17TH, VEHICLE TURNED OFF AT STOP LIGHT WHILE I WAS DRIVING AND RESTARTED AFTER LONG CRANK PERIOD. I PULLED OFF TO PARKING LOT AND CAR TURNED OFF AND FAILED TO RECRANK. THIS CREATES A VERY VERY DANGEROUS CONDITION IN THE VEHICLE JUST SHUTTING OFF WHILE DRIVING! DEALERSHIP INDICATED THE CAM SENSORS NEEDED TO BE REPLACED. I HAVE READ THAT SEVERAL OTHER PEOPLE HAVE HAD SIMILAR EXPERIENCES THROUGH RESEARCHING THIS PROBLEM. I ALSO UNDERSTAND THAT THERE HAS BEEN A RECALL ON CRANK POSITION SENSOR OR CAM POSITION SENSOR FOR THIS VEHICLE (YEAR, MAKE, MODEL) FOR THESE EXACT PROBLEMS, BUT WHEN INQUIRING TO NISSAN ABOUT THIS, MY VIN WAS NOT ASSOCIATED WITH THE RECALL, DESPITE BEING THE SAME MAKE, MODEL, AND YEAR! *TR
NHTSA ODI #10265744
116,000 miles · Apr 10, 2009
Power Train
NEEDED TO REPLACE A TRANSMISSION PART CALLED THE "VALUE BODY" IN A 2003 NISSAN MURANO. THE REPAIR WAS RECOMMENDED BY THE NISSAN DEALER AND WILL COST $1795 TOTAL PARTS & LABOR. APPARENTLY THE DEALER HAS REPLACED MANY TRANSMISSION PARTS CALLED THE VALUE BODY IN THE PAST HERE IN SAN ANTONIO,TEXAS. *TR
NHTSA ODI #10264925
Official recalls
6May 19, 2009
NISSAN IS RECALLING 362,891 MY 2003-2007 MURANO VEHICLES. THE INTAKE AIR DUCTS, WHICH ARE CONNECTED TO THE INTERMEDIATE RESONATOR IN THE AIR INTAKE SYSTEM OF THE ENGINE, MAY SEPARATE FROM THE RESONATOR WITH ENGINE MOVEMENT. THIS SEPARATION OCCURS DUE TO THE PREMATURE AGING OF THE MATERIAL USED IN THE INTAKE AIR DUCTS WHICH CAUSES EXCESSIVE SHRINKING.
Consequence & remedy
Consequence: ENGINE MAY STALL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE/REPAIR THE APPROPRIATE COMPONENTS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 24, 2009. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Feb 13, 2006
ON SOME SPORT UTILITY VEHICLES, IN CERTAIN HIGH SPEED FRONTAL CRASHES, THE WEBBING OF A REAR OUTBOARD SEAT BELT MAY CONTACT THE REAR SEAT BACK HINGE WHERE IT CAN BE CUT BY THE SHARP EDGE OF THE METAL PORTION OF THE HINGE.
Consequence & remedy
Consequence: IF THE WEBBING IS COMPLETELY SEPARATED, IT CAN INCREASE THE RISK OF INJURY TO AN OCCUPANT IN A CRASH.
Remedy: DEALERS WILL INSTALL PROTECTORS OVER THE WEBBING OF THE REAR SEAT BELTS. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jan 10, 2006
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO THE LOCATION OF THE FORWARD EDGE OF THE FUEL TANK, IN THE EVENT THAT A VEHICLE FRONT TIRE RUNS OVER A SMALL, SHARP OBJECT IN THE ROAD, CATCHES IT AND PROPELS IT TOWARDS THE REAR OF THE VEHICLE, IT MAY STRIKE AND PUNCTURE THE FUEL TANK.
Consequence & remedy
Consequence: A PUNCTURED TANK COULD INCREASE THE RISK OF A FIRE.
