IllustrationTL* THE CONTACT OWNS A 1994 MERCURY VILLAGER. THE CONTACT STATED THAT THE EXHAUST MANIFOLD BOLTS FRACTURED, CAUSING A LEAK OF EXHAUST FUMES INSIDE THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 170,000.
1994 Mercury Villager
Owner reports · Recalls · Investigations
More warning signs than most Villager years
Owner complaints for the 1994 Mercury Villager are substantially higher than the model-year median of 125.
About this comparison →How this year compares
Owner complaints by model year
Compare all Villager years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 22 of 253 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 91 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports6 fire reports4 injury reports
Engine And Engine Cooling complaints
91 reportsWHY WASN'T THE 94 VILLAGER EVER RECALLED FOR EXHAUST STUDS BREAKING OFF? THIS CAUSES EXHAUST GAS TO FILL THE PASSENGER COMPARTMENT. I STILL HAVE THE REAR MANIFOLD LEAKING. I MEASURED 300 PPM C.O. WHILE THE VAN WAS IDLING. I CAN'T AFFORD TO PAY HUNDREDS OF DOLLARS TO GET IT FIXED. *TR
MANIFOLD BOLT FAILURE ON A 1994 MERCURY VILLAGER. THIS HAS NOW OCCURRED TWICE. THE FIRST TIME IT WAS REPAIRED BY A NISAN DEALER. *JB
1) BACKED OUT OF DRIVEWAY AND WAS SITTING IDLING 2) ENGINE STOPPED, TRIED TO RESTART IT AND NOTHING WOULD HAPPEN. ENGINE WOULD TURN OVER BUT SOUNDED DIFFERENT 3) HAD VEHICLE TOWED TO MECHANIC'S GARAGE FOR EVALUATION. LEARNED THAT TIMING BELT HAD BROKEN BUT THE DAMAGE DONE TO CYLINDER HEADS IS THE ISSUE. *JB
CRANKSHAFT FAILED UNDER NORMAL DRIVING CONDITIONS. DEALER REPAIR COST WAS GOING TO BE $4200, ALTHOUGH THE VEHICLE WAS ONLY 3 MONTHS OUT OF WARRANTY WITH LESS THAN 25000 MILES, AND WAS WELL MAINTAINED, AND EVEN THOUGH THIS PROBLEM WAS WELL KNOWN WITH THIS ENGINE. NOTE THAT THIS HAPPENED 8 YEARS AGO, BUT I HAVE ALWAYS WANTED T…
Read full complaint
CRANKSHAFT FAILED UNDER NORMAL DRIVING CONDITIONS. DEALER REPAIR COST WAS GOING TO BE $4200, ALTHOUGH THE VEHICLE WAS ONLY 3 MONTHS OUT OF WARRANTY WITH LESS THAN 25000 MILES, AND WAS WELL MAINTAINED, AND EVEN THOUGH THIS PROBLEM WAS WELL KNOWN WITH THIS ENGINE. NOTE THAT THIS HAPPENED 8 YEARS AGO, BUT I HAVE ALWAYS WANTED TO FORMALLY DOCUMENT THE PROBLEM, AND JUST FOUND THE NHTSA COMPLAINT SITE.
MY 1994 MERCURY VILLAGER HAS 26 CYLINDER HEAD BOLTS, ONE OF WHICH APPARENTLY BROKE OFF SPONTANEOUSLY ACCORDING TO MY MECHANIC. AS A RESULT, THE BROKEN PIECE JAMMED THE CAMSHAFT, CAUSING IT TO FRACTURE NEAR THE END (WHERE THE PIN IS LOCATED). THE TIMING BELT REMAINED INTACT. COINCIDENATLY, THIS EVENT OCCURRED THREE DAYS AFT…
Read full complaint
MY 1994 MERCURY VILLAGER HAS 26 CYLINDER HEAD BOLTS, ONE OF WHICH APPARENTLY BROKE OFF SPONTANEOUSLY ACCORDING TO MY MECHANIC. AS A RESULT, THE BROKEN PIECE JAMMED THE CAMSHAFT, CAUSING IT TO FRACTURE NEAR THE END (WHERE THE PIN IS LOCATED). THE TIMING BELT REMAINED INTACT. COINCIDENATLY, THIS EVENT OCCURRED THREE DAYS AFTER THE VILLAGER WAS REPAIRED BY THE SAME MECHANIC FOR A FAILED TENSIONER THAT SNAPPED THE 5-MONTH-OLD TIMING BELT.*AK
