NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
72 reportsClear category filter155,000 miles · Jan 9, 2008
Fuel System, Gasoline
TL*THE CONTACT OWNS A 1995 MERCURY VILLAGER. WHILE IDLING, THE CONTACT SMELLED FUEL IN THE PASSENGER COMPARTMENT COMING FROM THE FRONT VENTS. THE VEHICLE HAS NOT YET BEEN DIAGNOSED. THE CURRENT MILEAGE WAS 163,000 AND FAILURE MILEAGE WAS 155,000. UPDATED 02-14-08. *KB THE CONSUMER STATED A RECALL HAD BEEN ISSUED IN 2001, …
Read full complaint
TL*THE CONTACT OWNS A 1995 MERCURY VILLAGER. WHILE IDLING, THE CONTACT SMELLED FUEL IN THE PASSENGER COMPARTMENT COMING FROM THE FRONT VENTS. THE VEHICLE HAS NOT YET BEEN DIAGNOSED. THE CURRENT MILEAGE WAS 163,000 AND FAILURE MILEAGE WAS 155,000. UPDATED 02-14-08. *KB THE CONSUMER STATED A RECALL HAD BEEN ISSUED IN 2001, FOR THE SAME PROBLEM SHE EXPERIENCED, HOWEVER HER VEHICLE IDENTIFICATION NUMBER WAS NOT INCLUDED. UPDATED .
NHTSA ODI #10214287
43,441 miles · Aug 15, 2007
Fuel System, Gasoline
TL*THE CONTACT OWNS A 1995 MERCURY VILLAGER. IN FEBRUARY OF 2001, THE FUEL SYSTEM WAS REPLACED BECAUSE IT WAS LEAKING GASOLINE. ON AUGUST 8, 2007, SHE NOTICED FUEL LEAKING FROM HER VEHICLE WHILE PARKED IN THE DRIVEWAY. THE LEAKING CONTINUED UNTIL THE FUEL LEVEL WAS LOWER THAN THE FILLER TUBE. THE VEHICLE IS CURRENTLY AT THE …
Read full complaint
TL*THE CONTACT OWNS A 1995 MERCURY VILLAGER. IN FEBRUARY OF 2001, THE FUEL SYSTEM WAS REPLACED BECAUSE IT WAS LEAKING GASOLINE. ON AUGUST 8, 2007, SHE NOTICED FUEL LEAKING FROM HER VEHICLE WHILE PARKED IN THE DRIVEWAY. THE LEAKING CONTINUED UNTIL THE FUEL LEVEL WAS LOWER THAN THE FILLER TUBE. THE VEHICLE IS CURRENTLY AT THE DEALER AND THEY STATED THAT THE FUEL SYSTEM NEEDED TO BE REPLACED AGAIN. SAFETY RECALL NUMBER 00V419002 (FUEL SYSTEM: GASOLINE: STORAGE: TANK ASSEMBLY) DOES NOT APPLY TO THE VEHICLE. THE POWERTRAIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 87,829 AND FAILURE MILEAGE WAS 43,441.
NHTSA ODI #10199660
100,000 miles · Mar 1, 2006
Fuel System, Gasoline
DT*: THE CONTACT STATED THE SMELL OF GASOLINE IS OFTEN PRESENT INSIDE THE VEHICLE. THERE IS A NHTSA RECALL, # 00V419002, REGARDING THE FUEL TANK ASSEMBLY. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE VEHICLE WAS NOT TAKEN FOR INSPECTION OR REPAIR. …
Read full complaint
DT*: THE CONTACT STATED THE SMELL OF GASOLINE IS OFTEN PRESENT INSIDE THE VEHICLE. THERE IS A NHTSA RECALL, # 00V419002, REGARDING THE FUEL TANK ASSEMBLY. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE VEHICLE WAS NOT TAKEN FOR INSPECTION OR REPAIR.
NHTSA ODI #10151510
139,580 miles · Feb 28, 2006
Fuel System, Gasoline
DT*: THE CONTACT STATED THERE WAS AN ODOR OF GAS IN THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP, WHERE IT WAS DETERMINED THERE WERE CRACKS IN THE VENT HOSE. THERE IS A NHTSA RECALL, # 00V419002, REGARDING THE TANK ASSEMBLY. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER, IT IS NOT …
Read full complaint
DT*: THE CONTACT STATED THERE WAS AN ODOR OF GAS IN THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP, WHERE IT WAS DETERMINED THERE WERE CRACKS IN THE VENT HOSE. THERE IS A NHTSA RECALL, # 00V419002, REGARDING THE TANK ASSEMBLY. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER, IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN.
