IllustrationCRANKSHAFT SNAPED OFF A GEAR IN TURNING BELT, CONTACTED AN INDEPENDENT MECHANIC, WHO SAID THAT THEY HAVE NEVER SEEN SOMETHING LIKE THIS. *AK
1995 Mercury Villager
Owner reports · Recalls · Investigations
More warning signs than most Villager years
Owner complaints for the 1995 Mercury Villager are substantially higher than the model-year median of 125.
About this comparison →How this year compares
Owner complaints by model year
Compare all Villager years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 44 of 367 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 72 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports7 fire reports19 injury reports
Engine And Engine Cooling complaints
95 reportsSTRONG FUEL SMELL INSIDE VEHICLE WHEN TURNING ON AIR CONDITIONER OR HEATER. TOOK VEHICLE TO DEALER 3 TIMES. REPLACED SOLENOID AND CANISTER. IT DID NOT REMEDY PROBLEM. *AK
CONSUMER STATES LEFT COIL SPRING FAILED, CONSUMER WAS ADVISED BY MECHANIC THAT MANUFACTURER SHOULD COVER SINCE COIL SPRING CONTAINED PREMATURE RUST ON THE SIDES, CONSUMER STATES LOWER FRONT BALL JOINT WAS ALSO REPLACED BECAUSE OF THE NOISE AND VIBRATION THAT WAS COMING FROM THE VEHICLE, AFTER LOWER FRONT BALL JOINT WAS REPLACED,…
Read full complaint
CONSUMER STATES LEFT COIL SPRING FAILED, CONSUMER WAS ADVISED BY MECHANIC THAT MANUFACTURER SHOULD COVER SINCE COIL SPRING CONTAINED PREMATURE RUST ON THE SIDES, CONSUMER STATES LOWER FRONT BALL JOINT WAS ALSO REPLACED BECAUSE OF THE NOISE AND VIBRATION THAT WAS COMING FROM THE VEHICLE, AFTER LOWER FRONT BALL JOINT WAS REPLACED, VEHICLE CONTINUED TO MAKE NOISE AND VIBRATE, CONSUMER WAS THEN ADVISED THE PROBLEM WAS WITH THE TIRES, DEALER THEN PERFORMED A WHEEL ALIGNMENT TO SEE IF VEHICLE WOULD STOP SHAKING, HOWEVER VEHICLE ONLY STOPPED SHAKING TEMPORARILY. *JB
ENGINE PISTON BEAT THE HEAD CAUSING COMPLETE ENGINE FAILURE WHILE DRIVING, CONSUMER IS UNABLE TO BUY NEW ENGINE FROM FORD AS THEY WILL CHARGE SURCHARGE. *MJS
HEAD GASKET WAS LEAKING FLUID. CONTACTED DEALER, DEALER NOTICED THAT HEAD GASKET NEEDED REPLACING. ALSO, A TSB WAS ISSUED FOR SAME TYPE OF PROBLEM. HOWEVER THIS VEHICLE WAS NOT INCLUDED. PLEASE PROVIDE ANY FURTHER DETAILS.*AK
HOW MANY CATALYTIC CONVERTERS ARE IN THIS VEHICLE? *AK
CONSUMER RECEIVED RECALL 00V419002/MANUFACTURER'S RECALL 00S59 FUEL TANK VENT HOSE. DEALER WILL NOT HAVE PART AVAILABLE FOR A FEW MONTHS. CONSUMER WAS HAVING A STRONG GAS ODOR ON INSIDE & OUTSIDE OF VEHICLE. SMELL WAS SO STRONG THAT WINDOWS COULD BE ROLLED DOWN IN SUMMER TIME. BATH AUTOMOTIVE GROUP IN BATH, NY. PHON…
Read full complaint
CONSUMER RECEIVED RECALL 00V419002/MANUFACTURER'S RECALL 00S59 FUEL TANK VENT HOSE. DEALER WILL NOT HAVE PART AVAILABLE FOR A FEW MONTHS. CONSUMER WAS HAVING A STRONG GAS ODOR ON INSIDE & OUTSIDE OF VEHICLE. SMELL WAS SO STRONG THAT WINDOWS COULD BE ROLLED DOWN IN SUMMER TIME. BATH AUTOMOTIVE GROUP IN BATH, NY. PHONE NUMBER 607-776-6000. *AK
