IllustrationWHILE IN MOTION, CAR BEGAN TO BECOME JERKY WHILE EXCELERATING, THAN THE TRANSMISSION DISINGAGED. NO GEAR WOULD WORK THEREAFTER.
2003 Mini Cooper
Owner reports · Recalls · Investigations
More warning signs than most Cooper years
Owner complaints for the 2003 Mini Cooper are substantially higher than the model-year median of 40.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cooper years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
200–25K
3125–50K
9050–75K
7475–100K
57100–150K
9150K+
281 reports with mileage · 39 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 159 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 89 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports27 fire reports3 injury reports
Power Train complaints
89 reportsWINDSHIELD CRACKED FROM THE BOTTOM WHERE IT MEETS THE HOOD OF THE CAR. DRIVER'S SIDE WINDOW DOES NOT GO DOWN. I ONLY HEAR A CLICKING SOUND. WATER PUMP, OIL PAN AND VALVE COVER GASKETS FAILED PREMATURELY. I CAN'T SHIFT THE CAR INTO FIRST GEAR WITHOUT MULTIPLE ATTEMPTS.
TL* THE CONTACT OWNS A 2003 MINI COOPER. WHILE DRIVING 70 MPH, THE VEHICLE STARTED LOSING POWER. THE ACCELERATOR PEDAL WAS BEING DEPRESSED WITH NO RESPONSE. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND WAS ABLE TO BE DRIVIN HOME AT A LOW RATE OF SPEED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE …
Read full complaint
TL* THE CONTACT OWNS A 2003 MINI COOPER. WHILE DRIVING 70 MPH, THE VEHICLE STARTED LOSING POWER. THE ACCELERATOR PEDAL WAS BEING DEPRESSED WITH NO RESPONSE. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND WAS ABLE TO BE DRIVIN HOME AT A LOW RATE OF SPEED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE REPAIRS WERE PERFORMED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 86,353. ...UPDATED 04/26/16 *BF UPDATED 12/11/2017*JS
THE CAR WOULD NOT EASILY SHIFT GEARS. WHEN I BROUGHT IT TO THE MINI COOPER DEALERSHIP, I WAS TOLD THAT ALL OF THE TRANSMISSION FLUID LEAKED OUT OF THE TRANSMISSION. THE TRANSMISSION IS "SEALED", SO THE TRANSMISSION FLUID CANNOT BE CHECKED OR CHANGED. I WAS TOLD THAT I NEEDED TO REPLACE THE TRANSMISSION AND CLUTCH. THE CAR SHOULD…
Read full complaint
THE CAR WOULD NOT EASILY SHIFT GEARS. WHEN I BROUGHT IT TO THE MINI COOPER DEALERSHIP, I WAS TOLD THAT ALL OF THE TRANSMISSION FLUID LEAKED OUT OF THE TRANSMISSION. THE TRANSMISSION IS "SEALED", SO THE TRANSMISSION FLUID CANNOT BE CHECKED OR CHANGED. I WAS TOLD THAT I NEEDED TO REPLACE THE TRANSMISSION AND CLUTCH. THE CAR SHOULD NOT HAVE A SEALED TRANSMISSION IF IT CAN DEVELOP A LEAK SO EASILY.
THE VEHICLE FOR MONTHS WOULD MAKE A SMALL JUMP FORWARD WHEN PUTTING IN REVERSE. THEN THE TRANSMISSION WOULD MAKE A GRINDING NOISE WHEN IN DRIVE. THE CAR WOULD FEEL SPONGY IN DRIVE WHEN FIRST STARTING OFF IN THE MORNING AND AT FULL STOPS.
TL* THE CONTACT OWNS A 2003 MINI COOPER. THE CONTACT STATED THAT THE GEAR SHIFTER FAILED TO MOVE WHEN ATTEMPTING TO OPERATE THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 158,000.
TRANSMISSION. *TR
TL* THE CONTACT OWNS A 2003 MINI COOPER. THE CONTACT STATED THAT THE TRANSMISSION WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ENTIRE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 59,000.
