IllustrationAIR BAG LIGHTS STAY ON BLINKING
2005 Nissan Frontier
Owner reports · Recalls · Investigations
More warning signs than most Frontier years
Owner complaints for the 2005 Nissan Frontier are substantially higher than the model-year median of 64.
About this comparison →How this year compares
Owner complaints by model year
Compare all Frontier years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
180–25K
5225–50K
9250–75K
12975–100K
156100–150K
32150K+
479 reports with mileage · 53 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 262 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 106 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports8 fire reports9 injury reports
What owners actually said
532 reportsLOST POWER COULD NOT MOVE TRUCK ON CITY STREET. DEALERSHIP TOLD ME IT WAS THE TRANSMISSION COOLANT WAS LEAKING INTO THE TRANSMISSION FLUID WARINESS THE GEARS AND THE TRANSMISSION HAD TO BE REPLACED. THEY TOLD ME THERE WAS A RECALL BUT I NEVER RECEIVED A NOTICE THEY SAID THE RECALL HAS EXPIRED AND I HAVE TO PAY FOR THE REPAIR.
ERRATIC GAS GAUGE AND CHECK ENGINE LIGHT. SAME ISSUE HAS RECALL ON 2006 AND ABOVE NISSAN FRONTIERS. HAS TO BE SAME ISSUE WITH SENDING UNIT USED IN 2005. TSB IS OPEN TO INCLUDE 2005 VEHICLES
FUEL GAUGE READS HALF TANK WHEN ACTUALLY EMPTY. VERY DANGEROUS. RAN OUT OF GAS ON A MAJOR INTERSTATE THAT WAS 3 LANES WIDE. I WAS IN THE FAR LEFT LANE WHEN ENGINE STOPPED. POWER STEERING AND BRAKES GO TO MANUAL WHEN ENGINE STOPS. HAD TO MANEUVER TO THE SHOULDER ACROSS 2 LANES TO THE RIGHT WITH NO POWER STEERING AND NO POWER BRAK…
Read full complaint
FUEL GAUGE READS HALF TANK WHEN ACTUALLY EMPTY. VERY DANGEROUS. RAN OUT OF GAS ON A MAJOR INTERSTATE THAT WAS 3 LANES WIDE. I WAS IN THE FAR LEFT LANE WHEN ENGINE STOPPED. POWER STEERING AND BRAKES GO TO MANUAL WHEN ENGINE STOPS. HAD TO MANEUVER TO THE SHOULDER ACROSS 2 LANES TO THE RIGHT WITH NO POWER STEERING AND NO POWER BRAKES WHILE VEHICLE WAS QUICKLY LOSING SPEED. NEARLY WAS HIT SEVERAL TIMES WHILE CHANGING LANES. VEHICLE HAD SLOWED TO ABOUT 25 MPH. WHEN SEMI MUST HAVE FIGURED I HAD NO POWER AND STAYED BEHIND ME BLOCKING TWO LANES SO I COULD GET TO THE SHOULDER. PROBABLY SAVED MY LIFE AND PREVENTED A VERY SERIOUS ACCIDENT. THIS UNRELIABLE FUEL GAUGE PROBLEM SHOULD BE RECALLED REGARDLESS OF AGE OF VEHICLE BEFORE SOMEONE IS KILLED OR SERIOUSLY INJURED.
TOTAL TRANSMISSION FAILURE DUE TO A FAULTY TRANSMISSION RADIATOR , RESULTING IN A TOTAL TRANSMISSION REBUILD.
I WAS DRIVING TO WORK IN THE MORNING , ABOUT 10 MILES TO WORK ON THE HIGHWAY NOT A TREE OR CAR INSIGHT , I HEARD WHAT SOUNDED LIKE A LOUD POP / I HAD NO IDEA WHAT IT WAS , NOT A TIRE OR ANYTHING I LOOK UP AND SEE MY SUNROOF SHATTERED
I HAVE REPEATED PROBLEMS WITH CAR STALLING. THEY'VE REPLACED THE CAMSHAFT AND CRANK SHAFT SENSORS BUT IT KEEPS COMING BACK. I KNOW THERE'S A RECALL ON OTHER NISSAN FRONTIERS WITH ECM PROBLEMS AND THINK MINE COULD BE AFFECTED.. IT'S NOT INCLUDED IN THE REALL HOWEVER.
