IllustrationA/C DRAINS TO THE INTERIOR DRIVERS SIDE FLOOR BOARD CREATING A SEVER SAFETY HAZARD, ALSO RUSTS OUT THE FAN BLOWER. *TR
2004 Mitsubishi Endeavor
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Endeavor years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
170–25K
1625–50K
2850–75K
2675–100K
24100–150K
20150K+
131 reports with mileage · 51 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports3 fire reports10 injury reports
Structure complaints
59 reportsI HAVE OWNED MY 04 ENDEAVOR UNLIMITED WHEN IT CAME OUT, DROVE IT OFF THE LOT. I CONTINUE TO OWN IT TO PRESENT DATE 09/09. I NOTICED THE PAINT JOB AT THE TOP OF VEHICLE AND LG AREAS ON THE HOOD AS WELL AS AREAS AT TOP OF THE BRAKE LIGHT AT REAR OF CAR ARE WEARING DOWN TO THE PRIMER. I FEEL THE PAINT JOB WAS NOT DONE PROPERLY AN…
Read full complaint
I HAVE OWNED MY 04 ENDEAVOR UNLIMITED WHEN IT CAME OUT, DROVE IT OFF THE LOT. I CONTINUE TO OWN IT TO PRESENT DATE 09/09. I NOTICED THE PAINT JOB AT THE TOP OF VEHICLE AND LG AREAS ON THE HOOD AS WELL AS AREAS AT TOP OF THE BRAKE LIGHT AT REAR OF CAR ARE WEARING DOWN TO THE PRIMER. I FEEL THE PAINT JOB WAS NOT DONE PROPERLY AND FEEL MITSUBISHI SHOULD BE HELD RESPONSIBLE FOR REPAINTING. IT WAS DECLINED SAYING IT EXCEEDED THE MILEAGE SPECIFICATION. 3YRS OR 36,000 MILES WOULD WARRANT A NEW PAINT JOB. WHAT HAPPENED TO BUMPER TO BUMPER WARRANTY WHICH IS WHAT WAS UNDERSTOOD AT THE TIME OF PURCHASE? *TR
THE CLEAR COAT ON THE VEHICLE IS COMING OFF, HAVE NOTICED THE PROBLEM FOR THE LAST COUPLE OF YEARS AND NOW EVERY MONTH GOES BY IT IS GETTING WORSE. *TR
PAINT DELAMINATES FROM VEHICLE SURFACE. EXTERIOR PAINT STARTS TO DEGRADE THEN DELAMINATES FROM THE VEHICLE'S SURFACE UNTIL EVENTUALLY THE ENTIRE VEHICLE IS EXPOSED TO THE METAL. THIS OCCURRED IN LESS THAN 2 YEARS AND CONTINUED THROUGHOUT MY OWNERSHIP OF THE VEHICLE, WHICH WAS A LEASE THAT I WAS CHARGED FOR THE DAMAGE. THIS IS CL…
Read full complaint
PAINT DELAMINATES FROM VEHICLE SURFACE. EXTERIOR PAINT STARTS TO DEGRADE THEN DELAMINATES FROM THE VEHICLE'S SURFACE UNTIL EVENTUALLY THE ENTIRE VEHICLE IS EXPOSED TO THE METAL. THIS OCCURRED IN LESS THAN 2 YEARS AND CONTINUED THROUGHOUT MY OWNERSHIP OF THE VEHICLE, WHICH WAS A LEASE THAT I WAS CHARGED FOR THE DAMAGE. THIS IS CLEARLY PROBLEM. AFTER A SHORT INTERNET SEARCH, THOUSANDS OF EXACT COMPLAINTS CAN BE FOUND. *TR
SERIOUS SAFETY ISSUE THAT WILL RESULT IN SLIPPERY FLOOR CARPETING, BRAKE, AND ACCELERATION PEDALS DUE TO DESIGN FLAW. WATER FROM A/C UNIT ENTERING DRIVER SIDE DRIVERS FLOOR AREA. WETTING FLOOR PANEL AND CARPETING. POSSIBLY A GROMMET IT SEEMS TO BE A COMMON PROBLEM IN MANY ENDEAVORS . *TR
