Illustration2005 MINI COOPER CONVERTIBLE AT FIRST INTERMITTENT POWER STEERING FAILURE AND NOW COMPLETE POWER STEERING FAILURE. THE FIRST TIME IT HAPPENED VERY SUDDENLY WHILE MAKING A LEFT TURN, I ALMOST RAN INTO ANOTHER CAR. NOW I AM NOT DRIVING THE CAR UNTIL I CAN AFFORD TO HAVE IT REPAIRED. *TR
2005 Mini Cooper Convertible
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cooper Convertible years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
50–25K
1525–50K
2950–75K
2175–100K
16100–150K
3150K+
89 reports with mileage · 7 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 75 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports5 fire reports3 injury reports
What owners actually said
96 reportsMINI COOPER , POWER STEERING FROZE UP AND CAME BACK WHILE DRIVING AT HIGHWAY SPEED. *TR
2005 MINI COOPER - SUDDEN LOSS OF STEERING ON INTERSTATE HIGHWAY AT 70 MPH. DEALER STATED POWER STEERING PUMP FAILURE & NOT UNCOMMON IN 5 YEAR OLD CAR. NOT COVERED UNDER WARRANTY. POWER STEERING PUMP REPLACED. *TR
LOSS OF POWER STEERING AND POWER BRAKES IN A 2005 MINI COOPER CONVERTIBLE. NO WARNING AND INTERMITTENT OCCURRENCE. SOMETIMES WOULD HAPPEN WHILE DRIVING AND SOME TIMES WOULD BE IMMEDIATELY AFTER TURNING CAR ON. TOOK CAR TO MECHANIC AND HE COULD NOT FIND CAUSE. NO COMPUTER DAMAGE, NO CODES PRESENT TO INDICATE THAT ANY THING UN…
Read full complaint
LOSS OF POWER STEERING AND POWER BRAKES IN A 2005 MINI COOPER CONVERTIBLE. NO WARNING AND INTERMITTENT OCCURRENCE. SOMETIMES WOULD HAPPEN WHILE DRIVING AND SOME TIMES WOULD BE IMMEDIATELY AFTER TURNING CAR ON. TOOK CAR TO MECHANIC AND HE COULD NOT FIND CAUSE. NO COMPUTER DAMAGE, NO CODES PRESENT TO INDICATE THAT ANY THING UNUSUAL HAD OCCURRED. I TRADED THE CAR IN FOR A DIFFERENT MAKER AND MODEL. *TR
I WAS ON MY REGULAR COMMUTE THROUGH CITY STREETS. AFTER ABOUT 10 MILES OF DRIVING I WAS GOING ABOUT 40MPH ON A FAIRLY STRAIGHT ROAD. ON THE NEXT LIGHT CURVE I NOTICED THE WHEEL WAS MORE DIFFICULT TO TURN. I SLOWED DOWN TO TURN INTO A SIDE ROAD AND THAT'S WHEN I REALIZED THE POWER STEERING MUST HAVE BEEN OUT. I CHECKED THE RESERV…
Read full complaint
I WAS ON MY REGULAR COMMUTE THROUGH CITY STREETS. AFTER ABOUT 10 MILES OF DRIVING I WAS GOING ABOUT 40MPH ON A FAIRLY STRAIGHT ROAD. ON THE NEXT LIGHT CURVE I NOTICED THE WHEEL WAS MORE DIFFICULT TO TURN. I SLOWED DOWN TO TURN INTO A SIDE ROAD AND THAT'S WHEN I REALIZED THE POWER STEERING MUST HAVE BEEN OUT. I CHECKED THE RESERVOIR AND IT WAS FULL. I CALLED THE DEALER AND THEY SAID THEY WERE AWARE OF MANY COMPLAINTS OF POWER STEERING GOING OUT. THEY ALSO MENTIONED THAT THERE IS NO RECALL FOR THE POWER STEERING. DEALER NOTIFIED ME THERE WOULD BE A $100 CHARGE FOR DIAGNOSTICS. IF ITS FOUND TO BE THE POWER STEERING FAN IT WOULD COST $300 PLUS LABOR. IF IT'S THE PUMP IT WOULD BE $800 PLUS LABOR. WARRANTY EXPIRED 5 MONTHS AGO. APPARENTLY MINI DOES NOT WANT TO HAVE TO PAY TO FIX A PROBLEM THAT NUMEROUS MINI OWNERS ARE HAVING. THIS IS A SAFETY ISSUE! HAVING THE POWER STEERING GO OUT MID-DRIVE CAN EASILY CAUSE AN ACCIDENT! *TR