ON 08/13/2014, I WAS DRIVING MY 2003 MINI COOPER, CAME TO A STOP LIGHT AND WHEN THE LIGHT CHANGED, I WENT TO START OUT THRU THE INTERSECTION AND LOST ALL POWER-I MANAGED TO GET IT THRU ABOUT THE TIME THE LIGHT HAD TURNED RED, AGAIN! I COASTED TO THE CURB, PUT IT IN PARK, SAT THERE FOR A FEW MINUTES AND TRIED, AGAIN, TO TAKE OFF.…
Read full complaint
ON 08/13/2014, I WAS DRIVING MY 2003 MINI COOPER, CAME TO A STOP LIGHT AND WHEN THE LIGHT CHANGED, I WENT TO START OUT THRU THE INTERSECTION AND LOST ALL POWER-I MANAGED TO GET IT THRU ABOUT THE TIME THE LIGHT HAD TURNED RED, AGAIN! I COASTED TO THE CURB, PUT IT IN PARK, SAT THERE FOR A FEW MINUTES AND TRIED, AGAIN, TO TAKE OFF. IT SEEMED TO BE FINE, THIS TIME,( EXCEPT FOR SOME TAKE-OFF JERKING, AND RPM'S SPIKING).DROVE 42 MILES THEN CAME TO A ONE WAY STOP SIGN AT THE INTERSECTION OF US HWY 40 & US HWY 56, WHEN TRAFFIC CLEARED I WENT TO CROSS THE INTERSECTION AND MY CAR JERKED AND DIED!!! I HAD TO BE PUSHED OUT OF THE INTERSECTION WHILE CROSS TRAFFIC HAD TO STOP & WAIT ON ME! NO WARNING LIGHTS CAME ON, IN FACT, I QUESTIONED WHETHER OR NOT THEY EVEN WORKED. IT'S NOW AT THE DEALERSHIP, WHERE I PURCHASED IT, USED, ON 07/29/2014, GETTING DIAGNOSED. *TR
DRIVING IN 2ND GEAR (MANUAL TRANSMISSION) AND THE CAR BRAKES EVERYTHING LOCKED UP SKIDDING TO AN IMMEDIATE, VIOLENT STOP THAT SQUEALED THE TIRES AND MADE SMOKE, OIL EVERYWHERE ON THE ROAD, ENGINE STILL RUNNING FINE. SCARY, COULD NOT EVEN PUSH THE CAR OFF THE ROAD BECAUSE IT WAS STUCK IN GEAR. WARRANTY COMPANY TOWED IT TO A MINI …
Read full complaint
DRIVING IN 2ND GEAR (MANUAL TRANSMISSION) AND THE CAR BRAKES EVERYTHING LOCKED UP SKIDDING TO AN IMMEDIATE, VIOLENT STOP THAT SQUEALED THE TIRES AND MADE SMOKE, OIL EVERYWHERE ON THE ROAD, ENGINE STILL RUNNING FINE. SCARY, COULD NOT EVEN PUSH THE CAR OFF THE ROAD BECAUSE IT WAS STUCK IN GEAR. WARRANTY COMPANY TOWED IT TO A MINI DEALER IN VALENCIA, CA. TWO WEEKS LATER, THEY GRANTED WARRANTY WORK HOWEVER, THE PRICE TAG IS $4000!! WARRANTY ONLY COVERS $2000 SO I HAVE TO GET ANOTHER USED TRANSMISSION! I SEE WHERE THERE IS A RECALL ON ALL AUTOMATIC TRANSMISSIONS 2003-2007 BECAUSE OF A CLASS ACTION LAW SUIT AGAINST MINI COOPER. ISN'T IT POSSIBLE THE SAME THING WRONG WITH THE AUTOMATIC TRANSMISSION IS ALSO HAPPENING WITH THE MANUAL TRANSMISSIONS? I CAN'T AFFORD THIS EVEN WITH THE WARRANTY AND I CERTAINLY DON'T WANT TO RISK PUTTING ANOTHER FAULTY TRANSMISSION THAT LOCKS UP, WHAT IF I WAS DOING 65? I'D ROLL AND BE DEAD, THAT'S WHAT! THIS CAR IS UNSAFE AND I FEEL THE NEW, APPROVED TRANSMISSION IS THE ONLY ANSWER. THIS ISN'T ABOUT MONEY, IT'S ABOUT THE FACT THE CAR LOCKED UP WITH NO SIGN OR WARNING WHATSOEVER. THOUGH, IF THERE IS A RECALL I WOULD LIKE REIMBURSED FOR THE COSTS OR HOWEVER THAT WORKS, THANK YOU FOR YOUR TIME. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Official recalls
215V660000 · Steering:electric Power Assist System
Oct 15, 2015
BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 MINI Cooper and Cooper S vehicles and 2005 Cooper and Cooper S Convertible vehicles. The affected vehicles may experience temporary or permanent loss of the electro-hydraulic steering assistance.
