Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
720–25K
7425–50K
12150–75K
23575–100K
239100–150K
60150K+
801 reports with mileage · 246 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 594 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 128 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
29 crash reports28 fire reports23 injury reports
What owners actually said
1,047 reports
118,000 miles · Nov 19, 2013
EngineSteeringVehicle Speed Control
MY CAR WON'T ACCELERATE BEYOND 20 MPH, THEN ENGINE WOULD STALL WHILE IN DRIVE GEAR. TOOK IT TO MY MECHANIC WHO TURNED OFF THE ENGINE SERVICE LIGHT WHICH ALLOWED ME TO ACCELERATE TO NORMAL SPEED. HOWEVER, THE ENGINE KEEPS STALLING WHILE I'M DRIVING. I NEARLY HAD SEVERAL ACCIDENTS WHILE DRIVING ON THE STREET AND EXITING THE F…
Read full complaint
MY CAR WON'T ACCELERATE BEYOND 20 MPH, THEN ENGINE WOULD STALL WHILE IN DRIVE GEAR. TOOK IT TO MY MECHANIC WHO TURNED OFF THE ENGINE SERVICE LIGHT WHICH ALLOWED ME TO ACCELERATE TO NORMAL SPEED. HOWEVER, THE ENGINE KEEPS STALLING WHILE I'M DRIVING. I NEARLY HAD SEVERAL ACCIDENTS WHILE DRIVING ON THE STREET AND EXITING THE FREEWAY. LUCKILY I CAN NOTICE THE ENGINE FAILING BEFORE IT COMPLETELY SHUT DOWN SO I HIT MY HAZARD LIGHTS EACH TIME TO AVOID ACCIDENT AND NOTIFY MOTORISTS BEHIND ME SOMETHING IS WRONG. SEVERAL TIMES CAR HAD TO SWERVED SUDDENLY AROUND ME TO AVOID REAR ENDING MY CAR. THEN YESTERDAY WHEN MY ENGINE STALLED WHILE PULLING OUT OF A PARKING LOT MY ENGINE STALLED AGAIN AND THE STEERING WHEELS LOCKED WHICH ALMOST CAUSED MY CAR TO ROLL STRAIGHT INTO A BRICK WALL. I HAD TO QUICKLY TURN OFF THE ENGINE PUT MY GEAR TO PARK THEN TURN BACK ON THE ENGINE TO GET POWER TO STEER AWAY FROM THE BRICK WALL JUST IN TIME. I TOOK MY CAR BACK TO MY MECHANIC TODAY WHO RAN DIAGNOSTIC AND SAID THE CAR'S CRANKSHAFT AND CRANKSHAFT NEED TO BE REPLACED. I SEARCHED ONLINE AND READ ABOUT THE RECALL FOR SIMILAR INCIDENTS WITH MY MAKE AND MODEL. HOWEVER, WHEN I CONTACT THE LOCAL NISSAN DEALER THEY SAY MY VIN IS NOT INCLUDED IN THE RECALL. SOMETHING IS WRONG HERE IF SO MANY 2002 NISSAN ALTIMA HAVE THIS SAME PROBLEM BUT ONLY A SELECTED VEHICLE ARE INCLUDED IN THE RECALL. PLEASE INVESTIGATE AND FINE NISSAN FOR THIS FAULTY PARTS ENDANGERING PUBLIC SAFETY AND THE DRIVERS. *TR
NHTSA ODI #10552956
121,000 miles · Nov 13, 2013
Engine
TL* THE CONTACT OWNS A 2002 NISSAN ALTIMA. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 121,000.
