NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
532 reports30,100 miles · Sep 1, 2008
Fuel System, Gasoline
AT 30,100 MILES PULLED A P0463 "FUEL LEVEL SENSOR A" CODE ON 2005 NISSAN FRONTIER - 3YR WARRANTY ENDED 6DAYS PRIOR TO MIL. ENTIRE FUEL PUMP ASSY NEEDS REPLACEMENT - NISSAN WON'T HONOR 3YR 36,000 MILE WARRANTY. SERVICE REP AT NISSAN DEALER IS AWARE OF PROBLEMS WITH THE FUEL PUMPS - ASKED ME IF MY FUEL GAUGE WAS INOP BEFORE KNOWI…
Read full complaint
AT 30,100 MILES PULLED A P0463 "FUEL LEVEL SENSOR A" CODE ON 2005 NISSAN FRONTIER - 3YR WARRANTY ENDED 6DAYS PRIOR TO MIL. ENTIRE FUEL PUMP ASSY NEEDS REPLACEMENT - NISSAN WON'T HONOR 3YR 36,000 MILE WARRANTY. SERVICE REP AT NISSAN DEALER IS AWARE OF PROBLEMS WITH THE FUEL PUMPS - ASKED ME IF MY FUEL GAUGE WAS INOP BEFORE KNOWING THE FAULT CODE. AFTER SEARCHING THE INTERNET FOUND MANY PEOPLE HAVE THE SAME PROBLEM - THERE SHOULD BE A RECALL ON THIS ISSUE. *TR
NHTSA ODI #10240537
52,000 miles · Aug 28, 2008
Fuel System, Gasoline
2005 NISSAN FRONTIER NISMO 4X4, 4 LITER. CHECK ENGINE ILLUMINATED. INTERMITTENT FUNCTION OF FUEL GAUGE , , DTC P0463, SAME CHASSIS AND ELECTRICAL AS PATHFINDER. SEVERAL SIMILAR COMPLAINTS FOR PATHFINDER. *TR
NHTSA ODI #10240131
80,000 miles · Jul 30, 2008
Fuel System, Gasoline
FUEL LEVEL SENSOR FAILURE ON A 3 YEAR OLD TRUCK. NISSAN DEALERSHIP TO BE CONTACTED SOON.*TR
NHTSA ODI #10236449
38,000 miles · Jul 23, 2008
Structure
I DO NOT KNOW EXACTLY WHAT CAUSED THE PROBLEM BUT I OPENED UP MY TAILGATE ONE MORNING AND THE TAILGATE CAME OFF OF THE HINGE AND PIECES WERE MISSING. I READ ON A FORUM THAT THIS IS A COMMON PROBLEM FOR THE TYPE OF VEHICLE I'M DRIVING AND IT SEEMS THAT THE TAIL GATE COULD HAVE FELL ON THE HIGHWAY IF I HADN'T TRIED IT THAT MORNIN…
Read full complaint
I DO NOT KNOW EXACTLY WHAT CAUSED THE PROBLEM BUT I OPENED UP MY TAILGATE ONE MORNING AND THE TAILGATE CAME OFF OF THE HINGE AND PIECES WERE MISSING. I READ ON A FORUM THAT THIS IS A COMMON PROBLEM FOR THE TYPE OF VEHICLE I'M DRIVING AND IT SEEMS THAT THE TAIL GATE COULD HAVE FELL ON THE HIGHWAY IF I HADN'T TRIED IT THAT MORNING. *TR
NHTSA ODI #10235469
40,000 miles · Jun 26, 2008
Electrical SystemFuel System, Gasoline
"I CURRENTLY OWN A 2005 NISSAN FRONTIER AND HAD 1/4 OF A TANK OF GAS IN MY FUEL TANK AND WENT TO FILL UP. AFTER FILLING UP MY GAS TANK, I TURNED ON THE CAR, AT WHICH POINT THE NEEDLE DID NOT REGISTER THE FULL TANK. AFTER DRIVING A COUPLE MILES, THE CHECK ENGINE LIGHT CAME ON. I WENT DIRECTLY TO THE DEALER AND WAS TOLD THAT IT WA…
Read full complaint
