IllustrationI GOT BRAKES CHANGED ON MY MONTERO TWICE IN 3 YEARS HAPPEN AGAIN WHILE DRIVING BRAKE FAIL PADS CAME OUT OF CALIPER BRAKES KEEPS GOING BAD AFTER 1.5 TO TWO YEARS DID CALIPERS CHANGE AS WELL SAME THING CALIPERS WILL GET STUCK AND PADS WILL COME OUT THEY HAVE A RECALL ON 1997 1998 MODELS FOR BRAKES ISSUE NOT 1999 AND 2000
2000 Mitsubishi Montero
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2000 Mitsubishi Montero do not stand out strongly from the model-year median of 20.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Montero years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 5 of 51 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports1 fire reports5 injury reports
Electrical System complaints
6 reports2000 MITSUBISHI MONTERO REAR PASSENGER SIDE WINDOW BUTTON CAUGHT FIRE. *TR
VEHICLE HAS STALLED 3 TIMES. DEALER STATED IT WAS DUE TO A BLOWN FUSE. FUSE WAS REPLACED, BUT DID NOT SOLVE PROBLEM. PLEASE PROVIDE ADDITIONAL INFORMATION.*AK
WITHOUT ANY INDICATION HORN WOULD SOUND OFF. CONSUMER WOULD HAVE TOO PULL HORN FUSE TO STOP. DEALER HAS BEEN CONTACTED. PLEASE PROVIDE FURTHER INFORMATION.*AK
UPON STARTING CAR, THE BATTERY EXPLODED SPEWING ACID ALL OVER THE ENGINE AND HOOD AND CAUSING SEVERAL DENTS ON BOTH THE INSIDE AND OUTSIDE OF THE HOOD. THIS RESULTING IN A TOTAL ELECTRICAL SYSTEM FAILURE AS WELL AS LOSS OF FUNCTIONABILITY OF THE VEHICLE. UPON REPORTING THIS TO MITSUBISHI ROADSIDE ASSISTANCE, WE WERE INFORMED T…
Read full complaint
UPON STARTING CAR, THE BATTERY EXPLODED SPEWING ACID ALL OVER THE ENGINE AND HOOD AND CAUSING SEVERAL DENTS ON BOTH THE INSIDE AND OUTSIDE OF THE HOOD. THIS RESULTING IN A TOTAL ELECTRICAL SYSTEM FAILURE AS WELL AS LOSS OF FUNCTIONABILITY OF THE VEHICLE. UPON REPORTING THIS TO MITSUBISHI ROADSIDE ASSISTANCE, WE WERE INFORMED THAT WAS THE SECOND CALL THAT DAY FOR AN EXPLODING BATTERY IN A 2000 MITSUBISHI MONTERO SPORT. OUR VEHICLE HAS APPROXIMATELY 26,700 MILES AND CURRENTLY THE ESTIMATED COST OF THE DAMAGE IS UNKNOWN.
WHEN APPLYING THE BRAKES THE INTERIOR AND EXTERIOR LIGHTS GO OUT FOR A COUPLE OF SECONDS. ALSO, SAME THING HAPPENS WITH THE RADIO AND THE WINDSHIELD WIPERS. DEALER HAS SEEN VEHICLE 3 TIMES, AND STILL THER IS NO SOLUTION. *AK
Official recalls
220V035000 · Air Bags:frontal:driver Side:inflator Module
Jan 23, 2020
Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 1998-2000 Montero vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Remedy: MMNA will notify owners, and dealers will replace the air bag inflator, free of charge. The recall began February 25, 2021. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-20-001.
04V428000 · Equipment:other:labels
Sep 1, 2004
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: MITSUBISHI CARIBBEAN WILL MAIL A CUSTOMER NOTIFICATION LETTER CONTAINING A WRITTEN DESCRIPTION AND A GRAPHIC OF THE BI-LINGUAL DASHBOARD AIR BAG WARNING LABEL. IN ADDITION, ALL CURRENT 2000-2004 NATIVA OWNERS WILL ALSO RECEIVE REPLACEMENT AIR BAG ALERT LABELS FOR THE SUN VISORS. THIS RECALL IS EXPECTED TO BEGIN DURING MARCH OR APRIL 2005. THE NOTIFICATION TO THE NATIVA OWNERS IS EXPECTED TO BEGIN DURING APRIL OR MAY 2005. OWNERS SHOULD CONTACT MITSUBISHI CARIBBEAN AT 1-787-251-8715.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.