SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2005 Nissan Frontier

Owner reports · Recalls · Investigations

More warning signs than most Frontier years

Owner complaints for the 2005 Nissan Frontier are substantially higher than the model-year median of 64.

About this comparison →
532Owner complaints

Model-year median: 64

3Recall campaigns

View recall details →

1Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
124
200277
200366
2004532
2005617
2006520
2007136
2008
Compare all Frontier years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Power Train
262Fuel System, Gasoline
119Engine And Engine Cooling
106Engine
80Electrical System
38
All reported categories
Fuel/propulsion System
25Fuel System, Other
18Structure
17Vehicle Speed Control
15Air Bags
14Unknown Or Other
14Steering
5Electronic Stability Control (esc)
4Latches/locks/linkages
4Service Brakes, Hydraulic
4Suspension
4Exterior Lighting
3Service Brakes
3Tires
3Equipment
2Visibility
2Wheels
2Parking Brake
1Seats
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

479 reports with mileage · 53 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 262 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Gasoline. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine And Engine Cooling. Review the 106 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports8 fire reports9 injury reports

Service Brakes, Hydraulic complaints

4 reports
Clear category filter
180,000 miles · Oct 28, 2016
Electrical SystemService Brakes, HydraulicFire

TL* THE CONTACT OWNS A 2005 NISSAN FRONTIER. AFTER THE DRIVER PARKED THE VEHICLE, SMOKE EMITTED UNDER THE HOOD WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE WIRING HARNESS PLUG CONNECTED TO THE ANTILOCK BRAKE SYSTEM FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. TH…

Read full complaint

TL* THE CONTACT OWNS A 2005 NISSAN FRONTIER. AFTER THE DRIVER PARKED THE VEHICLE, SMOKE EMITTED UNDER THE HOOD WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE WIRING HARNESS PLUG CONNECTED TO THE ANTILOCK BRAKE SYSTEM FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000.

NHTSA ODI #10919785

24,000 miles · Jan 17, 2012
Service Brakes, Hydraulic

TL* THE CONTACT OWNS A 2005 NISSAN FRONTIER. THE CONTACT STATED THAT THE FRONT CALIPERS SEIZED AND AS A RESULT, THE BRAKES FAILED. THE CONTACT STATED THAT HE REPLACED THE CALIPERS, BRAKE PADS AND ROTORS ON EACH SIDE TWICE PRIOR TO THE RECENT FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE…

Read full complaint

TL* THE CONTACT OWNS A 2005 NISSAN FRONTIER. THE CONTACT STATED THAT THE FRONT CALIPERS SEIZED AND AS A RESULT, THE BRAKES FAILED. THE CONTACT STATED THAT HE REPLACED THE CALIPERS, BRAKE PADS AND ROTORS ON EACH SIDE TWICE PRIOR TO THE RECENT FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 24,000 AND CURRENT MILEAGE WAS 72,000.

NHTSA ODI #10444100

95,200 miles · Feb 28, 2011
Service Brakes, HydraulicUnknown Or OtherVehicle Speed ControlCrashInjury

CRUISE CONTROL SET AT 50 MPH, AND AS CAR STARTED INCLINE, ACCELERATOR ENGAGED ABRUPTLY AND RPM INCREASED TO MAXIMUM. MULTIPLE ATTEMPTS TO BRAKE AND REGAIN CONTROL OF VEHICLE. TRUCK WENT OFF ROAD ON CURVE AND HEAD ON COLLISION WITH TREE OCCURRED. DRIVER HAD BOTH FEET ON BRAKE, YET WAS UNSUCCESSFUL IN SLOWING VEHICLE.

