← New search

2004 Mini Cooper

Owner reports · Recalls · Investigations

More warning signs than most Cooper years

Owner complaints for the 2004 Mini Cooper are substantially higher than the model-year median of 40.5.

About this comparison →

How this year compares

Owner complaints by model year

Other model years Selected year
Compare all Cooper years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

All reported categories

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

254 reports with mileage · 28 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Steering. Review the 238 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Power Train. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

5 crash reports9 fire reports1 injury reports

What owners actually said

282 reports
75,000 miles · Apr 9, 2013
Steering

POWER STEERING PUMP FAILURE. *TR

NHTSA ODI #10505694

Mileage unknown · Apr 3, 2013
Engine And Engine CoolingPower TrainSteering

2004 MINI COOPER. CONSUMER REQUESTS ASSISTANCE FOR HAZARDOUS VEHICLE TRANSMISSION AND STEERING WHEEL. *SMD THE CONSUMER STATED THE VEHICLE STALLED WHILE DRIVING ON A BUSY HIGHWAY.

NHTSA ODI #10506102

74,372 miles · Apr 2, 2013
Steering

THE STEERING BECAME VERY TIGHT AND THE STEERING WHEEL WAS VERY HARD TO TURN. THE SUDDEN LOSS OF POWER STEERING WAS VERY SCARY AT NORMAL STREET SPEEDS. SHUTTING OFF THE CAR AND RESTARTING IT WILL RETURN THE STEERING TO NORMAL ONLY FOR A LITTLE BIT...AFTER A FEW MINUTES THE POWER STEERING IS GONE AGAIN. *TR

NHTSA ODI #10505423

71,000 miles · Mar 6, 2013
Steering

LOSS OF POWER STEERING ON MY 2004 MINI COOPER. THIS PROBLEM COMES AN GOES AND MY LOCAL SERVICE STATION SAID THE PUMP HAS A CRACK. *TR

NHTSA ODI #10501891

77,000 miles · Mar 4, 2013
Steering

POWER STEERING FAILURE. UNKNOWN CAUSE. *TR

NHTSA ODI #10501200

58,000 miles · Feb 25, 2013
Steering

WHILE DRIVING ON I95 GOING AROUND A CURVE, MY STEERING COLUMN LOCKED UP. I WAS ABLE TO PULL OVER TO THE SHOULDER. IT HAS HAPPENED A FEW TIMES BUT I WAS ABLE TO PULL OVER AND WASN'T SURE WHAT TO TELL MY MECHANIC SINCE IT WAS SO RANDOM. THIS WEEKEND AS I DROVE THROUGH AN INTERSECTION MAKING A LEFT TURN, WITH MY CHILDREN IN THE CAR…

Read full complaint

WHILE DRIVING ON I95 GOING AROUND A CURVE, MY STEERING COLUMN LOCKED UP. I WAS ABLE TO PULL OVER TO THE SHOULDER. IT HAS HAPPENED A FEW TIMES BUT I WAS ABLE TO PULL OVER AND WASN'T SURE WHAT TO TELL MY MECHANIC SINCE IT WAS SO RANDOM. THIS WEEKEND AS I DROVE THROUGH AN INTERSECTION MAKING A LEFT TURN, WITH MY CHILDREN IN THE CAR, IT LOCKED UP AFTER MONTHS OF NOT RECURRING. I WAS ABLE TO STOP IN TIME BEFORE COLLIDING WITH ONCOMING CARS AT THE RED LIGHT BUT IT WAS VERY SCARY FOR ALL OF US. I AM APPALLED MINI HAS NOT ISSUED A RECALL CONSIDERING THE PRECIOUS LIVES THAT ARE AT STAKE. I SUPPOSE IT WILL TAKE A FATALITY FOR SOMEONE TO RECALL THIS DEFECTIVE PART. *TR

NHTSA ODI #10500071

102,000 miles · Feb 14, 2013
Steering

POWER STEERING WENT OUT AS WE WERE DRIVING DOWN THE ROAD. ALMOST CAUSED AN ACCIDENT. POWER STEERING STILL OUT. I JUST READ UP AND IT SEEMS EVERYONE'S WAITING FOR THE RECALL. THIS IS DANGEROUS!! *TR

NHTSA ODI #10498099

55,000 miles · Feb 12, 2013
Electrical SystemExterior LightingSteering

DRIVING OFF-RAMP AT 35 MPH POWER STEERING STOPPED FUNCTIONING AND STEERING BECAME REALLY HARD, LIGHTS WENT OFF, AC STOPPED WORKING, AND LOTS OF ENGINE LIGHTS CAME UP, ALMOST CRASHED WHEN TURNING A CORNER AND ENGINE STARTED FAILING.....GOT HOME AND SHUT OFF CAR, WHEN TRIED TO TURN ON AGAIN, IT FAILED TO START....... *TR

