IllustrationTHE MOTOR MOUNT BROKE, IT FELT LIKE THE ENGINE WAS GOING TO FALL OUT OF MY TRUCK. $550 FIX. *TR
2005 Nissan Frontier
Owner reports · Recalls · Investigations
More warning signs than most Frontier years
Owner complaints for the 2005 Nissan Frontier are substantially higher than the model-year median of 64.
About this comparison →How this year compares
Owner complaints by model year
Compare all Frontier years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
180–25K
5225–50K
9250–75K
12975–100K
156100–150K
32150K+
479 reports with mileage · 53 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 262 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 106 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports8 fire reports9 injury reports
What owners actually said
532 reportsTRANSMISSION COOLER LINE FAILURE, CAUSING CROSS CONTAMINATION FROM THE RADIATOR TO THE TRANSMISSION. CONTACTED NISSAN, THROUGH PHONE AND CERTIFIED LETTERS TO THE PRESIDENT OF NISSAN. NISSAN WOULD NOT EXCEPT ANY RESPONSIBILITY. MY VEHICLE WAS NON DRIVABLE FOR 6 MONTHS DUE TO THE COST OF REPAIRS. *TR
LETTER FROM SENATOR WARNER ON BEHALF OF CONSTITUENT RE AUTO PAINT CHIPPING-NISSAN FRONTIER TRUCK (ATTN: SHANE CLEM). *TGW THE CONSUMER BELIEVED THERE WAS A DEFECT IN THE PAINT. *JB
APPARENTLY A KNOWN ISSUE WITH THE RADIATOR LEAKING INTO THE TRANSMISSION - CAUSING AN $3000 REPAIR TO A VEHICLE THAT WAS WELL-MAINTAINED. THE TRANSMISSION STARTED SLIPPING AND AFTER DIAGNOSTICS WAS TOLD BY THE MECHANIC THIS WAS AN ISSUE THAT NISSAN KNEW ABOUT AND NEVER DID ANYTHING ABOUT. SPENT $3000 OF MY MONEY TO FIX SOMETHI…
Read full complaint
APPARENTLY A KNOWN ISSUE WITH THE RADIATOR LEAKING INTO THE TRANSMISSION - CAUSING AN $3000 REPAIR TO A VEHICLE THAT WAS WELL-MAINTAINED. THE TRANSMISSION STARTED SLIPPING AND AFTER DIAGNOSTICS WAS TOLD BY THE MECHANIC THIS WAS AN ISSUE THAT NISSAN KNEW ABOUT AND NEVER DID ANYTHING ABOUT. SPENT $3000 OF MY MONEY TO FIX SOMETHING THAT SHOULD HAVE BEEN PREVENTED AND FIXED BY THE MANUFACTURER. I LIKED NISSAN, BUT AFTER THIS; I MAY NOT BUY ANYMORE. HAVE DOCUMENTATION TO PROVE THE ISSUE. *TR
TRANS FLUID LEAKED INTO RADIATOR. *TR
AT OIL COOLER INTERNAL COMPONENT OF THE RADIATOR FAILED CAUSING TRANSMISSION FLUID TO GO IN TO THE RADIATOR AND COOLANT TO GO IN TO THE TRANSMISSION. DESTROYING. *TR
FUEL GAUGE READINGS INACCURATE. GAUGE READS THAT THERE IS APPROXIMATELY 1/4 TANK OF FUEL WHEN IN FACT THE TANK IS CLOSE TO OR COMPLETELY EMPTY. *TR
TL* THE CONTACT OWNS A 2005 NISSAN FRONTIER. WHILE DRIVING APPROXIMATELY 40 MPH, THE LOW BEAM EXTERIOR LIGHTS SUDDENLY SHUT OFF. IN ORDER TO REMEDY THE FAILURE, THE CONTACT CHANGED THE BULBS, BUT THE FAILURE RECURRED. THE DEALER STATED THAT THE INTELLIGENT POWER DISTRIBUTION MODULE WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHI…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN FRONTIER. WHILE DRIVING APPROXIMATELY 40 MPH, THE LOW BEAM EXTERIOR LIGHTS SUDDENLY SHUT OFF. IN ORDER TO REMEDY THE FAILURE, THE CONTACT CHANGED THE BULBS, BUT THE FAILURE RECURRED. THE DEALER STATED THAT THE INTELLIGENT POWER DISTRIBUTION MODULE WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER STATED THAT A NEW PART WAS MANUFACTURED TO ADDRESS THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,300.