2004 MITSUBISHI ENDEAVOR, OVER THE PASS YEAR ARE SO THE BLACK PAINT HAS BEEN FADING AWAY AND THEY ONLY PAINT THE SPOTS THAT HAS FADED (WHY NOT REPAINT THE HOLD THING AND SAME TIME THEY AGREE IT IS A DEFECT). THIS NEXT PROBLEM IS CURRENT, 12-1-2008 I CAN NOT REMOVE THE KEY FROM THE IGNITION AFTER I PUT IT IN PARK AND JUST ROTATE …
Read full complaint
2004 MITSUBISHI ENDEAVOR, OVER THE PASS YEAR ARE SO THE BLACK PAINT HAS BEEN FADING AWAY AND THEY ONLY PAINT THE SPOTS THAT HAS FADED (WHY NOT REPAINT THE HOLD THING AND SAME TIME THEY AGREE IT IS A DEFECT). THIS NEXT PROBLEM IS CURRENT, 12-1-2008 I CAN NOT REMOVE THE KEY FROM THE IGNITION AFTER I PUT IT IN PARK AND JUST ROTATE THE KEY TO TURN OFF THE SUV THE ROTATION STOP AND I CAN NOT REMOVE IT OR BEGAN TO FORCE IT TO HOME POSITION MY KEY AS OF TODAY 12-2-2008 IS STILL IN THE IGNITION IT WILL JUST ROTATE ENOUGH TO TURN THE MOTOR OFF AND THAT IS IT, WILL THIS FALL UNDER THE CURRENT RECALL OF THE ELECTRICAL IGNITION PROBLEM. *TR
ROLLING DOWN THE REAR WINDOWS CAUSES AN AIR VIBRATION THAT IS SO LOUD AND PULSING THAT IT HURTS YOUR EARS. OPENING ALL THE WINDOWS HELPS A LITTLE, BUT IS STILL UNACCEPTABLE. OPENING JUST THE REAR WINDOWS IS EXTREMELY PAINFUL. THIS PROBLEM HAS BEEN NOTED BY MANY MITSUBISHI ENDEAVOR OWNERS. THIS IS NOT THE TYPE OF ISSUE THAT C…
Read full complaint
ROLLING DOWN THE REAR WINDOWS CAUSES AN AIR VIBRATION THAT IS SO LOUD AND PULSING THAT IT HURTS YOUR EARS. OPENING ALL THE WINDOWS HELPS A LITTLE, BUT IS STILL UNACCEPTABLE. OPENING JUST THE REAR WINDOWS IS EXTREMELY PAINFUL. THIS PROBLEM HAS BEEN NOTED BY MANY MITSUBISHI ENDEAVOR OWNERS. THIS IS NOT THE TYPE OF ISSUE THAT CAN BE IDENTIFIED, PRIOR TO PURCHASING THE VEHICLE, WHEN ONE BUYS THE VEHICLE IN THE WINTER. WHY WOULD YOU EVER ROLL THE REAR WINDOWS DOWN? IT IS EXPECTED THAT YOU SHOULD BE ABLE TO DO SO, WITHOUT SERIOUS DISCOMFORT. *TR
I AM THE FIRST OWNER OF A 2004 MITSUBISHI ENDEAVOR. IT IS BLACK IN COLOR. THE PAINT IS FADING TERRIBLY AND TURNING WHITE. THIS IS HAPPENING ALL OVER THE HOOD AND ROOF OF THE VEHICLE. I HAVE DISCOVERED ON THE INTERNET THAT THIS IS A RECURRING AND COMMON COMPLAINT ABOUT THESE BLACK COLORED MITSUBISHI VEHICLES. IT HAS SOMETHING TO …
Read full complaint
I AM THE FIRST OWNER OF A 2004 MITSUBISHI ENDEAVOR. IT IS BLACK IN COLOR. THE PAINT IS FADING TERRIBLY AND TURNING WHITE. THIS IS HAPPENING ALL OVER THE HOOD AND ROOF OF THE VEHICLE. I HAVE DISCOVERED ON THE INTERNET THAT THIS IS A RECURRING AND COMMON COMPLAINT ABOUT THESE BLACK COLORED MITSUBISHI VEHICLES. IT HAS SOMETHING TO DO WITH THE CLEAR-COAT AND THE PAINT BEING DEFECTIVE. *TR
WATER LEAKING BEHIND DASH. HAS ANYONE HAD ANY SUCCESS IN REPAIRS FOR THIS PROBLEM. THANKYOU. *TR
