NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
25 reportsClear category filter137,650 miles · Jul 18, 2019
Fuel/propulsion System
FUEL GAUGE READS HALF TANK WHEN ACTUALLY EMPTY. VERY DANGEROUS. RAN OUT OF GAS ON A MAJOR INTERSTATE THAT WAS 3 LANES WIDE. I WAS IN THE FAR LEFT LANE WHEN ENGINE STOPPED. POWER STEERING AND BRAKES GO TO MANUAL WHEN ENGINE STOPS. HAD TO MANEUVER TO THE SHOULDER ACROSS 2 LANES TO THE RIGHT WITH NO POWER STEERING AND NO POWER BRAK…
Read full complaint
FUEL GAUGE READS HALF TANK WHEN ACTUALLY EMPTY. VERY DANGEROUS. RAN OUT OF GAS ON A MAJOR INTERSTATE THAT WAS 3 LANES WIDE. I WAS IN THE FAR LEFT LANE WHEN ENGINE STOPPED. POWER STEERING AND BRAKES GO TO MANUAL WHEN ENGINE STOPS. HAD TO MANEUVER TO THE SHOULDER ACROSS 2 LANES TO THE RIGHT WITH NO POWER STEERING AND NO POWER BRAKES WHILE VEHICLE WAS QUICKLY LOSING SPEED. NEARLY WAS HIT SEVERAL TIMES WHILE CHANGING LANES. VEHICLE HAD SLOWED TO ABOUT 25 MPH. WHEN SEMI MUST HAVE FIGURED I HAD NO POWER AND STAYED BEHIND ME BLOCKING TWO LANES SO I COULD GET TO THE SHOULDER. PROBABLY SAVED MY LIFE AND PREVENTED A VERY SERIOUS ACCIDENT. THIS UNRELIABLE FUEL GAUGE PROBLEM SHOULD BE RECALLED REGARDLESS OF AGE OF VEHICLE BEFORE SOMEONE IS KILLED OR SERIOUSLY INJURED.
NHTSA ODI #11232987
Mileage unknown · Jan 21, 2019
Fuel/propulsion System
THE GAS GAUGE MOSTLY SHOWS EMPTY ON A FULL TANK OF GAS AND THE FUEL LIGHT ON THE DASH STAYS LIT. THE DIAGNOSTIC READS P0463, WHICH IS A FUEL LEVEL SENSOR HIGH INPUT CIRCUIT A. SOMETIMES THE FUEL GAUGE WILL READ DIFFERENTLY AS THE TANK GETS CLOSER TO EMPTY. I BOUGHT THIS TRUCK USED AND THIS WAS THE ISSUE AT THE TIME OF PURCHASE…
Read full complaint
THE GAS GAUGE MOSTLY SHOWS EMPTY ON A FULL TANK OF GAS AND THE FUEL LIGHT ON THE DASH STAYS LIT. THE DIAGNOSTIC READS P0463, WHICH IS A FUEL LEVEL SENSOR HIGH INPUT CIRCUIT A. SOMETIMES THE FUEL GAUGE WILL READ DIFFERENTLY AS THE TANK GETS CLOSER TO EMPTY. I BOUGHT THIS TRUCK USED AND THIS WAS THE ISSUE AT THE TIME OF PURCHASE SO I'M NOT SURE WHEN THIS BEGAN.
