DT*: THE CONTACT STATED WHILE PARKED WITH THE ENGINE IDLING, IT WAS NOTICED THAT THE PULLEY FOR THE POWER STEERING WAS LOOSE. AS THE CONTACT ALREADY HAD THE RECALL # 00V311001, REGARDING ENGINE AND ENGINE COOLING:ENGINE REPAIRS PERFORMED ONCE, THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHO DETERMINED THE CRANKSHAFT HAD TO BE TIGHT…
Read full complaint
DT*: THE CONTACT STATED WHILE PARKED WITH THE ENGINE IDLING, IT WAS NOTICED THAT THE PULLEY FOR THE POWER STEERING WAS LOOSE. AS THE CONTACT ALREADY HAD THE RECALL # 00V311001, REGARDING ENGINE AND ENGINE COOLING:ENGINE REPAIRS PERFORMED ONCE, THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHO DETERMINED THE CRANKSHAFT HAD TO BE TIGHTEN AGAIN. THE CONTACT EXPRESSED CONCERN BECAUSE THE BOLT WAS REPLACED AND TIGHTENED BEFORE AND THE PROBLEM SHOULD NOT HAVE RECURRED. THE MANUFACTURER WAS CONTACTED WHO REFUSED TO COVER THE REPAIR A SECOND TIME UNDER THE RECALL.
NHTSA ODI #10174011
169,000 miles · Aug 25, 2004
Engine And Engine Cooling
ADDITION TO COMPLAINT 10088338. FTER HAVING THE VEHICLE CHECKED BY MY MECHANIC, THE PROBLEM IS THAT THE BOLT (THE ONE LISTED IN THE ORIGINAL RECALL) BACKED OUT OF THE CRANK SHAFT CAUSING THE PULLY TO WOBBLE (DISTROYING THE PULLEY IN THE PROCESS). ONCE THE BOLT WAS 3/4 OF THE WAY OUT, IT SNAPPED IN TWO.*AK
NHTSA ODI #10088566
45 miles · Aug 22, 2004
Engine And Engine Cooling
ON 03/16/01 RECALL WORK WAS DONE AT SERVICE DEALER. ON DATE OF INCIDENT, CRANK BOLT SHEERED OFF OR CAME OUT WHILE DRIVING AT 45M MPH. *JB
NHTSA ODI #10088338
79,000 miles · Dec 2, 2003
Engine And Engine Cooling
ENGINE STALLED IN THE MIDDLE OF AN INTERSECTION WHILE DRIVING AT 55 MPH. VEHICLE WAS TOWED TO INDEPENDENT SHOP. TECHNICIAN STATED THAT BOLT SECURING THE CRANKSHAFT PULLEY BROKE. AS A RESULT, ENGINE WAS OVERHAULED AT OWNER'S EXPENSE.*AK
NHTSA ODI #10049848
Mileage unknown · Aug 8, 2002
Engine And Engine Cooling
WHILE DRIVING AT 65MPH CRANKSHAFT BOLT SNAPPED, CAUSING MOTOR TO SHUTOFF WITH NO WARNING. DEALER NOTIFIED.*AK
NHTSA ODI #8015861
Mileage unknown · Feb 6, 2002
Engine And Engine Cooling
CRANKSHAFT PULLEY BOLT CAME LOOSE, CAUSING THE CRANKSHAFT TO STRIP OUT THE GEARING. THE VEHICLE SEEMED TO LOOSE POWER & WAS LESS RESPONSIVE ... & THE HIDEOUS SCREECHING SOUND SCARED THE HECK OUT OF ALL THE DRIVERS & PEDESTRIANS WHO WERE NEARBY AT THE INTERSECTION. REPAIRS ARE ESTIMATED TO BE AROUND $2,500.00 FOR A VEHICLE THAT…
Read full complaint
CRANKSHAFT PULLEY BOLT CAME LOOSE, CAUSING THE CRANKSHAFT TO STRIP OUT THE GEARING. THE VEHICLE SEEMED TO LOOSE POWER & WAS LESS RESPONSIVE ... & THE HIDEOUS SCREECHING SOUND SCARED THE HECK OUT OF ALL THE DRIVERS & PEDESTRIANS WHO WERE NEARBY AT THE INTERSECTION. REPAIRS ARE ESTIMATED TO BE AROUND $2,500.00 FOR A VEHICLE THAT IS NOT EVEN 10 YEARS OLD YET. *AK
NHTSA ODI #757851