DEAR SIR/MADAM, I HAVE A BLACK 2004 MITSUBISHI ENDEAVOR WHICH HAS SERIOUS PAINT ISSUES ON THE HOOD AND THE TOP OF THE CAR. THE PAINT IS DETERIORATING RAPIDLY ON SURFACES THAT ARE MOST EXPOSED TO SUNLIGHT. THE PAINT HAS PREMATURE AGING AND TURNS A WHITE COLOR. THE CAR LOOKS LIKE 10 YEARS OLD. TRIED TO SOLVE THE PROBLEM WITH …
Read full complaint
DEAR SIR/MADAM, I HAVE A BLACK 2004 MITSUBISHI ENDEAVOR WHICH HAS SERIOUS PAINT ISSUES ON THE HOOD AND THE TOP OF THE CAR. THE PAINT IS DETERIORATING RAPIDLY ON SURFACES THAT ARE MOST EXPOSED TO SUNLIGHT. THE PAINT HAS PREMATURE AGING AND TURNS A WHITE COLOR. THE CAR LOOKS LIKE 10 YEARS OLD. TRIED TO SOLVE THE PROBLEM WITH THE SERVICE MANAGERS BUT THEY ARE TELLING THAT MY WARRANTY IS NOT COVERED THIS PROBLEM. ACCORDING TO THE RESEARCH THAT I MADE ON THE INTERNET, THERE ARE HUNDREDS OF MITSUBISHI OWNERS THAT HAVE THE SAME PROBLEMS WITH MITSIBUSHI ENDEAVOR. ALSO, IT LOOKS LIKE IT IS A STANDING POLICY AT MITSUBISHI MOTORS TO INTENTIONALLY THIN THE CLEAR-COAT ON THEIR AUTOMOBILES IN AN ATTEMPT TO SAVE MONEY UP FRONT. I HOPE YOU CAN HELP US TO SOLVE THIS. THANK YOU. *TR
Official recalls
610V065000 · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Feb 25, 2010
MITSUBISHI IS RECALLING CERTAIN MODEL YEAR 2004-2010 ENDEAVOR VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND WASHINGTON D.C. COLD STATES INCLUDE NORTH DAKOTA, SOUTH DAKOTA, NEBRASKA, KANSAS, OKLAHOMA, COLORADO, WYOMING, MONTANA, IDAHO, WASHINGTON, OREGON, AND UTAH. ADJOINING STATES INCLUDE ARKANSAS, TENNESSEE, AND NORTH CAROLINA. IN SEVERE CORROSIVE ENVIRONMENTS WHERE ROAD SALTS ARE FREQUENTLY USED IN WINTER VEHICLES MAY BE EXPOSED TO ROAD DEBRIS (MUD) MIXED WITH ROAD SALT. THIS MATERIAL CAN BECOME TRAPPED BETWEEN A REINFORCING BRACKET AND THE FUEL FILLER PIPE, POTENTIALLY CAUSING CORROSION. OVER TIME, CORROSION COULD CREATE A LEAK IN THE FUEL FILLER PIPE THAT COULD RESULT IN A FUEL LEAKAGE WHEN FUELING THE VEHICLE.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL FILLER PIPE WITH A NEW IMPROVED PART FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JULY 5, 2010. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-0037.
08V139000 · Electrical System:ignition
Mar 26, 2008
MITSUBISHI IS RECALLING 120,000 MY 2004-2006 ENDEAVOR PASSENGER VEHICLES. DURING VEHICLE USE, THE IGNITION KEY INTERLOCK CABLE (WHICH IS A COMPONENT OF THE INTERLOCK SYSTEM) MAY ALLOW THE INTERLOCKING CAM TO FALL FORWARD AND ALLOW THE IGNITION KEY TO BE REMOVED FROM THE IGNITION SWITCH WHEN THE GEARSHIFT MECHANISM IS NOT IN THE PARK POSITION.
Consequence & remedy
Consequence: IF THE DRIVER DOES NOT SHIFT TO PARK BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSPECT AND CORRECT THESE VEHICLES FOR THE REPORTED CONDITION. THE RECALL WILL BEGIN ON JULY 7, 2008. OWNERS MAY CONTACT MITSUBISHI AT 1-888-648-7820.
