IllustrationI HEARD A NOISE WHILE DRIVING AT LOW SPEEDS WHILE HITTING BUMPS, WHEN I STOPPED DRIVING AND LOOKED UNDER THE VEHICLE I NOTICED THE FRAME WAS RUSTED COMPLETELY THROUGH TO THE OTHER SIDE, AND ESPECIALLY BAD WHERE THE REAR DIFFERENTIAL BRACKET IS ATTACHED TO THE FRAME, ITS SO LOOSE IT DOESN'T LOOK SAFE TO DRIVE.
2000 Mitsubishi Montero Sport
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2000 Mitsubishi Montero Sport do not stand out strongly from the model-year median of 33.
About this comparison →How this year compares
Owner complaints by model year
Compare all Montero Sport years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
60–25K
325–50K
750–75K
675–100K
21100–150K
9150K+
52 reports with mileage · 45 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports1 fire reports10 injury reports
Structure complaints
15 reportsMY MITSUBISHI MONTERO SPORT 00, HAS FRAME ROT, WILL NOT PASS INSPECTION, IT DEFINITELY SHOULD BE A FACTORY RECALL, SO MANY COMPLAINTS, AND SAFE ISSUES
I TOOK MY VEHICLE FOR A BACK BRAKE INSPECTION. IT WAS FOUND THAT THE UNDERBODY OF THE VEHICLE WAS SEVERELY CORRODED WITH RUST AND SOME UNDERBODY FRAMEWORK ROTTED THROUGH. THE STRUCTURE OF THE VEHICLE WAS DECLARED UNREPAIRABLE AND UNSAFE TO DRIVE DUE TO UNDERBODY RUST AND CORROSION TO THE METAL. *TR
I TOOK MY CAR TO INSPECT A BANGING NOISE UNDER THE LEFT REAR OF THE AUTO. UPON ISPECTION IT WAS FOUND THAT THE FRAME OF THE CAR WAS RUSTED AND ROTTED THRU THE ENTIRE FRAME . IT WAS FRACTURED IN SPOTS AND PARTS RUSTED ENTIRELY AWAY. IT WAS FOUND TO BE UNSAFE TO DRIVE. IT CAN NOT BE REPAIRED. THE MACHANIC TOLD ME IT IS A DEFECT…
Read full complaint
I TOOK MY CAR TO INSPECT A BANGING NOISE UNDER THE LEFT REAR OF THE AUTO. UPON ISPECTION IT WAS FOUND THAT THE FRAME OF THE CAR WAS RUSTED AND ROTTED THRU THE ENTIRE FRAME . IT WAS FRACTURED IN SPOTS AND PARTS RUSTED ENTIRELY AWAY. IT WAS FOUND TO BE UNSAFE TO DRIVE. IT CAN NOT BE REPAIRED. THE MACHANIC TOLD ME IT IS A DEFECT IN THE METAL. THE CAR HAS NEVER BEEN IN A FLOOD AND I DON'T LIVE NEAR SALD WATER. THE REST OF THE CAR IS IN GOOD SHAPE. THE CAR IS NOW UNDRIVABLE. *TR
TL* THE CONTACT OWNS A 2000 MITSUBISHI MONTERO SPORT. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, HE BEGAN TO HEAR A BANGING NOISE FROM THE REAR PASSENGER SIDE OF THE VEHICLE. UPON FURTHER INSPECTION, HE NOTICED THAT PART OF THE FRAME WAS FRACTURED. THE CONTACT REATTACHED THE FRAME AND TOOK THE VEHICLE TO AN INDEPENDENT MECHA…
Read full complaint
TL* THE CONTACT OWNS A 2000 MITSUBISHI MONTERO SPORT. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, HE BEGAN TO HEAR A BANGING NOISE FROM THE REAR PASSENGER SIDE OF THE VEHICLE. UPON FURTHER INSPECTION, HE NOTICED THAT PART OF THE FRAME WAS FRACTURED. THE CONTACT REATTACHED THE FRAME AND TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC TO REPAIR THE FAILURE. AFTER DIAGNOSIS, HE WAS ADVISED THAT THE ENTIRE FRAME EXHIBITED SEVERE RUST, FRACTURING AND THE VEHICLE WAS NO LONGER ABLE TO BE DRIVEN. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE AND CURRENT MILEAGE WAS 143,000.