Consequence & remedy
Consequence: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, potentially increasing the risk of a vehicle crash.
Remedy: MINI will notify owners, and dealers will inspect the electro-hydraulic power steering system, replacing the components and wiring, as necessary, free of charge. Interim notices were mailed to owners on December 10, 2015. Owners will receive a second notice when remedy parts become available. Owners may contact MINI customer service at 1-866-825-1525.
03V086000 · Suspension:rear:shock Absorber
Mar 10, 2003
ON CERTAIN VEHICLES, THE LOWER SCREW CONNECTION OF THE REAR STRUTS TO THE CHASSIS MAY FAIL. THE HEAD (TOP) OF THE SCREW SECURING THIS CONNECTION MAY BREAK. THE REMAINING PORTION OF THE SCREW WILL STILL HOLD THE STRUT IN PLACE.
Consequence & remedy
Consequence: IF LEFT UNATTENDED OVER A PERIOD OF TIME, AND DEPENDING ON DRIVING CONDITIONS, THE REMAINING PORTION OF THE SCREW MAY BREAK. IF IT BROKE, THE CHASSIS WOULD LEAN DIRECTLY ON THE TIRE DIMINISHING THE DRIVER'S ABILITY TO CONTROL THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE LOWER SCREW CONNECTION OF THE REAR STRUTS. OWNER NOTIFICATION BEGAN APRIL 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA11005 · Loss Of Power Steering Assist
Opened May 4, 2011 · Closed Jan 5, 2016
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Additional source detail variants (4)
Steering
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:electric Power Assist System
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:hydraulic Power Assist System
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
EA07011 · Engine Compartment Fire
Opened Aug 14, 2007 · Closed Aug 13, 2008
Status: closed (inferred from source dates) · Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:pump
THE OFFICE OF DEFECTS INVESTIGATION (ODI) ANALYZED CONSUMER COMPLAINTS TO BMW OF NORTH AMERICA, LLC (BMW)AND TO ODI THAT ALLEGED FAILURES OF THE ELECTROHYDRAULIC POWER STEERING (EHPS) USED IN MODEL YEAR 2002 THROUGH 2003 MINI COOPER VEHICLES.THE ANALYSIS DETERMINED THAT 43 OF THE 52 (83%) REPORTS WERE RELATED TO ALLEGATIONS OF POWER STEERING LOSS AND 9 (17%) WERE RELATED TO ALLEGATIONS OF ENGINE COMPARTMENT FIRES. ALTHOUGH SOME OF THE REPORTS ALLEGING FIRES NOTE SMALL FLAMES WERE VISIBLE IN THE ENGINE COMPARTMENT, ANALYSIS OF THE DAMAGE CAUSED BY THESE FAILURES INDICATES THAT EVEN THE MOST SEVERE INCIDENTS WERE LIMITED TO LOCALIZED THERMAL DAMAGE TO THE EHPS ELECTRICAL CONNECTIONS AND WIRING INSULATION.NONE OF THE COMPLAINTS ALLEGING LOSS OF POWER ASSISTED STEERING INDICATED THAT THE INCREASED EFFORT RESULTED IN A CRASH OR LOSS OF VEHICLE CONTROL. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (4)