PROBLEMS WITH BROKEN EXHAUST MANIFOLD BOLTS.*MR THE CONSUMER EXPRESSES HIS CONCERNS ABOUT HIS VEHICLE'S EXHAUST LEAKS AND BROKEN MANIFOLD BOLTS. THE DEALER DENIED ANY KNOWLEDGE OF THE PROBLEM EVEN THOUGH A SERVICE BULLETIN EXIST TO REPLACE THE OLD BOLTS WITH A STRONGER NEW BOLT. *NM
PROBLEMS WITH THE EXHAUST MANIFOLD BOLTS ON VEHICLE. *MR THE EXHAUST CYLINDER HEAD DEVELOPED A LEAK THAT BEGAN WHEN THREE OF THE SIX MANIFOLD BOLTS BROKE OFF LEAVING THE EXHAUST SYSTEM ONLY PARTLY ATTACHED TO THE ENGINE. (TWO MORE OF THE MANIFOLD BOLTS HAVE BROKEN OFF) THE CONSUMER REQUESTED REIMBURSEMENT. *SC *JB
1994 MERCURY VILLAGER EXHAUST MANIFOLD BOLTS FAILED AND CAUSED EXHAUST LEAK AND WARPING OF EXHAUST MANIFOLD. THIS IS A WIDESPREAD PROBLEM, AND FORD, AND NISSAN (QUEST) ARE NOT HONORING THIS DEFECT. THEY OFFER A DIFFERENT BOLT REPLACEMENT, INDICATING A DESIGN DEFECT. *LA
HAVING PROBLEM WITH THE BACK HEATER NOT WORKING AT ALL. TRANSMISSION HAS A SLOW SHIFT AND WILL SHIFT HARD WHEN DOWN SHIFTING, STERRING WHEEL GET HARD WHEN TEMP. ARE IN THE TEEN,S. CLUCK NOISES WHEN HITTING LIGHT BUMPS. BRAKES GRIND WHEN BRAKES ARE COLD. RADIO WILL LOOSE MEMORY. HEATER SWITCH WHEN ONE 1, MAKES A TICKING NOISE. SL…
Read full complaint
HAVING PROBLEM WITH THE BACK HEATER NOT WORKING AT ALL. TRANSMISSION HAS A SLOW SHIFT AND WILL SHIFT HARD WHEN DOWN SHIFTING, STERRING WHEEL GET HARD WHEN TEMP. ARE IN THE TEEN,S. CLUCK NOISES WHEN HITTING LIGHT BUMPS. BRAKES GRIND WHEN BRAKES ARE COLD. RADIO WILL LOOSE MEMORY. HEATER SWITCH WHEN ONE 1, MAKES A TICKING NOISE. SLIDING DOOR GETS HARD TO CLOSE. GAS TANK, HAVE TO TURN CAP SLOWLY SO GAS AIR WILL LEAK OUT. CHECK ENGINE LIGHT APPEARS THEN GOES OUT.
Official recalls
300V419002 · Fuel System, Gasoline:storage:tank Assembly
Jan 2, 2001
VEHICLE DESCRIPTION: MINIVANS. THE FUEL TANK VENT HOSE ALLOWS AIR TO VENT FROM THE FUEL TANK DURING REFUELING. CRACKS HAVE DEVELOPED IN THE VENT HOSE. IF (1) THE FUEL TANK IS OVERFILLED, NOT ALLOWING EXCESS FUEL IN THE VENT HOSE TO FLOW BACK INTO THE TANK, (2) THE VEHICLE IS DRIVEN ONLY A SHORT DISTANCE AFTER REFUELING AND, (3) THERE IS SUBSEQUENTLY SIGNIFICANT HEATING OF THE FUEL TANK, THE FUEL IN THE TANK CAN EXPAND INTO THE VENT HOSE AND LEAK FUEL.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE VENT HOSE.
96V253003 · Exterior Lighting:tail Lights
Aug 17, 1998
THE REAR LAMP SOCKET MAY NOT ILLUMINATE BECAUSE THE METAL CAN IN THE LAMP SOCKET MOVES OR SEPARATES FROM THE PLASTIC SOCKET HOUSING.
Consequence & remedy
Consequence: THIS CAN RESULT IN MALFUNCTION OF THE STOP OR REAR RUNNING LAMPS. CENTER HIGH MOUNT STOP LAMP FUNCTION IS UNAFFECTED. REAR LAMP MALFUNCTION CAN RESULT IN FOLLOWING DRIVERS NOT BEING ALERTED TO THE SUBJECT VEHICLE'S PRESENCE OR INTENDED ACTIONS, PARTICULARLY IN THE CASE IN WHICH BOTH LAMPS HAVE MALFUNCTIONED.
