IllustrationI EXPERIENCED WARPED ROTORS ON MY 2002 ALTIMA AFTER DRIVING FOR LESS THAN 18 MONTHS. THIS WAS A PREMATURE FAILURE THAT IS NOT COVERED UNDER WARRANTEE. PADS WERE ALSO REPLACED.*AK
2002 Nissan Altima
Owner reports · Recalls · Investigations
More warning signs than most Altima years
Owner complaints for the 2002 Nissan Altima are substantially higher than the model-year median of 231.
About this comparison →How this year compares
Owner complaints by model year
Compare all Altima years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
720–25K
7425–50K
12150–75K
23575–100K
239100–150K
60150K+
801 reports with mileage · 246 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 594 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 128 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
29 crash reports28 fire reports23 injury reports
Service Brakes, Hydraulic complaints
25 reportsREAR BRAKE CALIPERS CORRODED AND FAILED TO PERFORM PROPERLY. CALIPERS SEIZED IN AN APPLIED BRAKE FASHION (CONSTANT PRESSURE ON THE ROTORS). BOTH REAR BRAKES HAVE SUBSEQUENTLY FAILED TO THE POINT WHERE THERE IS NO MORE PAD ON THE BRAKES, ONLY METAL-TO-METAL CONTACT BETWEEN THE PAD BASE AND THE ROTORS. THE PADS, SHIMS, AND ROTO…
Read full complaint
REAR BRAKE CALIPERS CORRODED AND FAILED TO PERFORM PROPERLY. CALIPERS SEIZED IN AN APPLIED BRAKE FASHION (CONSTANT PRESSURE ON THE ROTORS). BOTH REAR BRAKES HAVE SUBSEQUENTLY FAILED TO THE POINT WHERE THERE IS NO MORE PAD ON THE BRAKES, ONLY METAL-TO-METAL CONTACT BETWEEN THE PAD BASE AND THE ROTORS. THE PADS, SHIMS, AND ROTORS HAVE TO BE REPLACED. THE CAR IS ONLY 1.5 YRS OLD, WITH 35,000 HIGHWAY MILES ON IT. THIS IS UNACCEPTABLE. THE DEALER HAS INDICATED THAT THE FRONT BRAKES ARE CLOSE TO THE SAME CONDITION. DEALER/NISSAN HAVE INDICATED THAT A $200 MAINTENANCE VISIT EVERY 15,OOO MILES IS REQUIRED TO PREVENT THIS. IN 150K+, AND 190K+ ,MILES ON 2 OF MY OLD HONDAS (I OWNED THEM FROM DAY 1) I NEVER HAD TO PERFORM THIS KIND OF MAINTENANCE, AND NEVER HAD THIS KIND OF FAILURE. SAME GOES FOR MY 2000 DODGE GRAND CARAVAN (60K+ MILES AND NO PROBLEMS WITH FRONT CALIPERS)
DEFECT ROTOR: I HAVE BEING DRIVING MY ALTIMA 02 FOR 2 YEARS. THREE WEEKS AGO (22 MONTH), AT LESS THAN 17000 MILES, I TOOK MY CAR FOR A BRAKE CHECK BECAUSE IT MADE A LOT OF NOISE. THE TECHNICIAN AT PERFORMANCE NISSAN DEALERSHIP FOUND THAT BOTH REAR ROTORS AND PADS NEED TO BE REPLACED AND THE FRONT ROTORS NEEDED TO BE CLEANED A…
Read full complaint