05V069000 · Parking Brake
Mar 2, 2005
ON CERTAIN SPORT UTILITY VEHICLES, THE PARKING BRAKE PEDAL CABLE LOCK NUT MAY NOT HAVE BEEN TIGHTENED TO THE PROPER TORQUE SPECIFICATION. THE LOCK NUT MAY LOOSEN AND COME OFF, WHICH WILL REDUCE THE EFFECTIVENESS OF THE PARKING BRAKE.
Consequence & remedy
Consequence: THIS CONDITION COULD ALLOW THE VEHICLE TO ROLL IF THE TRANSMISSION IS NOT PLACED INTO THE "PARK" POSITION AND THE VEHICLE IS PARKED ON A SLOPE, THUS RAISING THE POSSIBILITY OF A CRASH.
Remedy: DEALERS WILL INSPECT AND TIGHTEN THE PARKING BRAKE CABLE LOCK NUT, IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN FEBRUARY 24, 2005. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-5500.
04V428000 · Equipment:other:labels
Sep 1, 2004
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: MITSUBISHI CARIBBEAN WILL MAIL A CUSTOMER NOTIFICATION LETTER CONTAINING A WRITTEN DESCRIPTION AND A GRAPHIC OF THE BI-LINGUAL DASHBOARD AIR BAG WARNING LABEL. IN ADDITION, ALL CURRENT 2000-2004 NATIVA OWNERS WILL ALSO RECEIVE REPLACEMENT AIR BAG ALERT LABELS FOR THE SUN VISORS. THIS RECALL IS EXPECTED TO BEGIN DURING MARCH OR APRIL 2005. THE NOTIFICATION TO THE NATIVA OWNERS IS EXPECTED TO BEGIN DURING APRIL OR MAY 2005. OWNERS SHOULD CONTACT MITSUBISHI CARIBBEAN AT 1-787-251-8715.
04V279000 · Seats
Jun 7, 2004
ON CERTAIN VEHICLES, THE FOOT OF THE DRIVER'S SIDE SEAT RISER MAY DEVELOP A CRACK, RESULTING IN REDUCED STRENGTH OF THE SEAT ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT COULD BECOME DETACHED, INCREASING THE RISK OF OCCUPANT INJURY.
Remedy: DEALERS WILL INSPECT THE DRIVER'S SEAT BRACKET TO DETERMINE WHETHER IT REQUIRES REPLACEMENT. IF SO, THE DEALER WILL REPLACE IT WITH A NEW, IMPROVED PART. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT MITSUBISHI AT 1-888-648-7820.
04V197000 · Trailer Hitches
Apr 26, 2004
CERTAIN SPORT UTILITY VEHICLES MAY HAVE BEEN EQUIPPED WITH DEALER-INSTALLED TRAILER HITCH WIRING HARNESS AND CONTROL MODULE. THE ELECTRONIC CONTROL MODULE CAN OVERHEAT.
Consequence & remedy
Consequence: OVERHEATING OF THE TRAILER HITCH WIRING HARNESS MODULE COULD RESULT IN A FIRE.
Remedy: OWNERS ARE BEING REQUESTED TO STOP USING THE HARNESS UNTIL A NEWLY DESIGNED REPLACEMENT IS PROVIDED AND CAN BE INSTALLED BY THE DEALER. THE RECALL BEGAN ON MAY 28, 2004. OWNERS SHOULD CONTACT MITSUBISHI AT 1-888-648-7820.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE09056 · Gasoline Leaks
Opened Dec 30, 2009 · Closed Mar 12, 2010
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
THIS INVESTIGATION WAS OPENED ON DECEMBER 30, 2009, BASED ON FIVE CONSUMER REPORTS ALLEGING GASOLINE FUEL LEAKING FROM THE FUEL FILL PIPE.SOME OF THE COMPLAINANTS INDICATED THE FUEL FILL PIPE HAD CORRODED TO THE POINT OF BEING PERFORATED, ALLOWING FUEL TO LEAK FROM THE PIPE.BY LETTER OF FEBRUARY, 24, 2010, AND AMENDED MARCH 10, 2010, MITSUBISHI MOTORS NORTH AMERICA (MITSUBISHI) NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 26,135 SUBJECT VEHICLES.THE RECALLED VEHICLES WERE SOLD OR ARE CURRENTLY REGISTERED IN THE FOLLOWING SALT BELT STATES : CT, DE, IL, IN, IA, KY, ME, MD, MA, MI, MN, MO, NH, NJ, NY, OH, PA, RI, VT, VA, WV, WI, AND THE DISTRICT OF COLUMBIA.MITSUBISHI WILL ALSO INCLUDE IN THE RECALL THE FOLLOWING COLD CLIMATE STATES: ND, SD, NB, KS, OK, CO, WY, MT, ID, WA, OR, AND UT.MITIUBISHI STATES THAT A MIXTURE OF MUD AND ROAD SALT CAN BECOME TRAPPED BETWEEN A REINFORCING BRACKET AND THE FILL PIPE AND LEAD TO CORROSION OF THE FILL PIPE, RESULTING IN LEAKS DURING REFUELING.FOR SUBJECT VEHICLES NOT IN SALT BELT OR COLD STATES (APPROXIMATELY 28,077), MITSUBISHI WILL EXTEND THE WARRANTY OF THE FUEL FILL PIPE TO 10 YEARS OR 150,000 MILES, WHICHEVER COMES FIRST.