Remedy: DEALERS WILL INSTALL PROTECTORS IN FRONT OF THE TANK FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jul 14, 2005
ON CERTAIN SPORT UTILITY VEHICLES, THERE IS A POSSIBILITY THAT A WIRE BREAKING INSIDE THE ALTERNATOR COULD STOP THE BATTERY FROM CHARGING.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE CHARGER WARNING AND BRAKE WARNING LAMPS WILL IMMEDIATELY COME ON AND THE BATTERY WILL BEGIN TO DISCHARGE. AFTER A SHORT TIME, THE ENGINE WILL GO INTO A "FALL SAFE" CONDITION WHICH WILL LIMIT VEHICLE SPEED. THE ENGINE WILL STOP RUNNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE ALTERNATOR WITH A NEW VERSION WHICH HAS BEEN MODIFIED TO PREVENT MOVEMENT OF THE COIL. THE RECALL BEGAN ON AUGUST 1, 2005. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Nov 17, 2003
ON CERTAIN PASSENGER VEHICLES, THE CIRCUIT BOARD FOR THE CRANK POSITION SENSOR OR CAM POSITION SENSOR MAY HAVE AN IMPROPER SOLDER JOINT DUE TO SOLDER DEFORMATION CAUSED BY HEAT STRESS ACCELERATED BY THE EXISTENCE OF FLUX RESIDUE DURING THE SOLDERING PROCESS.
Consequence & remedy
Consequence: THIS COULD CAUSE THE "SERVICE ENGINE SOON" WARNING LIGHT TO COME ON, CREATE A NO START CONDITION, CAUSE REDUCED ENGINE POWER, OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING DURING VEHICLE OPERATION, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CRANK POSITION SENSORS. CAMSHAFT POSITION SENSOR(S), AND IN SOME CASES, THE VARIABLE TIMING CONTROL SENSOR(S). VEHICLES INVOLVED IN A PREVIOUS RECALL CAMPAIGN, 01V357, ARE ALSO INCLUDED IN THIS NEW CAMPAIGN. THE REPLACEMENT SENSORS USED IN THAT CAMPAIGN ARE ALSO AFFECTED. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261 OR INFINITI AT 1-800-662-6200.
Mar 31, 2003
ON CERTAIN SPORT UTILITY VEHICLES, THE NUT THAT ATTACHES THE TRANSMISSION GEAR SELECTOR SHAFT TO THE CONTROL VALVE LEVER IN THE TRANSMISSION MAY NOT BE ADEQUATELY TIGHTENED. THIS COULD RESULT IN THE TRANSMISSION NOT ACTUALLY BEING IN THE GEAR INDICATED BY THE GEAR SELECTOR LEVER. IN ADDITION, THE TRANSMISSION POSITION DISPLAY IN THE INSTRUMENT PANEL MAY NOT BE ON OR MAY BE INCORRECT.
Consequence & remedy
Consequence: IF THE GEAR DISPLAYED IS DIFFERENT FROM THE GEAR ENGAGED, THIS COULD RESULT IN UNEXPECTED VEHICLE MOVEMENT AND A CRASH.
Remedy: DEALERS WILL CHECK THE AFFECTED NUT IN THE TRANSMISSION SHIFT LEVER LINKAGE, AND TIGHTEN IT IF NECESSARY. OWNER NOTIFICATION BEGAN APRIL 15, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE08065 · Driver Seat Anchor Failure
Opened Nov 18, 2008 · Closed Jul 2, 2009
Status: closed (inferred from source dates) · Seats
THIS INVESTIGATION CONCERNS STRUCTURAL FAILURE OF THE ANCHOR/BRACKET ON THE LEFT REAR SIDE OF THE DRIVER'S SEAT.THE CONCERN IS THAT SUCH FAILURES MAY ALTER THE DRIVER'S SEATED POSITION SO AS TO REDUCE EFFECTIVENESS OF THE OCCUPANT PROTECTION SYSTEM OR POTENTIALLY COMPROMISE VEHICLE CONTROL.FAILURE OF THE SUBJECT ANCHOR BRACKET RESULTS FROM METAL FATIGUE AND CAUSES REARWARD TILTING OF THE DRIVER'S SEAT.THESE FAILURES USUALLY OCCUR DURING DRIVER INGRESS BUT MAY ALSO OCCUR WHILE THE VEHICLE IS BEING OPERATED.THE SAFETY RELATED CONCERNS DURING ACTUAL VEHICLE USE WERE NOT VALIDATED BY THIS INVESTIGATION.WHILE THE NUMBER OF COMPLAINTS OF THIS PROBLEM IS RELATIVELY HIGH, ONLY THREE VERY MINOR, UNDOCUMENTED INJURIES WERE REPORTED.THE REPORTED INJURIES OCCURRED DURING DRIVER INGRESS, NOT WHILE THE VEHICLE WAS IN MOTION.INVESTIGATION DISCLOSED THAT THE APPARENT RISK OF COMPROMISE TO VEHICLE CONTROL HAS NOT BEEN DEMONSTRATED.INVESTIGATION ALSO DISCLOSED THAT THE APPARENT RISK OF COLLAPSE OF THE DRIVER'S SEAT BACK HAS NOT BEEN DEMONSTRATEDA SAFETY RELATED DEFECT TREND WAS NOT IDENTIFIED AND THIS INVESTIGATION HAS BEEN CLOSED.