RECALL 00V419002, CONTACTED DEALER WHO INFORMED CONSUMER THERE WERE NO PARTS AVAILABLE FROM FORD. NO DATE GIVEN WHEN PARTS WERE DUE AT DEALER. *AK
CONSUMER HAS TAKEN VEHICLE TO DEALER NUMEROUS TIMES FOR SMELLING GAS AT VENTS. DEALER HAS CHANGED HOSE AND TRIED OTHER REMEDIES, SMELL WAS OVERWHELMING INSIDE VEHICLE. COSUEMR RECEIVED A RECALL00V419002 /MANUFACTURER'S RECALL 00S59 ANDWILL TAKE IT TO DEALER TO SEE IF IT WILL REPAIR PROBLEM. CONSUMER PLEASE ADD VIN. *AK
CONSUMER RECEIVED RECALL 00V419002 FOR FUEL INE VENT HOSE IN BEGINNING OF FEBRUARY, 2001. HAS CONTACTED DEALER AND MADE APPOINTMENTS. WENT TO ACTON MERCURY DEALER ON ROUTE 2A IN ACTON ,MA TWICE,BUT WAS TOLD THERE WERE NO PARTS AVAILABLE TO PERFORM RECALL REPAIRS. IN MEANTIME RECALL WAS NOT BEING DONE IN TIMELY MANNER, AND …
Read full complaint
CONSUMER RECEIVED RECALL 00V419002 FOR FUEL INE VENT HOSE IN BEGINNING OF FEBRUARY, 2001. HAS CONTACTED DEALER AND MADE APPOINTMENTS. WENT TO ACTON MERCURY DEALER ON ROUTE 2A IN ACTON ,MA TWICE,BUT WAS TOLD THERE WERE NO PARTS AVAILABLE TO PERFORM RECALL REPAIRS. IN MEANTIME RECALL WAS NOT BEING DONE IN TIMELY MANNER, AND CONSUMER WAS DRIVING AN UNSAFE VEHICLE. *AK
Official recalls
300V419002 · Fuel System, Gasoline:storage:tank Assembly
Jan 2, 2001
VEHICLE DESCRIPTION: MINIVANS. THE FUEL TANK VENT HOSE ALLOWS AIR TO VENT FROM THE FUEL TANK DURING REFUELING. CRACKS HAVE DEVELOPED IN THE VENT HOSE. IF (1) THE FUEL TANK IS OVERFILLED, NOT ALLOWING EXCESS FUEL IN THE VENT HOSE TO FLOW BACK INTO THE TANK, (2) THE VEHICLE IS DRIVEN ONLY A SHORT DISTANCE AFTER REFUELING AND, (3) THERE IS SUBSEQUENTLY SIGNIFICANT HEATING OF THE FUEL TANK, THE FUEL IN THE TANK CAN EXPAND INTO THE VENT HOSE AND LEAK FUEL.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE VENT HOSE.
96V253003 · Exterior Lighting:tail Lights
Aug 17, 1998
THE REAR LAMP SOCKET MAY NOT ILLUMINATE BECAUSE THE METAL CAN IN THE LAMP SOCKET MOVES OR SEPARATES FROM THE PLASTIC SOCKET HOUSING.
Consequence & remedy
Consequence: THIS CAN RESULT IN MALFUNCTION OF THE STOP OR REAR RUNNING LAMPS. CENTER HIGH MOUNT STOP LAMP FUNCTION IS UNAFFECTED. REAR LAMP MALFUNCTION CAN RESULT IN FOLLOWING DRIVERS NOT BEING ALERTED TO THE SUBJECT VEHICLE'S PRESENCE OR INTENDED ACTIONS, PARTICULARLY IN THE CASE IN WHICH BOTH LAMPS HAVE MALFUNCTIONED.
Remedy: DEALERS WILL INSTALL A REVISED REAR LAMP SOCKET AND WIRING ASSEMBLIES.
96V089001 · Seats
Jun 3, 1996
AN OUT-OF-SPECIFICATION CONDITION IN THE SEAT CABLE ROLLER PULLEY ASSEMBLY CAN ALLOW THE CABLE THAT CONNECTS THE SEAT ADJUST LEVER TO THE LATCH TO BE PINCHED IN THE ROLLER ASSEMBLY.