PE08006 · IGNITION-PARK Interlock System
Opened Jan 29, 2008 · Closed Apr 14, 2008
Status: closed (inferred from source dates) · Electrical System:ignition:switch; Power Train:manual Transmission:floor Shift Assembly
THE SUBJECT VEHICLE IGNITION-PARK INTERLOCK AND SHIFT LOCK (BRAKE-SHIFT INTERLOCK) SYSTEMS ARE MECHANICALLY ACTUATED.THE SYSTEMS UTILIZE TWO CABLE ASSEMBLIES THAT CONNECT TO A PLASTIC HOUSING MOUNTED TO THE SHIFT LEVER MECHANISM.WITHIN THE HOUSING IS A LEVER (INTERLOCK LEVER) THAT THE IGNITION-PARK INTERLOCK CABLE CONNECTS TO.WHEN THE INTERLOCK LEVER IS POSITIONED IN ITS REARWARD TRAVEL RANGE, THE IGNITION KEY REMOVAL IS PREVENTED; WHEN THE LEVER IS POSITIONED IN ITS FORWARD POSITION, KEY REMOVAL IS ALLOWED.ACCORDING TO MITSUBISHI, THE IGNITION KEY INTERLOCK CABLE MAY ALLOW THE INTERLOCK LEVER TO FALL FORWARD DURING VEHICLE USE.IN THIS STATE THE IGNITION KEY CAN BE REMOVED FROM THE IGNITION SWITCH WHEN THE GEARSHIFT MECHANISM IS NOT IN THE PARK POSITION.IF THE DRIVER DOES NOT SHIFT TO PARK BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.MOST OF THE REPORTED CRASH INCIDENTS WERE MINOR IN NATURE INVOLVING UNOCCUPIED VEHICLES ROLLING FROM A PARKED CONDITION AND STRIKING OTHER VEHICLES OR OBJECTS.THE SINGLE INJURY INCIDENT OCCURRED WHEN THE OPERATOR PARKED THE VEHICLE, EXITED, AND WAS SUBSEQUENTLY STRUCK BY THE VEHICLE AS IT ROLLED AWAY.THE TYPE AND SEVERITY OF THE INJURIES WERE NOT DESCRIBED.IN A LETTER DATED MARCH 21, 2008, MITSUBISHI ADVISED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL TO ADDRESS THIS CONDITION (SEE WWW.SAFERCAR.GOV, RECALL ACTION 08V-139 FOR FURTHER DETAILS); REMEDY DETAILS AND TIMING ARE TO BE DETERMINED.ACCORDINGLY THE INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:ignition:switch
THE SUBJECT VEHICLE IGNITION-PARK INTERLOCK AND SHIFT LOCK (BRAKE-SHIFT INTERLOCK) SYSTEMS ARE MECHANICALLY ACTUATED.THE SYSTEMS UTILIZE TWO CABLE ASSEMBLIES THAT CONNECT TO A PLASTIC HOUSING MOUNTED TO THE SHIFT LEVER MECHANISM.WITHIN THE HOUSING IS A LEVER (INTERLOCK LEVER) THAT THE IGNITION-PARK INTERLOCK CABLE CONNECTS TO.WHEN THE INTERLOCK LEVER IS POSITIONED IN ITS REARWARD TRAVEL RANGE, THE IGNITION KEY REMOVAL IS PREVENTED; WHEN THE LEVER IS POSITIONED IN ITS FORWARD POSITION, KEY REMOVAL IS ALLOWED.ACCORDING TO MITSUBISHI, THE IGNITION KEY INTERLOCK CABLE MAY ALLOW THE INTERLOCK LEVER TO FALL FORWARD DURING VEHICLE USE.IN