Steering:electric Power Assist System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) ANALYZED CONSUMER COMPLAINTS TO BMW OF NORTH AMERICA, LLC (BMW)AND TO ODI THAT ALLEGED FAILURES OF THE ELECTROHYDRAULIC POWER STEERING (EHPS) USED IN MODEL YEAR 2002 THROUGH 2003 MINI COOPER VEHICLES.THE ANALYSIS DETERMINED THAT 43 OF THE 52 (83%) REPORTS WERE RELATED TO ALLEGATIONS OF POWER STEERING LOSS AND 9 (17%) WERE RELATED TO ALLEGATIONS OF ENGINE COMPARTMENT FIRES. ALTHOUGH SOME OF THE REPORTS ALLEGING FIRES NOTE SMALL FLAMES WERE VISIBLE IN THE ENGINE COMPARTMENT, ANALYSIS OF THE DAMAGE CAUSED BY THESE FAILURES INDICATES THAT EVEN THE MOST SEVERE INCIDENTS WERE LIMITED TO LOCALIZED THERMAL DAMAGE TO THE EHPS ELECTRICAL CONNECTIONS AND WIRING INSULATION.NONE OF THE COMPLAINTS ALLEGING LOSS OF POWER ASSISTED STEERING INDICATED THAT THE INCREASED EFFORT RESULTED IN A CRASH OR LOSS OF VEHICLE CONTROL. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Steering:hydraulic Power Assist:hose, Piping, And Connections
THE OFFICE OF DEFECTS INVESTIGATION (ODI) ANALYZED CONSUMER COMPLAINTS TO BMW OF NORTH AMERICA, LLC (BMW)AND TO ODI THAT ALLEGED FAILURES OF THE ELECTROHYDRAULIC POWER STEERING (EHPS) USED IN MODEL YEAR 2002 THROUGH 2003 MINI COOPER VEHICLES.THE ANALYSIS DETERMINED THAT 43 OF THE 52 (83%) REPORTS WERE RELATED TO ALLEGATIONS OF POWER STEERING LOSS AND 9 (17%) WERE RELATED TO ALLEGATIONS OF ENGINE COMPARTMENT FIRES. ALTHOUGH SOME OF THE REPORTS ALLEGING FIRES NOTE SMALL FLAMES WERE VISIBLE IN THE ENGINE COMPARTMENT, ANALYSIS OF THE DAMAGE CAUSED BY THESE FAILURES INDICATES THAT EVEN THE MOST SEVERE INCIDENTS WERE LIMITED TO LOCALIZED THERMAL DAMAGE TO THE EHPS ELECTRICAL CONNECTIONS AND WIRING INSULATION.NONE OF THE COMPLAINTS ALLEGING LOSS OF POWER ASSISTED STEERING INDICATED THAT THE INCREASED EFFORT RESULTED IN A CRASH OR LOSS OF VEHICLE CONTROL. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Steering:hydraulic Power Assist:pump
THE OFFICE OF DEFECTS INVESTIGATION (ODI) ANALYZED CONSUMER COMPLAINTS TO BMW OF NORTH AMERICA, LLC (BMW)AND TO ODI THAT ALLEGED FAILURES OF THE ELECTROHYDRAULIC POWER STEERING (EHPS) USED IN MODEL YEAR 2002 THROUGH 2003 MINI COOPER VEHICLES.THE ANALYSIS DETERMINED THAT 43 OF THE 52 (83%) REPORTS WERE RELATED TO ALLEGATIONS OF POWER STEERING LOSS AND 9 (17%) WERE RELATED TO ALLEGATIONS OF ENGINE COMPARTMENT FIRES. ALTHOUGH SOME OF THE REPORTS ALLEGING FIRES NOTE SMALL FLAMES WERE VISIBLE IN THE ENGINE COMPARTMENT, ANALYSIS OF THE DAMAGE CAUSED BY THESE FAILURES INDICATES THAT EVEN THE MOST SEVERE INCIDENTS WERE LIMITED TO LOCALIZED THERMAL DAMAGE TO THE EHPS ELECTRICAL CONNECTIONS AND WIRING INSULATION.NONE OF THE COMPLAINTS ALLEGING LOSS OF POWER ASSISTED STEERING INDICATED THAT THE INCREASED EFFORT RESULTED IN A CRASH OR LOSS OF VEHICLE CONTROL. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Steering:hydraulic Power Assist System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) ANALYZED CONSUMER COMPLAINTS TO BMW OF NORTH AMERICA, LLC (BMW)AND TO ODI THAT ALLEGED FAILURES OF THE ELECTROHYDRAULIC POWER STEERING (EHPS) USED IN MODEL YEAR 2002 THROUGH 2003 MINI COOPER VEHICLES.THE ANALYSIS DETERMINED THAT 43 OF THE 52 (83%) REPORTS WERE RELATED TO ALLEGATIONS OF POWER STEERING LOSS AND 9 (17%) WERE RELATED TO ALLEGATIONS OF ENGINE COMPARTMENT FIRES. ALTHOUGH SOME OF THE REPORTS ALLEGING FIRES NOTE SMALL FLAMES WERE VISIBLE IN THE ENGINE COMPARTMENT, ANALYSIS OF THE DAMAGE CAUSED BY THESE FAILURES INDICATES THAT EVEN THE MOST SEVERE INCIDENTS WERE LIMITED TO LOCALIZED THERMAL DAMAGE TO THE EHPS ELECTRICAL CONNECTIONS AND WIRING INSULATION.NONE OF THE COMPLAINTS ALLEGING LOSS OF POWER ASSISTED STEERING INDICATED THAT THE INCREASED EFFORT RESULTED IN A CRASH OR LOSS OF VEHICLE CONTROL. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE07022 · Engine Compartment Fire
Opened Apr 19, 2007 · Closed Aug 15, 2007
Status: closed (inferred from source dates) · Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:pump
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), BMW STATED THAT THE CAUSE OF THE ALLEGED DEFECT IS AN INSUFFICIENT SEAL OF THE GROUND CABLE OF THE POWER STEERING PUMP AT ITS ATTACHMENT TO THE CHASSIS.WATER INGRESS CAN OCCUR AND THE WATER CAN TRAVEL ALONG THE POWER STEERING PUMP POWER CABLE AND COME IN CONTACT WITH THE POWER STEERING PUMP POWER CABLE CONNECTOR.THE CONNECTOR CAN THEN CORRODE AND A HIGH THERMAL LOAD CONDITION CAN OCCUR.ACCORDING TO BMW, THIS ULTIMATELY COULD RESULT IN A LOCALIZED SMOLDERING CONDITION THAT DOES NOT PROPAGATE. TO CORRECT THE WATER INGRESS ISSUE, BMW IMPLEMENTED CHANGES TO THE WIRE ROUTING, THE POWER STEERINGPUMP CONNECTOR AND THE GROUND EYELET CONNECTION BETWEEN FEBRUARY AND JULY OF 2002. IN A REVIEW OF WARRANTY CLAIM DATA SENT BY BMW, 67 PERCENT OF THE VEHICLES NOTED IN WARRANTY CLAIMS HAD PRODUCTION DATES AFTER AUGUST 1, 2002. ADDITIONALLY, ODI NOTED EIGHT REPORTS OF CONSUMERS WITNESSING FLAMES COMING FROM THE ENGINE COMPARTMENT.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-011) TO FURTHER ASSESS THE SCOPE, FREQUENCY ANDPOTENTIAL SAFETY CONSEQUENCES ASSOCIATED WITH THE ALLEGED DEFECT.
Additional source detail variants (4)
Steering:electric Power Assist System
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), BMW STATED THAT THE CAUSE OF THE ALLEGED DEFECT IS AN INSUFFICIENT SEAL OF THE GROUND CABLE OF THE POWER STEERING PUMP AT ITS ATTACHMENT TO THE CHASSIS.WATER INGRESS CAN OCCUR AND THE WATER CAN TRAVEL ALONG THE POWER STEERING PUMP POWER CABLE AND COME IN CONTACT WITH THE POWER STEERING PUMP POWER CABLE CONNECTOR.THE CONNECTOR CAN THEN CORRODE AND A HIGH THERMAL LOAD CONDITION CAN OCCUR.ACCORDING TO BMW, THIS ULTIMATELY COULD RESULT IN A LOCALIZED SMOLDERING CONDITION THAT DOES NOT PROPAGATE. TO CORRECT THE WATER INGRESS ISSUE, BMW IMPLEMENTED CHANGES TO THE WIRE ROUTING, THE POWER STEERINGPUMP CONNECTOR AND THE GROUND EYELET CONNECTION BETWEEN FEBRUARY AND JULY OF 2002. IN A REVIEW OF WARRANTY CLAIM DATA SENT BY BMW, 67 PERCENT OF THE VEHICLES NOTED IN WARRANTY CLAIMS HAD PRODUCTION DATES AFTER AUGUST 1, 2002. ADDITIONALLY, ODI NOTED EIGHT REPORTS OF CONSUMERS WITNESSING FLAMES COMING FROM THE ENGINE COMPARTMENT.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-011) TO FURTHER ASSESS THE SCOPE, FREQUENCY ANDPOTENTIAL SAFETY CONSEQUENCES ASSOCIATED WITH THE ALLEGED DEFECT.