TL* THE CONTACT OWNS A 2000 MITSUBISHI MONTERO SPORT. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN FOR STATE INSPECTION AND THE CONTACT WAS TOLD THAT THE REAR AXLE, FRAME AND THE STRUCTURE OF THE VEHICLE WERE COMPLETELY RUSTED. THE STATE INSPECTION OFFICER ADVISED THE CONTACT THAT THE VEHICLE COULD NOT BE REPAIRED. THE VEHICLE …
Read full complaint
TL* THE CONTACT OWNS A 2000 MITSUBISHI MONTERO SPORT. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN FOR STATE INSPECTION AND THE CONTACT WAS TOLD THAT THE REAR AXLE, FRAME AND THE STRUCTURE OF THE VEHICLE WERE COMPLETELY RUSTED. THE STATE INSPECTION OFFICER ADVISED THE CONTACT THAT THE VEHICLE COULD NOT BE REPAIRED. THE VEHICLE HAD NOT BEEN TAKEN TO THE DEALER. THE FAILURE AND CURRENT MILEAGES WERE 109,000.
I BROUGHT MY VEHICLE TO A GARAGE FOR ROUTINE MAINTENANCE, UPON INSPECTION ATTENDANT INFORMED ME THAT THE FRAME OF THE VEHICLE WAS SEVERELY CORRODED AND UNSAFE TO DRIVE. I AM STUNNED TO LEARN THIS, AS I AM THE ORIGINAL OWNER OF THE VEHICLE AND IT HAS BEEN GARAGED SINCE OWNERSHIP. I AM ANGRY, FRUSTRATED AND FEEL AS A CONSUMER THIS…
Read full complaint
I BROUGHT MY VEHICLE TO A GARAGE FOR ROUTINE MAINTENANCE, UPON INSPECTION ATTENDANT INFORMED ME THAT THE FRAME OF THE VEHICLE WAS SEVERELY CORRODED AND UNSAFE TO DRIVE. I AM STUNNED TO LEARN THIS, AS I AM THE ORIGINAL OWNER OF THE VEHICLE AND IT HAS BEEN GARAGED SINCE OWNERSHIP. I AM ANGRY, FRUSTRATED AND FEEL AS A CONSUMER THIS IS NOT RIGHT.
TL* THE CONTACT OWNS A 2000 MITSUBISHI MONTERO SPORT. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE UNDERCARRIAGE WAS EXTREMELY CORRODED. THE CONTACT HAD NOT EXPERIENCED A FAILURE AND STATED THE UNDER CARRIAGE WAS NOT FRACTURED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE APPROXIMATE FA…
Read full complaint
TL* THE CONTACT OWNS A 2000 MITSUBISHI MONTERO SPORT. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE UNDERCARRIAGE WAS EXTREMELY CORRODED. THE CONTACT HAD NOT EXPERIENCED A FAILURE AND STATED THE UNDER CARRIAGE WAS NOT FRACTURED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
TL* THE CONTACT OWNS A 2000 MITSUBISHI MONTERO SPORT. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SHAKE EXCESSIVELY. THE CONTACT LATER DISCOVERED THAT THE FRAME WAS FRACTURED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO ADVISED HIM THAT THE FRAME WAS FRACTURED AND THAT THE VEHICLE WAS UNABL…
Read full complaint
TL* THE CONTACT OWNS A 2000 MITSUBISHI MONTERO SPORT. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SHAKE EXCESSIVELY. THE CONTACT LATER DISCOVERED THAT THE FRAME WAS FRACTURED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO ADVISED HIM THAT THE FRAME WAS FRACTURED AND THAT THE VEHICLE WAS UNABLE TO BE REPAIRED. THERE WERE NO REPAIRS TO THE VEHICLE. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 120,000. THE VIN WAS UNAVAILABLE.
TL* THE CONTACT OWNS A 2000 MITSUBISHI MONTERO SPORT. THE CONTACT STATED THAT THE VEHICLE WAS HAVING ROUTINE MAINTENANCE PERFORMED WHEN THE MECHANIC DISCOVERED THAT THE CHASSIS WAS COMPLETELY CORRODED. THE DEALER WAS CONTACTED BUT THEY DID NOT OFFER ANY ASSISTANCE AND THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAI…
Read full complaint
TL* THE CONTACT OWNS A 2000 MITSUBISHI MONTERO SPORT. THE CONTACT STATED THAT THE VEHICLE WAS HAVING ROUTINE MAINTENANCE PERFORMED WHEN THE MECHANIC DISCOVERED THAT THE CHASSIS WAS COMPLETELY CORRODED. THE DEALER WAS CONTACTED BUT THEY DID NOT OFFER ANY ASSISTANCE AND THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 115,000.
Official recalls
101V027000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Feb 5, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH 3.5L ENGINES. THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 106, "BRAKE HOSES." THESE VEHICLES ARE EQUIPPED WITH NONCOMPLIANT BRAKE VACUUM HOSES.
Consequence & remedy
Consequence: THESE HOSES COULD BURST CAUSING FLUID LEAKAGE, INCREASING THE BRAKING CAPABILITY OF THE VEHICLE AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE VACUUM HOSE. OWNER NOTIFICATION BEGAN FEBRUARY 15, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AT 1-800-222-0037.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.