PE05050 · Fuel Tank Punctures From Road Debris
Opened Sep 13, 2005 · Closed Jan 31, 2006
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly
ODI OPENED A PRELIMINARY EVALUATION BASED ON FOUR VEHICLE OWNER QUESTIONNAIRES (VOQ'S) INDICATING THAT THE FUEL TANKS WEREPUNCTURED BY ROAD DEBRIS UNDER NORMAL, NON OFF-ROAD DRIVING CONDITIONS.AS OF NOVEMBER 30, 2005, THE COMPLAINT TOTAL INCREASED TO 12.NISSAN SUPPLIED ODI WITH 31 COMPLAINTS OF FUEL TANK PUNCTURES, INCLUDING 26 NOT PREVIOUSLY KNOWN TO ODI FROM THE VOQ RECORDS. IN A LETTER DATED JANUARY 9, 2006, NISSAN NORTH AMERICA, INC. NOTIFIED ODI OF ITS PLAN TO RECALL APPROXIMATELY 209,000 MODEL YEAR 2003 - 2006 NISSAN MURANO VEHICLES BUILT FROM APRIL 24, 2002 (START OF PRODUCTION OF MY 2003) THROUGH NOVEMBER 24, 2005 (INCLUDING A PORTION OF MY 2006 VEHICLES) TO CORRECT A DEFICIENCY IN FUEL TANK SHIELDING FROM ROAD DEBRIS.THIS RECALL HAS BEEN DESIGNATED NHTSA NO. 06V-003.RECALLED VEHICLES WILL BE FITTED WITH PROTECTIVE SHIELDING FOR THE FRONTAL PORTION OF THE FUEL TANK TO REDUCE THE POSSIBILITY OF PUNCTURE BY PROJECTILES FROM THE FRONT WHEELS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.
Additional source detail variants (2)
Fuel System, Gasoline:storage:tank Assembly
ODI OPENED A PRELIMINARY EVALUATION BASED ON FOUR VEHICLE OWNER QUESTIONNAIRES (VOQ'S) INDICATING THAT THE FUEL TANKS WEREPUNCTURED BY ROAD DEBRIS UNDER NORMAL, NON OFF-ROAD DRIVING CONDITIONS.AS OF NOVEMBER 30, 2005, THE COMPLAINT TOTAL INCREASED TO 12.NISSAN SUPPLIED ODI WITH 31 COMPLAINTS OF FUEL TANK PUNCTURES, INCLUDING 26 NOT PREVIOUSLY KNOWN TO ODI FROM THE VOQ RECORDS. IN A LETTER DATED JANUARY 9, 2006, NISSAN NORTH AMERICA, INC. NOTIFIED ODI OF ITS PLAN TO RECALL APPROXIMATELY 209,000 MODEL YEAR 2003 - 2006 NISSAN MURANO VEHICLES BUILT FROM APRIL 24, 2002 (START OF PRODUCTION OF MY 2003) THROUGH NOVEMBER 24, 2005 (INCLUDING A PORTION OF MY 2006 VEHICLES) TO CORRECT A DEFICIENCY IN FUEL TANK SHIELDING FROM ROAD DEBRIS.THIS RECALL HAS BEEN DESIGNATED NHTSA NO. 06V-003.RECALLED VEHICLES WILL BE FITTED WITH PROTECTIVE SHIELDING FOR THE FRONTAL PORTION OF THE FUEL TANK TO REDUCE THE POSSIBILITY OF PUNCTURE BY PROJECTILES FROM THE FRONT WHEELS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.
