2005 Nissan Frontier

"I CURRENTLY OWN A 2005 NISSAN FRONTIER AND HAD 1/4 OF A TANK OF GAS IN MY FUEL TANK AND WENT TO FILL UP. AFTER FILLING UP MY GAS TANK, I TURNED ON THE CAR, AT WHICH POINT THE NEEDLE DID NOT REGISTER THE FULL TANK. AFTER DRIVING A COUPLE MILES, THE CHECK ENGINE LIGHT CAME ON. I WENT DIRECTLY TO THE DEALER AND WAS TOLD THAT IT WAS A FUEL SENDING UNIT/SENSOR AND THAT IT WAS NO LONGER COVERED AFTER 30K MILES. AFTER RETURNING HOME AND DOING RESEARCH, I WENT ONLINE TO X.NISSANHELP.COM AFTER PERFORMING A SEARCH, I CAME ACROSS COUNTLESS OTHERS WHO HAVE EXPERIENCED THE SAME PROBLEM. APPARENTLY IT HAS SOMETHING TO DO WITH THE FUEL SENDING UNIT. A SIMILAR PROBLEM WAS FOUND ON THE 2000-2004 XTERRA MODELS AND A RECALL WAS PERFORMED WHEN THE VEHICLE WOULD STOP AFTER NOT GETTING ANY FUEL, POSING A GREAT DANGER. IT SEEMS THAT SOMETHING IN THE UNIT IS FAULTY AND WILL CORRODE OVER TIME. THERE IS A GENERAL CONSENSUS THAT EVERYONE WHO IS HAVING THE PROBLEM IS EXPERIENCING THE SAME THING AFTER HAVING THE VEHICLE FOR OVER 2 YRS AND WITH AROUND 39K-49K. IF THIS PROBLEM EXISTED IN PREVIOUS MODELS, AND IT WAS RECALLED, THE 2005-2007 XTERRAS, FRONTIERS, AND PATHFINDERS SHOULD GET THIS FIXED AT NO CHARGE TO THE CUSTOMER!! WHY WAIT FOR ACCIDENTS AND POSSIBLE DEATHS, ESPECIALLY SINCE THE PROBLEM LIES IN AN INTEGRAL PART OF THE VEHICLE. COST OF REPAIR RANGES FROM $300-600." *TR

I HAD 1/4 OF A TANK OF GAS AND WENT TO FILL UP. AFTER FILLING UP MY GAS TANK, I TURNED ON MY NISSAN FRONTIER 2005, AT WHICH POINT THE NEEDLE DID NOT REGISTER THE FULL TANK. AFTER DRIVING A COUPLE MILES, THE CHECK ENGINE LIGHT CAME ON. I WENT DIRECTLY TO THE DEALER AND WAS TOLD THAT IT WAS A FUEL SENDING UNIT/SENSOR AND THAT IT WAS NO LONGER COVERED AFTER 30K MILES. MY NISSAN FRONTIER HAS BEEN DRIVEN ONLY 46K MILES. AFTER RETURNING HOME AND DOING RESEARCH, I WENT ONLINE TO X.NISSANHELP.COM AFTER PERFORMING A SEARCH, I CAME ACROSS MANY OTHERS WHO HAVE EXPERIENCED THE SAME PROBLEM. APPARENTLY IT HAS SOMETHING TO DO WITH THE FUEL SENDING UNIT. A SIMILAR PROBLEM WAS FOUND ON THE 2000-2004 XTERRA MODELS AND A RECALL WAS PERFORMED WHEN THE VEHICLE WOULD STOP AFTER NOT GETTING ANY FUEL, POSING A GREAT DANGER. IT SEEMS THAT SOMETHING IN THE UNIT IS FAULTY AND WILL CORRODE OVER TIME. THERE IS A GENERAL CONSENSUS THAT EVERYONE WHO IS HAVING THE PROBLEM IS EXPERIENCING THE SAME THING AFTER HAVING THE VEHICLE FOR OVER 2 YRS AND WITH AROUND 39K-49K. IF THIS PROBLEM EXISTED IN PREVIOUS MODELS, AND IT WAS RECALLED, THE 2005-2007 XTERRAS, FRONTIERS, AND PATHFINDERS SHOULD GET THIS FIXED AT NO CHARGE TO THE CUSTOMER!! WHY WAIT FOR ACCIDENTS AND POSSIBLE DEATHS, ESPECIALLY SINCE THE PROBLEM LIES IN AN INTEGRAL PART OF THE VEHICLE. COST OF REPAIR RANGES FROM $300-600. *TR