2005 MINI COOPER CONVERTIBLE DOES NOT TURN OFF EVEN AFTER KEY IS REMOVED. SAFETY ISSUE POTENTIAL WITH THEIR DRIVE-BY-WIRE IGNITION? DEALER SAID IT IS CAUSED BY WIRE HARNESS AND/OR REAR TAIL LIGHT CONNECTION. CAR MAY BE UNSAFE? *TR
NOTHING SPECIFIC TO LEAD UP TO FAILURE POWER STEERING WILL INTERMITTENTLY FAIL, AND OCCASIONALLY BE RESTORED NOTHING HAS BEEN DONE TO CORRECT THE FAILURE. *TR
I WAS DRIVING ON THE HIGHWAY WHEN I NOTICED MY STEERING FELT "TIGHT". IT WAS DIFFICULT TO NAVIGATE A CURVE. I TRIED TO PULL INTO A REST AREA WHEN I REALIZED I HAD ALMOST NO STEERING ABILITY. I WAS ABLE TO TURN THE CAR BY USING BOTH HANDS. I ALMOST CRASHED ON THE RAMP. IT WAS A VERY SCARY EXPERIENCE. THE PROBLEM IS STILL THERE. …
Read full complaint
I WAS DRIVING ON THE HIGHWAY WHEN I NOTICED MY STEERING FELT "TIGHT". IT WAS DIFFICULT TO NAVIGATE A CURVE. I TRIED TO PULL INTO A REST AREA WHEN I REALIZED I HAD ALMOST NO STEERING ABILITY. I WAS ABLE TO TURN THE CAR BY USING BOTH HANDS. I ALMOST CRASHED ON THE RAMP. IT WAS A VERY SCARY EXPERIENCE. THE PROBLEM IS STILL THERE. I SPOKE WITH THE DEALER. IT IS MY POWER STEERING PUMP. IT IS A VERY EXPENSIVE REPAIR AND IT SEEMS THERE ARE LOTS OF COMPLAINTS. I AM VERY GLAD I DID NOT HAVE TO DO ANY EMERGENCY TURNS, I WOULD NOT HAVE BEEN ABLE TO STEER THE CAR. THIS COULD HAVE BEEN A DISASTER. *TR
HI, I'M WRITING TO REPORT THAT MY 2005 MINI COOPER, WITH LESS THAN 43K MILES IS IN NEED OF A THIRD TRANSMISSION. I NEARLY DID NOT MAKE IT HOME ONE EVENING BECAUSE THE JERKING MOTION THE CAR WAS MAKING AND BECAUSE THE ENGINE JUST FELT LIKE IT WAS GOING TO SHUT OFF. I NEARLY STALLED ON THE HIGHWAY, WHILE IN TRAFFIC. THE FIRST TR…
Read full complaint
HI, I'M WRITING TO REPORT THAT MY 2005 MINI COOPER, WITH LESS THAN 43K MILES IS IN NEED OF A THIRD TRANSMISSION. I NEARLY DID NOT MAKE IT HOME ONE EVENING BECAUSE THE JERKING MOTION THE CAR WAS MAKING AND BECAUSE THE ENGINE JUST FELT LIKE IT WAS GOING TO SHUT OFF. I NEARLY STALLED ON THE HIGHWAY, WHILE IN TRAFFIC. THE FIRST TRANSMISSION, WHILE UNDER WARRANTY WAS REPLACED IN NOVEMBER 2007 AT 28K MILES. ON 12/16/08, I HAD AN ACCIDENT WHERE THE TRANSMISSION PAN AMONG OTHER THINGS HAD TO BE REPLACED. IT WAS THE ONLY KNOWN DAMAGE CAUSED TO THE TRANSMISSION. THE AUTO BODY AND PAINT SHOP THAT I CONTRACTED WITH DID NOT KNOW HOW TO FILL THE TRANSMISSION FLUID AND THEREFORE THE CAR HAD TO BE TOWED THE LOCAL MINI COOPER DEALERSHIP. THEY PERFORMED THAT PIECE OF IT. NOW, THE DEALER IS TELLING ME I NEED A NEW TRANSMISSION AND THE CAR IS OUT OF WARRANTY. THE DEALERSHIP ALSO STATES THEY DON'T KNOW IF THE TRANSMISSION DAMAGE WAS A RESIDUAL OF THE ACCIDENT OR NOT AND THEREFORE, WERE TRYING TO OPEN UP THE OLD INSURANCE CLAIM FROM JANUARY 2009. HOWEVER, MY INSURANCE COMPANY DOES NOT WANT TO PAY FOR THE NEW TRANSMISSION BECAUSE THEY STATE THE REPAIRS FROM THE ACCIDENT $7,888.70, PLUS THE COST OF A NEW TRANSMISSION, AROUND 8K WILL BE MORE THAN THE VALUE OF THE CAR. SO, WHO SHOULD PAY FOR THIS NEW TRANSMISSION, THE DEALER, THE AUTO BODY SHOP (WHOM DID NO WORK ON THE TRANSMISSION, SEEMINGLY) OR ME? HOW DO I KNOW, THIS IS NOT JUST ANOTHER BAD TRANSMISSION? THERE IS NO WAY TO TELL ON A MINI COOPER (NO WAY TO CHECK) TRANSMISSION FLUID AND NO INDICATOR LIGHT CAME ON. *TR