TRANSMISSION DAMAGE CAUSED BY TRANSMISSION COOLER.
THE GAS GAUGE MOSTLY SHOWS EMPTY ON A FULL TANK OF GAS AND THE FUEL LIGHT ON THE DASH STAYS LIT. THE DIAGNOSTIC READS P0463, WHICH IS A FUEL LEVEL SENSOR HIGH INPUT CIRCUIT A. SOMETIMES THE FUEL GAUGE WILL READ DIFFERENTLY AS THE TANK GETS CLOSER TO EMPTY. I BOUGHT THIS TRUCK USED AND THIS WAS THE ISSUE AT THE TIME OF PURCHASE…
Read full complaint
THE GAS GAUGE MOSTLY SHOWS EMPTY ON A FULL TANK OF GAS AND THE FUEL LIGHT ON THE DASH STAYS LIT. THE DIAGNOSTIC READS P0463, WHICH IS A FUEL LEVEL SENSOR HIGH INPUT CIRCUIT A. SOMETIMES THE FUEL GAUGE WILL READ DIFFERENTLY AS THE TANK GETS CLOSER TO EMPTY. I BOUGHT THIS TRUCK USED AND THIS WAS THE ISSUE AT THE TIME OF PURCHASE SO I'M NOT SURE WHEN THIS BEGAN.
TRUCK WOULD NOT CRANK. THE INDICATOR FOR THE GEARS WENT OUT. I WAS AT HOME PARKED WHEN IT WOULD NOT START. HAD A MECHANIC TEST IT. THE TEST INDICATED THE TRANSMISSION COMPUTER IS THE PROBLEM. THERE IS TRANSMISSION FLUID IN THE ANTIFREEZE. THIS IS A DEFECT FROM NISSAN.
Official recalls
310V517000 · Engine And Engine Cooling
Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
08V690000 · Air Bags:frontal
Dec 29, 2008
NISSAN IS RECALLING 242,720 MY 2005-2009 PATHFINDER, FRONTIER AND XTERRA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THOSE AREAS OF THE COUNTRY WHICH USE HEAVY CONCENTRATIONS OF ROAD SALT IN THE WINTER, A MIXTURE OF SNOW/WATER AND SALT CAN ENTER INTO THE FRONT CRASH ZONE SENSOR (CZS) HOUSING. IF THIS OCCURS, THE CZS MAY INTERNALLY RUST RESULTING IN A SIGNAL INTERRUPTION. IF THIS HAPPENS, THE RED AIR BAG WARNING LIGHT WILL ILLUMINATE TO ALERT THE VEHICLE OPERATOR.
Consequence & remedy
Consequence: THIS ISSUE COULD RESULT IN THE NON-DEPLOYMENT OF THE DRIVER AND PASSENGER FRONT AIR BAGS IN A CRASH, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE FRONT CZS WITH A REDESIGNED SENSOR. THE RECALL BEGAN ON JANUARY 26, 2009. OWNERS IN THE OTHER STATES WILL RECEIVE EXTENDED WARRANTY COVERAGE FOR THE SENSOR TO 10 YEARS. THESE OWNERS WILL BE NOTIFIED OF THE WARRANTY EXTENSION BY MAIL AND WILL RECEIVE A STICKER TO PLACE IN THEIR WARRANTY BOOKLET EXPLAINING THE EXTENDED WARRANTY COVERAGE. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
06V092000 · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Mar 30, 2006
ON CERTAIN KING CAB TRUCKS, IN A SEVERE SIDE IMPACT CRASH, THERE IS A POSSIBILITY THAT DEFORMATION OF THE VEHICLE'S BODY COULD CAUSE THE FUEL FILLER CAP TETHER TO BE STRETCHED TO THE POINT OF UNSCREWING THE FUEL FILLER CAP.
Consequence & remedy
Consequence: THIS MAY RESULT IN A FUEL SPILL WHICH IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL CAP TETHER PIN ASSEMBLY WITH A MODIFIED ONE FREE OF CHARGE. THE RECALL BEGAN ON APRIL 24, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP12004 · Transmission Failures
Opened Jun 11, 2012 · Closed Oct 22, 2016
Status: closed (inferred from source dates) · Power Train; Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm); Power Train:automatic Transmission:cooling Unit And Lines; Power Train:automatic Transmission:torque Converter
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Additional source detail variants (5)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission:cooling Unit And Lines
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission:torque Converter
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.