SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2005 Nissan Frontier

Owner reports · Recalls · Investigations

More warning signs than most Frontier years

Owner complaints for the 2005 Nissan Frontier are substantially higher than the model-year median of 64.

About this comparison →
532Owner complaints

Model-year median: 64

3Recall campaigns

View recall details →

1Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
124
200277
200366
2004532
2005617
2006520
2007136
2008
Compare all Frontier years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Power Train
262Fuel System, Gasoline
119Engine And Engine Cooling
106Engine
80Electrical System
38
All reported categories
Fuel/propulsion System
25Fuel System, Other
18Structure
17Vehicle Speed Control
15Air Bags
14Unknown Or Other
14Steering
5Electronic Stability Control (esc)
4Latches/locks/linkages
4Service Brakes, Hydraulic
4Suspension
4Exterior Lighting
3Service Brakes
3Tires
3Equipment
2Visibility
2Wheels
2Parking Brake
1Seats
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

479 reports with mileage · 53 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 262 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Gasoline. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine And Engine Cooling. Review the 106 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports8 fire reports9 injury reports

Fuel/propulsion System complaints

25 reports
Clear category filter
87,000 miles · Feb 7, 2013
Fuel/propulsion System

AFTER FILLING TRUCK UP WITH GAS THE FUEL GAUGE DID NOT REGISTER FULL. AFTER DRIVING A FEW MILES DOWN THE ROAD THE CHECK ENGINE LIGHT CAME ON AND THE GAS GAUGE WENT TO EMPTY. MECHANIC CHECKED THE THE CHECK ENGINE CODE, WHICH WAS A FUEL SENSOR ERROR. THE MECHANIC RESET THE CHECK ENGINE. AFTER SEVERAL MILES THE GAS GAUGE STARTED WO…

Read full complaint

AFTER FILLING TRUCK UP WITH GAS THE FUEL GAUGE DID NOT REGISTER FULL. AFTER DRIVING A FEW MILES DOWN THE ROAD THE CHECK ENGINE LIGHT CAME ON AND THE GAS GAUGE WENT TO EMPTY. MECHANIC CHECKED THE THE CHECK ENGINE CODE, WHICH WAS A FUEL SENSOR ERROR. THE MECHANIC RESET THE CHECK ENGINE. AFTER SEVERAL MILES THE GAS GAUGE STARTED WORKING AGAIN. IT HAS BEEN THIS WAY FOR SIX MONTHS NOW. EVERY TIME I FILL MY TRUCK UP WITH GAS IT DOES NOT REGISTER FULL. A FEW MILES LATER THE GAS GAUGE GOES TO EMPTY AND THE CHECK ENGINE LIGHT COMES ON. AFTER SEVERAL MILES (VARIES FROM APPROXIMATELY 20 TO 100 MILES) THE FUEL GAUGE STARTS WORKING AGAIN. SOMETIMES IT NOT A MATTER OF MILES BUT TIME. FILL MY TRUCK UP, GAS GAUGE GOES TO EMPTY, PARK MY TRUCK AT THE AIRPORT FOR A FEW DAYS AND WHEN I GET BACK THE FUEL GAUGE WORKS. *TR

NHTSA ODI #10496732

57,000 miles · Jan 2, 2013
Fuel/propulsion System

TL* THE CONTACT OWNS A 2005 NISSAN FRONTIER. THE CONTACT STATED THAT AFTER REFUELING, THE FUEL LEVEL INDICATOR PROVIDED AN INACCURATE READING OF EMPTY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 57,000.

NHTSA ODI #10490783

74,303 miles · Oct 29, 2012
EngineFuel/propulsion System

FUEL SENSOR WILL SHOW 1/4 TANK OF GASOLINE AND LOW FUEL LIGHT WILL COME ON AND GAUGE WILL SHOW EMPTY SHORTLY AFTER. *TR

NHTSA ODI #10482580

78,100 miles · Sep 17, 2012
Fuel/propulsion System

SERVICE ENGINE SOON LIGHT CAME ON AND THE FUEL GAUGE STARTED GOING WACKY AND ULTIMATELY SHOWED EMPTY EVENTHOUGH I HAD 1/2 TANK OF GAS. LIGHT WOULD NOT GO OUT, SO I RESEARCHED THE ISSUE ON THE INTERNET AND FOUND THAT IT IS A KNOWN ISSUE ON MY NISSAN TRUCK. THERE IS EVEN A SERVICE BULLETIN OUT ON IT. SO, OFF I WENT AND TOOK IT INT…