DEFECT ROTOR: I HAVE BEING DRIVING MY ALTIMA 02 FOR 2 YEARS. THREE WEEKS AGO (22 MONTH), AT LESS THAN 17000 MILES, I TOOK MY CAR FOR A BRAKE CHECK BECAUSE IT MADE A LOT OF NOISE. THE TECHNICIAN AT PERFORMANCE NISSAN DEALERSHIP FOUND THAT BOTH REAR ROTORS AND PADS NEED TO BE REPLACED AND THE FRONT ROTORS NEEDED TO BE CLEANED AND MACHINED. IT SURPRISED ME SINCE IT IS SUCH A SHORT PERIOD OF TIME AND MILEAGE. BY THE WAY, I PLACED A ORDER FOR REAR ROTORS FROM A NISSAN DEALERSHIP IN TX. THEY TOLD ME THEY HAVE TO PLACE A NATIONAL ORDER TO FIND THE PART, AND I HAVE TO WAIT FOR A UNKNOWN PERIOD OF TIME FOR THE PART TO COME IN. SO EVERYDAY, I HAVE TO WALK TO WORK. RUSTY GAS INTAKE PIPE: THERE IS A HOLE AT THE INTAKE ABOVE THE LEFT REAR TIRE, SO MUD AND WATER CAME IN DURING SNOW WEATHER, THEN THE INTAKE MOUTH BECAME RUSTY.*JB
WHEN APPLYING BRAKES VEHICLE SHUTS OFF WITHOUT WARNING.*AK
THE CALIPER ASSEMBLY CORRODED WHICH CAUSED THE BRAKES TO WEAR PREMATURELY. *NLM
Official recalls
507V527000 · Engine And Engine Cooling
Nov 14, 2007
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.5L ENGINE, THE CRANKSHAFT POSITION SENSOR CAN OVERHEAT CAUSING A BRIEF INTERRUPTION IN THE SIGNAL OUTPUT FROM THE SENSOR.
Consequence & remedy
Consequence: IF THE INTERRUPTION IN THE SIGNAL FROM THE CRANKSHAFT POSITION SENSOR IS SO BRIEF THAT THE ELECTRONIC CONTROL MODULE (ECM) LOGIC DOES NOT HAVE TIME TO DIAGNOSE THE CONDITION, THE ENGINE MAY STOP RUNNING WITHOUT WARNING WHILE THE VEHICLE IS DRIVEN AT A LOW SPEED INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ECM FREE OF CHARGE. CERTAIN MY 2006 ALTIMAS WHICH HAVE BEEN PREVIOUSLY REMEDIED UNDER RECALL CAMPAIGN 06V223 (NISSAN R0606) ARE NOT INCLUDED IN THIS RECALL SINCE THE REPROGRAMMING FOR 06V223 ALSO INCLUDED THIS REPROGRAMMING. THE RECALL BEGAN ON DECEMBER 31, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
03V455000 · Engine And Engine Cooling
Nov 17, 2003
ON CERTAIN PASSENGER VEHICLES, THE CIRCUIT BOARD FOR THE CRANK POSITION SENSOR OR CAM POSITION SENSOR MAY HAVE AN IMPROPER SOLDER JOINT DUE TO SOLDER DEFORMATION CAUSED BY HEAT STRESS ACCELERATED BY THE EXISTENCE OF FLUX RESIDUE DURING THE SOLDERING PROCESS.
Consequence & remedy
Consequence: THIS COULD CAUSE THE "SERVICE ENGINE SOON" WARNING LIGHT TO COME ON, CREATE A NO START CONDITION, CAUSE REDUCED ENGINE POWER, OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING DURING VEHICLE OPERATION, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CRANK POSITION SENSORS. CAMSHAFT POSITION SENSOR(S), AND IN SOME CASES, THE VARIABLE TIMING CONTROL SENSOR(S). VEHICLES INVOLVED IN A PREVIOUS RECALL CAMPAIGN, 01V357, ARE ALSO INCLUDED IN THIS NEW CAMPAIGN. THE REPLACEMENT SENSORS USED IN THAT CAMPAIGN ARE ALSO AFFECTED. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261 OR INFINITI AT 1-800-662-6200.