Steering:hydraulic Power Assist:hose, Piping, And Connections
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), BMW STATED THAT THE CAUSE OF THE ALLEGED DEFECT IS AN INSUFFICIENT SEAL OF THE GROUND CABLE OF THE POWER STEERING PUMP AT ITS ATTACHMENT TO THE CHASSIS.WATER INGRESS CAN OCCUR AND THE WATER CAN TRAVEL ALONG THE POWER STEERING PUMP POWER CABLE AND COME IN CONTACT WITH THE POWER STEERING PUMP POWER CABLE CONNECTOR.THE CONNECTOR CAN THEN CORRODE AND A HIGH THERMAL LOAD CONDITION CAN OCCUR.ACCORDING TO BMW, THIS ULTIMATELY COULD RESULT IN A LOCALIZED SMOLDERING CONDITION THAT DOES NOT PROPAGATE. TO CORRECT THE WATER INGRESS ISSUE, BMW IMPLEMENTED CHANGES TO THE WIRE ROUTING, THE POWER STEERINGPUMP CONNECTOR AND THE GROUND EYELET CONNECTION BETWEEN FEBRUARY AND JULY OF 2002. IN A REVIEW OF WARRANTY CLAIM DATA SENT BY BMW, 67 PERCENT OF THE VEHICLES NOTED IN WARRANTY CLAIMS HAD PRODUCTION DATES AFTER AUGUST 1, 2002. ADDITIONALLY, ODI NOTED EIGHT REPORTS OF CONSUMERS WITNESSING FLAMES COMING FROM THE ENGINE COMPARTMENT.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-011) TO FURTHER ASSESS THE SCOPE, FREQUENCY ANDPOTENTIAL SAFETY CONSEQUENCES ASSOCIATED WITH THE ALLEGED DEFECT.
Steering:hydraulic Power Assist:pump
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), BMW STATED THAT THE CAUSE OF THE ALLEGED DEFECT IS AN INSUFFICIENT SEAL OF THE GROUND CABLE OF THE POWER STEERING PUMP AT ITS ATTACHMENT TO THE CHASSIS.WATER INGRESS CAN OCCUR AND THE WATER CAN TRAVEL ALONG THE POWER STEERING PUMP POWER CABLE AND COME IN CONTACT WITH THE POWER STEERING PUMP POWER CABLE CONNECTOR.THE CONNECTOR CAN THEN CORRODE AND A HIGH THERMAL LOAD CONDITION CAN OCCUR.ACCORDING TO BMW, THIS ULTIMATELY COULD RESULT IN A LOCALIZED SMOLDERING CONDITION THAT DOES NOT PROPAGATE. TO CORRECT THE WATER INGRESS ISSUE, BMW IMPLEMENTED CHANGES TO THE WIRE ROUTING, THE POWER STEERINGPUMP CONNECTOR AND THE GROUND EYELET CONNECTION BETWEEN FEBRUARY AND JULY OF 2002. IN A REVIEW OF WARRANTY CLAIM DATA SENT BY BMW, 67 PERCENT OF THE VEHICLES NOTED IN WARRANTY CLAIMS HAD PRODUCTION DATES AFTER AUGUST 1, 2002. ADDITIONALLY, ODI NOTED EIGHT REPORTS OF CONSUMERS WITNESSING FLAMES COMING FROM THE ENGINE COMPARTMENT.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-011) TO FURTHER ASSESS THE SCOPE, FREQUENCY ANDPOTENTIAL SAFETY CONSEQUENCES ASSOCIATED WITH THE ALLEGED DEFECT.
Steering:hydraulic Power Assist System
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), BMW STATED THAT THE CAUSE OF THE ALLEGED DEFECT IS AN INSUFFICIENT SEAL OF THE GROUND CABLE OF THE POWER STEERING PUMP AT ITS ATTACHMENT TO THE CHASSIS.WATER INGRESS CAN OCCUR AND THE WATER CAN TRAVEL ALONG THE POWER STEERING PUMP POWER CABLE AND COME IN CONTACT WITH THE POWER STEERING PUMP POWER CABLE CONNECTOR.THE CONNECTOR CAN THEN CORRODE AND A HIGH THERMAL LOAD CONDITION CAN OCCUR.ACCORDING TO BMW, THIS ULTIMATELY COULD RESULT IN A LOCALIZED SMOLDERING CONDITION THAT DOES NOT PROPAGATE. TO CORRECT THE WATER INGRESS ISSUE, BMW IMPLEMENTED CHANGES TO THE WIRE ROUTING, THE POWER STEERINGPUMP CONNECTOR AND THE GROUND EYELET CONNECTION BETWEEN FEBRUARY AND JULY OF 2002. IN A REVIEW OF WARRANTY CLAIM DATA SENT BY BMW, 67 PERCENT OF THE VEHICLES NOTED IN WARRANTY CLAIMS HAD PRODUCTION DATES AFTER AUGUST 1, 2002. ADDITIONALLY, ODI NOTED EIGHT REPORTS OF CONSUMERS WITNESSING FLAMES COMING FROM THE ENGINE COMPARTMENT.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-011) TO FURTHER ASSESS THE SCOPE, FREQUENCY ANDPOTENTIAL SAFETY CONSEQUENCES ASSOCIATED WITH THE ALLEGED DEFECT.