Fuel System, Other:storage:tank Assembly
ODI OPENED A PRELIMINARY EVALUATION BASED ON FOUR VEHICLE OWNER QUESTIONNAIRES (VOQ'S) INDICATING THAT THE FUEL TANKS WEREPUNCTURED BY ROAD DEBRIS UNDER NORMAL, NON OFF-ROAD DRIVING CONDITIONS.AS OF NOVEMBER 30, 2005, THE COMPLAINT TOTAL INCREASED TO 12.NISSAN SUPPLIED ODI WITH 31 COMPLAINTS OF FUEL TANK PUNCTURES, INCLUDING 26 NOT PREVIOUSLY KNOWN TO ODI FROM THE VOQ RECORDS. IN A LETTER DATED JANUARY 9, 2006, NISSAN NORTH AMERICA, INC. NOTIFIED ODI OF ITS PLAN TO RECALL APPROXIMATELY 209,000 MODEL YEAR 2003 - 2006 NISSAN MURANO VEHICLES BUILT FROM APRIL 24, 2002 (START OF PRODUCTION OF MY 2003) THROUGH NOVEMBER 24, 2005 (INCLUDING A PORTION OF MY 2006 VEHICLES) TO CORRECT A DEFICIENCY IN FUEL TANK SHIELDING FROM ROAD DEBRIS.THIS RECALL HAS BEEN DESIGNATED NHTSA NO. 06V-003.RECALLED VEHICLES WILL BE FITTED WITH PROTECTIVE SHIELDING FOR THE FRONTAL PORTION OF THE FUEL TANK TO REDUCE THE POSSIBILITY OF PUNCTURE BY PROJECTILES FROM THE FRONT WHEELS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.
EA05006 · Alternator Failure / Engine Stalling
Opened Mar 25, 2005 · Closed Aug 17, 2005
Status: closed (inferred from source dates) · Electrical System; Electrical System:alternator/generator/regulator
ODI RECEIVED 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE ON MY 2003-2004 MURANO (SUBJECT) VEHICLES.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.BASED ON THESE COMPLAINTS, ODI OPENED PE04-077 AND LATER UPGRADED TO EA05-006 FOR THE SUBJECT VEHICLES.DURING EA05-006, ADDITIONAL FAILURE DATA WERE IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.ON JULY 12, 2005, NISSAN NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2003-2005 MURANO VEHICLES PRODUCED FROM APRIL 8, 2002 AND SEPTEMBER 24, 2004 (RECALL 05V-319).THE NOTIFICATION STATED THAT AN OPEN CIRCUIT IN THE ALTERNATOR CAN OCCUR DUE TO WIRE FATIGUE CAUSED BY MOVEMENT OF THE ROTOR COIL DURING RAPID CHANGES IN ENGINE SPEED IN VEHICLES EQUIPPED WITH A CONTINUOUSLY VARIABLE TRANSMISSION (CVT).HIGHER ENGINE COMPARTMENT TEMPERATURE IN THE MURANO COMPARED TO OTHER NISSAN MODELS MAY ALSO BE A CONTRIBUTING FACTOR TO THE WIRE FATIGUE.NISSAN ALSO REPORTED THAT WHEN THIS HAPPENS, THE CHARGE WARNING AND BRAKE WARNING LAMPS WILL ILLUMINATE AND THE BATTERY WILL BEGIN TO DISCHARGE.AFTER A SHORT TIME, THE ENGINE WILL THEN ENTER A FAIL SAFE MODE THAT LIMITS VEHICLE SPEED.VERY SHORTLY AFTER REACHING THIS CONDITION, THE ENGINE WILL STOP.NHTSA'S TESTING, HOWEVER, SHOWED THAT ALTHOUGH THE WARNING LAMPS ILLUMINATE, THE VEHICLE SPEED IS LIMITED TO ONLY 4-7 MPH RATHER THAN WHAT NHTSA CONSIDERS A FAIL SAFE MODE. NISSAN WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY NISSAN DEALER FOR AN ALTERNATOR INSPECTION AND REPLACEMENT, IF REQUIRED.NOTE:SOME VEHICLES MAY HAVE HAD THE NEWLY DESIGNED ALTERNATOR PREVIOUSLY INSTALLED UNDER WARRANTY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (2)
Electrical System:alternator/generator/regulator