NHTSA ODI #10385989

16,000 miles · Sep 20, 2006
Service Brakes, Hydraulic

DT*: THE CONTACT STATED WHILE BRAKE PRESSURE WAS APPLIED AT VARIOUS SPEEDS ON NORMAL ROAD CONDITIONS, THERE WAS A PRONOUNCED VIBRATION AND INCREASED STOPPING DISTANCE. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT REPAIR SHOP BUT WAS UNABLE TO DUPLICATE THE PROBLEM. THE VEHICLE WAS LATER INSPECTED BY A DEALER WHO DETERMINED THE …

Read full complaint

DT*: THE CONTACT STATED WHILE BRAKE PRESSURE WAS APPLIED AT VARIOUS SPEEDS ON NORMAL ROAD CONDITIONS, THERE WAS A PRONOUNCED VIBRATION AND INCREASED STOPPING DISTANCE. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT REPAIR SHOP BUT WAS UNABLE TO DUPLICATE THE PROBLEM. THE VEHICLE WAS LATER INSPECTED BY A DEALER WHO DETERMINED THE ROTORS WERE WORN AND TWISTED. AFTER REPLACEMENT OF THE ROTORS, THE PROBLEM PERSISTED. THE VEHICLE WAS ROAD TESTED BY THE DEALER WHO DETERMINED THAT BRAKING WAS NORMAL. THE MANUFACTURER WAS NOT NOTIFIED.

NHTSA ODI #10168774

Official recalls

3

10V517000 · Engine And Engine Cooling

Oct 28, 2010

NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.

Consequence & remedy

Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

08V690000 · Air Bags:frontal

Dec 29, 2008

NISSAN IS RECALLING 242,720 MY 2005-2009 PATHFINDER, FRONTIER AND XTERRA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THOSE AREAS OF THE COUNTRY WHICH USE HEAVY CONCENTRATIONS OF ROAD SALT IN THE WINTER, A MIXTURE OF SNOW/WATER AND SALT CAN ENTER INTO THE FRONT CRASH ZONE SENSOR (CZS) HOUSING. IF THIS OCCURS, THE CZS MAY INTERNALLY RUST RESULTING IN A SIGNAL INTERRUPTION. IF THIS HAPPENS, THE RED AIR BAG WARNING LIGHT WILL ILLUMINATE TO ALERT THE VEHICLE OPERATOR.

Consequence & remedy

Consequence: THIS ISSUE COULD RESULT IN THE NON-DEPLOYMENT OF THE DRIVER AND PASSENGER FRONT AIR BAGS IN A CRASH, INCREASING THE RISK OF PERSONAL INJURY.

Remedy: DEALERS WILL REPLACE THE FRONT CZS WITH A REDESIGNED SENSOR. THE RECALL BEGAN ON JANUARY 26, 2009. OWNERS IN THE OTHER STATES WILL RECEIVE EXTENDED WARRANTY COVERAGE FOR THE SENSOR TO 10 YEARS. THESE OWNERS WILL BE NOTIFIED OF THE WARRANTY EXTENSION BY MAIL AND WILL RECEIVE A STICKER TO PLACE IN THEIR WARRANTY BOOKLET EXPLAINING THE EXTENDED WARRANTY COVERAGE. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

06V092000 · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

Mar 30, 2006

ON CERTAIN KING CAB TRUCKS, IN A SEVERE SIDE IMPACT CRASH, THERE IS A POSSIBILITY THAT DEFORMATION OF THE VEHICLE'S BODY COULD CAUSE THE FUEL FILLER CAP TETHER TO BE STRETCHED TO THE POINT OF UNSCREWING THE FUEL FILLER CAP.

Consequence & remedy

Consequence: THIS MAY RESULT IN A FUEL SPILL WHICH IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL CAP TETHER PIN ASSEMBLY WITH A MODIFIED ONE FREE OF CHARGE. THE RECALL BEGAN ON APRIL 24, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

DP12004 · Transmission Failures

Opened Jun 11, 2012 · Closed Oct 22, 2016

Status: closed (inferred from source dates) · Power Train; Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm); Power Train:automatic Transmission:cooling Unit And Lines; Power Train:automatic Transmission:torque Converter

On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.

Additional source detail variants (5)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.

Power Train:automatic Transmission:cooling Unit And Lines

On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.

Power Train:automatic Transmission

On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.

Power Train:automatic Transmission:torque Converter

On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.

Power Train

On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.