NHTSA ODI #11171128
Mileage unknown · May 30, 2018
Air BagsFuel/propulsion System
SPANISH - M NISSAN FRONTIER TIENE PROBLEMAS DE VELOCIDAD LOS MECNICOS ME DICEN QUE SON LOS 4 CATALIZADORES ADEMS LA LUZ DE CHECK INGINE EST PRENDIDA Y TAMBIN LA LUZ DE AIR BAR LLEVA 5 MESES PRENDIDA
NHTSA ODI #11098906
80,800 miles · Apr 7, 2018
EngineFuel/propulsion SystemPower Train
MY TRUCK JUST REACHED 80,800 MILES AND IT HAS LOST POWER. I TOOK IT TO THE NISSAN DEALER FOR A DIAGNOSTIC TEST AND IT CAME BACK WITH THE RADIATOR, TRANSMISSION AND THE FUEL PUMP ALL NEED TO BE REPLACED. THEY TOLD ME I HAD NO WARRANTY ON ANY OF THESE PARTS AS OF 2010 AND THEY QUOTED ME ALMOST $7,000 TO REPLACE ALL. AFTER GOING HO…
Read full complaint
MY TRUCK JUST REACHED 80,800 MILES AND IT HAS LOST POWER. I TOOK IT TO THE NISSAN DEALER FOR A DIAGNOSTIC TEST AND IT CAME BACK WITH THE RADIATOR, TRANSMISSION AND THE FUEL PUMP ALL NEED TO BE REPLACED. THEY TOLD ME I HAD NO WARRANTY ON ANY OF THESE PARTS AS OF 2010 AND THEY QUOTED ME ALMOST $7,000 TO REPLACE ALL. AFTER GOING HOME AND LOOKING UP TRANSMISSION SHOPS I FOUND HUNDREDS OF ARTICLES ABOUT THE SAME PROBLEM WITH THOUSANDS OF NISSAN CARS. I HAVE NEVER RECEIVED A NOTICE OF RECALL ON MY TRUCK. THEN I FIND THEY HAVE SNEAKILY EXTENDED THEIR WARRANTY WITHOUT NOTIFYING US AND NOW MY TRUCK IS 12YEARS OLD WITH ONLY 80,800 MILES AND I NEED TO COME UP WITH $7,000 BECAUSE THEY FAILED TO NOTIFY THEIR CLIENTS ABOUT THEIR MISTAKES.
NHTSA ODI #11083756
102,000 miles · Mar 19, 2018
Fuel/propulsion System
AS I WAS DRIVING DOWN THE FREEWAY @ 70MPH IN THE FAST LANE ON INTERSTATE 80 IN THE SAN FRANCISCO'S BAY AREA, MY TRUCK SUDDENLY TURNED OFF. I HAD TO FIGHT TO GET FROM THE FAST LANE, TO GET OVER 4 LANES TO THE SHOULDER. I HAD JUST FILLED UP MY TRUCK IN BERKELEY AT A CHEVRON, I PUT $60.00 IN. SO I KNEW I HAD FUEL. I ENDED UP HA…
Read full complaint
AS I WAS DRIVING DOWN THE FREEWAY @ 70MPH IN THE FAST LANE ON INTERSTATE 80 IN THE SAN FRANCISCO'S BAY AREA, MY TRUCK SUDDENLY TURNED OFF. I HAD TO FIGHT TO GET FROM THE FAST LANE, TO GET OVER 4 LANES TO THE SHOULDER. I HAD JUST FILLED UP MY TRUCK IN BERKELEY AT A CHEVRON, I PUT $60.00 IN. SO I KNEW I HAD FUEL. I ENDED UP HAVING MY TRUCK TOWED HOME. THE FOLLOWING DAY I WENT TO AUTO ZONE AND HOOKED UP THE DIAGNOSTIC READER. IT SAID THAT I NEEDED A NEW FUEL PUMP. UPON FURTHER READ EACH I FOUND OUT THAT THIS IS A TYPICAL ISSUE FOR THE NISSAN FRONTIER. IT HAS BEEN SO MUCH AN ISSUE NISSAN RECALLED 2004 & 2006 MODELS BUT DID NOT INCLUDE THE 2005 MODEL EVEN THOUGH ITS THE SAME FAULTY PART! I HAVE NOT BEEN ABLE TO HAVE THE FUEL PUMP SENSOR REPLACED DUE TO COST AND I AM A SINGLE MOTHER. THIS HAS HAPPENED ON NUMEROUS OCCASIONS AND IS A SEVERE HAZARD THAT SHOULD BE ENFORCED BY YOU TO GET NISSAN TO INCLUDE THE 2005 NISSAN FRONTIER FOR THIS DEATH HAZARD FUEL PUMP SENSOR ISSUE!!!