NHTSA ODI #10497950

81,000 miles · Jan 27, 2013
Steering

2004 MINI COOPER OCCASIONALLY WOULD LOSE POWER STEERING ONCE EVERY COUPLE MONTHS AFTER A FEW YEARS OF OWNING IT. TURNING OFF CAR AND STARTING IT BACK UP WOULD ALWAYS RESOLVE IT. WHILE DRIVING DOWN HIGHWAY AT 60MPH, LOST POWER STEERING. COULD NOT PULL OVER IMMEDIATELY. TOOK EXIT RAMP WITH A SHARP CURVE, COULD BARELY MAKE IT AROUN…

Read full complaint

2004 MINI COOPER OCCASIONALLY WOULD LOSE POWER STEERING ONCE EVERY COUPLE MONTHS AFTER A FEW YEARS OF OWNING IT. TURNING OFF CAR AND STARTING IT BACK UP WOULD ALWAYS RESOLVE IT. WHILE DRIVING DOWN HIGHWAY AT 60MPH, LOST POWER STEERING. COULD NOT PULL OVER IMMEDIATELY. TOOK EXIT RAMP WITH A SHARP CURVE, COULD BARELY MAKE IT AROUND THE CURVE, ENDED UP ON THE SHOULDER. EASILY COULD HAVE BEEN AN ACCIDENT, OR WORSE. *TR

NHTSA ODI #10494850

91,000 miles · Jan 10, 2013
Steering

TL* THE CONTACT OWNS A 2004 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE POWER STEERING FAILED. THE VEHICLE WAS SHUTDOWN AND RESTARTED AND AFTER A FEW MINUTES, OPERATED AS DESIGNED. THE VEHICLE HAD NOT BEEN DIAGNOSED BY A MECHANIC BUT THE CONTACT WAS SURE THAT THE POWER STEERING PUMP WAS THE CAUSE OF THE FAILUR…

Read full complaint

TL* THE CONTACT OWNS A 2004 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE POWER STEERING FAILED. THE VEHICLE WAS SHUTDOWN AND RESTARTED AND AFTER A FEW MINUTES, OPERATED AS DESIGNED. THE VEHICLE HAD NOT BEEN DIAGNOSED BY A MECHANIC BUT THE CONTACT WAS SURE THAT THE POWER STEERING PUMP WAS THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 91,000.

NHTSA ODI #10492100

Official recalls

2

15V660000 · Steering:electric Power Assist System

Oct 15, 2015

BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 MINI Cooper and Cooper S vehicles and 2005 Cooper and Cooper S Convertible vehicles. The affected vehicles may experience temporary or permanent loss of the electro-hydraulic steering assistance.

Consequence & remedy

Consequence: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, potentially increasing the risk of a vehicle crash.

Remedy: MINI will notify owners, and dealers will inspect the electro-hydraulic power steering system, replacing the components and wiring, as necessary, free of charge. Interim notices were mailed to owners on December 10, 2015. Owners will receive a second notice when remedy parts become available. Owners may contact MINI customer service at 1-866-825-1525.

04V348000 · Tires:pressure Monitoring And Regulating Systems

Jul 12, 2004

ON CERTAIN PASSENGER VEHICLES, THE FLAT TIRE MONITORING SYSTEM HAS NOT BEEN CORRECTLY PROGRAMMED. IN THE EVENT OF A FLAT TIRE, AN AUDIBLE SIGNAL WILL NOT SOUND TO ALERT THE DRIVER TO A FLAT TIRE.

Consequence & remedy

Consequence: DUE TO THE LACK OF AN AUDIBLE SIGNAL, THE DRIVER MAY NOT BE AWARE OF A FLAT TIRE, WHICH COULD INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL REPROGRAM THE VEHICLE'S SOFTWARE IN ORDER TO ACTUATE THE FLAT TIRE MONITORING SYSTEM'S AUDIBLE SIGNAL. THE RECALL BEGAN OCTOBER 13, 2004. OWNERS SHOULD CONTACT MINI CUSTOMER RELATIONS AT 1-866-275-6464.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

EA11005 · Loss Of Power Steering Assist

Opened May 4, 2011 · Closed Jan 5, 2016

Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump

The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si

Additional source detail variants (4)

Steering

The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si

Steering:electric Power Assist System

The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si

Steering:hydraulic Power Assist:pump

The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si

Steering:hydraulic Power Assist System

The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si

PE10038 · Loss Of Power Steering Assist

Opened Sep 24, 2010 · Closed May 10, 2011

Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump

ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).

Additional source detail variants (4)

Steering

ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).

Steering:electric Power Assist System

ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).

Steering:hydraulic Power Assist:pump

ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).

Steering:hydraulic Power Assist System

ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).