"I CURRENTLY OWN A 2005 NISSAN FRONTIER AND HAD 1/4 OF A TANK OF GAS IN MY FUEL TANK AND WENT TO FILL UP. AFTER FILLING UP MY GAS TANK, I TURNED ON THE CAR, AT WHICH POINT THE NEEDLE DID NOT REGISTER THE FULL TANK. AFTER DRIVING A COUPLE MILES, THE CHECK ENGINE LIGHT CAME ON. I WENT DIRECTLY TO THE DEALER AND WAS TOLD THAT IT WAS A FUEL SENDING UNIT/SENSOR AND THAT IT WAS NO LONGER COVERED AFTER 30K MILES. AFTER RETURNING HOME AND DOING RESEARCH, I WENT ONLINE TO X.NISSANHELP.COM AFTER PERFORMING A SEARCH, I CAME ACROSS COUNTLESS OTHERS WHO HAVE EXPERIENCED THE SAME PROBLEM. APPARENTLY IT HAS SOMETHING TO DO WITH THE FUEL SENDING UNIT. A SIMILAR PROBLEM WAS FOUND ON THE 2000-2004 XTERRA MODELS AND A RECALL WAS PERFORMED WHEN THE VEHICLE WOULD STOP AFTER NOT GETTING ANY FUEL, POSING A GREAT DANGER. IT SEEMS THAT SOMETHING IN THE UNIT IS FAULTY AND WILL CORRODE OVER TIME. THERE IS A GENERAL CONSENSUS THAT EVERYONE WHO IS HAVING THE PROBLEM IS EXPERIENCING THE SAME THING AFTER HAVING THE VEHICLE FOR OVER 2 YRS AND WITH AROUND 39K-49K. IF THIS PROBLEM EXISTED IN PREVIOUS MODELS, AND IT WAS RECALLED, THE 2005-2007 XTERRAS, FRONTIERS, AND PATHFINDERS SHOULD GET THIS FIXED AT NO CHARGE TO THE CUSTOMER!! WHY WAIT FOR ACCIDENTS AND POSSIBLE DEATHS, ESPECIALLY SINCE THE PROBLEM LIES IN AN INTEGRAL PART OF THE VEHICLE. COST OF REPAIR RANGES FROM $300-600." *TR
NHTSA ODI #10232418
54,045 miles · Jun 7, 2008
Fuel System, Gasoline
2005 NISSAN FRONTIER LE GAS GAUGE BEHAVES ERRATICALLY AND "SERVICE ENGINE SOON" LIGHT APPEARS. OBDII CODE IS P0463, FUEL LEVEL SENSOR A CIRCUIT HIGH INPUT - REPLACE FUEL SENDING UNIT. I HAVE SEEN THIS PROBLEM ALL OVER INTERNET FORUMS/CHATS, ESPECIALLY WITH XTERRAS. PLEASE CONSIDER A RECALL ON THE FUEL PUMP MODULE. *TR
NHTSA ODI #10230227
46,000 miles · May 28, 2008
Fuel System, Gasoline
I HAD 1/4 OF A TANK OF GAS AND WENT TO FILL UP. AFTER FILLING UP MY GAS TANK, I TURNED ON MY NISSAN FRONTIER 2005, AT WHICH POINT THE NEEDLE DID NOT REGISTER THE FULL TANK. AFTER DRIVING A COUPLE MILES, THE CHECK ENGINE LIGHT CAME ON. I WENT DIRECTLY TO THE DEALER AND WAS TOLD THAT IT WAS A FUEL SENDING UNIT/SENSOR AND THAT IT W…
Read full complaint
I HAD 1/4 OF A TANK OF GAS AND WENT TO FILL UP. AFTER FILLING UP MY GAS TANK, I TURNED ON MY NISSAN FRONTIER 2005, AT WHICH POINT THE NEEDLE DID NOT REGISTER THE FULL TANK. AFTER DRIVING A COUPLE MILES, THE CHECK ENGINE LIGHT CAME ON. I WENT DIRECTLY TO THE DEALER AND WAS TOLD THAT IT WAS A FUEL SENDING UNIT/SENSOR AND THAT IT WAS NO LONGER COVERED AFTER 30K MILES. MY NISSAN FRONTIER HAS BEEN DRIVEN ONLY 46K MILES. AFTER RETURNING HOME AND DOING RESEARCH, I WENT ONLINE TO X.NISSANHELP.COM AFTER PERFORMING A SEARCH, I CAME ACROSS MANY OTHERS WHO HAVE EXPERIENCED THE SAME PROBLEM. APPARENTLY IT HAS SOMETHING TO DO WITH THE FUEL SENDING UNIT. A SIMILAR PROBLEM WAS FOUND ON THE 2000-2004 XTERRA MODELS AND A RECALL WAS PERFORMED WHEN THE VEHICLE WOULD STOP AFTER NOT GETTING ANY FUEL, POSING A GREAT DANGER. IT SEEMS THAT SOMETHING IN THE UNIT IS FAULTY AND WILL CORRODE OVER TIME. THERE IS A