2013 Mini Clubman

Vehicle: MINI Cooper Clubman (Model R55) VIN: [XXX] Recall: NHTSA 23V-337 Dealer: Flow MINI of Raleigh, NC 1. COMPONENT FAILED: The Junction Box Electronics (JBE) failed due to moisture/water intrusion, producing electrical fault codes across all core systems including airbags, brakes, and a JBE communication fault. The vehicle is located at Flow MINI of Raleigh and is available for inspection. 2. SAFETY RISK: Recall 23V-337 identifies that moisture intrusion into the JBE can lead to corrosion, short circuit, and in rare cases a thermal event (fire). My vehicle's carpet is wet, confirming active water intrusion into the footwell where the JBE is installed. Airbag and brake faults appear exclusively when it rains or when the vehicle is washed, directly and unambiguously linking all symptoms to water intrusion. The vehicle is currently unsafe to operate. 3. DEALER CONFIRMATION: Flow MINI of Raleigh confirmed moisture/water intrusion is causing the JBE faults — directly reproducing the failure during a dealer-performed wash. The dealer declined the recall repair solely because [XXX] is not listed among covered states. 4. MANUFACTURER RESPONSE: MINI USA denied coverage exclusively on the basis that North Carolina is not included in the recall's geographic region. The defect itself has not been disputed. 5. BASIS FOR COMPLAINT: The recall's geographic restriction was established based on road salt usage. North Carolina roads do receive road salt treatment during winter weather events. The recall documentation (RCRIT-23V337-7125.pdf, Page 4, Item 12) explicitly names the JBE as a covered component. I request that NHTSA: (1) treat this as urgent given confirmed airbag and brake faults, (2) review whether NC should be included in the recall's geographic scope, and (3) compel MINI USA to perform the recall repair on VIN [XXX] at no cost. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I HAVE A 2013 MINI CLUBMAN S WITH ONLY 8K MILES ON IT. AS I STARTED IT TODAY AND WAS DRIVING OUT OF MY GARAGE THE BRAKES WOULD NOT FUNCTION AS THE BRAKE PEDAL WAS VERY HARD, (LIKE STEPPING ON A BRICK) AND WAS UNABLE TO BRING THE CAR TO A STOP USING THE BRAKE PEDAL? LUCKILY I WAS ABLE TO STOP THE CAR WITH THE PARKING BRAKE LEVER BEFORE I HIT ANYTHING... (THANK GOD MY WIFE WASN'T DRIVING...) AS IT, OF COURSE IS STILL UNDER WARRANTY IT IS GOING INTO THE DEALER TOMORROW, BUT THEY CLAIM "THEY HAVE NEVER HERD OF THIS PROBLEM"? THIS WAS VERY FRIGHTENING AND AM NOW CONCERNED ABOUT A RECURRENCE OF THE BRAKES FAILING AGAIN AND CAUSING A SERIOUS ACCIDENT IF IT WERE TO REOCCUR ON THE HIGHWAY AND HIGHER SPEEDS... THE CAR, (BRAKES) WERE FUNCTIONING PROPERLY WHEN I PARKED THE CAR IN THE GARAGE THE NIGHT BEFORE... I'M CONFIDENT THE DEALER WILL CORRECT THE PROBLEM, BUT I'M VERY UNNERVED BY THE IMPLICATIONS OF THIS INCIDENT... *TR