Remedy: DEALERS WILL INSTALL A REVISED REAR LAMP SOCKET AND WIRING ASSEMBLIES.
94V142000 · Visibility:windshield
Aug 1, 1994
THE WINDSHIELDS WERE MARKED WITH A "PROTOTYPE" DESIGNATION AND NOT MARKED AS REQUIRED BY FMVSS NO. 205, "GLAZING MATERIALS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: INCORRECT LABELING OF WINDSHIELD MAY CAUSE CONCERN OR CONFUSION ABOUT THE PROTOTYPE DESIGNATION.
Remedy: DEALERS WILL REPLACE THE WINDSHIELDS ON THE AFFECTED VANS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA00014 · Fuel Tank Vent Hose Leakage
Opened May 22, 2000 · Closed Jan 4, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
PERIODIC EXPOSURE TO LIQUID GASOLINE MAY RESULT IN EXTRACTION OF ANTIDEGRADANTS FROM THE SUBJECT FUEL TANK VENT HOSE.HOSES WHICH HAVE SUFFERED LOSS OF ANTIDEGRADANTS CAN DEVELOP CRACKS IN AREAS OF HIGH STRAIN.FUEL MAY SPRAY OR DRIP FROM CRACKED VENT HOSES FOLLOWING TANK FILL.STARTING AT JOB#1 1998 MY (CALIFORNIA EMISSIONS VEHICLES) AND JOB#1 1999 MY (FEDERAL EMISSIONS VEHICLES), THE SUBJECT VENT HOSE COMPOSITION CHANGED FROM NITRILE RUBBER HOSES WITH CHLOROPRENE RUBBER COVERS (NBR/CR) TO FLUOROCARBON RUBBER HOSES WITH AN OUTER LAYER BLEND OF NBR/PVC.THE CHANGES WERE MADE TO IMPROVE HYDRACARBON RESISTANCE FOR COMPLAINCE WITH NEW EVAPORATIVE EMISSIONS REGULATIONS.THE MODIFIED HOSES ARE ALSO SIGNIFICANTLY MORE RESISTANT TO DEGRADATION AND CRACKING.IN A LETTER DATED JANUARY 2, 2001, FORD NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL CAMPAIGN TO REPLACE THE SUBJECT VENT HOSE IN AFFACTED VEHICLES.FORD WILL BEGIN NOTIFYING CUSTOMERS OF THE AFFECTED VEHICLES ON OR ABOUT THE WEEK OF FEBRUARY 12, 2001 TO RETURN THEIR VEHICLES TO DEALERS FOR REPLACEMENT OF THE FUEL TANK VENT HOSE WITH THE LATEST DESIGN LEVER PART.
PE99077 · Fuel Tank Vent Hose Leakage
Opened Dec 28, 1999 · Closed May 22, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99015 · Fuel Rail Hose Fitting Leakage
Opened Jun 29, 1999 · Closed Apr 18, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE ENGINEERING ANALYSIS CLOSING REPORT COVERS 1993-1998 MERCURY VILLAGER AND NISSAN QUEST MINIVANS.THESE TWO MINIVANS SHARE A COMMON BODY PLATFORM AND POWER TRAIN.BASED ON THE LOW NUMBER OF REPORTED INCIDENTS AND THE ABSENCE OF A DEMONSTRABLE FAILURE TREND, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES IS NOT WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ENGINEERING CLOSING REPORT EA99-015 FOR DETAILS.
PE99013 · Fuel Rail Hose Fitting Leakage
Opened Feb 9, 1999 · Closed Jun 29, 1999
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
SINCE SEPTEMBER 1998, ODI HAS RECEIVED SEVEN COMPLAINTS OF FUEL ODOR OR LEAKAGE IN 1994 THROUGH 1995 MERCURY VILLAGER VEHICLES.FOUR OF THE LEAKS HAVE BEEN TRACED TO A SHORT SECTION OF HOSE THAT CONNECTS THE FUEL SUPPLY TUBE TO THE REAR OF THE FUEL RAIL.INFORMAITON CONTAINED IN THE REPORTS INDICATE THAT THE PROBLEM MAY BE DIFFICULT TO DIAGNOSE, WITH SEVERAL OWNERS ALLEGING MULTIPLE DEALER SERVICE REPAIRS.ADVANCED COMPRESSION SET IS EVIDENT IN A HOSE REMOVED FROM THE MOST RECENT COMPLAINT VEHICLE.
EA96005 · Battery Explosions
Opened May 30, 1996 · Closed May 29, 1997
Status: closed (inferred from source dates) · Electrical System
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED IN THE PUBLIC FILE.