NHTSA ODI #10552122
57,000 miles · Oct 18, 2013
Structure
DURING A SAFETY INSPECTION I WAS RECENTLY SHOWN TWO LARGE HOLES IN THE FLOOR PAN OF THE CAR THAT HAVE OBVIOUSLY BEEN RUSTING FOR QUITE A LONG TIME. I WAS ADVISED THAT THIS IS A SAFETY CONCERN BECAUSE OF THE EXTENT OF THE DAMAGE AND THEIR LOCATIONS UNDER THE DRIVER AND PASSENGER SEATS. FURTHER RESEARCH ON THE INTERNET HAS PROVE…
Read full complaint
DURING A SAFETY INSPECTION I WAS RECENTLY SHOWN TWO LARGE HOLES IN THE FLOOR PAN OF THE CAR THAT HAVE OBVIOUSLY BEEN RUSTING FOR QUITE A LONG TIME. I WAS ADVISED THAT THIS IS A SAFETY CONCERN BECAUSE OF THE EXTENT OF THE DAMAGE AND THEIR LOCATIONS UNDER THE DRIVER AND PASSENGER SEATS. FURTHER RESEARCH ON THE INTERNET HAS PROVEN THIS IS A COMMON PROBLEM FOR ALL THE ALTIMAS OF THIS ERA. THE INSPECTION SHOP ALSO TOLD ME THAT THEY HAVE SEEN IT MANY TIMES BEFORE ON ALTIMAS. NISSAN IS NOT RECEPTIVE TO ANY COMPLAINS ABOUT THIS PROBLEM FROM WHAT I HAVE READ AND IT'S CLEARLY A GENERIC PROBLEM WITH THIS CAR. SINCE THIS PROBLEM OBVIOUSLY STARTED A LONG TIME AGO WITH NO ONE NOTICING IT I HAVE MADE AN ESTIMATE AS TO THE DATE AND MILEAGE WHEN IT MAY HAVE FIRST BEEN NOTICEABLE. THE CAR CURRENTLY HAS 72000 MILES ON IT. *TR
NHTSA ODI #10548393
70,000 miles · Oct 16, 2013
Engine
MY 2002 NISSAN ALTIMA 2.5S HAS AROUND 70K MILES ON IT AND SO FAR HAD BEEN RUNNING VERY WELL UNTIL VERY RECENTLY, WHEN THE SERVICE ENGINE LIGHT TURNED ON LAST WEEKEND. WITHIN A DAY OR TWO, THE CAR STARTED RUNNING A LITTLE ROUGH. A FEW DAYS AGO THE CAR SHOWED LOW OIL PRESSURE LIGHT ON THE DASH BOARD. WHEN I CHECKED FOR THE ENGINE …
Read full complaint
MY 2002 NISSAN ALTIMA 2.5S HAS AROUND 70K MILES ON IT AND SO FAR HAD BEEN RUNNING VERY WELL UNTIL VERY RECENTLY, WHEN THE SERVICE ENGINE LIGHT TURNED ON LAST WEEKEND. WITHIN A DAY OR TWO, THE CAR STARTED RUNNING A LITTLE ROUGH. A FEW DAYS AGO THE CAR SHOWED LOW OIL PRESSURE LIGHT ON THE DASH BOARD. WHEN I CHECKED FOR THE ENGINE OIL LEVEL, THERE WAS BARELY ANY OIL LEFT. I IMMEDIATELY PUT 5 QTS OF MOBILE FULL SYNTHETIC OIL AND TOOK IT TO THE NISSAN DEALERSHIP IN DENVILLE, NJ. THERE I GOT A SHOCKER THAT THE CATALYTIC CONVERTOR OF MY CAR GOT SUCKED INTO THE ENGINE AND FURTHERMORE SOME OF THAT MATERIAL WAS BRACING AGAINST THE CYLINDER WALLS. IT WAS THE REASON WHY MY CAR WAS RUNNING ROUGH SOMETIMES AND BURNING OIL. I WAS FURTHER TOLD THAT THE ONLY FIX TO THIS PROBLEM IS TO REPLACE BOTH THE ENGINE AS WELL AS THE CATALYTIC CONVERTOR. JOB COST WAS ESTIMATED TO BE AROUND $6000 TO $6500. THE DEALERSHIP FURTHERMORE WARNED ME ABOUT THE FIRE HAZARD OR ENGINE SEIZURE DUE TO OVERHEATING. WITH SOME INVESTIGATION I FOUND A NHSTA RECALL ON MY GENERATION