THIS STATE THE IGNITION KEY CAN BE REMOVED FROM THE IGNITION SWITCH WHEN THE GEARSHIFT MECHANISM IS NOT IN THE PARK POSITION.IF THE DRIVER DOES NOT SHIFT TO PARK BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.MOST OF THE REPORTED CRASH INCIDENTS WERE MINOR IN NATURE INVOLVING UNOCCUPIED VEHICLES ROLLING FROM A PARKED CONDITION AND STRIKING OTHER VEHICLES OR OBJECTS.THE SINGLE INJURY INCIDENT OCCURRED WHEN THE OPERATOR PARKED THE VEHICLE, EXITED, AND WAS SUBSEQUENTLY STRUCK BY THE VEHICLE AS IT ROLLED AWAY.THE TYPE AND SEVERITY OF THE INJURIES WERE NOT DESCRIBED.IN A LETTER DATED MARCH 21, 2008, MITSUBISHI ADVISED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL TO ADDRESS THIS CONDITION (SEE WWW.SAFERCAR.GOV, RECALL ACTION 08V-139 FOR FURTHER DETAILS); REMEDY DETAILS AND TIMING ARE TO BE DETERMINED.ACCORDINGLY THE INVESTIGATION IS CLOSED.
Electrical System:ignition:switch
THE SUBJECT VEHICLE IGNITION-PARK INTERLOCK AND SHIFT LOCK (BRAKE-SHIFT INTERLOCK) SYSTEMS ARE MECHANICALLY ACTUATED.THE SYSTEMS UTILIZE TWO CABLE ASSEMBLIES THAT CONNECT TO A PLASTIC HOUSING MOUNTED TO THE SHIFT LEVER MECHANISM.WITHIN THE HOUSING IS A LEVER (INTERLOCK LEVER) THAT THE IGNITION-PARK INTERLOCK CABLE CONNECTS TO.WHEN THE INTERLOCK LEVER IS POSITIONED IN ITS REARWARD TRAVEL RANGE, THE IGNITION KEY REMOVAL IS PREVENTED; WHEN THE LEVER IS POSITIONED IN ITS FORWARD POSITION, KEY REMOVAL IS ALLOWED.ACCORDING TO MITSUBISHI, THE IGNITION KEY INTERLOCK CABLE MAY ALLOW THE INTERLOCK LEVER TO FALL FORWARD DURING VEHICLE USE.IN THIS STATE THE IGNITION KEY CAN BE REMOVED FROM THE IGNITION SWITCH WHEN THE GEARSHIFT MECHANISM IS NOT IN THE PARK POSITION.IF THE DRIVER DOES NOT SHIFT TO PARK BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.MOST OF THE REPORTED CRASH INCIDENTS WERE MINOR IN NATURE INVOLVING UNOCCUPIED VEHICLES ROLLING FROM A PARKED CONDITION AND STRIKING OTHER VEHICLES OR OBJECTS.THE SINGLE INJURY INCIDENT OCCURRED WHEN THE OPERATOR PARKED THE VEHICLE, EXITED, AND WAS SUBSEQUENTLY STRUCK BY THE VEHICLE AS IT ROLLED AWAY.THE TYPE AND SEVERITY OF THE INJURIES WERE NOT DESCRIBED.IN A LETTER DATED MARCH 21, 2008, MITSUBISHI ADVISED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL TO ADDRESS THIS CONDITION (SEE WWW.SAFERCAR.GOV, RECALL ACTION 08V-139 FOR FURTHER DETAILS); REMEDY DETAILS AND TIMING ARE TO BE DETERMINED.ACCORDINGLY THE INVESTIGATION IS CLOSED.