ODI RECEIVED 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE ON MY 2003-2004 MURANO (SUBJECT) VEHICLES.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.BASED ON THESE COMPLAINTS, ODI OPENED PE04-077 AND LATER UPGRADED TO EA05-006 FOR THE SUBJECT VEHICLES.DURING EA05-006, ADDITIONAL FAILURE DATA WERE IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.ON JULY 12, 2005, NISSAN NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2003-2005 MURANO VEHICLES PRODUCED FROM APRIL 8, 2002 AND SEPTEMBER 24, 2004 (RECALL 05V-319).THE NOTIFICATION STATED THAT AN OPEN CIRCUIT IN THE ALTERNATOR CAN OCCUR DUE TO WIRE FATIGUE CAUSED BY MOVEMENT OF THE ROTOR COIL DURING RAPID CHANGES IN ENGINE SPEED IN VEHICLES EQUIPPED WITH A CONTINUOUSLY VARIABLE TRANSMISSION (CVT).HIGHER ENGINE COMPARTMENT TEMPERATURE IN THE MURANO COMPARED TO OTHER NISSAN MODELS MAY ALSO BE A CONTRIBUTING FACTOR TO THE WIRE FATIGUE.NISSAN ALSO REPORTED THAT WHEN THIS HAPPENS, THE CHARGE WARNING AND BRAKE WARNING LAMPS WILL ILLUMINATE AND THE BATTERY WILL BEGIN TO DISCHARGE.AFTER A SHORT TIME, THE ENGINE WILL THEN ENTER A FAIL SAFE MODE THAT LIMITS VEHICLE SPEED.VERY SHORTLY AFTER REACHING THIS CONDITION, THE ENGINE WILL STOP.NHTSA'S TESTING, HOWEVER, SHOWED THAT ALTHOUGH THE WARNING LAMPS ILLUMINATE, THE VEHICLE SPEED IS LIMITED TO ONLY 4-7 MPH RATHER THAN WHAT NHTSA CONSIDERS A FAIL SAFE MODE. NISSAN WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY NISSAN DEALER FOR AN ALTERNATOR INSPECTION AND REPLACEMENT, IF REQUIRED.NOTE:SOME VEHICLES MAY HAVE HAD THE NEWLY DESIGNED ALTERNATOR PREVIOUSLY INSTALLED UNDER WARRANTY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Electrical System
ODI RECEIVED 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE ON MY 2003-2004 MURANO (SUBJECT) VEHICLES.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.BASED ON THESE COMPLAINTS, ODI OPENED PE04-077 AND LATER UPGRADED TO EA05-006 FOR THE SUBJECT VEHICLES.DURING EA05-006, ADDITIONAL FAILURE DATA WERE IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.ON JULY 12, 2005, NISSAN NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2003-2005 MURANO VEHICLES PRODUCED FROM APRIL 8, 2002 AND SEPTEMBER 24, 2004 (RECALL 05V-319).THE NOTIFICATION STATED THAT AN OPEN CIRCUIT IN THE ALTERNATOR CAN OCCUR DUE TO WIRE FATIGUE CAUSED BY MOVEMENT OF THE ROTOR COIL DURING RAPID CHANGES IN ENGINE SPEED IN VEHICLES EQUIPPED WITH A CONTINUOUSLY VARIABLE TRANSMISSION (CVT).HIGHER ENGINE COMPARTMENT TEMPERATURE IN THE MURANO COMPARED TO OTHER NISSAN MODELS MAY ALSO BE A CONTRIBUTING FACTOR TO THE WIRE FATIGUE.NISSAN ALSO REPORTED THAT WHEN THIS HAPPENS, THE CHARGE WARNING AND BRAKE WARNING LAMPS WILL ILLUMINATE AND THE BATTERY WILL BEGIN TO DISCHARGE.AFTER A SHORT TIME, THE ENGINE WILL THEN ENTER A FAIL SAFE MODE THAT LIMITS VEHICLE SPEED.VERY SHORTLY AFTER REACHING THIS CONDITION, THE ENGINE WILL STOP.NHTSA'S TESTING, HOWEVER, SHOWED THAT ALTHOUGH THE WARNING LAMPS ILLUMINATE, THE VEHICLE SPEED IS LIMITED TO ONLY 4-7 MPH RATHER THAN WHAT NHTSA CONSIDERS A FAIL SAFE MODE. NISSAN WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY NISSAN DEALER FOR AN ALTERNATOR INSPECTION AND REPLACEMENT, IF REQUIRED.NOTE:SOME VEHICLES MAY HAVE HAD THE NEWLY DESIGNED ALTERNATOR PREVIOUSLY INSTALLED UNDER WARRANTY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