THE TRANSMISSION COOLER LINE LEAKS COOLANT INTO THE TRANSMISSION CAUSING A FAILURE. NISSAN HAS KNOWN OF THIS PROBLEM FOR MANY YEARS AND HAS NOT NOTIFIED OWNERS OF THE NEED TO REPLACE THE RADIATOR. *TR
TRANSMISSION DEMORA EN APLICAR, ESTA VAGA, NO DESARROLLA VELOCIDAD SE ENCONTRO QUE LA GUAGUA MEZCLA ACEITE DE TRANSMISSION Y COOLANT EN LA BARILLA DE ACEITE Y EN EL RADIADOR. SE LLEVO AL DEALER Y SE NOS NOTIFICO QUE ERA UN DESPERFECTO DE LA GUAGUA Y TUVIMOS QUE PAGAR 3,287.88 YA QUE LA GUAGUA TIENE 9 ANOS Y LA GARANTIA ERA 80,00…
Read full complaint
TRANSMISSION DEMORA EN APLICAR, ESTA VAGA, NO DESARROLLA VELOCIDAD SE ENCONTRO QUE LA GUAGUA MEZCLA ACEITE DE TRANSMISSION Y COOLANT EN LA BARILLA DE ACEITE Y EN EL RADIADOR. SE LLEVO AL DEALER Y SE NOS NOTIFICO QUE ERA UN DESPERFECTO DE LA GUAGUA Y TUVIMOS QUE PAGAR 3,287.88 YA QUE LA GUAGUA TIENE 9 ANOS Y LA GARANTIA ERA 80,000 MILLAS O 8 ANOS LO QUE SURGIERA PRIMERO. ENTIENDO QUE NO ES JUSTO YA QUE NO ES NUESTRA CULPA DEL DESPERFECTO QUE TIENE LA GUAGUA. *TR
Official recalls
310V517000 · Engine And Engine Cooling
Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
08V690000 · Air Bags:frontal
Dec 29, 2008
NISSAN IS RECALLING 242,720 MY 2005-2009 PATHFINDER, FRONTIER AND XTERRA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THOSE AREAS OF THE COUNTRY WHICH USE HEAVY CONCENTRATIONS OF ROAD SALT IN THE WINTER, A MIXTURE OF SNOW/WATER AND SALT CAN ENTER INTO THE FRONT CRASH ZONE SENSOR (CZS) HOUSING. IF THIS OCCURS, THE CZS MAY INTERNALLY RUST RESULTING IN A SIGNAL INTERRUPTION. IF THIS HAPPENS, THE RED AIR BAG WARNING LIGHT WILL ILLUMINATE TO ALERT THE VEHICLE OPERATOR.
Consequence & remedy
Consequence: THIS ISSUE COULD RESULT IN THE NON-DEPLOYMENT OF THE DRIVER AND PASSENGER FRONT AIR BAGS IN A CRASH, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE FRONT CZS WITH A REDESIGNED SENSOR. THE RECALL BEGAN ON JANUARY 26, 2009. OWNERS IN THE OTHER STATES WILL RECEIVE EXTENDED WARRANTY COVERAGE FOR THE SENSOR TO 10 YEARS. THESE OWNERS WILL BE NOTIFIED OF THE WARRANTY EXTENSION BY MAIL AND WILL RECEIVE A STICKER TO PLACE IN THEIR WARRANTY BOOKLET EXPLAINING THE EXTENDED WARRANTY COVERAGE. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
06V092000 · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Mar 30, 2006
ON CERTAIN KING CAB TRUCKS, IN A SEVERE SIDE IMPACT CRASH, THERE IS A POSSIBILITY THAT DEFORMATION OF THE VEHICLE'S BODY COULD CAUSE THE FUEL FILLER CAP TETHER TO BE STRETCHED TO THE POINT OF UNSCREWING THE FUEL FILLER CAP.
Consequence & remedy
Consequence: THIS MAY RESULT IN A FUEL SPILL WHICH IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL CAP TETHER PIN ASSEMBLY WITH A MODIFIED ONE FREE OF CHARGE. THE RECALL BEGAN ON APRIL 24, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP12004 · Transmission Failures
Opened Jun 11, 2012 · Closed Oct 22, 2016
Status: closed (inferred from source dates) · Power Train; Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm); Power Train:automatic Transmission:cooling Unit And Lines; Power Train:automatic Transmission:torque Converter
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Additional source detail variants (5)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission:cooling Unit And Lines
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission:torque Converter
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.