GENERAL CONSENSUS THAT EVERYONE WHO IS HAVING THE PROBLEM IS EXPERIENCING THE SAME THING AFTER HAVING THE VEHICLE FOR OVER 2 YRS AND WITH AROUND 39K-49K. IF THIS PROBLEM EXISTED IN PREVIOUS MODELS, AND IT WAS RECALLED, THE 2005-2007 XTERRAS, FRONTIERS, AND PATHFINDERS SHOULD GET THIS FIXED AT NO CHARGE TO THE CUSTOMER!! WHY WAIT FOR ACCIDENTS AND POSSIBLE DEATHS, ESPECIALLY SINCE THE PROBLEM LIES IN AN INTEGRAL PART OF THE VEHICLE. COST OF REPAIR RANGES FROM $300-600. *TR
NHTSA ODI #10229127
41,012 miles · May 25, 2008
Fuel System, Gasoline
I HAD 1/4 OF A TANK OF GAS AND WENT TO FILL UP. AFTER FILLING UP MY GAS TANK, I TURNED ON THE CAR, AT WHICH POINT THE NEEDLE DID NOT REGISTER THE FULL TANK. AFTER DRIVING A COUPLE MILES, THE CHECK ENGINE LIGHT CAME ON. I WENT DIRECTLY TO THE DEALER AND WAS TOLD THAT IT WAS A FUEL SENDING UNIT/SENSOR AND THAT IT WAS NO LONGER COV…
Read full complaint
I HAD 1/4 OF A TANK OF GAS AND WENT TO FILL UP. AFTER FILLING UP MY GAS TANK, I TURNED ON THE CAR, AT WHICH POINT THE NEEDLE DID NOT REGISTER THE FULL TANK. AFTER DRIVING A COUPLE MILES, THE CHECK ENGINE LIGHT CAME ON. I WENT DIRECTLY TO THE DEALER AND WAS TOLD THAT IT WAS A FUEL SENDING UNIT/SENSOR AND THAT IT WAS NO LONGER COVERED AFTER 30K MILES. AFTER RETURNING HOME AND DOING RESEARCH, I WENT ONLINE TO X.NISSANHELP.COM AFTER PERFORMING A SEARCH, I CAME ACROSS MANY OTHERS WHO HAVE EXPERIENCED THE SAME PROBLEM. APPARENTLY IT HAS SOMETHING TO DO WITH THE FUEL SENDING UNIT. A SIMILAR PROBLEM WAS FOUND ON THE 2000-2004 XTERRA MODELS AND A RECALL WAS PERFORMED WHEN THE VEHICLE WOULD STOP AFTER NOT GETTING ANY FUEL, POSING A GREAT DANGER. IT SEEMS THAT SOMETHING IN THE UNIT IS FAULTY AND WILL CORRODE OVER TIME. THERE IS A GENERAL CONSENSUS THAT EVERYONE WHO IS HAVING THE PROBLEM IS EXPERIENCING THE SAME THING AFTER HAVING THE VEHICLE FOR OVER 2 YRS AND WITH AROUND 39K-49K. IF THIS PROBLEM EXISTED IN PREVIOUS MODELS, AND IT WAS RECALLED, THE 2005-2007 XTERRAS, FRONTIERS, AND PATHFINDERS SHOULD GET THIS FIXED AT NO CHARGE TO THE CUSTOMER!! WHY WAIT FOR ACCIDENTS AND POSSIBLE DEATHS, ESPECIALLY SINCE THE PROBLEM LIES IN AN INTEGRAL PART OF THE VEHICLE. COST OF REPAIR RANGES FROM $300-600." *TR
NHTSA ODI #10228870
49,000 miles · May 25, 2008
Fuel System, Gasoline
FUEL LEVEL SENSOR CAUSING "CHECK ENGINE SOON" LIGHT TO COME ON. APPARENTLY MANY SIMILAR ISSUES BEING REPORTED. 2005 NISSAN FRONTIER W/ 50K MILES. *TR
NHTSA ODI #10228865
40,000 miles · May 9, 2008
Structure
WE HAVE A 2005 NISSAN FRONTIER WITH 40,000 MILES ON IT - WELL MAINTAINED AND IN EXCELLENT CONDITION. BOTH HINGES ON THE TAILGATE BROKE. IT IS A KNOWN PROBLEM. FORTUNATELY, IT CAME OFF WHEN IT WAS PARKED IN MY DRIVEWAY. IF IT BROKE AND FELL OFF ON THE HIGHWAY WHILE THE VEHICLE WAS IN MOTION, IT COULD HAVE BEEN DISASTROUS. NISS…