03V251000 · Fuel System, Gasoline:storage:tank Assembly
Jul 14, 2003
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, COLORADO, CONNECTICUT, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WISCONSIN, AND WYOMING. AT EXTREMELY COLD TEMPERATURES, MOISTURE IN THE FUEL TANK COULD FREEZE AND FORM ICE CRYSTALS. THESE ICE CRYSTALS MAY OBSTRUCT THE SUCTION OPENING OF THE FUEL PUMP.
Consequence & remedy
Consequence: THIS CAN PREVENT THE SUPPLY OF FUEL TO THE ENGINE AND CAUSE THE ENGINE TO STOP, WHICH COULD RESULT IN A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A SCREEN AT THE SUCTION OPENING OF THE FUEL PUMP TO PREVENT ICE CRYSTALS FROM BLOCKING THE OPENING. OWNER NOTIFICATION BEGAN ON AUGUST 18, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-333-0829.
03V084000 · Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Mar 11, 2003
ON CERTAIN VEHICLES EQUIPPED WITH THE 2.5 LITER ENGINE, THE EXHAUST PIPE HANGER PIN MAY CATCH DEBRIS FROM THE ROAD THAT COULD BE IGNITED BY CONTACT WITH THE MAIN CATALYST. ALSO ON 2002 ALTIMA AND SENTRA VEHICLES, CERTAIN ENGINE OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT AND DAMAGE THE CATALYST SUBSTRATE.
Consequence & remedy
Consequence: EITHER OF THESE TWO CONDITIONS COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REMOVE THE PROTRUDING PORTION OF THE EXHAUST PIPE HANGER PIN. IN ADDITION TO THE CORRECTIVE ACTION, IN ORDER TO REDUCE THE RISK OF FIRE IN THE EVENT OF POOR OR IMPROPER MAINTENANCE THAT COULD RESULT IN OIL SPILLAGE, HEAT SHIELD(S) WILL BE INSTALLED ON THE PRE-CATALYST AND EXHAUST TUBE. OWNER NOTIFICATION BEGAN ON JULY 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261. NISSAN RECALL NOS. R3007, R3014, R3015, R3016, R3017. ALSO ON 2002 ALTIMA AND SENTRA VEHICLES, CERTAIN ENGINE OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT AND DAMAGE THE CATALYST SUBSTRATE. IF SUBSTRATE PARTICLES ENTER THE COMBUSTION CHAMBER, THEY COULD SCORE THE CYLINDER WALLS, RESULTING IN INCREASED OIL CONSUMPTION. IF THE ENGINE OIL LEVEL IS NOT CHECKED ON A PERIODIC BASIS AND DROPS BELOW THE LOW LEVEL, AND THE DRIVER CONTINUES TO OPERATE THE VEHICLE IGNORING NOTICEABLE ENGINE NOISE, ENGINE DAMAGE MAY OCCUR WHICH COULD RESULT IN A FIRE. THE PRE-CATALYST WILL BE TESTED TO ENSURE IT IS WORKING PROPERLY AND REPLACED IF NECESSARY. IF DAMAGE IS FOUND INSIDE THE PRE-CATALYST, IT WILL BE NECESSARY TO REPLACE THE ENGINE.
03V061000 · Air Bags:frontal:driver Side:inflator Module
Feb 27, 2003
ON CERTAIN VEHICLES, THE ELECTRICAL CONNECTOR FOR THE DRIVER AIR BAG MAY COME LOOSE. IF THE CONNECTOR COMES LOOSE, THE SUPPLEMENTAL AIR BAG WARNING LIGHT FLASHES INTERMITTENTLY.