OF ALTIMAS-NHTSA CAMPAIGN# 03V084000. IN ORDER TO SEEK FURTHER HELP IN THIS REGARDS, I OPENED UP A CASE WITH NISSAN MOTORS USA- CASE # 12257145. I GOT A CALLBACK FROM THE REGIONAL REPRESENTATIVE ON THURSDAY- 10/10/2013 WHERE I WAS TOLD THAT MY VIN DID NOT QUALIFY FOR A RECALL WHICH HAD BEEN ISSUED BY NISSAN EARLIER. I ASKED HER ABOUT THE NHSTA CAMPAIGN FOR MY CAR, FOR WHICH SHE ASKED ME TO HOLD ON TO THE CAR FOR A FEW MORE DAYS, BEFORE THEY COULD RESOLVE THE ISSUE. ON, 10/14/2013 I GOT A CALL FROM THE SAME REPRESENTATIVE AND THIS TIME I WAS GIVEN A DIFFERENT ANSWER STATING THAT ALTHOUGH THE CATALYTIC CONVERTOR HAS A WARRANTY OF 80,000 MILES BUT IT IS FOR ONLY 8 YRS. I DO NOT QUALIFY FOR THE WARRANTY, BECAUSE ALTHOUGH I DROVE VERY LESS, BUT STILL MY CAR IS 10+YRS OLD. SHE FURTHER TOLD ME THAT NISSAN WILL NOT BARE ANY EXPENSE ON MY CAR. *TR
NHTSA ODI #10548174
14,300 miles · Oct 13, 2013
Engine
SPARK PLUG BENTING. *TR
NHTSA ODI #10547774
98,026 miles · Oct 10, 2013
Structure
TL* THE CONTACT OWNS A 2002 NISSAN ALTIMA. THE CONTACT STATED THAT AN INDEPENDENT MECHANIC INFORMED HIM THAT THE UNDER CARRIAGE WAS CORRODED NEAR THE FRONT PASSENGER'S SIDE FLOOR BOARD. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 98,026.
NHTSA ODI #10547556
Mileage unknown · Oct 2, 2013
Structure
TL* THE CONTACT OWNS A 2002 NISSAN ALTIMA. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE FLOORBOARDS WERE RUSTED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE THE FAILURE WAS CONFIRMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE VIN AND FAILURE MILEAGE WAS UNAVAILABLE.
NHTSA ODI #10546514
130,000 miles · Sep 15, 2013
Air BagsCrashInjury
I WAS AT A LIGHT PROCEEDING TO GO AND A VEHICLE DID NOT YIELD TO TURN AND SHE SLAMMED RIGHT INTO THE FRONT OF MY VEHICLE AT 50 MPH, MY AIR BAGS DIDN'T DEPLOY AND MY HEAD HIT THE WINDSHIELD .IM GLAD I HAD MY SEATBELT .THE WINDSHIELD OF THE VEHICLE WAS BROKEN BY MY HEAD. *TR
NHTSA ODI #10543686
107,000 miles · Sep 11, 2013
Structure
ON ABOVE DATE FOUNT THAT THERE WAS SUBSTANTIAL RUST ON THE DRIVER AND FRONT PASSENGER FLOORBOARDS. THERE IS NO OTHER RUST ON THE VEHICLE DUE TO CAR BEING GARAGE-KEPT AT HOME. RUST IS COMPLETELY THROUGH THE FLOORBOARD ON THE PASSENGER SIDE IN A FEW SMALL AREAS. COST TO REPAIR AT ONE BODY SHOP IS $2303.00. ESTIMATOR AT SHOP ST…
Read full complaint