NHTSA ODI #11080157
53,000 miles · Nov 10, 2017
Fuel/propulsion System
SAFETY RECALL FUEL SENSOR SENDING UNIT - OUR VEHICLE IS IN IMPECCABLE SHAPE AND GARAGED WITH 53,000 MILES - WARRANTY/RECALL ON ISSUE. NISSAN WILL NOT FIX THIS SAFETY ISSUE. FUEL SENSOR MALFUNCTION. ALSO HAPPENED ON OUR 2006 NISSAN PATHFINDER AND WAS COVERED. FULL TANK OF GAS READS EMPTY.
NHTSA ODI #11045230
77,000 miles · Aug 14, 2017
Fuel/propulsion System
RADIATOR LEAKED INTO TRANSMISSION COOLER AND DESTROYED TRANSMISSION. REBUILD OF TRANSMISSION AND RADIATOR REPLACEMENT COST OF OVER 5000 VEHICLE STALLED IN MIDDLE OF INTERSECTION
NHTSA ODI #11014984
78,000 miles · May 31, 2016
Fuel/propulsion System
NISSAN FRONTIER 2005 TRUCK: FUEL TANK SENDING UNIT STARTED SHOWING VARIABLE FUEL LEVELS, FLUCTUATING WILDLY, THEN COMPLETELY STOPPED FUNCTIONING. THIS AFTER SOME 75,000 MILES. NO PRIOR WARNING. NO EXTREME USE CONDITIONS, JUST NORMAL EVERYDAY DRIVING ON THIS VEHICLE. DEALER REFUSED REPLACEMENT BECAUSE IT WAS OVER 75,000 MILE…
Read full complaint
NISSAN FRONTIER 2005 TRUCK: FUEL TANK SENDING UNIT STARTED SHOWING VARIABLE FUEL LEVELS, FLUCTUATING WILDLY, THEN COMPLETELY STOPPED FUNCTIONING. THIS AFTER SOME 75,000 MILES. NO PRIOR WARNING. NO EXTREME USE CONDITIONS, JUST NORMAL EVERYDAY DRIVING ON THIS VEHICLE. DEALER REFUSED REPLACEMENT BECAUSE IT WAS OVER 75,000 MILES.
NHTSA ODI #10871494
94,000 miles · Apr 20, 2016
EngineFuel/propulsion SystemService Brakes
VEHICLE SHUT OFF WHILE DRIVING ON THE HIGHWAY. I WAS DRIVING DOWN THE HIGHWAY AT 65 MPH WHEN THE TRUCK MADE A QUICK JERK AND THEM COMPLETELY SHUT OFF. I CAME VERY CLOSE TO CAUSING A HIGHWAY PILE UP!! I HAD NO POWER, NO STEERING NO NOTHING. LUCKILY I WAS ABLE TO GET ACROSS 3 LANES SAFELY. CARS WERE SLAMMING ON BRAKES AND LUC…
Read full complaint
VEHICLE SHUT OFF WHILE DRIVING ON THE HIGHWAY. I WAS DRIVING DOWN THE HIGHWAY AT 65 MPH WHEN THE TRUCK MADE A QUICK JERK AND THEM COMPLETELY SHUT OFF. I CAME VERY CLOSE TO CAUSING A HIGHWAY PILE UP!! I HAD NO POWER, NO STEERING NO NOTHING. LUCKILY I WAS ABLE TO GET ACROSS 3 LANES SAFELY. CARS WERE SLAMMING ON BRAKES AND LUCKILY I DIDNT KILL MYSELF OR ANYONE ELSE. ONCE I GOT THE THE SIDE OF THE ROAD I WAS ABLE TO GET THE TRUCK GOING AND SAFELY GET TO AN EXIT. I CREEPED HOME ON A WING A PRAYER AND NOW THE TRUCK IS SITTING IN MY DRIVEWAY. I DONT DARE TO USE IT AND I NEED IT. I AM SCARED TO DRIVE IT, ITHAS GIVEN ME ANXIETY, IT WAS HORRIFIC. MY TRUCK HAS 94220 MILES ON IT.