PE05053 · Air Bag Warning Lamp Illumination
Opened Sep 27, 2005 · Closed Mar 1, 2006
Status: closed (inferred from source dates) · Air Bags; Air Bags:side/window
IN MARCH 2006, BMW REISSUED A SERVICE BULLETIN FIRST ISSUED IN SEPTEMBER 2003, TO MINI DEALERS REGARDING THE REPAIR PROCEDURE FOR IMPROPER WIRE CRIMPS IN APPROXIMATELY 31,500 MODEL YEAR 2002 AND 2003 MINI COOPER VEHICLES PRODUCED UP TO JANUARY 2003.THE NEW SERVICE BULLETIN STATES THAT THE WARRANTY COVERAGE FOR THE ISSUE (I.E., AIR BAG WARNING LAMP ILLUMINATION WITH FAULT CODE FOR HIGH RESISTANCE IN SIDE AIR BAG/SEAT BELT PRETENSIONER CIRCUIT) IS EXTENDED TO 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.BMW PLANS TO SEND LETTERS TO OWNERS DURING MARCH 2006.THE SUBJECT WIRE CRIMPS ARE LOCATED UNDER THE FRONT SEATS AND ARE PART OF THE MAIN WIRING HARNESS THAT INTERFACE WITH THE UNDER-SEAT WIRING HARNESS CONNECTORS FOR SIDE AIR BAG AND SEAT BELT PRETENSIONER MODULES.BMW STATED THAT, ALTHOUGH THE SUBJECT CRIMPS WERE IMPROPERLY MANUFACTURED, THE CRIMP CONNECTION IS STILL SUFFICIENT FOR THE RESTRAINT SYSTEM TO DEPLOY WHEN NEEDED.ACCORDING TO BMW, THE ELECTRICAL RESISTANCE LEVELS IN THE SUBJECT VEHICLES CAN EXCEED THE THRESHOLD THAT ILLUMINATES THE AIR BAG WARNING LAMP, BUT THEY DO NOT EXCEED A MUCH HIGHER LIMIT IN WHICH DEPLOYMENT OF THE RESTRAINTS MAY NO LONGER OCCUR.ODI BELIEVES THAT THERE IS LACK OF EVIDENCE AT THIS TIME TO CONCLUDE THAT THE RESTRAINT SYSTEMS MAY NOT DEPLOY WITH THE HIGH RESISTANCE CONDITION.THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Air Bags
IN MARCH 2006, BMW REISSUED A SERVICE BULLETIN FIRST ISSUED IN SEPTEMBER 2003, TO MINI DEALERS REGARDING THE REPAIR PROCEDURE FOR IMPROPER WIRE CRIMPS IN APPROXIMATELY 31,500 MODEL YEAR 2002 AND 2003 MINI COOPER VEHICLES PRODUCED UP TO JANUARY 2003.THE NEW SERVICE BULLETIN STATES THAT THE WARRANTY COVERAGE FOR THE ISSUE (I.E., AIR BAG WARNING LAMP ILLUMINATION WITH FAULT CODE FOR HIGH RESISTANCE IN SIDE AIR BAG/SEAT BELT PRETENSIONER CIRCUIT) IS EXTENDED TO 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.BMW PLANS TO SEND LETTERS TO OWNERS DURING MARCH 2006.THE SUBJECT WIRE CRIMPS ARE LOCATED UNDER THE FRONT SEATS AND ARE PART OF THE MAIN WIRING HARNESS THAT INTERFACE WITH THE UNDER-SEAT WIRING HARNESS CONNECTORS FOR SIDE AIR BAG AND SEAT BELT PRETENSIONER MODULES.BMW STATED THAT, ALTHOUGH THE SUBJECT CRIMPS WERE IMPROPERLY MANUFACTURED, THE CRIMP CONNECTION IS STILL SUFFICIENT FOR THE RESTRAINT SYSTEM TO DEPLOY WHEN NEEDED.ACCORDING TO BMW, THE ELECTRICAL RESISTANCE