IllustrationOUR 2004 MINI COOPER (CVT) AUTOMATIC TRANSMISSION NEEDS TO BE REPLACED. THE CAR HAS ONLY 74,000 MILE ON IT. *TR
2004 Mini Cooper
Owner reports · Recalls · Investigations
More warning signs than most Cooper years
Owner complaints for the 2004 Mini Cooper are substantially higher than the model-year median of 40.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cooper years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
130–25K
3325–50K
8750–75K
6375–100K
49100–150K
9150K+
254 reports with mileage · 28 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 238 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports9 fire reports1 injury reports
What owners actually said
282 reportsTL*THE CONTACT OWNS A 2004 MINI COOPER. WHILE DRIVING 50 MPH, THE CONTACT NOTICED A BUMP ON THE REAR DRIVER'S SIDE OF THE VEHICLE. SHE EXAMINED THE VEHICLE AND NOTICED THAT THE REAR DRIVER'S SIDE TIRE WAS DETACHING FROM THE VEHICLE. IN ADDITION, THE LOWER CONTROL ARM SNAPPED. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STAT…
Read full complaint
TL*THE CONTACT OWNS A 2004 MINI COOPER. WHILE DRIVING 50 MPH, THE CONTACT NOTICED A BUMP ON THE REAR DRIVER'S SIDE OF THE VEHICLE. SHE EXAMINED THE VEHICLE AND NOTICED THAT THE REAR DRIVER'S SIDE TIRE WAS DETACHING FROM THE VEHICLE. IN ADDITION, THE LOWER CONTROL ARM SNAPPED. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THE LOWER CONTROL ARM NEEDED TO BE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 71,000.
2004 MINI COOPER NON S , TRANSMISSION FAILURE DUE TO A MIDLAND TRANSMISSION. *TR
TL*THE CONTACT OWNS A 2004 MINI COOPER. THE CONTACT HEARD A LOUD NOISE WHILE DRIVING 10 MPH OUT OF THE DRIVEWAY. SHE EXAMINED THE VEHICLE AND NOTICED THAT THE REAR DRIVER'S SIDE TIRE WAS BENT. THE VEHICLE WAS TOWED TO THE REPAIR SHOP AND THE MECHANIC STATED THAT THE REAR SPRING LEAF CRACKED. THE REAR SPRING LEAF WAS REPLACED…
Read full complaint
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
TL*THE CONTACT OWNS A 2004 MINI COOPER. WHILE THE DRIVER WAS PLACING ITEMS IN THE REAR OF THE VEHICLE, HIS CALF WAS BURNED BY THE EXTENDED TAIL PIPE. THE DRIVER HAS INCURRED MULTIPLE BURNS TO HIS CALF DUE TO THE EXTENDED TAIL PIPE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THEY COULD NOT ASSIST BECAUSE THERE WE…
Read full complaint
TL*THE CONTACT OWNS A 2004 MINI COOPER. WHILE THE DRIVER WAS PLACING ITEMS IN THE REAR OF THE VEHICLE, HIS CALF WAS BURNED BY THE EXTENDED TAIL PIPE. THE DRIVER HAS INCURRED MULTIPLE BURNS TO HIS CALF DUE TO THE EXTENDED TAIL PIPE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THEY COULD NOT ASSIST BECAUSE THERE WERE NO RECALLS FOR THIS FAILURE. THE MANUFACTURER WOULD NOT PROVIDE COMPENSATION BECAUSE THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 6,000 AND CURRENT MILEAGE WAS 9,000.
TRANSMISSION GAVE WAY. *TR
TL*THE CONTACT OWNS A 2004 MINI COOPER. WHILE DRIVING 15-20 MPH, THE POWER STEERING SUDDENLY FAILED. THE CONTACT HAD TO PULL THE VEHICLE OVER. A DIAGNOSTIC HAS NOT BEEN PERFORMED TO DETERMINE THE CAUSE OF THE FAILURE. THE FAILURE MILEAGE WAS 37,640.