ON ABOVE DATE FOUNT THAT THERE WAS SUBSTANTIAL RUST ON THE DRIVER AND FRONT PASSENGER FLOORBOARDS. THERE IS NO OTHER RUST ON THE VEHICLE DUE TO CAR BEING GARAGE-KEPT AT HOME. RUST IS COMPLETELY THROUGH THE FLOORBOARD ON THE PASSENGER SIDE IN A FEW SMALL AREAS. COST TO REPAIR AT ONE BODY SHOP IS $2303.00. ESTIMATOR AT SHOP STATED THAT THIS SHOULD NOT BE HAPPENING TO A CAR THAT IS THIS OLD AND WITH THE MILEAGE IT HAS. HAVE FOUND ON THE INTERNET THAT THIS IS A COMMON PROBLEM WITH ALTIMAS FROM 2002 TO AT LEAST 2006 MODEL YEARS. MY WIFE AND I HAVE BEEN THE ONLY OWNERS OF THIS VEHICLE. NISSAN DEALER HAS BEEN USED FOR MULTIPLE REPAIRS AND OIL CHANGES AND NEVER INDICATED THE RUST PROBLEM WHICH IS VISIBLE UNDER THE CAR (THEY DO A SAFETY INSPECTION OF THE VEHICLE AS PART OF THEIR NORMAL SERVICE PROCEDURE WHEN THEY HAVE POINTED OUT OTHER ISSUES WITH THE VEHICLE OVER THE YEARS). I TAKE MY CAR TO THE NISSAN DEALER IN CHANTILLY, VA. *TR
NHTSA ODI #10543163
205,000 miles · Aug 26, 2013
Traction Control System
MY AUTOMOBILE TCS OFF SLIP LIGHT CAME ON AND THE CAR LOST ACCELERATION. ONCE CAR SHUTOFF THE VEHICLE HESITATES FOR A LENGTH OF TIME BEFORE IT WILL START. THIS HAS OCCURRED FOR 3 DAYS IN A ROW. I AM SO AFRAID THIS CAR IS GOING TO CAUSE AN ACCIDENT. *TR
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.5L ENGINE, THE CRANKSHAFT POSITION SENSOR CAN OVERHEAT CAUSING A BRIEF INTERRUPTION IN THE SIGNAL OUTPUT FROM THE SENSOR.
Consequence & remedy
Consequence: IF THE INTERRUPTION IN THE SIGNAL FROM THE CRANKSHAFT POSITION SENSOR IS SO BRIEF THAT THE ELECTRONIC CONTROL MODULE (ECM) LOGIC DOES NOT HAVE TIME TO DIAGNOSE THE CONDITION, THE ENGINE MAY STOP RUNNING WITHOUT WARNING WHILE THE VEHICLE IS DRIVEN AT A LOW SPEED INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ECM FREE OF CHARGE. CERTAIN MY 2006 ALTIMAS WHICH HAVE BEEN PREVIOUSLY REMEDIED UNDER RECALL CAMPAIGN 06V223 (NISSAN R0606) ARE NOT INCLUDED IN THIS RECALL SINCE THE REPROGRAMMING FOR 06V223 ALSO INCLUDED THIS REPROGRAMMING. THE RECALL BEGAN ON DECEMBER 31, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
ON CERTAIN PASSENGER VEHICLES, THE CIRCUIT BOARD FOR THE CRANK POSITION SENSOR OR CAM POSITION SENSOR MAY HAVE AN IMPROPER SOLDER JOINT DUE TO SOLDER DEFORMATION CAUSED BY HEAT STRESS ACCELERATED BY THE EXISTENCE OF FLUX RESIDUE DURING THE SOLDERING PROCESS.
Consequence & remedy
Consequence: THIS COULD CAUSE THE "SERVICE ENGINE SOON" WARNING LIGHT TO COME ON, CREATE A NO START CONDITION, CAUSE REDUCED ENGINE POWER, OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING DURING VEHICLE OPERATION, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CRANK POSITION SENSORS. CAMSHAFT POSITION SENSOR(S), AND IN SOME CASES, THE VARIABLE TIMING CONTROL SENSOR(S). VEHICLES INVOLVED IN A PREVIOUS RECALL CAMPAIGN, 01V357, ARE ALSO INCLUDED IN THIS NEW CAMPAIGN. THE REPLACEMENT SENSORS USED IN THAT CAMPAIGN ARE ALSO AFFECTED. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261 OR INFINITI AT 1-800-662-6200.