Consequence & remedy
Consequence: THE DRIVER SIDE AIR BAG WILL NOT DEPLOY IN THE EVENT OF A CRASH, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSTALL A RETAINING CLIP ON THE CLOCK SPRING ELECTRICAL CONNECTOR. OWNER NOTIFICATION BEGAN APRIL 21, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE02078 · Engine Compartment Fires
Opened Oct 18, 2002 · Closed Mar 25, 2003
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION ON OCTOBER 18, 2002 BASED ON THREE REPORTS INDICATING THAT THE ENGINE COMPARTMENT IN MODEL YEAR (MY) 2002 NISSAN ALTIMA VEHICLES EQUIPPED WITH THE 2.5 LITER ENGINE CAUGHT ON FIRE WITHOUT ANY WARNING TO THE DRIVER WHILE THE VEHICLE WAS DRIVEN AT HIGHWAY SPEEDS.ONE NON-BURN RELATED INJURY WAS REPORTED AS A RESULT OF THE COMPLAINANT EXITING THE VEHICLE IN HASTE AFTER IT HAD CAUGHT ON FIRE.NISSAN DISCOVERED THAT ONE OF THE HANGER PINS WHICH HOLDS EXHAUST PIPE IN PLACE MAY CATCH DEBRIS FROM THE ROAD.IF THE DEBRIS WERE TO COME IN CONTACT WITH THE MAIN CATALYST, A FIRE COULD RESULT.THIS CONDITION IS ALSO PRESENT IN MY 2003 NISSAN ALTIMA VEHICLES BUILT THRU FEBRUARY 18, 2003.NISSAN ALSO STATED IN ITS DEFECT INFORMATION REPORT THAT ON MY 2002 ALTIMAS AND SENTRAS (EQUIPPED WITH THE 2.5-LITER ENGINE) THAT CERTAIN OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT, WHICH WOULD CAUSE CATALYST SUBSTRATE PARTICLES TO FLOW INTO THE ENGINE.THESE PARTICLES CAN SCORE THE CYLINDER WALLS WHICH RESULTS IN INCREASE OIL CONSUMPTION.IF THE ENGINE OIL LEVEL IS LOW, ENGINE NOISE AND DAMAGE CAN OCCUR WHICH COULD RESULT IN A FIRE.THE RECALL INCLUDES 268,000 MY 2002-2003 ALTIMAS AND 2002 SENTRAS EQUIPPED WITH THE 2.5-LITER ENGINE.TO CORRECT THE CONDITION NISSAN WILL REMOVE THE PROTRUDING PORTION OF THE EXHAUST PIN ON THE ALTIMAS.NISSAN IS DEVELOPING A CORRECTIVE ACTION TO ADDRESS THE PRE-CATALYST.IN ADDITION TO THE CORRECTIVE ACTION, NISSAN WILL INSTALL HEAT SHIELDS ON THE PRE-CATALYST AND THE SURROUNDING EXHAUST TUBING.NISSAN WILL BEGIN OWNER NOTIFICATION IN MAY OF 2003.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION ON OCTOBER 18, 2002 BASED ON THREE REPORTS INDICATING THAT THE ENGINE COMPARTMENT IN MODEL YEAR (MY) 2002 NISSAN ALTIMA VEHICLES EQUIPPED WITH THE 2.5 LITER ENGINE CAUGHT ON FIRE WITHOUT ANY WARNING TO THE DRIVER WHILE THE VEHICLE WAS DRIVEN AT HIGHWAY SPEEDS.ONE NON-BURN RELATED INJURY WAS REPORTED AS A RESULT OF THE COMPLAINANT EXITING THE VEHICLE IN HASTE AFTER IT HAD CAUGHT ON FIRE.NISSAN DISCOVERED THAT ONE OF THE HANGER PINS WHICH HOLDS EXHAUST PIPE IN PLACE MAY CATCH DEBRIS FROM THE ROAD.IF THE DEBRIS WERE TO COME IN CONTACT WITH THE MAIN CATALYST, A FIRE COULD RESULT.THIS