Read full complaint
WE HAVE A 2005 NISSAN FRONTIER WITH 40,000 MILES ON IT - WELL MAINTAINED AND IN EXCELLENT CONDITION. BOTH HINGES ON THE TAILGATE BROKE. IT IS A KNOWN PROBLEM. FORTUNATELY, IT CAME OFF WHEN IT WAS PARKED IN MY DRIVEWAY. IF IT BROKE AND FELL OFF ON THE HIGHWAY WHILE THE VEHICLE WAS IN MOTION, IT COULD HAVE BEEN DISASTROUS. NISSAN REFUSES TO ACKNOWLEDGE THE PROBLEM OR MAKE THE NECESSARY REPAIRS. THE DEALERSHIP SERVICE MANAGER LIED AND CLAIMED THE FAILURE WAS DUE TO OVERLOAD - WE DON'T USE THE TRUCK TO HAUL ANYTHING. *TR
NHTSA ODI #10227123
Official recalls
3Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Dec 29, 2008
NISSAN IS RECALLING 242,720 MY 2005-2009 PATHFINDER, FRONTIER AND XTERRA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THOSE AREAS OF THE COUNTRY WHICH USE HEAVY CONCENTRATIONS OF ROAD SALT IN THE WINTER, A MIXTURE OF SNOW/WATER AND SALT CAN ENTER INTO THE FRONT CRASH ZONE SENSOR (CZS) HOUSING. IF THIS OCCURS, THE CZS MAY INTERNALLY RUST RESULTING IN A SIGNAL INTERRUPTION. IF THIS HAPPENS, THE RED AIR BAG WARNING LIGHT WILL ILLUMINATE TO ALERT THE VEHICLE OPERATOR.
Consequence & remedy
Consequence: THIS ISSUE COULD RESULT IN THE NON-DEPLOYMENT OF THE DRIVER AND PASSENGER FRONT AIR BAGS IN A CRASH, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE FRONT CZS WITH A REDESIGNED SENSOR. THE RECALL BEGAN ON JANUARY 26, 2009. OWNERS IN THE OTHER STATES WILL RECEIVE EXTENDED WARRANTY COVERAGE FOR THE SENSOR TO 10 YEARS. THESE OWNERS WILL BE NOTIFIED OF THE WARRANTY EXTENSION BY MAIL AND WILL RECEIVE A STICKER TO PLACE IN THEIR WARRANTY BOOKLET EXPLAINING THE EXTENDED WARRANTY COVERAGE. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 30, 2006
ON CERTAIN KING CAB TRUCKS, IN A SEVERE SIDE IMPACT CRASH, THERE IS A POSSIBILITY THAT DEFORMATION OF THE VEHICLE'S BODY COULD CAUSE THE FUEL FILLER CAP TETHER TO BE STRETCHED TO THE POINT OF UNSCREWING THE FUEL FILLER CAP.
Consequence & remedy
Consequence: THIS MAY RESULT IN A FUEL SPILL WHICH IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL CAP TETHER PIN ASSEMBLY WITH A MODIFIED ONE FREE OF CHARGE. THE RECALL BEGAN ON APRIL 24, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP12004 · Transmission Failures
Opened Jun 11, 2012 · Closed Oct 22, 2016
Status: closed (inferred from source dates) · Power Train; Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm); Power Train:automatic Transmission:cooling Unit And Lines; Power Train:automatic Transmission:torque Converter
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Additional source detail variants (5)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission:cooling Unit And Lines
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission:torque Converter
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Illustration