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, COLORADO, CONNECTICUT, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WISCONSIN, AND WYOMING. AT EXTREMELY COLD TEMPERATURES, MOISTURE IN THE FUEL TANK COULD FREEZE AND FORM ICE CRYSTALS. THESE ICE CRYSTALS MAY OBSTRUCT THE SUCTION OPENING OF THE FUEL PUMP.
Consequence & remedy
Consequence: THIS CAN PREVENT THE SUPPLY OF FUEL TO THE ENGINE AND CAUSE THE ENGINE TO STOP, WHICH COULD RESULT IN A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A SCREEN AT THE SUCTION OPENING OF THE FUEL PUMP TO PREVENT ICE CRYSTALS FROM BLOCKING THE OPENING. OWNER NOTIFICATION BEGAN ON AUGUST 18, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-333-0829.
ON CERTAIN VEHICLES EQUIPPED WITH THE 2.5 LITER ENGINE, THE EXHAUST PIPE HANGER PIN MAY CATCH DEBRIS FROM THE ROAD THAT COULD BE IGNITED BY CONTACT WITH THE MAIN CATALYST. ALSO ON 2002 ALTIMA AND SENTRA VEHICLES, CERTAIN ENGINE OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT AND DAMAGE THE CATALYST SUBSTRATE.
Consequence & remedy
Consequence: EITHER OF THESE TWO CONDITIONS COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REMOVE THE PROTRUDING PORTION OF THE EXHAUST PIPE HANGER PIN. IN ADDITION TO THE CORRECTIVE ACTION, IN ORDER TO REDUCE THE RISK OF FIRE IN THE EVENT OF POOR OR IMPROPER MAINTENANCE THAT COULD RESULT IN OIL SPILLAGE, HEAT SHIELD(S) WILL BE INSTALLED ON THE PRE-CATALYST AND EXHAUST TUBE. OWNER NOTIFICATION BEGAN ON JULY 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261. NISSAN RECALL NOS. R3007, R3014, R3015, R3016, R3017. ALSO ON 2002 ALTIMA AND SENTRA VEHICLES, CERTAIN ENGINE OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT AND DAMAGE THE CATALYST SUBSTRATE. IF SUBSTRATE PARTICLES ENTER THE COMBUSTION CHAMBER, THEY COULD SCORE THE CYLINDER WALLS, RESULTING IN INCREASED OIL CONSUMPTION. IF THE ENGINE OIL LEVEL IS NOT CHECKED ON A PERIODIC BASIS AND DROPS BELOW THE LOW LEVEL, AND THE DRIVER CONTINUES TO OPERATE THE VEHICLE IGNORING NOTICEABLE ENGINE NOISE, ENGINE DAMAGE MAY OCCUR WHICH COULD RESULT IN A FIRE. THE PRE-CATALYST WILL BE TESTED TO ENSURE IT IS WORKING PROPERLY AND REPLACED IF NECESSARY. IF DAMAGE IS FOUND INSIDE THE PRE-CATALYST, IT WILL BE NECESSARY TO REPLACE THE ENGINE.
ON CERTAIN VEHICLES, THE ELECTRICAL CONNECTOR FOR THE DRIVER AIR BAG MAY COME LOOSE. IF THE CONNECTOR COMES LOOSE, THE SUPPLEMENTAL AIR BAG WARNING LIGHT FLASHES INTERMITTENTLY.
