2024 Mitsubishi Outlander

The vehicle exhibits an intense, overpowering raw gasoline smell inside the passenger cabin, specifically originating from beneath the rear seat area. When the climate control/AC fan is turned on, raw fuel vapors are siphoned directly out of the dashboard air vents into the faces of the occupants, causing headaches and dizziness.Two independent mechanics have pressure-tested the fuel lines and confirmed there are no liquid fuel leaks, proving this is a structural vapor siphoning defect. Mitsubishi has documented this exact factory defect under TSB TS-25-13-001 (NHTSA ID: MC-11018002-0001), but the local dealership refuses to perform the safety repair without a massive out-of-pocket payment because the vehicle has 87,000 miles. This is an immediate fire and health hazard for anyone inside the vehicle.

I own a 2024 Mitsubishi Outlander that I purchased new on December 21, 2024. Since shortly after purchase, the vehicle has experienced ongoing problems involving the brakes, electrical system, and fuel fumes entering the passenger cabin. The most serious issue is the brake system. I have experienced hard braking, inconsistent brake response, brake warning lights, and at least one incident where the brakes suddenly failed and I had to take emergency action to stop the vehicle. The dealership has attempted multiple repairs, including replacing the brake booster, master cylinder, and other brake components, but the problem continues. The vehicle has also had repeated electrical problems, including warning lights, low-voltage issues, radio malfunctions, and steering wheel controls that stopped working. In addition, fuel fumes continue to enter the cabin while driving and when the vehicle is parked. The dealership has already replaced the fuel vapor canister and fuel filler neck, but the fuel odor persists. On June 13, 2026, I went to the emergency room because of symptoms related to inhaling the fuel vapors. I have reported these issues to both the dealership and Mitsubishi Motors North America on multiple occasions since the problems first began. Despite repeated repair attempts and ongoing communication, the defects remain unresolved. Based on the repeated failures, the number of repair visits, and the amount of time the vehicle has been out of service, I believe this vehicle qualifies as a lemon. The vehicle has been in the repair shop numerous times and has been out of service for approximately 45 days. I am filing this complaint because I am concerned that the brake failures and fuel vapor intrusion could put me, my passengers, and other drivers at risk. I am seeking assistance in resolving this issue as soon as possible to prevent further safety and health risks.

In the morning where I live for the last few days it has been below 0. The Outlander PHEV even when plugged in over night will start the gas engine and drive for about one minute until the gas engine shuts off and comes up with a message saying power reduced with a turtle symbol. When it does this you have no heat (HVAC) the heated seats and heated steering wheel does not work as well as the front and rear defrost. The car speed seems to be limited to about 40MPH. This issue is not news as many PHEV owners are dealing with the same issue, From my understanding Mitsubishi didn't install a battery warmer on the new generation Outlander PHEV however the prior generation Outlander PHEV did have a battery warmer and there were no issues with that model in cold climates. Your vehicle should always be a reliable source of heat when needed it doesn't seem to be very reliable in cold climates and it really is a hazard when it decides to reduce power with no warning.