Power Train:manual Transmission:floor Shift Assembly
THE SUBJECT VEHICLE IGNITION-PARK INTERLOCK AND SHIFT LOCK (BRAKE-SHIFT INTERLOCK) SYSTEMS ARE MECHANICALLY ACTUATED.THE SYSTEMS UTILIZE TWO CABLE ASSEMBLIES THAT CONNECT TO A PLASTIC HOUSING MOUNTED TO THE SHIFT LEVER MECHANISM.WITHIN THE HOUSING IS A LEVER (INTERLOCK LEVER) THAT THE IGNITION-PARK INTERLOCK CABLE CONNECTS TO.WHEN THE INTERLOCK LEVER IS POSITIONED IN ITS REARWARD TRAVEL RANGE, THE IGNITION KEY REMOVAL IS PREVENTED; WHEN THE LEVER IS POSITIONED IN ITS FORWARD POSITION, KEY REMOVAL IS ALLOWED.ACCORDING TO MITSUBISHI, THE IGNITION KEY INTERLOCK CABLE MAY ALLOW THE INTERLOCK LEVER TO FALL FORWARD DURING VEHICLE USE.IN THIS STATE THE IGNITION KEY CAN BE REMOVED FROM THE IGNITION SWITCH WHEN THE GEARSHIFT MECHANISM IS NOT IN THE PARK POSITION.IF THE DRIVER DOES NOT SHIFT TO PARK BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.MOST OF THE REPORTED CRASH INCIDENTS WERE MINOR IN NATURE INVOLVING UNOCCUPIED VEHICLES ROLLING FROM A PARKED CONDITION AND STRIKING OTHER VEHICLES OR OBJECTS.THE SINGLE INJURY INCIDENT OCCURRED WHEN THE OPERATOR PARKED THE VEHICLE, EXITED, AND WAS SUBSEQUENTLY STRUCK BY THE VEHICLE AS IT ROLLED AWAY.THE TYPE AND SEVERITY OF THE INJURIES WERE NOT DESCRIBED.IN A LETTER DATED MARCH 21, 2008, MITSUBISHI ADVISED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL TO ADDRESS THIS CONDITION (SEE WWW.SAFERCAR.GOV, RECALL ACTION 08V-139 FOR FURTHER DETAILS); REMEDY DETAILS AND TIMING ARE TO BE DETERMINED.ACCORDINGLY THE INVESTIGATION IS CLOSED.
Power Train:manual Transmission:floor Shift Assembly
THE SUBJECT VEHICLE IGNITION-PARK INTERLOCK AND SHIFT LOCK (BRAKE-SHIFT INTERLOCK) SYSTEMS ARE MECHANICALLY ACTUATED.THE SYSTEMS UTILIZE TWO CABLE ASSEMBLIES THAT CONNECT TO A PLASTIC HOUSING MOUNTED TO THE SHIFT LEVER MECHANISM.WITHIN THE HOUSING IS A LEVER (INTERLOCK LEVER) THAT THE IGNITION-PARK INTERLOCK CABLE CONNECTS TO.WHEN THE INTERLOCK LEVER IS POSITIONED IN ITS REARWARD TRAVEL RANGE, THE IGNITION KEY REMOVAL IS PREVENTED; WHEN THE LEVER IS POSITIONED IN ITS FORWARD POSITION, KEY REMOVAL IS ALLOWED.ACCORDING TO MITSUBISHI, THE IGNITION KEY INTERLOCK CABLE MAY ALLOW THE INTERLOCK LEVER TO FALL FORWARD DURING VEHICLE USE.IN THIS STATE THE IGNITION KEY CAN BE REMOVED FROM THE IGNITION SWITCH WHEN THE GEARSHIFT MECHANISM IS NOT IN THE PARK POSITION.IF THE DRIVER DOES NOT SHIFT TO PARK BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.MOST OF THE REPORTED CRASH INCIDENTS WERE MINOR IN NATURE INVOLVING UNOCCUPIED VEHICLES ROLLING FROM A PARKED CONDITION AND STRIKING OTHER VEHICLES OR OBJECTS.THE SINGLE INJURY INCIDENT OCCURRED WHEN THE OPERATOR PARKED THE VEHICLE, EXITED, AND WAS SUBSEQUENTLY STRUCK BY THE VEHICLE AS IT ROLLED AWAY.THE TYPE AND SEVERITY OF THE INJURIES WERE NOT DESCRIBED.IN A LETTER DATED MARCH 21, 2008, MITSUBISHI ADVISED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL TO ADDRESS THIS CONDITION (SEE WWW.SAFERCAR.GOV, RECALL ACTION 08V-139 FOR FURTHER DETAILS); REMEDY DETAILS AND TIMING ARE TO BE DETERMINED.ACCORDINGLY THE INVESTIGATION IS CLOSED.