MOUNTAINEER PREMIER AWD WITH JUST OVER 150,000 MILES. WENT TO RAISE REAR (THIRD ROW) ELECTRICAL SEAT ON DRIVER/LEFT SIDE. MAKES A SLIGHT CLICKING SOUND AND WILL RAISE UP ABOUT 1 INCH, THEN JUST STOPS GOING UP WITH SOUNDS STILL HEARD. FURTHER INVESTIGATION SHOWS A MOTOR IN THE CENTER ALONG A GEAR SHAFT WHICH MUST RAISE THE SEAT.…
Read full complaint
MOUNTAINEER PREMIER AWD WITH JUST OVER 150,000 MILES. WENT TO RAISE REAR (THIRD ROW) ELECTRICAL SEAT ON DRIVER/LEFT SIDE. MAKES A SLIGHT CLICKING SOUND AND WILL RAISE UP ABOUT 1 INCH, THEN JUST STOPS GOING UP WITH SOUNDS STILL HEARD. FURTHER INVESTIGATION SHOWS A MOTOR IN THE CENTER ALONG A GEAR SHAFT WHICH MUST RAISE THE SEAT. THE MOTOR IS WHIRRING LIKE IT IS FUNCTIONING BUT THE SHAFT DOESN'T MOVE. THERE IS NO WAY TO MANUALLY FULLY RAISE THE SEAT.
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
Consequence & remedy
Consequence: AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2006 Mercury Mountaineer Problems, Complaints & Recalls | Skip That Year
Illustration