IllustrationCVT TRANSMISSION ON 2003 MINI COPPER FAILED AT 87,000 MILES. THE COST TO REPLACE IS QUOTED BY THE DEALER AT $7400. COME TO FIND OUT THAT THIS IS A RECURRING ISSUE WITH THIS TRANSMISSION TO THE POINT THAT IT SHOULD BE CONSIDERED A RECALL ISSUE. *TR
2003 Mini Cooper
Owner reports · Recalls · Investigations
More warning signs than most Cooper years
Owner complaints for the 2003 Mini Cooper are substantially higher than the model-year median of 40.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cooper years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
200–25K
3125–50K
9050–75K
7475–100K
57100–150K
9150K+
281 reports with mileage · 39 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 159 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 89 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports27 fire reports3 injury reports
Power Train complaints
89 reports2003 MINI COOPER, 66,000 MILES AND THE TRANSMISSION NEEDS REPLACED. THE COST IS GOING TO BE 8,500.00. *TR
BOUGHT THE CAR IN 2003 BRAND NEW AND HAD COMPLAINED TO THE SERVICE DEPT WHEN IN FOR REPAIRS THAT THE TRANSMISSION FELT ODD. IT WOULD JERK AT LOW SPEEDS, BETWEEN 5 AND 10. THEY SAID THIS WAS NORMAL FOR THE CVT AND IT SHOULD GO AWAY ONCE THE TRANSMISSION WAS ACCUSTOMED TO THE WAY I DRIVE. IN 2006 MY HUSBAND WAS GIVING BLOOD IN M…
Read full complaint
BOUGHT THE CAR IN 2003 BRAND NEW AND HAD COMPLAINED TO THE SERVICE DEPT WHEN IN FOR REPAIRS THAT THE TRANSMISSION FELT ODD. IT WOULD JERK AT LOW SPEEDS, BETWEEN 5 AND 10. THEY SAID THIS WAS NORMAL FOR THE CVT AND IT SHOULD GO AWAY ONCE THE TRANSMISSION WAS ACCUSTOMED TO THE WAY I DRIVE. IN 2006 MY HUSBAND WAS GIVING BLOOD IN MANCHESTER, NH AND WHILE HE WAS DOING THAT I WENT TO THE MALL FOR A FEW HOURS. AS I WAS RETURNING TO PICK HIM UP I CAME TO A YELLOW LIGHT THAT I COULD NOT MAKE IT THROUGH. I STOPPED THE CAR, LIKE NORMAL NOT A HARD STOP, AND HEARD A CLANK NOISE ALMOST AS IF I HAD HIT SOMETHING IN THE ROAD. THE LIGHT TURNED GREEN AND I PRESSED ON THE ACCELERATOR TO GO AND NOTHING WOULD HAPPEN EXCEPT MY RPMS WOULD GO UP. I WAS ON A SLIGHT HILL AND BEGAN TO COAST BUT I WASN'T SURE IF I WAS COASTING OR IF THE CAR WAS JUST GOING REALLY SLOW, UNTIL I STARTED IN AN UPHILL AND THE CAR STOPPED. I TRIED TO TURN OF THE CAR AND TURN IT BACK ON, CRAZY LOGIC THAT SOMETIMES DOES THE TRICK, AND THERE WAS NO CHANGE. I PUSHED THE CAR INTO A DRIVEWAY AS I WAS ON A 2 LANE ROAD AND BLOCKING TRAFFIC AND CALLED AAA TO HAVE THE CAR TOWED. THE CAR WAS TOWED TO MINI OF PEABODY. WHEN THEY CALLED ON MONDAY THEY SAID THAT THE CVT HAD FAILED, THEY FOUND THE CHAIN AND LINKS IN THE OIL PAN AND THAT IT WOULD HAVE TO BE REPLACED. I ASKED HOW MUCH THE REPLACEMENT WOULD BE AND THEY TOLD ME PARTS AND LABOR WOULD BE $7700. WHEN I WAS TOLD THAT I TALKED TO THE SA ABOUT THE OTHER PEOPLE THAT HAD PROBLEMS WITH THEY'RE CVT'S AT 60K MILES. HE SAID HE WOULD TALK TO THE MANAGER AND CALL BACK. HE CALLED BACK AND SAID THAT HE TALKED TO THE MANAGER AND SPOKE WITH MINI USA AND THEY WOULD COME HALF THE COST OF THE REPLACEMENT BRINGING IT TO $3850. I WENT TO PICK IT UP AND IT FELT LIKE A COMPLETELY DIFFERENT CAR. THERE IS NO JERKINESS AT SLOW SPEEDS SO I'M CONVINCED THAT I HAD A DUD TRANSMISSION ALL ALONG. *TR
MY TRANSMISSION FAILED ON MY MINI-COOPER ONCE WHEN IT WAS IN WARRANTY AND I HAD TO PAY TO HAVE IT FIXED, ONCE AGAIN, AND IT WAS JUST OUT OF WARRANTY AND I PAID 3000$ TO HAVE IT FIXED AND ONCE AGAIN WHEN THE 2ND TRANSMISSION WAS IN WARRANTY AND MINICOOPER FIXED IT. THIS CAR WAS A LEMON AND MINI NEVER ACCEPTED RESPONSIBILITY FOR …