CONDITION IS ALSO PRESENT IN MY 2003 NISSAN ALTIMA VEHICLES BUILT THRU FEBRUARY 18, 2003.NISSAN ALSO STATED IN ITS DEFECT INFORMATION REPORT THAT ON MY 2002 ALTIMAS AND SENTRAS (EQUIPPED WITH THE 2.5-LITER ENGINE) THAT CERTAIN OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT, WHICH WOULD CAUSE CATALYST SUBSTRATE PARTICLES TO FLOW INTO THE ENGINE.THESE PARTICLES CAN SCORE THE CYLINDER WALLS WHICH RESULTS IN INCREASE OIL CONSUMPTION.IF THE ENGINE OIL LEVEL IS LOW, ENGINE NOISE AND DAMAGE CAN OCCUR WHICH COULD RESULT IN A FIRE.THE RECALL INCLUDES 268,000 MY 2002-2003 ALTIMAS AND 2002 SENTRAS EQUIPPED WITH THE 2.5-LITER ENGINE.TO CORRECT THE CONDITION NISSAN WILL REMOVE THE PROTRUDING PORTION OF THE EXHAUST PIN ON THE ALTIMAS.NISSAN IS DEVELOPING A CORRECTIVE ACTION TO ADDRESS THE PRE-CATALYST.IN ADDITION TO THE CORRECTIVE ACTION, NISSAN WILL INSTALL HEAT SHIELDS ON THE PRE-CATALYST AND THE SURROUNDING EXHAUST TUBING.NISSAN WILL BEGIN OWNER NOTIFICATION IN MAY OF 2003.
Engine And Engine Cooling:exhaust System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION ON OCTOBER 18, 2002 BASED ON THREE REPORTS INDICATING THAT THE ENGINE COMPARTMENT IN MODEL YEAR (MY) 2002 NISSAN ALTIMA VEHICLES EQUIPPED WITH THE 2.5 LITER ENGINE CAUGHT ON FIRE WITHOUT ANY WARNING TO THE DRIVER WHILE THE VEHICLE WAS DRIVEN AT HIGHWAY SPEEDS.ONE NON-BURN RELATED INJURY WAS REPORTED AS A RESULT OF THE COMPLAINANT EXITING THE VEHICLE IN HASTE AFTER IT HAD CAUGHT ON FIRE.NISSAN DISCOVERED THAT ONE OF THE HANGER PINS WHICH HOLDS EXHAUST PIPE IN PLACE MAY CATCH DEBRIS FROM THE ROAD.IF THE DEBRIS WERE TO COME IN CONTACT WITH THE MAIN CATALYST, A FIRE COULD RESULT.THIS CONDITION IS ALSO PRESENT IN MY 2003 NISSAN ALTIMA VEHICLES BUILT THRU FEBRUARY 18, 2003.NISSAN ALSO STATED IN ITS DEFECT INFORMATION REPORT THAT ON MY 2002 ALTIMAS AND SENTRAS (EQUIPPED WITH THE 2.5-LITER ENGINE) THAT CERTAIN OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT, WHICH WOULD CAUSE CATALYST SUBSTRATE PARTICLES TO FLOW INTO THE ENGINE.THESE PARTICLES CAN SCORE THE CYLINDER WALLS WHICH RESULTS IN INCREASE OIL CONSUMPTION.IF THE ENGINE OIL LEVEL IS LOW, ENGINE NOISE AND DAMAGE CAN OCCUR WHICH COULD RESULT IN A FIRE.THE RECALL INCLUDES 268,000 MY 2002-2003 ALTIMAS AND 2002 SENTRAS EQUIPPED WITH THE 2.5-LITER ENGINE.TO CORRECT THE CONDITION NISSAN WILL REMOVE THE PROTRUDING PORTION OF THE EXHAUST PIN ON THE ALTIMAS.NISSAN IS DEVELOPING A CORRECTIVE ACTION TO ADDRESS THE PRE-CATALYST.IN ADDITION TO THE CORRECTIVE ACTION, NISSAN WILL INSTALL HEAT SHIELDS ON THE PRE-CATALYST AND THE SURROUNDING EXHAUST TUBING.NISSAN WILL BEGIN OWNER NOTIFICATION IN MAY OF 2003.