2005 MINI COOPER POWER STEERING PUMP FAILURE, WHILE MAKING A TURN, WITHOUT NOTICE MY POWER STEERING PUMP FAILED MY VEHICLE HAS APROX. 80K MILES ON IT. MINI IS REMANUFACTUING THE PUMP WITH DESIGN IMPROVEMENTS THIS TELLS ME THEY KNOW SOMETHING IS WRONG WITH THE ORIGINAL PUMP, THEY SHOULD BE MADE TO REPAIR THE ORIGINAL PUMPS FEE OF…
Read full complaint
2005 MINI COOPER POWER STEERING PUMP FAILURE, WHILE MAKING A TURN, WITHOUT NOTICE MY POWER STEERING PUMP FAILED MY VEHICLE HAS APROX. 80K MILES ON IT. MINI IS REMANUFACTUING THE PUMP WITH DESIGN IMPROVEMENTS THIS TELLS ME THEY KNOW SOMETHING IS WRONG WITH THE ORIGINAL PUMP, THEY SHOULD BE MADE TO REPAIR THE ORIGINAL PUMPS FEE OF CHARGE NOT THE $800.00 THEY WANT JUST FOR THE PUMP. THIS IS NOT AN ISOLATED INCIDENT. *TR
Official recalls
115V205000 · Air Bags:frontal
Apr 6, 2015
BMW of North America, LLC (BMW) is recalling certain model year 2005-2006 MINI Cooper and Cooper S vehicles manufactured January 5, 2005, to November 28, 2006, and 2005-2008 MINI Cooper Convertible and Cooper S Convertible vehicles manufactured January 5, 2005, to July 31, 2008. Due to manufacturing, installation, and exposure issues, the front passenger seat occupant detection mat may not function properly and, as a result, the front passenger air bag may not deploy in a crash.
Consequence & remedy
Consequence: An improperly functioning mat may cause the passenger frontal air bag to be inactive when the seat is occupied, and in the event of a crash, the air bag will not deploy, increasing the passenger's risk of injury.
Remedy: MINI will notify owners, and dealers will replace the front passenger seat occupant detection mat, free of charge. The recall began on October 12, 2015. Owners may contact MINI customer service at 1-866-825-1525.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11005 · Loss Of Power Steering Assist
Opened May 4, 2011 · Closed Jan 5, 2016
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Additional source detail variants (4)
Steering
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:electric Power Assist System
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:hydraulic Power Assist System
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
PE10038 · Loss Of Power Steering Assist
Opened Sep 24, 2010 · Closed May 10, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Additional source detail variants (4)
Steering
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:electric Power Assist System
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:hydraulic Power Assist:pump
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:hydraulic Power Assist System
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).