IllustrationBRAKE ASSEMBLIES OVERHEATING AND LOCKING FRONT WHEEL DOWN BRAKE DRUMS WERE RED HOT TO MELT ABS SENSORS. *JB
2002 Monaco Coach Knight
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Knight years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 16 of 19 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Air. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports1 fire reports0 injury reports
Service Brakes, Air complaints
3 reportsRECALL 02V78000 FOR BRAKES ON THE MONACO MOTOR HOMES. AFTER TAKING THE VEHICLE TO TWO DEALERS, CONSUMER WAS TOLD, THAT THE VEHICLE COULD NOT BE SERVICED BECAUSE THE MANUFACTURER WAS TRYING TO HOLD THEM TO FIVE HOURS OF SERVICE ONLY. NO DEALER COULD CERTIFY THAT THE SERVICE WOULD TAKE 5 HOURS OR LESS.*AK
CONSUMER HAS HAD TO HAVE BRAKES SERVICED 5X TIMES SINCE MOTORHOME WAS PURCHASED. THE BRAKES PULSATED AND WARPED EXCESSIVELY WHILE DRIVING. THE DEALER CONSTANTLY SERVICED THE VEHICLE BUT ADVISED THE CONSUMER THAT THERE WAS NO REMEDY. THE DEALER ALSO ADVISED THAT MANUFACTURER WAS USING BRAKES NOT EQUIPPED FOR THE VEHICLE'S LOAD…
Read full complaint
CONSUMER HAS HAD TO HAVE BRAKES SERVICED 5X TIMES SINCE MOTORHOME WAS PURCHASED. THE BRAKES PULSATED AND WARPED EXCESSIVELY WHILE DRIVING. THE DEALER CONSTANTLY SERVICED THE VEHICLE BUT ADVISED THE CONSUMER THAT THERE WAS NO REMEDY. THE DEALER ALSO ADVISED THAT MANUFACTURER WAS USING BRAKES NOT EQUIPPED FOR THE VEHICLE'S LOAD. CONSUMER ADVISED THAT BRAKES ARE "AIR OVER HYDRAULIC". *NLM
Official recalls
508V257000 · Equipment:recreational Vehicle/trailer
Jun 5, 2008
MONACO IS RECALLING CERTAIN MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.
Consequence & remedy
Consequence: EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.
Remedy: MONACO IS WORKING WITH NORCOLD TO REPAIR THESE REFRIGERATORS. NORCOLD WILL PROVIDE THERMAL SWITCH KITS TO OWNERS ALONG WITH THE NECESSARY FORMS AND INSTRUCTIONS. THE RECALL BEGAN ON AUGUST 29, 2008. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR MONACO AT 1-800-685-6545.
05V053000 · Suspension:rear:springs:leaf Spring Assembly
Feb 14, 2005
ON CERTAIN CLASS A MOTOR HOMES, THE SPACER PLATE UNDER THE TRAILING ARMS HAD A TRANSVERSE WELD WHICH CREATES A HEAT RISER AND CAUSE THE TRAILING ARMS TO CRACK.
Consequence & remedy
Consequence: THIS COULD CREATE ROUGH DRIVING CONDITIONS AND DAMAGE TO REAR SUSPENSION SYSTEM. THE DRIVER COULD LOOSE CONTROL OF THE MOTORHOME AND A CRASH COULD OCCUR WITHOUT PRIOR NOTICE.
Remedy: DEALERS WILL INSPECT THE REPLACE THE TRAILING ARMS FOR CRACKS AND REPLACING THE TRAILING ARMS AND U-BOLTS IN THE REAR SUSPENSION OF THE MOTORHOMES FREE OF CHARGE. THE RECALL BEGAN ON MARCH 29, 2005. OWNERS MAY CONTACT MONACO AT 1-800-685-6545.
04V038000 · Suspension:front
Jan 28, 2004
ON CERTAIN MOTORHOMES, THE I-BEAM LEAF IMITATOR IN THE FRONT AXLE SUSPENSION COULD CRACK AND BREAK DUE TO AN INADEQUATE WELDING PROCESS.
Consequence & remedy
Consequence: THE I-BEAMS ON THE FRONT AXLE AND THE PANARD BRACKET ON THE REAR AXLE COULD CRACK AND BREAK CAUSING THE DRIVER TO LOSE CONTROL OF THE VEHICLE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ORIGINAL I-BEAM. ALSO, DEALERS WILL WELD THE STIFFENERS FROM THE PANARD BAR BRACKET TO THE CENTER DIFFERENTIAL OF THE REAR AXLE HOUSING. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT MONACO AT 1-877-466-6226.
02V278000 · Service Brakes, Hydraulic:foundation Components
Oct 22, 2002
ON CERTAIN MOTOR HOMES, THE BRAKE ASSEMBLIES EXHIBIT ELEVATED TEMPERATURES THAT CAN LEAD TO CATASTROPHIC DETERIORATION OF THE WHEEL END COMPONENTS SUCH AS BEARINGS, RACES, SPINDLES, KNUCKLES, SEALS, HUBS, ROTORS, PATCH BOLTS, CALIPERS, BRAKE PADS, AND ABS SENSORS.
Consequence & remedy
Consequence: THIS COULD RESULT IN LOSS OF CONTROL, AND/OR THE POTENTIAL FOR A FIRE.
Remedy: DEALERS WILL INSPECT THE FRONT AND REAR BRAKE CALIPERS FOR CORROSION AND REPLACE OR REBUILD THE CALIPERS AS NECESSARY. THE RECALL BEGAN ON AUGUST 18, 2004. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.
01V256000 · Steering: Steering Wheel/handle Bar
Aug 15, 2001
VEHICLE DESCRIPTION: MOTOR HOMES. A UNIT IS AFFECTED IF THE INTERMEDIATE STEERING SHAFT IS FULLY COMPRESSED OR IS TOO SHORT TO MEET MAXIMUM EXTENSION SPECIFICATIONS.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND/OR REPLACE THE INTERMEDIATE STEERING SHAFT. OWNER NOTIFICATION BEGAN AUGUST 13, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-800-685-6545.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE04068 · Unprotected Lp Gas Line
Opened Sep 29, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Equipment:recreational Vehicle/trailer:lpg Systems:lines And Fittings
MONACO INFORMED ODI THAT IT HAS RECEIVED NO OWNER REPORTS OF MISSING LP GAS LINE SHILEDS OTHER THAN THE ONE FORWARDED BY ODI.ODI HAS FOUND NO OTHER VEHICLE THAT WAS MISSING THE LP LINE SHIELD. DURING THE COURSE OF THE INVESTIGATION ODI: ?CONDUCTED FIELD INSPECTIONS AT NUMEROUS DEALERS; ?REQUESTED WARRANTY CLAIMS AND FIELD REPORTS FROM MONACO(THERE WERE NONE);REVIEWED ENGINEERING DRAWINGS;AND?REVIEWED THE ANSI A119.2 AND THE NATIONAL FIRE PROTECTION ASSOCIATION 1192 STANDARDS ON RECREATION VEHICLES (RV?S) PERTAINING TO LP GAS LINE INSTALLATION ON RV?S. BASED ON MONACO?S DATA AND THE ABSENCE OF ANY FURTHER COMPLAINTS, A SAFTEY RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FUTHER USE OF AGENCY RESOURCES IS NOT CURRENTLY WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFTEY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION ON THE VEHICLES IF WARRANTED BY THE CIRCUMSTANCES. ODI WILL CONTINUE TO MONITOR FIELD REPORTS AND TAKE APPROPRIATE ACTION IF INDICATED.