Read full complaint
MY TRANSMISSION FAILED ON MY MINI-COOPER ONCE WHEN IT WAS IN WARRANTY AND I HAD TO PAY TO HAVE IT FIXED, ONCE AGAIN, AND IT WAS JUST OUT OF WARRANTY AND I PAID 3000$ TO HAVE IT FIXED AND ONCE AGAIN WHEN THE 2ND TRANSMISSION WAS IN WARRANTY AND MINICOOPER FIXED IT. THIS CAR WAS A LEMON AND MINI NEVER ACCEPTED RESPONSIBILITY FOR THE DEFECTIVE TRANSMISSION PROBLEMS. *TR
ON 9/2/08 I BROUGHT MY 2003 MINI COOPER TO THE DEALER FOR SERVICE. I WAS HEARING A NOISE FROM THE FRONT THAT CLOCKED AT LOW SPEED. I THOUGHT IT WAS A BAD CV JOINT AND ASKED THE SERVICE WRITER TO VERIFY AND GIVE ME A ESTIMATE. WHEN THEY WERE DONE IT WAS DETERMINED THE NOISE WAS COMING FROM THE TRANSMISSION AND IT WOULD NEED TO BE…
Read full complaint
ON 9/2/08 I BROUGHT MY 2003 MINI COOPER TO THE DEALER FOR SERVICE. I WAS HEARING A NOISE FROM THE FRONT THAT CLOCKED AT LOW SPEED. I THOUGHT IT WAS A BAD CV JOINT AND ASKED THE SERVICE WRITER TO VERIFY AND GIVE ME A ESTIMATE. WHEN THEY WERE DONE IT WAS DETERMINED THE NOISE WAS COMING FROM THE TRANSMISSION AND IT WOULD NEED TO BE REPLACED. THE ESTIMATE WAS $7613.00 PLUS TAX. I DROVE HOME AND SPENT SOME TIME RESEARCHING THE CVT TRANSMISSION IN THE MINI COOPERS AND FOUND WHAT APPEARS TO BE A HIGH FAILURE RATE. A LOOK AT SEVERAL FORUMS FOR MINI'S SHOWS POSTINGS OF PROBLEMS SIMILAR TO MINE IN COOPER MODELS WITH MILEAGES FROM 34,000 TO 113,000 ALL WITH CVT TRANSMISSIONS. THE REPLACEMENT COSTS WERE SIMILAR TOO. THERE WERE MANY COMMENTS FROM FORUM USERS TO AVOID BUYING A USED MINI COOPER WITH A CVT, "AVOID IT LIKE THE PLAGUE" WAS ONE COMMENT. MINI NO LONGER USES THIS TRANSMISSION. MAYBE THE FAILURES MADE THEM LOOK TO ANOTHER SOURCE, I DO NOT KNOW. I ALSO CONTACTED A PERSON WHO IS GATHERING NAMES, 50 SO FAR, TO FILE A CLASS ACTION LAWSUIT AGAINST MINI TO TRY AND RECOUP THE MONEY SPENT REPAIRING A FAULTY TRANSMISSION. THAT IS JUST 50 PEOPLE WHO KNEW HOW TO CONTACT HER TO BE ADDED TO THE LIST. AS OF RIGHT NOW THESE PEOPLE ARE STILL LOOKING FOR AN ATTORNEY TO REPRESENT THEM. THERE MUST BE MORE, AND 50 TRANSMISSIONS IS ALOT OF MONEY. IF A INVESTIGATION IS DONE BY THE NHTSA AND A RECALL IS INITIATED THEN MAYBE THESE PEOPLE CAN BE REIMBURSED BY MINI. I FIND IT UNUSUAL THAT A TRANSMISSION SHOULD FAIL IN A VEHICLE WITH 81,500 MILES AND MOST COMPLAINTS I HAVE READ HAVE A AVERAGE FAILURE MILEAGE AT 60,000. MINIS WARRANTY EXPIRES AT 50,000 MILES. THIS IS UNACCEPTABLE. THE MINI DEALER HAS MADE A EFFORT TO SHARE THE EXPENSE WITH ME AND IN GOOD FAITH WILL REPLACE THE TRANSMISSION FOR 1/2 PRICE. AS OF THIS WRITING I HAVE NOT MADE A DECISION YET. THE VEHICLE HAS A TRADE-IN VALUE OF $10,000, SO SPENDING ALMOST $4000.00 TO REPAIR A OBVIOUSLY DEFECTIVE PART IS CRAZY. *TR
AUTOMATIC TRANSMISSION (CVT) FAILED. IT WILL COST $8000 (MINI/BMW DEALER QUOTE) TO REPLACE. I NOTICED THERE WERE MANY COMPLAINTS OF THIS PROBLEM ON THE INTERNET MANY RECOMMENDED TO FILE A COMPLAINT ON THE NHTSA WEBSITE. *TR
I OWN A 2003 MINI COOPER WITH 67K MILES ( OUT OF WARRANTY). TWO WEEKS AGO WHILE DRIVING UP A HILL TO MY HOME, THE TRANSMISSION WOULD NOT GO INTO GEAR. I COULD BARELY MAKE IT UP THE HILL AND HAD TO CHANGE TO THE SLOW LANE AND PULL OFF THE ROAD. AFTER DOING MUCH SEARCHING ON THE INTERNET, I FOUND THAT MANY WERE HAVING THIS PRO…
Read full complaint