NHTSA ODI #10860461
128,232 miles · Feb 25, 2016
Fuel/propulsion System
MY TRUCKS FUEL GAUGE DOES NOT REGISTER, I UNDERSTAND THERE WAS A RECALL. SO I CALLED 2 DEALERS THEY TOLD ME THAT MY VIN/TRUCK IS NOT COVERED. BUT WHAT I'VE SEEN IS THAT IT IS AN ACCIDENT WAITING TO HAPPEN. IT DOES IT ALL THE TIME, PARKED, ON THE STREETS OR FREEWAY WHICH I DRIVE DAILY FOR WORK. NO INJURY, CRASH OR FATALITY YET…
Read full complaint
MY TRUCKS FUEL GAUGE DOES NOT REGISTER, I UNDERSTAND THERE WAS A RECALL. SO I CALLED 2 DEALERS THEY TOLD ME THAT MY VIN/TRUCK IS NOT COVERED. BUT WHAT I'VE SEEN IS THAT IT IS AN ACCIDENT WAITING TO HAPPEN. IT DOES IT ALL THE TIME, PARKED, ON THE STREETS OR FREEWAY WHICH I DRIVE DAILY FOR WORK. NO INJURY, CRASH OR FATALITY YET. I LOVE MY TRUCK, WORK IN A LEVEL 1 TRAUMA CENTER, I SEE MANY CAR ACCIDENT VICTIM'S WHEN IT COULD HAVE BEEN AVOIDED, LIKE WITH ME NOW. PLEASE HELP ME I WOULD BE FOREVER GRATEFUL!! I PRAY NISSAN WILL DO WHAT IS RIGHT!!
NHTSA ODI #10838189
Official recalls
3Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Dec 29, 2008
NISSAN IS RECALLING 242,720 MY 2005-2009 PATHFINDER, FRONTIER AND XTERRA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THOSE AREAS OF THE COUNTRY WHICH USE HEAVY CONCENTRATIONS OF ROAD SALT IN THE WINTER, A MIXTURE OF SNOW/WATER AND SALT CAN ENTER INTO THE FRONT CRASH ZONE SENSOR (CZS) HOUSING. IF THIS OCCURS, THE CZS MAY INTERNALLY RUST RESULTING IN A SIGNAL INTERRUPTION. IF THIS HAPPENS, THE RED AIR BAG WARNING LIGHT WILL ILLUMINATE TO ALERT THE VEHICLE OPERATOR.
Consequence & remedy
Consequence: THIS ISSUE COULD RESULT IN THE NON-DEPLOYMENT OF THE DRIVER AND PASSENGER FRONT AIR BAGS IN A CRASH, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE FRONT CZS WITH A REDESIGNED SENSOR. THE RECALL BEGAN ON JANUARY 26, 2009. OWNERS IN THE OTHER STATES WILL RECEIVE EXTENDED WARRANTY COVERAGE FOR THE SENSOR TO 10 YEARS. THESE OWNERS WILL BE NOTIFIED OF THE WARRANTY EXTENSION BY MAIL AND WILL RECEIVE A STICKER TO PLACE IN THEIR WARRANTY BOOKLET EXPLAINING THE EXTENDED WARRANTY COVERAGE. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 30, 2006
ON CERTAIN KING CAB TRUCKS, IN A SEVERE SIDE IMPACT CRASH, THERE IS A POSSIBILITY THAT DEFORMATION OF THE VEHICLE'S BODY COULD CAUSE THE FUEL FILLER CAP TETHER TO BE STRETCHED TO THE POINT OF UNSCREWING THE FUEL FILLER CAP.
Consequence & remedy
Consequence: THIS MAY RESULT IN A FUEL SPILL WHICH IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL CAP TETHER PIN ASSEMBLY WITH A MODIFIED ONE FREE OF CHARGE. THE RECALL BEGAN ON APRIL 24, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP12004 · Transmission Failures
Opened Jun 11, 2012 · Closed Oct 22, 2016
Status: closed (inferred from source dates) · Power Train; Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm); Power Train:automatic Transmission:cooling Unit And Lines; Power Train:automatic Transmission:torque Converter
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Additional source detail variants (5)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission:cooling Unit And Lines
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission:torque Converter
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Illustration