NHTSA ODI #10151457
Mileage unknown · Nov 23, 2005
Fuel System, Gasoline
STRONG SMELL OF GASOLINE IN PASSENGER COMPARTMENT. PROBLEM COMES AND GOES. MECHANICS DO NOT KNOW WHY. I CALLED THE DEALER BUT THEY (3037611560) STATED THAT MY VEHICLE'S VIN NUMBER WASN'T AMONG THOSE RECALLED FOR THE SAME PROBLEM. *JB
NHTSA ODI #10143540
96,000 miles · Sep 6, 2005
Fuel System, Gasoline
DT: CALLER SAID THERE IS A RECALL ON HER YEAR, MAKE, AND MODEL BUT NOT ON HER VEHICLE. THE RECALL #00V419002, FUEL TANK VENT HOSE LEAKAGE. DEALER HAS NOT BEEN CONTACTED YET. MANUFACTURER SAID HER VEHICLE IS NOT INCLUDED IN THE RECALL. CALLER HAS BEEN HAVING THIS PROBLEM FOR ABOUT A YEAR. SHE SAID IT IS GETTING WORSE. CALLER WAS…
Read full complaint
DT: CALLER SAID THERE IS A RECALL ON HER YEAR, MAKE, AND MODEL BUT NOT ON HER VEHICLE. THE RECALL #00V419002, FUEL TANK VENT HOSE LEAKAGE. DEALER HAS NOT BEEN CONTACTED YET. MANUFACTURER SAID HER VEHICLE IS NOT INCLUDED IN THE RECALL. CALLER HAS BEEN HAVING THIS PROBLEM FOR ABOUT A YEAR. SHE SAID IT IS GETTING WORSE. CALLER WAS NEVER CONTACTED ABOUT RECALL.*AK *JB
NHTSA ODI #10128862
Mileage unknown · Apr 11, 2004
Fuel System, Gasoline
I OWN A 1995 MERCURY VILLAGER. I PURCHASED THE VEHICLE FROM A USED CAR DEALER. SINCE I PURCHASED THIS VEHICLE THREE YEARS AGO, I HAVE HAD A RECURRENT PROBLEM WITH SMELLING GAS FUMES IN THE PASSENGER COMPARTMENT OF THE VAN. I HAVE TAKEN THE VAN TO A FORD DEALERSHIP, AN INDEPENDENT MECHANIC, A CHEVROLET DEALERSHIP, AND AN INDEP…
Read full complaint
I OWN A 1995 MERCURY VILLAGER. I PURCHASED THE VEHICLE FROM A USED CAR DEALER. SINCE I PURCHASED THIS VEHICLE THREE YEARS AGO, I HAVE HAD A RECURRENT PROBLEM WITH SMELLING GAS FUMES IN THE PASSENGER COMPARTMENT OF THE VAN. I HAVE TAKEN THE VAN TO A FORD DEALERSHIP, AN INDEPENDENT MECHANIC, A CHEVROLET DEALERSHIP, AND AN INDEPENDENT SERVICE STATION. NO ONE SEEMS TO BE ABLE TO LOCATE THE SOURCE OF THE GAS SMELL. I AM CONCERNED ABOUT MY SAFETY AND THE SAFETY OF MY CHILDREN. GAS FUMES ARE VOLATILE, AND IF THEY ARE STRONG ENOUGH FOR ME TO DETECT THE ODOR, THEN I FEEL THE VAN IS UNSAFE TO DRIVE. I HAVE TRIED SEVERAL TIMES TO HAVE THE PROBLEM REPAIRED, BUT NO ONE SEEMS ABLE TO DETECT THE SOURCE OF THE PROBLEM. I HAVE CONTACTED FORD MOTOR COMPANY DIRECTLY, BUT I RECEIVED VERY LITTLE INFORMATION FROM THEM. I HAVE READ SEVERAL COMPLAINTS ON THE INTERNET OF OTHER VEHICLE OWNERS WITH THE SAME PROBLEM. I HAVE READ WHERE OTHER VEHICLE OWNERS HAVE CONTACTED FORD MOTOR COMPANY REGARDING THIS PROBLEM. WHEN I CALLED FORD, THEY TOLD ME THEY HAD RECEIVED NO OTHER COMPLAINTS OF THIS TYPE. I FEEL THERE IS A PROBLEM THAT SHOULD BE INVESTIGATED. MY MAIN CONCERN IS THE SAFETY ISSUE OF DRIVING A DEFECTIVE VEHICLE. *JB
NHTSA ODI #10065936
147,000 miles · Feb 19, 2004
Fuel System, Gasoline
FUEL ODOR INSIDE PASSANGER COMPARTMENT DUE TO FUEL LINE LEAK ON FUEL INJECTOR RAIL SEVERE FIRE HAZARD BAD PLACEMENT OF RUBBER FUEL LINE.!!!!!