LEVELS IN THE SUBJECT VEHICLES CAN EXCEED THE THRESHOLD THAT ILLUMINATES THE AIR BAG WARNING LAMP, BUT THEY DO NOT EXCEED A MUCH HIGHER LIMIT IN WHICH DEPLOYMENT OF THE RESTRAINTS MAY NO LONGER OCCUR.ODI BELIEVES THAT THERE IS LACK OF EVIDENCE AT THIS TIME TO CONCLUDE THAT THE RESTRAINT SYSTEMS MAY NOT DEPLOY WITH THE HIGH RESISTANCE CONDITION.THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Air Bags:side/window
IN MARCH 2006, BMW REISSUED A SERVICE BULLETIN FIRST ISSUED IN SEPTEMBER 2003, TO MINI DEALERS REGARDING THE REPAIR PROCEDURE FOR IMPROPER WIRE CRIMPS IN APPROXIMATELY 31,500 MODEL YEAR 2002 AND 2003 MINI COOPER VEHICLES PRODUCED UP TO JANUARY 2003.THE NEW SERVICE BULLETIN STATES THAT THE WARRANTY COVERAGE FOR THE ISSUE (I.E., AIR BAG WARNING LAMP ILLUMINATION WITH FAULT CODE FOR HIGH RESISTANCE IN SIDE AIR BAG/SEAT BELT PRETENSIONER CIRCUIT) IS EXTENDED TO 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.BMW PLANS TO SEND LETTERS TO OWNERS DURING MARCH 2006.THE SUBJECT WIRE CRIMPS ARE LOCATED UNDER THE FRONT SEATS AND ARE PART OF THE MAIN WIRING HARNESS THAT INTERFACE WITH THE UNDER-SEAT WIRING HARNESS CONNECTORS FOR SIDE AIR BAG AND SEAT BELT PRETENSIONER MODULES.BMW STATED THAT, ALTHOUGH THE SUBJECT CRIMPS WERE IMPROPERLY MANUFACTURED, THE CRIMP CONNECTION IS STILL SUFFICIENT FOR THE RESTRAINT SYSTEM TO DEPLOY WHEN NEEDED.ACCORDING TO BMW, THE ELECTRICAL RESISTANCE LEVELS IN THE SUBJECT VEHICLES CAN EXCEED THE THRESHOLD THAT ILLUMINATES THE AIR BAG WARNING LAMP, BUT THEY DO NOT EXCEED A MUCH HIGHER LIMIT IN WHICH DEPLOYMENT OF THE RESTRAINTS MAY NO LONGER OCCUR.ODI BELIEVES THAT THERE IS LACK OF EVIDENCE AT THIS TIME TO CONCLUDE THAT THE RESTRAINT SYSTEMS MAY NOT DEPLOY WITH THE HIGH RESISTANCE CONDITION.THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
DP05006 · Air Bag Warning Lamp Illumination
Opened Sep 19, 2005 · Closed Oct 6, 2005
Status: closed (inferred from source dates) · Air Bags; Air Bags:side/window
ODI HAS GRANTED THE PETITION AND HAS OPENED A PRELIMINARY EVALUATION (PE05-053) ON ILLUMINATION OF AIR BAG WARNING LAMP ON MODEL YEAR 2002 AND 2003 MINI COOPER VEHICLES.
Additional source detail variants (2)
Air Bags
ODI HAS GRANTED THE PETITION AND HAS OPENED A PRELIMINARY EVALUATION (PE05-053) ON ILLUMINATION OF AIR BAG WARNING LAMP ON MODEL YEAR 2002 AND 2003 MINI COOPER VEHICLES.
Air Bags:side/window
ODI HAS GRANTED THE PETITION AND HAS OPENED A PRELIMINARY EVALUATION (PE05-053) ON ILLUMINATION OF AIR BAG WARNING LAMP ON MODEL YEAR 2002 AND 2003 MINI COOPER VEHICLES.