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THIS CONDITION CAN PREVENT THE LATCH ON THE LEFT SIDE FROM FULLY ENGAGING THE SEAT RAIL. THIS DOES NOT COMPLY WITH THE REQUIREMENT OF FMVSS NO. 207, "SEATING SYSTEMS."
Remedy: DEALERS WILL REPLACE A COMPONENT IN THE THIRD ROW SLIDING BENCH SEAT LATCH ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA00014 · Fuel Tank Vent Hose Leakage
Opened May 22, 2000 · Closed Jan 4, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
PERIODIC EXPOSURE TO LIQUID GASOLINE MAY RESULT IN EXTRACTION OF ANTIDEGRADANTS FROM THE SUBJECT FUEL TANK VENT HOSE.HOSES WHICH HAVE SUFFERED LOSS OF ANTIDEGRADANTS CAN DEVELOP CRACKS IN AREAS OF HIGH STRAIN.FUEL MAY SPRAY OR DRIP FROM CRACKED VENT HOSES FOLLOWING TANK FILL.STARTING AT JOB#1 1998 MY (CALIFORNIA EMISSIONS VEHICLES) AND JOB#1 1999 MY (FEDERAL EMISSIONS VEHICLES), THE SUBJECT VENT HOSE COMPOSITION CHANGED FROM NITRILE RUBBER HOSES WITH CHLOROPRENE RUBBER COVERS (NBR/CR) TO FLUOROCARBON RUBBER HOSES WITH AN OUTER LAYER BLEND OF NBR/PVC.THE CHANGES WERE MADE TO IMPROVE HYDRACARBON RESISTANCE FOR COMPLAINCE WITH NEW EVAPORATIVE EMISSIONS REGULATIONS.THE MODIFIED HOSES ARE ALSO SIGNIFICANTLY MORE RESISTANT TO DEGRADATION AND CRACKING.IN A LETTER DATED JANUARY 2, 2001, FORD NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL CAMPAIGN TO REPLACE THE SUBJECT VENT HOSE IN AFFACTED VEHICLES.FORD WILL BEGIN NOTIFYING CUSTOMERS OF THE AFFECTED VEHICLES ON OR ABOUT THE WEEK OF FEBRUARY 12, 2001 TO RETURN THEIR VEHICLES TO DEALERS FOR REPLACEMENT OF THE FUEL TANK VENT HOSE WITH THE LATEST DESIGN LEVER PART.
SQ00008 · Unexpected Opening On Sliding Door
Opened May 12, 2000 · Closed Apr 1, 2002
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99077 · Fuel Tank Vent Hose Leakage
Opened Dec 28, 1999 · Closed May 22, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99015 · Fuel Rail Hose Fitting Leakage
Opened Jun 29, 1999 · Closed Apr 18, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE ENGINEERING ANALYSIS CLOSING REPORT COVERS 1993-1998 MERCURY VILLAGER AND NISSAN QUEST MINIVANS.THESE TWO MINIVANS SHARE A COMMON BODY PLATFORM AND POWER TRAIN.BASED ON THE LOW NUMBER OF REPORTED INCIDENTS AND THE ABSENCE OF A DEMONSTRABLE FAILURE TREND, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES IS NOT WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ENGINEERING CLOSING REPORT EA99-015 FOR DETAILS.
PE99013 · Fuel Rail Hose Fitting Leakage
Opened Feb 9, 1999 · Closed Jun 29, 1999
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
SINCE SEPTEMBER 1998, ODI HAS RECEIVED SEVEN COMPLAINTS OF FUEL ODOR OR LEAKAGE IN 1994 THROUGH 1995 MERCURY VILLAGER VEHICLES.FOUR OF THE LEAKS HAVE BEEN TRACED TO A SHORT SECTION OF HOSE THAT CONNECTS THE FUEL SUPPLY TUBE TO THE REAR OF THE FUEL RAIL.INFORMAITON CONTAINED IN THE REPORTS INDICATE THAT THE PROBLEM MAY BE DIFFICULT TO DIAGNOSE, WITH SEVERAL OWNERS ALLEGING MULTIPLE DEALER SERVICE REPAIRS.ADVANCED COMPRESSION SET IS EVIDENT IN A HOSE REMOVED FROM THE MOST RECENT COMPLAINT VEHICLE.
EA96005 · Battery Explosions
Opened May 30, 1996 · Closed May 29, 1997
Status: closed (inferred from source dates) · Electrical System
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED IN THE PUBLIC FILE.