I OWN A 2003 MINI COOPER WITH 67K MILES ( OUT OF WARRANTY). TWO WEEKS AGO WHILE DRIVING UP A HILL TO MY HOME, THE TRANSMISSION WOULD NOT GO INTO GEAR. I COULD BARELY MAKE IT UP THE HILL AND HAD TO CHANGE TO THE SLOW LANE AND PULL OFF THE ROAD. AFTER DOING MUCH SEARCHING ON THE INTERNET, I FOUND THAT MANY WERE HAVING THIS PROBLEM. THIS IS A MAJOR DRIVE CHAIN COMPONENT THAT SHOULDN'T GO OUT AT 67K. THE CVT TRANSMISSION SEEMS TO BE FLAWED AND ACKNOWLEDGED BY THE MANUFACTURER AS THEY DO NOT PUT THESE TRANSMISSIONS INTO THE NEWER MODELS. ALSO IT SEEMS, EVEN OUT OF WARRANTY MINI'S GET TRANSMISSIONS REPLACED; WITH THE OWNER ONLY HAVING TO PAY FOR LABOR IF THE OWNER CAUSES A "STINK" OR ALLUDES TO MAKING PROBLEMS FOR MINI. IF THE MANUFACTURER REALLY BELIEVED THE CVT TRANSMISSION WERE NOT FAULTY, I BELIEVE THEY WOULD STICK TO THEIR POSITION WITH ALL CUSTOMERS, INSTEAD OF MAKING EXCEPTIONS. MINI SHOULD BE ORDERED TO RECALL CARS WITH THE CVT TRANSMISSION. *TR
PURCHASED 2003 MINI COOPER IN 3/03 AT MINI STERLING IN VA. MOVED TO PA, SERVICING CAR UNDER WARRANTY AT THE NEAREST DEALERSHIP, OTTO'S MINI IN WEST CHESTER (50 MI AWAY). MINOR ISSUES CORRECTED UNDER WARRANTY, WHICH EXPIRED IN LATE 2005. IN JULY 2007, AT 78,000 MILES, WHILE DRIVING ON LOCAL EXPRESSWAY CAR SUDDENLY LOST ABILITY TO…
Read full complaint
PURCHASED 2003 MINI COOPER IN 3/03 AT MINI STERLING IN VA. MOVED TO PA, SERVICING CAR UNDER WARRANTY AT THE NEAREST DEALERSHIP, OTTO'S MINI IN WEST CHESTER (50 MI AWAY). MINOR ISSUES CORRECTED UNDER WARRANTY, WHICH EXPIRED IN LATE 2005. IN JULY 2007, AT 78,000 MILES, WHILE DRIVING ON LOCAL EXPRESSWAY CAR SUDDENLY LOST ABILITY TO DRIVE IN GEAR AND I PULLED OVER (LUCKILY SAFE - TRAFFIC WAS MOVING AT 60-70 MPH). ENGINE RAN BUT CAR WOULD NOT GO INTO GEAR. ALL SIGNS POINTED TO MAJOR TRANSMISSION PROBLEM. CAR TOWED TO TRANSMISSION SHOP IN YORK (NEAREST RECOMMENDED SHOP) WHO CONFIRMED TRANSMISSION ISSUE. CALLED MINI OF TOWSON (NEAREST DEALER) FOR QUOTE ON REPLACING TRANSMISSION - IT WAS $7800! CAR WAS ONLY WORTH $12,000-$13,000 AT THAT TIME - REPAIR WAS OVER 50% OF CAR VALUE. LOCAL SHOP TRIED FIX IT WITH REBUILT TRANSMISSION. TURNED INTO 7 MONTH NIGHTMARE AS MULTIPLE REBUILT TRANSMISSIONS DIDN'T WORK DUE TO COMPUTER CODE ISSUES, SO CAR TOWED TO MINI OF TOWSON TWICE TO SEE IF THEY COULD CORRECT ISSUES, BUT EACH TIME DEALER ONLY OFFERED TO FIX WITH NEW TRANSMISSION FROM THEM AT $7800. TRIED TRADING CAR TO THEM FOR NEW MINI, BUT THEY ONLY OFFERED ME $4000 FOR THE CAR, SAYING THEIR COST TO FIX WAS STILL $6000. LOCAL SHOP FINALLY GAVE UP, REFUNDING MY DEPOSIT AND RETURNING CAR WITH REBUILT TRANSMISSION THAT WILL ONLY DRIVES IN LOW GEAR AT 20 MPH. NOW HAVE MINI IN MY GARAGE (WITH BALANCE ON CAR LOAN) THAT SHOULD BE WORTH $10,000 BUT IS UNUSABLE. MINI IS REFUSING TO DO ANYTHING ABOUT THIS DESIGN FLAW (NEW CARS HAVE DIFFERENT TRANSMISSION), WHICH IS UNSAFE AT ANY SPEED, AS THEY SAY. NETSCAPE SHOULD ORDER RECALL OF THESE CARS AND REPAIR AT MINE'S COST. I HAVE INFORMED MY CONGRESSMAN BROTHER ABOUT THIS ISSUE (HE SITS ON HOUSE TRANSPORTATION COMMITTEE) - HE IS AWAITING WORD ON HOW NETSCAPE AND MINI RESPOND TO MY COMPLAINT (OBVIOUSLY SHARED MY MANY OTHERS). THANK YOU. *TR
PURCHASED 2002 MINI COOPER IN 3/03 AT MINI STERLING IN VA. MOVED TO PA, SERVICING CAR UNDER WARRANTY AT THE NEAREST DEALERSHIP, OTTO'S MINI IN WEST CHESTER (50 MI AWAY). MINOR ISSUES CORRECTED UNDER WARRANTY, WHICH EXPIRED IN LATE 2005. IN JULY 2007, AT 78,000 MILES, WHILE DRIVING ON LOCAL EXPRESSWAY CAR SUDDENLY LOST ABILITY TO…
Read full complaint