I HAD 1/4 OF A TANK OF GAS AND WENT TO FILL UP. AFTER FILLING UP MY GAS TANK, I TURNED ON THE CAR, AT WHICH POINT THE NEEDLE DID NOT REGISTER THE FULL TANK. AFTER DRIVING A COUPLE MILES, THE CHECK ENGINE LIGHT CAME ON. I WENT DIRECTLY TO THE DEALER AND WAS TOLD THAT IT WAS A FUEL SENDING UNIT/SENSOR AND THAT IT WAS NO LONGER COVERED AFTER 30K MILES. AFTER RETURNING HOME AND DOING RESEARCH, I WENT ONLINE TO X.NISSANHELP.COM AFTER PERFORMING A SEARCH, I CAME ACROSS MANY OTHERS WHO HAVE EXPERIENCED THE SAME PROBLEM. APPARENTLY IT HAS SOMETHING TO DO WITH THE FUEL SENDING UNIT. A SIMILAR PROBLEM WAS FOUND ON THE 2000-2004 XTERRA MODELS AND A RECALL WAS PERFORMED WHEN THE VEHICLE WOULD STOP AFTER NOT GETTING ANY FUEL, POSING A GREAT DANGER. IT SEEMS THAT SOMETHING IN THE UNIT IS FAULTY AND WILL CORRODE OVER TIME. THERE IS A GENERAL CONSENSUS THAT EVERYONE WHO IS HAVING THE PROBLEM IS EXPERIENCING THE SAME THING AFTER HAVING THE VEHICLE FOR OVER 2 YRS AND WITH AROUND 39K-49K. IF THIS PROBLEM EXISTED IN PREVIOUS MODELS, AND IT WAS RECALLED, THE 2005-2007 XTERRAS, FRONTIERS, AND PATHFINDERS SHOULD GET THIS FIXED AT NO CHARGE TO THE CUSTOMER!! WHY WAIT FOR ACCIDENTS AND POSSIBLE DEATHS, ESPECIALLY SINCE THE PROBLEM LIES IN AN INTEGRAL PART OF THE VEHICLE. COST OF REPAIR RANGES FROM $300-600." *TR

TL*THE CONTACT OWNS A 2005 NISSAN FRONTIER. THE CONTACT SMELLED A FUEL ODOR IN THE PASSENGER COMPARTMENT. WHILE DRIVING APPROXIMATELY 15 TO 25 MPH, A PUFF OF SMOKE WAS NOTICED FOLLOWED BY FLAMES IN THE FRONT END OF THE VEHICLE. THE TIRES WERE ALSO BURNED. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THERE WERE NO WARNING LIGHTS ILLUMINATED PRIOR TO THE FIRE. THE FAILURE WAS DUE TO A LEAK IN THE FUEL SYSTEM IN THE ENGINE COMPARTMENT. THE VEHICLE WAS DESTROYED. THE CONTACT HAS PHOTOS AND A VIDEO OF THE FAILURE AVAILABLE. THE FAILURE MILEAGE WAS 23,000. UPDATED 5/20/08 *CN THE FIRE WAS A RESULT OF A FUEL LEAK IN THE FUEL LINE. UPDATED 05/20/08

WHILE DRIVING MY 2005 NISSAN FRONTIER, I NOTICED A GASOLINE SMELL. I GOT OUT OF THE TRUCK, AND LOOKED UNDERNEATH. GAS WAS POURING ON THE GROUND FROM ON TOP OF THE FUEL TANK. FURTHER INVESTIGATION SHOWED THAT GAS WAS SPRAYING FROM THE FUEL PUMP ALL OVER THE UNDERSIDE OF THE TRUCK, EVEN ONTO THE CATALYTIC CONVERTER. THE AMOUNT OF GAS SPRAYING WAS ABSOLUTELY FRIGHTENING. THE DEALER TOLD ME THAT THE FUEL TANK HIT A ROCK ON A RECENT TRIP. THIS CAUSED THE FUEL PUMP TO SMASH AGAINST THE BOTTOM OF THE TRUCK AND CREATE THIS PROBLEM. FURTHER INVESTIGATION SHOWED THAT WHEN THE GAS TANK IS FULL, TO 3/4 FULL, ANY IMPACT ON THE CENTER OF THE FUEL TANK, WILL RESULT IN CATASTROPHIC FAILURE TO THE FUEL PUMP LIKE I EXPERIENCED. IMPACT TO THE FUEL TANK IS ALMOST UNAVOIDABLE IN ANY OFF ROAD SITUATION. THE FUEL TANK IS THE LOWEST COMPONENT UNDER THE TRUCK, AND THE MAIN POWER WHEEL IN 4WD IS THE WHEEL DIRECTLY IN FRONT OF THE FUEL TANK. THIS PROBLEM WILL RESULT IN FIERY DEATH, AND/OR FOREST FIRES. THERE IS NO SKID PLATE KIT AVAILABLE TO PROTECT THE GAS TANK AT THIS TIME. THE DEALER REFUSED TO WARRANTY THIS ITEM THE SECOND TIME IT OCCURRED. A NEW FUEL PUMP COST IS IN EXCESS OF $600.00 THIS IS A POOR DESIGN, AND TRULY WILL RESULT IN DEATH. *JB