POWER STEERING FAILED SOON AFTER STARTING. THE CAR HAD BEEN OUTSIDE ON A COLD DAY, BUT NOT UNUSUAL (~20 DEGREES F). IT FUNCTIONED AGAIN WHEN RE-STARTED. *TR
WHILE DRIVING ON THE FREEWAY MY POWER STEERING PUMP DIED I COULD HARDLY CHANGE LANES ON THE FREEWAY, IT FELT LIKE MY STEERING WHEEL HAD LOCKED, TURNING IN ANY ANGLE WAS VERY HARD WORST THAN DRIVING A TRUCK, I KEPT A FIRM GRIP WITH ONE HAND WHILE TRYING TO CONTROL THE GEARS, MY ARMS, BACK, AND HAND IS STILL HURTING, HAD NO WARNI…
Read full complaint
WHILE DRIVING ON THE FREEWAY MY POWER STEERING PUMP DIED I COULD HARDLY CHANGE LANES ON THE FREEWAY, IT FELT LIKE MY STEERING WHEEL HAD LOCKED, TURNING IN ANY ANGLE WAS VERY HARD WORST THAN DRIVING A TRUCK, I KEPT A FIRM GRIP WITH ONE HAND WHILE TRYING TO CONTROL THE GEARS, MY ARMS, BACK, AND HAND IS STILL HURTING, HAD NO WARNING SIGNALS, IT WHEEL JUST LOCKED UP AND WAS VERY HARD TO MANAGED I WASNT ABLE TO HANDLE THE CAR DID NOT FEEL SAFE, DID NOT HAVE FULL CONTROL OF HANDLING THE STEERING THIS IS SERIOUS PROTENTIAL ACCIDENT WAITING TO HAPPEN I CALLED THE DEALER AND WAS TOLD THAT THERE WERE RECALLS BUT NOT FOR MY VIN 2004. MY MINI IS NOW IN THE REPAIR SHOP TO HAVE THE PUMP REPLACE AND THE FAN. THIS IS A DEADLY ISSUE AND MINI SHOULD RECALL AND PAY FOR THIS PROBLEM FOR THOSE OF US WHO HAD TO PAY OUT OF POCKET WE SHOULD GET REFUNDS, SO FAR OUT OF POCKET IS OVER $1100.00, I HOPE THIS SEND A MESSAGE TO THE MANAUFACTURE THAT LIVES ARE AT STAKE HERE, GREAT CAR BUT NOT SAFE TO DRIVE WITHOUT FULL CONTROL. I'M SO THANKFUL I DIDNT HAVE TO MOVE QUICKLY OUT OF THE WAY OR I WOULD NOT BE HERE TO REPORT THIS BAD EXPERIENCE I LOST A DAY OF WORK TRYING TO GET THIS RESOLVED AND THE COST OF A RENTAL CAR. *TR
APPROXIMATELY ONE MONTH AGO I WAS ON ORTEGA HIGHWAY IN SOUTHERN CALIFORNIA WITH MY CHILD IN THE BACK SEAT. AS I WAS MANEUVERING THE MINI ALONG THE CURVY ROAD THE POWER STEERING WENT OUT. FORTUNATELY I HAD GOTTEN THROUGH THE WORST OF THE HAIR PINS AND WAS GOING SLOWER THAN THE SPEED LIMIT ETC. SUDDENLY THE STEERING BEGAN TO WORK …
Read full complaint
APPROXIMATELY ONE MONTH AGO I WAS ON ORTEGA HIGHWAY IN SOUTHERN CALIFORNIA WITH MY CHILD IN THE BACK SEAT. AS I WAS MANEUVERING THE MINI ALONG THE CURVY ROAD THE POWER STEERING WENT OUT. FORTUNATELY I HAD GOTTEN THROUGH THE WORST OF THE HAIR PINS AND WAS GOING SLOWER THAN THE SPEED LIMIT ETC. SUDDENLY THE STEERING BEGAN TO WORK AGAIN. MY HUSBAND WAS INFORMED BY A MECHANIC THAT IT WAS THE POWER STEERING FAN. WE HAD IT REPLACED AND IT SEEMED OKAY. ON NOVEMBER 26TH I HAD MY CHILDREN IN THE CAR GOING TO MY SISTERS I WENT TO MAKE A LEFT HAND TURN AND THE CAR DIDN'T WANT TO TURN. THE POWER STEERING FAILED AGAIN. I WAS FORTUNATE ONCE AGAIN AS THERE WAS NO ON COMING TRAFFIC BECAUSE IF THERE WAS I WOULD HAVE HAD A HEAD-ON COLLISION. THERE ARE NO WARNING LIGHTS FOR THIS ISSUE AND I HAD NEVER BEEN INFORMED OF POWER STEERING ISSUES BEING SO SUDDEN ON THIS