PURCHASED 2002 MINI COOPER IN 3/03 AT MINI STERLING IN VA. MOVED TO PA, SERVICING CAR UNDER WARRANTY AT THE NEAREST DEALERSHIP, OTTO'S MINI IN WEST CHESTER (50 MI AWAY). MINOR ISSUES CORRECTED UNDER WARRANTY, WHICH EXPIRED IN LATE 2005. IN JULY 2007, AT 78,000 MILES, WHILE DRIVING ON LOCAL EXPRESSWAY CAR SUDDENLY LOST ABILITY TO DRIVE IN GEAR AND I PULLED OVER (LUCKILY SAFE - TRAFFIC WAS MOVING AT 60-70 MPH). ENGINE RAN BUT CAR WOULD NOT GO INTO GEAR. ALL SIGNS POINTED TO MAJOR TRANSMISSION PROBLEM. CAR TOWED TO TRANSMISSION SHOP IN YORK (NEAREST RECOMMENDED SHOP) WHO CONFIRMED TRANSMISSION ISSUE. CALLED MINI OF TOWSON (NEAREST DEALER) FOR QUOTE ON REPLACING TRANSMISSION - IT WAS $7800! CAR WAS ONLY WORTH $12,000-$13,000 AT THAT TIME - REPAIR WAS OVER 50% OF CAR VALUE. LOCAL SHOP TRIED FIX IT WITH REBUILT TRANSMISSION. TURNED INTO 7 MONTH NIGHTMARE AS MULTIPLE REBUILT TRANSMISSIONS DIDN'T WORK DUE TO COMPUTER CODE ISSUES, SO CAR TOWED TO MINI OF TOWSON TWICE TO SEE IF THEY COULD CORRECT ISSUES, BUT EACH TIME DEALER ONLY OFFERED TO FIX WITH NEW TRANSMISSION FROM THEM AT $7800. TRIED TRADING CAR TO THEM FOR NEW MINI, BUT THEY ONLY OFFERED ME $4000 FOR THE CAR, SAYING THEIR COST TO FIX WAS STILL $6000. LOCAL SHOP FINALLY GAVE UP, REFUNDING MY DEPOSIT AND RETURNING CAR WITH REBUILT TRANSMISSION THAT WILL ONLY DRIVES IN LOW GEAR AT 20 MPH. NOW HAVE MINI IN MY GARAGE (WITH BALANCE ON CAR LOAN) THAT SHOULD BE WORTH $10,000 BUT IS UNUSABLE. MINI IS REFUSING TO DO ANYTHING ABOUT THIS DESIGN FLAW (NEW CARS HAVE DIFFERENT TRANSMISSION), WHICH IS UNSAFE AT ANY SPEED, AS THEY SAY. NTSB SHOULD ORDER RECALL OF THESE CARS AND REPAIR AT MINI'S COST. I HAVE INFORMED MY CONGRESSMAN BROTHER ABOUT THIS ISSUE (HE SITS ON HOUSE TRANSPIRATION COMMITTEE) - HE IS AWAITING WORD ON HOW NTSB AND MINI RESPOND TO MY COMPLAINT (OBVIOUSLY SHARED MY MANY OTHERS). THANK YOU. *TR
2003 MINI COOPER, TRANSMISSION PROBLEMS. DEALERS STATES IT WOULD COST SEVEN THOUSAND DOLLARS TO REPLACE AND FIX. WITH THE CAR ONLY WORTH DOUBLE THAN THAT IT IS AN SHAMEFUL ACT ON MINI FOR DOING THIS TO CUSTOMERS. SOUNDS OF RATTLING AND TRANSMISSION SLIPPING, DEALER STATES IT IS A REGULAR PROBLEM WITH THE COOPER BUT THERE IS NO R…
Read full complaint
2003 MINI COOPER, TRANSMISSION PROBLEMS. DEALERS STATES IT WOULD COST SEVEN THOUSAND DOLLARS TO REPLACE AND FIX. WITH THE CAR ONLY WORTH DOUBLE THAN THAT IT IS AN SHAMEFUL ACT ON MINI FOR DOING THIS TO CUSTOMERS. SOUNDS OF RATTLING AND TRANSMISSION SLIPPING, DEALER STATES IT IS A REGULAR PROBLEM WITH THE COOPER BUT THERE IS NO RECALL OF ANY SORT. *TR
Official recalls
215V660000 · Steering:electric Power Assist System
Oct 15, 2015
BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 MINI Cooper and Cooper S vehicles and 2005 Cooper and Cooper S Convertible vehicles. The affected vehicles may experience temporary or permanent loss of the electro-hydraulic steering assistance.
Consequence & remedy
Consequence: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, potentially increasing the risk of a vehicle crash.
Remedy: MINI will notify owners, and dealers will inspect the electro-hydraulic power steering system, replacing the components and wiring, as necessary, free of charge. Interim notices were mailed to owners on December 10, 2015. Owners will receive a second notice when remedy parts become available. Owners may contact MINI customer service at 1-866-825-1525.
03V086000 · Suspension:rear:shock Absorber
Mar 10, 2003
ON CERTAIN VEHICLES, THE LOWER SCREW CONNECTION OF THE REAR STRUTS TO THE CHASSIS MAY FAIL. THE HEAD (TOP) OF THE SCREW SECURING THIS CONNECTION MAY BREAK. THE REMAINING PORTION OF THE SCREW WILL STILL HOLD THE STRUT IN PLACE.