PE04077 · Alternator Failure/ Engine Stalling
Opened Nov 19, 2004 · Closed Mar 25, 2005
Status: closed (inferred from source dates) · Electrical System; Electrical System:alternator/generator/regulator
ODI OPENED PE04-077 BASED ON 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.DURING PE04-077, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE . DURING THE INVESTIGATION, NISSAN IDENTIFIED THAT THERE HAD BEEN ALTERNATOR WARRANTY REPLACEMENTS DUE TO AN OPEN CIRCUIT IN THE ROTOR COIL CAUSED BY WIRE FATIGUE. ODI?S ANALYSIS SHOWS FAILURE RATES THAT ARE OF CONCERN TO ODI AND INDICATES THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES.ODI'S ANALYSIS ALSO SHOWS THAT NEARLY ALL OF THE ALTERNATOR WARRANTY CLAIMS SUBMITTED RESULTED IN ENGINE STALLS AND AT LEAST 25% OF THE ENGINE STALLS RESULTED IN A NO RESTART CONDITION.HOWEVER, IN 71% OF THE WARRANTY DATA SUBMITTED, ODI HAS NOT BEEN ABLE TO DETERMINE IF THE CONSUMER COULD RESTART THE VEHICLE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Additional source detail variants (2)
Electrical System:alternator/generator/regulator
ODI OPENED PE04-077 BASED ON 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.DURING PE04-077, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE . DURING THE INVESTIGATION, NISSAN IDENTIFIED THAT THERE HAD BEEN ALTERNATOR WARRANTY REPLACEMENTS DUE TO AN OPEN CIRCUIT IN THE ROTOR COIL CAUSED BY WIRE FATIGUE. ODI?S ANALYSIS SHOWS FAILURE RATES THAT ARE OF CONCERN TO ODI AND INDICATES THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES.ODI'S ANALYSIS ALSO SHOWS THAT NEARLY ALL OF THE ALTERNATOR WARRANTY CLAIMS SUBMITTED RESULTED IN ENGINE STALLS AND AT LEAST 25% OF THE ENGINE STALLS RESULTED IN A NO RESTART CONDITION.HOWEVER, IN 71% OF THE WARRANTY DATA SUBMITTED, ODI HAS NOT BEEN ABLE TO DETERMINE IF THE CONSUMER COULD RESTART THE VEHICLE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Electrical System
ODI OPENED PE04-077 BASED ON 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.DURING PE04-077, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE . DURING THE INVESTIGATION, NISSAN IDENTIFIED THAT THERE HAD BEEN ALTERNATOR WARRANTY REPLACEMENTS DUE TO AN OPEN CIRCUIT IN THE ROTOR COIL CAUSED BY WIRE FATIGUE. ODI?S ANALYSIS SHOWS FAILURE RATES THAT ARE OF CONCERN TO ODI AND INDICATES THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES.ODI'S ANALYSIS ALSO SHOWS THAT NEARLY ALL OF THE ALTERNATOR WARRANTY CLAIMS SUBMITTED RESULTED IN ENGINE STALLS AND AT LEAST 25% OF THE ENGINE STALLS RESULTED IN A NO RESTART CONDITION.HOWEVER, IN 71% OF THE WARRANTY DATA SUBMITTED, ODI HAS NOT BEEN ABLE TO DETERMINE IF THE CONSUMER COULD RESTART THE VEHICLE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Illustration