NHTSA ODI #10058446
Mileage unknown · Jan 15, 2004
Engine And Engine CoolingFuel System, GasolineStructure
SIDE SLIDING DOOR STICKS,SLIDING DOOR WINDOW DOESNT STAY SHUT,LOCKS WILL LOCK THEMSELVES ,BACK WIPER MALFUNCTIONS,GRINDING AND SQUEAKING FROM BRAKES,SMELL OF FUEL FROM PASSENGER SIDE AND PASSENGER P/W STICKS SOMETIMES
NHTSA ODI #10070535
88,740 miles · May 1, 2003
Fuel System, Gasoline
STRONG SMELL OF RAW FUEL IN PASSENGER COMPARTMENT WITH THE HEATER RUNNING IN COLD OR COOL WEATHER
NHTSA ODI #10016854
NHTSA investigations
6EA00014 · Fuel Tank Vent Hose Leakage
Opened May 22, 2000 · Closed Jan 4, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
PERIODIC EXPOSURE TO LIQUID GASOLINE MAY RESULT IN EXTRACTION OF ANTIDEGRADANTS FROM THE SUBJECT FUEL TANK VENT HOSE.HOSES WHICH HAVE SUFFERED LOSS OF ANTIDEGRADANTS CAN DEVELOP CRACKS IN AREAS OF HIGH STRAIN.FUEL MAY SPRAY OR DRIP FROM CRACKED VENT HOSES FOLLOWING TANK FILL.STARTING AT JOB#1 1998 MY (CALIFORNIA EMISSIONS VEHICLES) AND JOB#1 1999 MY (FEDERAL EMISSIONS VEHICLES), THE SUBJECT VENT HOSE COMPOSITION CHANGED FROM NITRILE RUBBER HOSES WITH CHLOROPRENE RUBBER COVERS (NBR/CR) TO FLUOROCARBON RUBBER HOSES WITH AN OUTER LAYER BLEND OF NBR/PVC.THE CHANGES WERE MADE TO IMPROVE HYDRACARBON RESISTANCE FOR COMPLAINCE WITH NEW EVAPORATIVE EMISSIONS REGULATIONS.THE MODIFIED HOSES ARE ALSO SIGNIFICANTLY MORE RESISTANT TO DEGRADATION AND CRACKING.IN A LETTER DATED JANUARY 2, 2001, FORD NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL CAMPAIGN TO REPLACE THE SUBJECT VENT HOSE IN AFFACTED VEHICLES.FORD WILL BEGIN NOTIFYING CUSTOMERS OF THE AFFECTED VEHICLES ON OR ABOUT THE WEEK OF FEBRUARY 12, 2001 TO RETURN THEIR VEHICLES TO DEALERS FOR REPLACEMENT OF THE FUEL TANK VENT HOSE WITH THE LATEST DESIGN LEVER PART.
SQ00008 · Unexpected Opening On Sliding Door
Opened May 12, 2000 · Closed Apr 1, 2002
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99077 · Fuel Tank Vent Hose Leakage
Opened Dec 28, 1999 · Closed May 22, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99015 · Fuel Rail Hose Fitting Leakage
Opened Jun 29, 1999 · Closed Apr 18, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE ENGINEERING ANALYSIS CLOSING REPORT COVERS 1993-1998 MERCURY VILLAGER AND NISSAN QUEST MINIVANS.THESE TWO MINIVANS SHARE A COMMON BODY PLATFORM AND POWER TRAIN.BASED ON THE LOW NUMBER OF REPORTED INCIDENTS AND THE ABSENCE OF A DEMONSTRABLE FAILURE TREND, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES IS NOT WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ENGINEERING CLOSING REPORT EA99-015 FOR DETAILS.
PE99013 · Fuel Rail Hose Fitting Leakage
Opened Feb 9, 1999 · Closed Jun 29, 1999
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
SINCE SEPTEMBER 1998, ODI HAS RECEIVED SEVEN COMPLAINTS OF FUEL ODOR OR LEAKAGE IN 1994 THROUGH 1995 MERCURY VILLAGER VEHICLES.FOUR OF THE LEAKS HAVE BEEN TRACED TO A SHORT SECTION OF HOSE THAT CONNECTS THE FUEL SUPPLY TUBE TO THE REAR OF THE FUEL RAIL.INFORMAITON CONTAINED IN THE REPORTS INDICATE THAT THE PROBLEM MAY BE DIFFICULT TO DIAGNOSE, WITH SEVERAL OWNERS ALLEGING MULTIPLE DEALER SERVICE REPAIRS.ADVANCED COMPRESSION SET IS EVIDENT IN A HOSE REMOVED FROM THE MOST RECENT COMPLAINT VEHICLE.
EA96005 · Battery Explosions
Opened May 30, 1996 · Closed May 29, 1997
Status: closed (inferred from source dates) · Electrical System
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED IN THE PUBLIC FILE.
Illustration