Consequence & remedy
Consequence: IF LEFT UNATTENDED OVER A PERIOD OF TIME, AND DEPENDING ON DRIVING CONDITIONS, THE REMAINING PORTION OF THE SCREW MAY BREAK. IF IT BROKE, THE CHASSIS WOULD LEAN DIRECTLY ON THE TIRE DIMINISHING THE DRIVER'S ABILITY TO CONTROL THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE LOWER SCREW CONNECTION OF THE REAR STRUTS. OWNER NOTIFICATION BEGAN APRIL 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA11005 · Loss Of Power Steering Assist
Opened May 4, 2011 · Closed Jan 5, 2016
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Additional source detail variants (4)
Steering
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:electric Power Assist System
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:hydraulic Power Assist System
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
EA07011 · Engine Compartment Fire
Opened Aug 14, 2007 · Closed Aug 13, 2008
Status: closed (inferred from source dates) · Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:pump
THE OFFICE OF DEFECTS INVESTIGATION (ODI) ANALYZED CONSUMER COMPLAINTS TO BMW OF NORTH AMERICA, LLC (BMW)AND TO ODI THAT ALLEGED FAILURES OF THE ELECTROHYDRAULIC POWER STEERING (EHPS) USED IN MODEL YEAR 2002 THROUGH 2003 MINI COOPER VEHICLES.THE ANALYSIS DETERMINED THAT 43 OF THE 52 (83%) REPORTS WERE RELATED TO ALLEGATIONS OF POWER STEERING LOSS AND 9 (17%) WERE RELATED TO ALLEGATIONS OF ENGINE COMPARTMENT FIRES. ALTHOUGH SOME OF THE REPORTS ALLEGING FIRES NOTE SMALL FLAMES WERE VISIBLE IN THE ENGINE COMPARTMENT, ANALYSIS OF THE DAMAGE CAUSED BY THESE FAILURES INDICATES THAT EVEN THE MOST SEVERE INCIDENTS WERE LIMITED TO LOCALIZED THERMAL DAMAGE TO THE EHPS ELECTRICAL CONNECTIONS AND WIRING INSULATION.NONE OF THE COMPLAINTS ALLEGING LOSS OF POWER ASSISTED STEERING INDICATED THAT THE INCREASED EFFORT RESULTED IN A CRASH OR LOSS OF VEHICLE CONTROL. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (4)
Steering:electric Power Assist System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) ANALYZED CONSUMER COMPLAINTS TO BMW OF NORTH AMERICA, LLC (BMW)AND TO ODI THAT ALLEGED FAILURES OF THE ELECTROHYDRAULIC POWER STEERING (EHPS) USED IN MODEL YEAR 2002 THROUGH 2003 MINI COOPER VEHICLES.THE ANALYSIS DETERMINED THAT 43 OF THE 52 (83%) REPORTS WERE RELATED TO ALLEGATIONS OF POWER STEERING LOSS AND 9 (17%) WERE RELATED TO ALLEGATIONS OF ENGINE COMPARTMENT FIRES. ALTHOUGH SOME OF THE REPORTS ALLEGING FIRES NOTE SMALL FLAMES WERE VISIBLE IN THE ENGINE COMPARTMENT, ANALYSIS OF THE DAMAGE CAUSED BY THESE FAILURES INDICATES THAT EVEN THE MOST SEVERE INCIDENTS WERE LIMITED TO LOCALIZED THERMAL DAMAGE TO THE EHPS ELECTRICAL CONNECTIONS AND WIRING INSULATION.NONE OF THE COMPLAINTS ALLEGING LOSS OF POWER ASSISTED STEERING INDICATED THAT THE INCREASED EFFORT RESULTED IN A CRASH OR LOSS OF VEHICLE CONTROL. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Steering:hydraulic Power Assist:hose, Piping, And Connections
THE OFFICE OF DEFECTS INVESTIGATION (ODI) ANALYZED CONSUMER COMPLAINTS TO BMW OF NORTH AMERICA, LLC (BMW)AND TO ODI THAT ALLEGED FAILURES OF THE ELECTROHYDRAULIC POWER STEERING (EHPS) USED IN MODEL YEAR 2002 THROUGH 2003 MINI COOPER VEHICLES.THE ANALYSIS DETERMINED THAT 43 OF THE 52 (83%) REPORTS WERE RELATED TO ALLEGATIONS OF POWER STEERING LOSS AND 9 (17%) WERE RELATED TO ALLEGATIONS OF ENGINE COMPARTMENT FIRES. ALTHOUGH SOME OF THE REPORTS ALLEGING FIRES NOTE SMALL FLAMES WERE VISIBLE IN THE ENGINE COMPARTMENT, ANALYSIS OF THE DAMAGE CAUSED BY THESE FAILURES INDICATES THAT EVEN THE MOST SEVERE INCIDENTS WERE LIMITED TO LOCALIZED THERMAL DAMAGE TO THE EHPS ELECTRICAL CONNECTIONS AND WIRING INSULATION.NONE OF THE COMPLAINTS ALLEGING LOSS OF POWER ASSISTED STEERING INDICATED THAT THE INCREASED EFFORT RESULTED IN A CRASH OR LOSS OF VEHICLE CONTROL. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Steering:hydraulic Power Assist:pump
THE OFFICE OF DEFECTS INVESTIGATION (ODI) ANALYZED CONSUMER COMPLAINTS TO BMW OF NORTH AMERICA, LLC (BMW)AND TO ODI THAT ALLEGED FAILURES OF THE ELECTROHYDRAULIC POWER STEERING (EHPS) USED IN MODEL YEAR 2002 THROUGH 2003 MINI COOPER VEHICLES.THE ANALYSIS DETERMINED THAT 43 OF THE 52 (83%) REPORTS WERE RELATED TO ALLEGATIONS OF POWER STEERING LOSS AND 9 (17%) WERE RELATED TO ALLEGATIONS OF ENGINE COMPARTMENT FIRES. ALTHOUGH SOME OF THE REPORTS ALLEGING FIRES NOTE SMALL FLAMES WERE VISIBLE IN THE ENGINE COMPARTMENT, ANALYSIS OF THE DAMAGE CAUSED BY THESE FAILURES INDICATES THAT EVEN THE MOST SEVERE INCIDENTS WERE LIMITED TO LOCALIZED THERMAL DAMAGE TO THE EHPS ELECTRICAL CONNECTIONS AND WIRING INSULATION.NONE OF THE COMPLAINTS ALLEGING LOSS OF POWER ASSISTED STEERING INDICATED THAT THE INCREASED EFFORT RESULTED IN A CRASH OR LOSS OF VEHICLE CONTROL. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Steering:hydraulic Power Assist System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) ANALYZED CONSUMER COMPLAINTS TO BMW OF NORTH AMERICA, LLC (BMW)AND TO ODI THAT ALLEGED FAILURES OF THE ELECTROHYDRAULIC POWER STEERING (EHPS) USED IN MODEL YEAR 2002 THROUGH 2003 MINI COOPER VEHICLES.THE ANALYSIS DETERMINED THAT 43 OF THE 52 (83%) REPORTS WERE RELATED TO ALLEGATIONS OF POWER STEERING LOSS AND 9 (17%) WERE RELATED TO ALLEGATIONS OF ENGINE COMPARTMENT FIRES. ALTHOUGH SOME OF THE REPORTS ALLEGING FIRES NOTE SMALL FLAMES WERE VISIBLE IN THE ENGINE COMPARTMENT, ANALYSIS OF THE DAMAGE CAUSED BY THESE FAILURES INDICATES THAT EVEN THE MOST SEVERE INCIDENTS WERE LIMITED TO LOCALIZED THERMAL DAMAGE TO THE EHPS ELECTRICAL CONNECTIONS AND WIRING INSULATION.NONE OF THE COMPLAINTS ALLEGING LOSS OF POWER ASSISTED STEERING INDICATED THAT THE INCREASED EFFORT RESULTED IN A CRASH OR LOSS OF VEHICLE CONTROL. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE07022 · Engine Compartment Fire
Opened Apr 19, 2007 · Closed Aug 15, 2007
Status: closed (inferred from source dates) · Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:pump
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), BMW STATED THAT THE CAUSE OF THE ALLEGED DEFECT IS AN INSUFFICIENT SEAL OF THE GROUND CABLE OF THE POWER STEERING PUMP AT ITS ATTACHMENT TO THE CHASSIS.WATER INGRESS CAN OCCUR AND THE WATER CAN TRAVEL ALONG THE POWER STEERING PUMP POWER CABLE AND COME IN CONTACT WITH THE POWER STEERING PUMP POWER CABLE CONNECTOR.THE CONNECTOR CAN THEN CORRODE AND A HIGH THERMAL LOAD CONDITION CAN OCCUR.ACCORDING TO BMW, THIS ULTIMATELY COULD RESULT IN A LOCALIZED SMOLDERING CONDITION THAT DOES NOT PROPAGATE. TO CORRECT THE WATER INGRESS ISSUE, BMW IMPLEMENTED CHANGES TO THE WIRE ROUTING, THE POWER STEERINGPUMP CONNECTOR AND THE GROUND EYELET CONNECTION BETWEEN FEBRUARY AND JULY OF 2002. IN A REVIEW OF WARRANTY CLAIM DATA SENT BY BMW, 67 PERCENT OF THE VEHICLES NOTED IN WARRANTY CLAIMS HAD PRODUCTION DATES AFTER AUGUST 1, 2002. ADDITIONALLY, ODI NOTED EIGHT REPORTS OF CONSUMERS WITNESSING FLAMES COMING FROM THE ENGINE COMPARTMENT.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-011) TO FURTHER ASSESS THE SCOPE, FREQUENCY ANDPOTENTIAL SAFETY CONSEQUENCES ASSOCIATED WITH THE ALLEGED DEFECT.
Additional source detail variants (4)
Steering:electric Power Assist System
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), BMW STATED THAT THE CAUSE OF THE ALLEGED DEFECT IS AN INSUFFICIENT SEAL OF THE GROUND CABLE OF THE POWER STEERING PUMP AT ITS ATTACHMENT TO THE CHASSIS.WATER INGRESS CAN OCCUR AND THE WATER CAN TRAVEL ALONG THE POWER STEERING PUMP POWER CABLE AND COME IN CONTACT WITH THE POWER STEERING PUMP POWER CABLE CONNECTOR.THE CONNECTOR CAN THEN CORRODE AND A HIGH THERMAL LOAD CONDITION CAN OCCUR.ACCORDING TO BMW, THIS ULTIMATELY COULD RESULT IN A LOCALIZED SMOLDERING CONDITION THAT DOES NOT PROPAGATE. TO CORRECT THE WATER INGRESS ISSUE, BMW IMPLEMENTED CHANGES TO THE WIRE ROUTING, THE POWER STEERINGPUMP CONNECTOR AND THE GROUND EYELET CONNECTION BETWEEN FEBRUARY AND JULY OF 2002. IN A REVIEW OF WARRANTY CLAIM DATA SENT BY BMW, 67 PERCENT OF THE VEHICLES NOTED IN WARRANTY CLAIMS HAD PRODUCTION DATES AFTER AUGUST 1, 2002. ADDITIONALLY, ODI NOTED EIGHT REPORTS OF CONSUMERS WITNESSING FLAMES COMING FROM THE ENGINE COMPARTMENT.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-011) TO FURTHER ASSESS THE SCOPE, FREQUENCY ANDPOTENTIAL SAFETY CONSEQUENCES ASSOCIATED WITH THE ALLEGED DEFECT.
Steering:hydraulic Power Assist:hose, Piping, And Connections
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), BMW STATED THAT THE CAUSE OF THE ALLEGED DEFECT IS AN INSUFFICIENT SEAL OF THE GROUND CABLE OF THE POWER STEERING PUMP AT ITS ATTACHMENT TO THE CHASSIS.WATER INGRESS CAN OCCUR AND THE WATER CAN TRAVEL ALONG THE POWER STEERING PUMP POWER CABLE AND COME IN CONTACT WITH THE POWER STEERING PUMP POWER CABLE CONNECTOR.THE CONNECTOR CAN THEN CORRODE AND A HIGH THERMAL LOAD CONDITION CAN OCCUR.ACCORDING TO BMW, THIS ULTIMATELY COULD RESULT IN A LOCALIZED SMOLDERING CONDITION THAT DOES NOT PROPAGATE. TO CORRECT THE WATER INGRESS ISSUE, BMW IMPLEMENTED CHANGES TO THE WIRE ROUTING, THE POWER STEERINGPUMP CONNECTOR AND THE GROUND EYELET CONNECTION BETWEEN FEBRUARY AND JULY OF 2002. IN A REVIEW OF WARRANTY CLAIM DATA SENT BY BMW, 67 PERCENT OF THE VEHICLES NOTED IN WARRANTY CLAIMS HAD PRODUCTION DATES AFTER AUGUST 1, 2002. ADDITIONALLY, ODI NOTED EIGHT REPORTS OF CONSUMERS WITNESSING FLAMES COMING FROM THE ENGINE COMPARTMENT.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-011) TO FURTHER ASSESS THE SCOPE, FREQUENCY ANDPOTENTIAL SAFETY CONSEQUENCES ASSOCIATED WITH THE ALLEGED DEFECT.