Mileage unknown · Mar 22, 2001
Engine And Engine Cooling
THE CRANKSHAFT BOLTS FAILED WHILE DRIVING CAUSING A SUDDEN LOSS OF POWER STEERING PRIOR TO RECALL NOTICE 00V-311, THE CONSUMER REQUEST REIMBURSEMENT. NLM
NHTSA ODI #560490
Mileage unknown · Mar 9, 2000
Engine And Engine CoolingSteering
STEERING WHEEL DEVELOPED A 2 TO 3 INCH FRONT TO BACK MOTION. TRUCK WILL NOT PASS PA INSPECTION. A MITSU MASTER MECHANIC SAYS WHOLE STEERING COLUMN MUST BE REPLACED AS BAD BEARING IN COLUMN CAN NOT BE. AS FOR BROKEN MANIFOLD BOLT ON LEFT SIDE OF ENGINE IT ALLOWS A HIGH PRESSURE EXHAUST LEAK INTO ENGINE COMPARTMENT AND I…
Read full complaint
STEERING WHEEL DEVELOPED A 2 TO 3 INCH FRONT TO BACK MOTION. TRUCK WILL NOT PASS PA INSPECTION. A MITSU MASTER MECHANIC SAYS WHOLE STEERING COLUMN MUST BE REPLACED AS BAD BEARING IN COLUMN CAN NOT BE. AS FOR BROKEN MANIFOLD BOLT ON LEFT SIDE OF ENGINE IT ALLOWS A HIGH PRESSURE EXHAUST LEAK INTO ENGINE COMPARTMENT AND INTO VEHICLE. THIS WILL NOT PASS STATE INSPECTION AND I WAS ADVISED THAT ALL BOLTS MUST BE REPLACED ! CAN NOT BE
VEHICLE DESCRIPTION: PASSENGER VEHICLES: MIRAGE MODEL VEHICLES EQUIPPED WITH 1.5L ENGINES; MONTERO SPORT MODELS EQUIPPED WITH 3.0L ENGINES; AND MONTERO MODELS EQUIPPED WITH 3.0L ENGINES. THE BOLT SECURING THE CRANKSHAFT PULLEY CAN BECOME LOOSE AND THE PULLEY COULD FALL OFF THE VEHICLE.
Consequence & remedy
Consequence: THE CONDITION CAN RESULT IN A LOSS OF POWER STEERING ASSIST, INCREASING THE RISK OF A CRASH.
Remedy: ON THE MIRAGE VEHICLES, THE DEALERS WILL INSTALL A NEW, IMPROVED CRANKSHAFT PULLEY BOLT ON THE OLDER ENGINES. ON NEW ENGINES WHICH ALREADY HAVE THE IMPROVED BOLT, THE DEALER WILL TIGHTEN THE CRANKSHAFT PULLEY BOLT TO THE CORRECT TORQUE SPECIFICATION. ON THE MONTERO MODELS, DEALERS WILL TIGHTEN THE CRANKSHAFT PULLEY BOLT TO THE CORRECT TORQUE SPECIFICATIONS. IF THE BOLT IS DAMAGED, IT WILL BE REPLACED.
UNDER CONDITIONS OF FULL LOCK STEERING AND FULL SUSPENSION TRAVEL, THE LEFT OR RIGHT FRONT WHEEL-SIDE BRAKE HOSE CAN CRACK, RESULTING IN BRAKE FLUID LEAKAGE.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE WILL CAUSE ILLUMINATION OF THE BRAKE WARNING LAMP AND REDUCTION IN BRAKING EFFECTIVENESS INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT WHEEL-SIDE BRAKE HOSES WITH REVISED HOSE ASSEMBLIES.
UNDER CONDITIONS OF FULL LOCK STEERING AND FULL SUSPENSION TRAVEL, THE LEFT OR RIGHT FRONT WHEEL-SIDE BRAKE HOSE CAN CRACK, RESULTING IN BRAKE FLUID LEAKAGE.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE WILL CAUSE ILLUMINATION OF THE BRAKE WARNING LAMP AND REDUCTION IN BRAKING EFFICIENCY INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT WHEEL-SIDE BRAKE HOSES WITH REVISED HOSE ASSEMBLIES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1993 Mitsubishi Montero Problems, Complaints & Recalls | Skip That Year
Illustration