Consequence & remedy
Consequence: THE DRIVER SIDE AIR BAG WILL NOT DEPLOY IN THE EVENT OF A CRASH, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSTALL A RETAINING CLIP ON THE CLOCK SPRING ELECTRICAL CONNECTOR. OWNER NOTIFICATION BEGAN APRIL 21, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE02078 · Engine Compartment Fires
Opened Oct 18, 2002 · Closed Mar 25, 2003
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION ON OCTOBER 18, 2002 BASED ON THREE REPORTS INDICATING THAT THE ENGINE COMPARTMENT IN MODEL YEAR (MY) 2002 NISSAN ALTIMA VEHICLES EQUIPPED WITH THE 2.5 LITER ENGINE CAUGHT ON FIRE WITHOUT ANY WARNING TO THE DRIVER WHILE THE VEHICLE WAS DRIVEN AT HIGHWAY SPEEDS.ONE NON-BURN RELATED INJURY WAS REPORTED AS A RESULT OF THE COMPLAINANT EXITING THE VEHICLE IN HASTE AFTER IT HAD CAUGHT ON FIRE.NISSAN DISCOVERED THAT ONE OF THE HANGER PINS WHICH HOLDS EXHAUST PIPE IN PLACE MAY CATCH DEBRIS FROM THE ROAD.IF THE DEBRIS WERE TO COME IN CONTACT WITH THE MAIN CATALYST, A FIRE COULD RESULT.THIS CONDITION IS ALSO PRESENT IN MY 2003 NISSAN ALTIMA VEHICLES BUILT THRU FEBRUARY 18, 2003.NISSAN ALSO STATED IN ITS DEFECT INFORMATION REPORT THAT ON MY 2002 ALTIMAS AND SENTRAS (EQUIPPED WITH THE 2.5-LITER ENGINE) THAT CERTAIN OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT, WHICH WOULD CAUSE CATALYST SUBSTRATE PARTICLES TO FLOW INTO THE ENGINE.THESE PARTICLES CAN SCORE THE CYLINDER WALLS WHICH RESULTS IN INCREASE OIL CONSUMPTION.IF THE ENGINE OIL LEVEL IS LOW, ENGINE NOISE AND DAMAGE CAN OCCUR WHICH COULD RESULT IN A FIRE.THE RECALL INCLUDES 268,000 MY 2002-2003 ALTIMAS AND 2002 SENTRAS EQUIPPED WITH THE 2.5-LITER ENGINE.TO CORRECT THE CONDITION NISSAN WILL REMOVE THE PROTRUDING PORTION OF THE EXHAUST PIN ON THE ALTIMAS.NISSAN IS DEVELOPING A CORRECTIVE ACTION TO ADDRESS THE PRE-CATALYST.IN ADDITION TO THE CORRECTIVE ACTION, NISSAN WILL INSTALL HEAT SHIELDS ON THE PRE-CATALYST AND THE SURROUNDING EXHAUST TUBING.NISSAN WILL BEGIN OWNER NOTIFICATION IN MAY OF 2003.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION ON OCTOBER 18, 2002 BASED ON THREE REPORTS INDICATING THAT THE ENGINE COMPARTMENT IN MODEL YEAR (MY) 2002 NISSAN ALTIMA VEHICLES EQUIPPED WITH THE 2.5 LITER ENGINE CAUGHT ON FIRE WITHOUT ANY WARNING TO THE DRIVER WHILE THE VEHICLE WAS DRIVEN AT HIGHWAY SPEEDS.ONE NON-BURN RELATED INJURY WAS REPORTED AS A RESULT OF THE COMPLAINANT EXITING THE VEHICLE IN HASTE AFTER IT HAD CAUGHT ON FIRE.NISSAN DISCOVERED THAT ONE OF THE HANGER PINS WHICH HOLDS EXHAUST PIPE IN PLACE MAY CATCH DEBRIS FROM THE ROAD.IF THE DEBRIS WERE TO COME IN CONTACT WITH THE MAIN CATALYST, A FIRE COULD RESULT.THIS CONDITION