Steering:hydraulic Power Assist:pump
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), BMW STATED THAT THE CAUSE OF THE ALLEGED DEFECT IS AN INSUFFICIENT SEAL OF THE GROUND CABLE OF THE POWER STEERING PUMP AT ITS ATTACHMENT TO THE CHASSIS.WATER INGRESS CAN OCCUR AND THE WATER CAN TRAVEL ALONG THE POWER STEERING PUMP POWER CABLE AND COME IN CONTACT WITH THE POWER STEERING PUMP POWER CABLE CONNECTOR.THE CONNECTOR CAN THEN CORRODE AND A HIGH THERMAL LOAD CONDITION CAN OCCUR.ACCORDING TO BMW, THIS ULTIMATELY COULD RESULT IN A LOCALIZED SMOLDERING CONDITION THAT DOES NOT PROPAGATE. TO CORRECT THE WATER INGRESS ISSUE, BMW IMPLEMENTED CHANGES TO THE WIRE ROUTING, THE POWER STEERINGPUMP CONNECTOR AND THE GROUND EYELET CONNECTION BETWEEN FEBRUARY AND JULY OF 2002. IN A REVIEW OF WARRANTY CLAIM DATA SENT BY BMW, 67 PERCENT OF THE VEHICLES NOTED IN WARRANTY CLAIMS HAD PRODUCTION DATES AFTER AUGUST 1, 2002. ADDITIONALLY, ODI NOTED EIGHT REPORTS OF CONSUMERS WITNESSING FLAMES COMING FROM THE ENGINE COMPARTMENT.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-011) TO FURTHER ASSESS THE SCOPE, FREQUENCY ANDPOTENTIAL SAFETY CONSEQUENCES ASSOCIATED WITH THE ALLEGED DEFECT.
Steering:hydraulic Power Assist System
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), BMW STATED THAT THE CAUSE OF THE ALLEGED DEFECT IS AN INSUFFICIENT SEAL OF THE GROUND CABLE OF THE POWER STEERING PUMP AT ITS ATTACHMENT TO THE CHASSIS.WATER INGRESS CAN OCCUR AND THE WATER CAN TRAVEL ALONG THE POWER STEERING PUMP POWER CABLE AND COME IN CONTACT WITH THE POWER STEERING PUMP POWER CABLE CONNECTOR.THE CONNECTOR CAN THEN CORRODE AND A HIGH THERMAL LOAD CONDITION CAN OCCUR.ACCORDING TO BMW, THIS ULTIMATELY COULD RESULT IN A LOCALIZED SMOLDERING CONDITION THAT DOES NOT PROPAGATE. TO CORRECT THE WATER INGRESS ISSUE, BMW IMPLEMENTED CHANGES TO THE WIRE ROUTING, THE POWER STEERINGPUMP CONNECTOR AND THE GROUND EYELET CONNECTION BETWEEN FEBRUARY AND JULY OF 2002. IN A REVIEW OF WARRANTY CLAIM DATA SENT BY BMW, 67 PERCENT OF THE VEHICLES NOTED IN WARRANTY CLAIMS HAD PRODUCTION DATES AFTER AUGUST 1, 2002. ADDITIONALLY, ODI NOTED EIGHT REPORTS OF CONSUMERS WITNESSING FLAMES COMING FROM THE ENGINE COMPARTMENT.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-011) TO FURTHER ASSESS THE SCOPE, FREQUENCY ANDPOTENTIAL SAFETY CONSEQUENCES ASSOCIATED WITH THE ALLEGED DEFECT.
PE05053 · Air Bag Warning Lamp Illumination
Opened Sep 27, 2005 · Closed Mar 1, 2006
Status: closed (inferred from source dates) · Air Bags; Air Bags:side/window
IN MARCH 2006, BMW REISSUED A SERVICE BULLETIN FIRST ISSUED IN SEPTEMBER 2003, TO MINI DEALERS REGARDING THE REPAIR PROCEDURE FOR IMPROPER WIRE CRIMPS IN APPROXIMATELY 31,500 MODEL YEAR 2002 AND 2003 MINI COOPER VEHICLES PRODUCED UP TO JANUARY 2003.THE NEW SERVICE BULLETIN STATES THAT THE WARRANTY COVERAGE FOR THE ISSUE (I.E., AIR BAG WARNING LAMP ILLUMINATION WITH FAULT CODE FOR HIGH RESISTANCE IN SIDE AIR BAG/SEAT BELT PRETENSIONER CIRCUIT) IS EXTENDED TO 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.BMW PLANS TO SEND LETTERS TO OWNERS DURING MARCH 2006.THE SUBJECT WIRE CRIMPS ARE LOCATED UNDER THE FRONT SEATS AND ARE PART OF THE MAIN WIRING HARNESS THAT INTERFACE WITH THE UNDER-SEAT WIRING HARNESS CONNECTORS FOR SIDE AIR BAG AND SEAT BELT PRETENSIONER MODULES.BMW STATED THAT, ALTHOUGH THE SUBJECT CRIMPS WERE IMPROPERLY MANUFACTURED, THE CRIMP CONNECTION IS STILL SUFFICIENT FOR THE RESTRAINT SYSTEM TO DEPLOY WHEN NEEDED.ACCORDING TO BMW, THE ELECTRICAL RESISTANCE LEVELS IN THE SUBJECT VEHICLES CAN EXCEED THE THRESHOLD THAT ILLUMINATES THE AIR BAG WARNING LAMP, BUT THEY DO NOT EXCEED A MUCH HIGHER LIMIT IN WHICH DEPLOYMENT OF THE RESTRAINTS MAY NO LONGER OCCUR.ODI BELIEVES THAT THERE IS LACK OF EVIDENCE AT THIS TIME TO CONCLUDE THAT THE RESTRAINT SYSTEMS MAY NOT DEPLOY WITH THE HIGH RESISTANCE CONDITION.THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Air Bags