VEHICLE. I BELIEVE A MASSIVE RECALL FOR THE 02-04 YEARS WOULD BE AN EXTREMELY GOOD IDEA. I GOGGLED THE ISSUE AND HAVE FOUND MANY OTHERS WITH THESE YEARS THAT ARE HAVING THE SAME PROBLEM. MY VEHICLE IS ONLY 4 YEARS OLD. I HAVE A TRUCK OLDER THAN IT THAT HAS NEVER HAD TO HAVE THE POWER STEERING REPLACED. I CAN NOT AFFORD TO REPLACE IT NOW DUE TO FINANCIAL ISSUES. THE PUMP ALONE IS BETWEEN 400-500 DOLLARS. PLEASE, PLEASE, PLEASE GET THEM TO RECALL THIS BEFORE SOMEONE DIES! OR IS THAT WHAT EVERYONE IS WAITING FOR?!? *TR
Official recalls
215V660000 · Steering:electric Power Assist System
Oct 15, 2015
BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 MINI Cooper and Cooper S vehicles and 2005 Cooper and Cooper S Convertible vehicles. The affected vehicles may experience temporary or permanent loss of the electro-hydraulic steering assistance.
Consequence & remedy
Consequence: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, potentially increasing the risk of a vehicle crash.
Remedy: MINI will notify owners, and dealers will inspect the electro-hydraulic power steering system, replacing the components and wiring, as necessary, free of charge. Interim notices were mailed to owners on December 10, 2015. Owners will receive a second notice when remedy parts become available. Owners may contact MINI customer service at 1-866-825-1525.
04V348000 · Tires:pressure Monitoring And Regulating Systems
Jul 12, 2004
ON CERTAIN PASSENGER VEHICLES, THE FLAT TIRE MONITORING SYSTEM HAS NOT BEEN CORRECTLY PROGRAMMED. IN THE EVENT OF A FLAT TIRE, AN AUDIBLE SIGNAL WILL NOT SOUND TO ALERT THE DRIVER TO A FLAT TIRE.
Consequence & remedy
Consequence: DUE TO THE LACK OF AN AUDIBLE SIGNAL, THE DRIVER MAY NOT BE AWARE OF A FLAT TIRE, WHICH COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPROGRAM THE VEHICLE'S SOFTWARE IN ORDER TO ACTUATE THE FLAT TIRE MONITORING SYSTEM'S AUDIBLE SIGNAL. THE RECALL BEGAN OCTOBER 13, 2004. OWNERS SHOULD CONTACT MINI CUSTOMER RELATIONS AT 1-866-275-6464.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11005 · Loss Of Power Steering Assist
Opened May 4, 2011 · Closed Jan 5, 2016
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Additional source detail variants (4)
Steering
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:electric Power Assist System
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:hydraulic Power Assist System
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
PE10038 · Loss Of Power Steering Assist
Opened Sep 24, 2010 · Closed May 10, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Additional source detail variants (4)
Steering
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:electric Power Assist System
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:hydraulic Power Assist:pump
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:hydraulic Power Assist System
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).