IS ALSO PRESENT IN MY 2003 NISSAN ALTIMA VEHICLES BUILT THRU FEBRUARY 18, 2003.NISSAN ALSO STATED IN ITS DEFECT INFORMATION REPORT THAT ON MY 2002 ALTIMAS AND SENTRAS (EQUIPPED WITH THE 2.5-LITER ENGINE) THAT CERTAIN OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT, WHICH WOULD CAUSE CATALYST SUBSTRATE PARTICLES TO FLOW INTO THE ENGINE.THESE PARTICLES CAN SCORE THE CYLINDER WALLS WHICH RESULTS IN INCREASE OIL CONSUMPTION.IF THE ENGINE OIL LEVEL IS LOW, ENGINE NOISE AND DAMAGE CAN OCCUR WHICH COULD RESULT IN A FIRE.THE RECALL INCLUDES 268,000 MY 2002-2003 ALTIMAS AND 2002 SENTRAS EQUIPPED WITH THE 2.5-LITER ENGINE.TO CORRECT THE CONDITION NISSAN WILL REMOVE THE PROTRUDING PORTION OF THE EXHAUST PIN ON THE ALTIMAS.NISSAN IS DEVELOPING A CORRECTIVE ACTION TO ADDRESS THE PRE-CATALYST.IN ADDITION TO THE CORRECTIVE ACTION, NISSAN WILL INSTALL HEAT SHIELDS ON THE PRE-CATALYST AND THE SURROUNDING EXHAUST TUBING.NISSAN WILL BEGIN OWNER NOTIFICATION IN MAY OF 2003.
Engine And Engine Cooling:exhaust System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION ON OCTOBER 18, 2002 BASED ON THREE REPORTS INDICATING THAT THE ENGINE COMPARTMENT IN MODEL YEAR (MY) 2002 NISSAN ALTIMA VEHICLES EQUIPPED WITH THE 2.5 LITER ENGINE CAUGHT ON FIRE WITHOUT ANY WARNING TO THE DRIVER WHILE THE VEHICLE WAS DRIVEN AT HIGHWAY SPEEDS.ONE NON-BURN RELATED INJURY WAS REPORTED AS A RESULT OF THE COMPLAINANT EXITING THE VEHICLE IN HASTE AFTER IT HAD CAUGHT ON FIRE.NISSAN DISCOVERED THAT ONE OF THE HANGER PINS WHICH HOLDS EXHAUST PIPE IN PLACE MAY CATCH DEBRIS FROM THE ROAD.IF THE DEBRIS WERE TO COME IN CONTACT WITH THE MAIN CATALYST, A FIRE COULD RESULT.THIS CONDITION IS ALSO PRESENT IN MY 2003 NISSAN ALTIMA VEHICLES BUILT THRU FEBRUARY 18, 2003.NISSAN ALSO STATED IN ITS DEFECT INFORMATION REPORT THAT ON MY 2002 ALTIMAS AND SENTRAS (EQUIPPED WITH THE 2.5-LITER ENGINE) THAT CERTAIN OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT, WHICH WOULD CAUSE CATALYST SUBSTRATE PARTICLES TO FLOW INTO THE ENGINE.THESE PARTICLES CAN SCORE THE CYLINDER WALLS WHICH RESULTS IN INCREASE OIL CONSUMPTION.IF THE ENGINE OIL LEVEL IS LOW, ENGINE NOISE AND DAMAGE CAN OCCUR WHICH COULD RESULT IN A FIRE.THE RECALL INCLUDES 268,000 MY 2002-2003 ALTIMAS AND 2002 SENTRAS EQUIPPED WITH THE 2.5-LITER ENGINE.TO CORRECT THE CONDITION NISSAN WILL REMOVE THE PROTRUDING PORTION OF THE EXHAUST PIN ON THE ALTIMAS.NISSAN IS DEVELOPING A CORRECTIVE ACTION TO ADDRESS THE PRE-CATALYST.IN ADDITION TO THE CORRECTIVE ACTION, NISSAN WILL INSTALL HEAT SHIELDS ON THE PRE-CATALYST AND THE SURROUNDING EXHAUST TUBING.NISSAN WILL BEGIN OWNER NOTIFICATION IN MAY OF 2003.
Illustration