IN MARCH 2006, BMW REISSUED A SERVICE BULLETIN FIRST ISSUED IN SEPTEMBER 2003, TO MINI DEALERS REGARDING THE REPAIR PROCEDURE FOR IMPROPER WIRE CRIMPS IN APPROXIMATELY 31,500 MODEL YEAR 2002 AND 2003 MINI COOPER VEHICLES PRODUCED UP TO JANUARY 2003.THE NEW SERVICE BULLETIN STATES THAT THE WARRANTY COVERAGE FOR THE ISSUE (I.E., AIR BAG WARNING LAMP ILLUMINATION WITH FAULT CODE FOR HIGH RESISTANCE IN SIDE AIR BAG/SEAT BELT PRETENSIONER CIRCUIT) IS EXTENDED TO 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.BMW PLANS TO SEND LETTERS TO OWNERS DURING MARCH 2006.THE SUBJECT WIRE CRIMPS ARE LOCATED UNDER THE FRONT SEATS AND ARE PART OF THE MAIN WIRING HARNESS THAT INTERFACE WITH THE UNDER-SEAT WIRING HARNESS CONNECTORS FOR SIDE AIR BAG AND SEAT BELT PRETENSIONER MODULES.BMW STATED THAT, ALTHOUGH THE SUBJECT CRIMPS WERE IMPROPERLY MANUFACTURED, THE CRIMP CONNECTION IS STILL SUFFICIENT FOR THE RESTRAINT SYSTEM TO DEPLOY WHEN NEEDED.ACCORDING TO BMW, THE ELECTRICAL RESISTANCE LEVELS IN THE SUBJECT VEHICLES CAN EXCEED THE THRESHOLD THAT ILLUMINATES THE AIR BAG WARNING LAMP, BUT THEY DO NOT EXCEED A MUCH HIGHER LIMIT IN WHICH DEPLOYMENT OF THE RESTRAINTS MAY NO LONGER OCCUR.ODI BELIEVES THAT THERE IS LACK OF EVIDENCE AT THIS TIME TO CONCLUDE THAT THE RESTRAINT SYSTEMS MAY NOT DEPLOY WITH THE HIGH RESISTANCE CONDITION.THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Air Bags:side/window
IN MARCH 2006, BMW REISSUED A SERVICE BULLETIN FIRST ISSUED IN SEPTEMBER 2003, TO MINI DEALERS REGARDING THE REPAIR PROCEDURE FOR IMPROPER WIRE CRIMPS IN APPROXIMATELY 31,500 MODEL YEAR 2002 AND 2003 MINI COOPER VEHICLES PRODUCED UP TO JANUARY 2003.THE NEW SERVICE BULLETIN STATES THAT THE WARRANTY COVERAGE FOR THE ISSUE (I.E., AIR BAG WARNING LAMP ILLUMINATION WITH FAULT CODE FOR HIGH RESISTANCE IN SIDE AIR BAG/SEAT BELT PRETENSIONER CIRCUIT) IS EXTENDED TO 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.BMW PLANS TO SEND LETTERS TO OWNERS DURING MARCH 2006.THE SUBJECT WIRE CRIMPS ARE LOCATED UNDER THE FRONT SEATS AND ARE PART OF THE MAIN WIRING HARNESS THAT INTERFACE WITH THE UNDER-SEAT WIRING HARNESS CONNECTORS FOR SIDE AIR BAG AND SEAT BELT PRETENSIONER MODULES.BMW STATED THAT, ALTHOUGH THE SUBJECT CRIMPS WERE IMPROPERLY MANUFACTURED, THE CRIMP CONNECTION IS STILL SUFFICIENT FOR THE RESTRAINT SYSTEM TO DEPLOY WHEN NEEDED.ACCORDING TO BMW, THE ELECTRICAL RESISTANCE LEVELS IN THE SUBJECT VEHICLES CAN EXCEED THE THRESHOLD THAT ILLUMINATES THE AIR BAG WARNING LAMP, BUT THEY DO NOT EXCEED A MUCH HIGHER LIMIT IN WHICH DEPLOYMENT OF THE RESTRAINTS MAY NO LONGER OCCUR.ODI BELIEVES THAT THERE IS LACK OF EVIDENCE AT THIS TIME TO CONCLUDE THAT THE RESTRAINT SYSTEMS MAY NOT DEPLOY WITH THE HIGH RESISTANCE CONDITION.THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
DP05006 · Air Bag Warning Lamp Illumination
Opened Sep 19, 2005 · Closed Oct 6, 2005
Status: closed (inferred from source dates) · Air Bags; Air Bags:side/window
ODI HAS GRANTED THE PETITION AND HAS OPENED A PRELIMINARY EVALUATION (PE05-053) ON ILLUMINATION OF AIR BAG WARNING LAMP ON MODEL YEAR 2002 AND 2003 MINI COOPER VEHICLES.
Additional source detail variants (2)
Air Bags
ODI HAS GRANTED THE PETITION AND HAS OPENED A PRELIMINARY EVALUATION (PE05-053) ON ILLUMINATION OF AIR BAG WARNING LAMP ON MODEL YEAR 2002 AND 2003 MINI COOPER VEHICLES.
Air Bags:side/window
ODI HAS GRANTED THE PETITION AND HAS OPENED A PRELIMINARY EVALUATION (PE05-053) ON ILLUMINATION OF AIR BAG WARNING LAMP ON MODEL YEAR 2002 AND 2003 MINI COOPER VEHICLES.