Read full complaint

SERVICE ENGINE SOON LIGHT CAME ON AND THE FUEL GAUGE STARTED GOING WACKY AND ULTIMATELY SHOWED EMPTY EVENTHOUGH I HAD 1/2 TANK OF GAS. LIGHT WOULD NOT GO OUT, SO I RESEARCHED THE ISSUE ON THE INTERNET AND FOUND THAT IT IS A KNOWN ISSUE ON MY NISSAN TRUCK. THERE IS EVEN A SERVICE BULLETIN OUT ON IT. SO, OFF I WENT AND TOOK IT INTO MY NISSAN SERVICE DEPARTMENT AND THEY SAID THE CODE P0463 WAS A FUEL SENSING UNIT THAT THEY WOULD REPAIR FOR OVER $350. I SEE THIS AS A SAFETY ISSUE, SINCE MY WIFE DRIVES THE TRUCK AND IF SHE IS UNABLE TO CORRECTLY DETERMINE HOW MUCH FUEL IS IN THE TRUCK SHE RUNS THE RISK OF RUNNING OUT OF GAS IN TRAFFIC OR MAYBE EVEN IN AN UNSAFE NEIGHBORHOOD. *TR

NHTSA ODI #10475708

Mileage unknown · May 12, 2012
Fuel/propulsion System

I AM HAVING A FUEL SENDING UNIT PROBLEM. SAME PROBLEM NISSAN IS HAVING WITH OTHER NISSAN TRUCKS AND THEY HAVE RECALLED THE NEWER MODELS FOR REPLACE AT NO COST TO THE CUSTOMER. ON MY 2005 THEY OFFER NO HELP AT ALL. THEY KNOW SENDING UNIT IS DEFECTIVE. THIS PROBLEM OF MAYBE RUNNING OUT OF GAS AND BEING REAR ENDED I THINK IS A SAFE…

Read full complaint

I AM HAVING A FUEL SENDING UNIT PROBLEM. SAME PROBLEM NISSAN IS HAVING WITH OTHER NISSAN TRUCKS AND THEY HAVE RECALLED THE NEWER MODELS FOR REPLACE AT NO COST TO THE CUSTOMER. ON MY 2005 THEY OFFER NO HELP AT ALL. THEY KNOW SENDING UNIT IS DEFECTIVE. THIS PROBLEM OF MAYBE RUNNING OUT OF GAS AND BEING REAR ENDED I THINK IS A SAFETY CONCERN. NISSAN SHOULD REPAIR ALL TRUCKS THAT THEY HAVE DEFECTIVE PARTS IN. I HAVE HAD NO ACCIDENTS. *TR

NHTSA ODI #10458203

Official recalls

3

10V517000 · Engine And Engine Cooling

Oct 28, 2010

NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.

Consequence & remedy

Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

08V690000 · Air Bags:frontal

Dec 29, 2008

NISSAN IS RECALLING 242,720 MY 2005-2009 PATHFINDER, FRONTIER AND XTERRA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THOSE AREAS OF THE COUNTRY WHICH USE HEAVY CONCENTRATIONS OF ROAD SALT IN THE WINTER, A MIXTURE OF SNOW/WATER AND SALT CAN ENTER INTO THE FRONT CRASH ZONE SENSOR (CZS) HOUSING. IF THIS OCCURS, THE CZS MAY INTERNALLY RUST RESULTING IN A SIGNAL INTERRUPTION. IF THIS HAPPENS, THE RED AIR BAG WARNING LIGHT WILL ILLUMINATE TO ALERT THE VEHICLE OPERATOR.

Consequence & remedy

Consequence: THIS ISSUE COULD RESULT IN THE NON-DEPLOYMENT OF THE DRIVER AND PASSENGER FRONT AIR BAGS IN A CRASH, INCREASING THE RISK OF PERSONAL INJURY.

Remedy: DEALERS WILL REPLACE THE FRONT CZS WITH A REDESIGNED SENSOR. THE RECALL BEGAN ON JANUARY 26, 2009. OWNERS IN THE OTHER STATES WILL RECEIVE EXTENDED WARRANTY COVERAGE FOR THE SENSOR TO 10 YEARS. THESE OWNERS WILL BE NOTIFIED OF THE WARRANTY EXTENSION BY MAIL AND WILL RECEIVE A STICKER TO PLACE IN THEIR WARRANTY BOOKLET EXPLAINING THE EXTENDED WARRANTY COVERAGE. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

06V092000 · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

Mar 30, 2006

ON CERTAIN KING CAB TRUCKS, IN A SEVERE SIDE IMPACT CRASH, THERE IS A POSSIBILITY THAT DEFORMATION OF THE VEHICLE'S BODY COULD CAUSE THE FUEL FILLER CAP TETHER TO BE STRETCHED TO THE POINT OF UNSCREWING THE FUEL FILLER CAP.

Consequence & remedy

Consequence: THIS MAY RESULT IN A FUEL SPILL WHICH IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL CAP TETHER PIN ASSEMBLY WITH A MODIFIED ONE FREE OF CHARGE. THE RECALL BEGAN ON APRIL 24, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

DP12004 · Transmission Failures

Opened Jun 11, 2012 · Closed Oct 22, 2016

Status: closed (inferred from source dates) · Power Train; Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm); Power Train:automatic Transmission:cooling Unit And Lines; Power Train:automatic Transmission:torque Converter

On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.

Additional source detail variants (5)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.

Power Train:automatic Transmission:cooling Unit And Lines

On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.

Power Train:automatic Transmission

On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.

Power Train:automatic Transmission:torque Converter

On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.

Power Train

On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.