NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
28 reportsClear category filter153,000 miles · Mar 16, 2016
Vehicle Speed Control
I WAS ON MY WAY HOME FROM WORK(APPROX 12 MILES) AND DECIDED I'D TRY OUT THE CRUISE CONTROL IN MY NEWLY ACQUIRED 2000 MOUNTAINEER 302 AWD. THE FIRST PART OF THE COMMUTE IS WHAT I WOULD CONSIDER HARMLESS AND A VERY SAFE STRETCH TO TEST OUT THIS FEATURE SO I PRESS THE CRUISE BUTTON TO SET MY SPEED AT THE POSTED SPEED LIMIT OF 55MPH…
Read full complaint
I WAS ON MY WAY HOME FROM WORK(APPROX 12 MILES) AND DECIDED I'D TRY OUT THE CRUISE CONTROL IN MY NEWLY ACQUIRED 2000 MOUNTAINEER 302 AWD. THE FIRST PART OF THE COMMUTE IS WHAT I WOULD CONSIDER HARMLESS AND A VERY SAFE STRETCH TO TEST OUT THIS FEATURE SO I PRESS THE CRUISE BUTTON TO SET MY SPEED AT THE POSTED SPEED LIMIT OF 55MPH. ALL WAS WELL UNTIL I APPROACHED A SHARP HAIR PIN CURVE ABOUT 4 MILES INTO THE TRIP. I GENTLY STARTED TO APPLY THE BRAKE TO CANCEL THE CRUISE BUT THE VEHICLE DIDN'T RESPOND TO MY ATTEMPT. IN A STATE OF PANIC, I FIRMLY APPLY THE BRAKE TO REDUCE SPEED AND WAS ONLY ABLE TO DROP APPROXIMATELY 6-7 MPH. STILL WELL ABOVE THE ADVISED LIMIT FOR THAT PARTICULAR CURVE. AFTER MAKING IT THOUGH THE CURVE, THE MOUNTAINEER TRANSMISSION DOWN SHIFTED AND I WAS OFF TO THE RACES. I PANICKED AND IN DOING SO, FAILED TO PROCESS AND THINK CLEARLY. MY INSTINCT WAS TO KEEP POUNDING ON THE BRAKES IN HOPE THAT THE CRUISE CABLE WITH BREAK OR POP FREE. AT 70MPH MY BRAKES WERE USELESS. IT ACCELERATED JUST PAST 80MPH AND FINALLY RIGHT BEFORE MY TURN OFF ONTO THE ROAD THAT I LIVE, MY HEAD CLEARED AND I TURNED THE IGNITION KEY TO THE OFF POSITION AND WAS ABLE TO COAST INTO MY NEIGHBORHOOD. AS I EXITED THE VEHICLE, EVERY OUNCE OF COOLANT WAS BEING SHOT OUT OF THE RADIATOR AND ALL FOUR BRAKE ROTORS WERE GLOWING CHERRY RED. I WAS SCARED THE THING WAS GOING TO CATCH FIRE. LIKE INCIDENT REPORT PRIOR TO MINE, MY CRUISE CABLE RETAINER HAD MALFUNCTIONED AND WAS NO LONGER ANCHORED TO ITS USUAL POSITION. FORD HAS A MAJOR FLAW IN THE WAY THIS SYSTEM WAS DESIGNED AND NEEDS TO TAKE ACTION SO SOMEONE DOESN'T GET KILLED. HANDS DOWN, THE ABSOLUTE SCARIEST SITUATION I'VE EVER EXPERIENCED.
NHTSA ODI #10849904
183,345 miles · Nov 25, 2014
Electrical SystemEngineVehicle Speed ControlFire
I WAS DRIVING TO AN INTERSECTION WITH MY FAMILY WHILE GOING 45 MPH. I NOTICED BLACK COMING THROUGH THE VENTS. I PULLED OFF TO A GAS STATION PARKING LOT. I PROCEEDED TO USE FIRE EXTINGUISHERS UNDER THE HOOD, THE FIRE DEPARTMENT HAD TO COME PUT IT OUT. THEY DID A LOOK THROUGH AND DETERMINED THE FIRE STARTED AT THE FUSE BOX. …
Read full complaint
I WAS DRIVING TO AN INTERSECTION WITH MY FAMILY WHILE GOING 45 MPH. I NOTICED BLACK COMING THROUGH THE VENTS. I PULLED OFF TO A GAS STATION PARKING LOT. I PROCEEDED TO USE FIRE EXTINGUISHERS UNDER THE HOOD, THE FIRE DEPARTMENT HAD TO COME PUT IT OUT. THEY DID A LOOK THROUGH AND DETERMINED THE FIRE STARTED AT THE FUSE BOX. I WENT HOME AND RESEARCHED THAT THIS IS A RECURRING PROBLEM WITH THIS TYPE OF VEHICLE. I'M NOW OUT THE 6500 I USED TO PURCHASE IT. I CANT FIX IT OR TRADE IT IN NOW. *TR
NHTSA ODI #10660886
165,000 miles · May 2, 2013
EngineVehicle Speed ControlFire
TL* THE CONTACT OWNS A 2000 MERCURY MOUNTAINEER. THE CONTACT STATED THAT SMOKE EMITTED FROM UNDER THE HOOD AREA. THE CONTACT INSPECTED THE VEHICLE AND NOTICED BLACK SMOKE AND FLAMES IN THE ENGINE AREA. THE FIRE DEPARTMENT WAS CONTACTED TO EXTINGUISH THE FIRE. THE VEHICLE WAS TOWED TO THE CONTACT'S INSURANCE COMPANY FOR FURTHER I…
Read full complaint
TL* THE CONTACT OWNS A 2000 MERCURY MOUNTAINEER. THE CONTACT STATED THAT SMOKE EMITTED FROM UNDER THE HOOD AREA. THE CONTACT INSPECTED THE VEHICLE AND NOTICED BLACK SMOKE AND FLAMES IN THE ENGINE AREA. THE FIRE DEPARTMENT WAS CONTACTED TO EXTINGUISH THE FIRE. THE VEHICLE WAS TOWED TO THE CONTACT'S INSURANCE COMPANY FOR FURTHER INVESTIGATION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 165,000. UPDATED 06/26/13*LJ THE CONSUMER BELIEVED THE SPEED CONTROL DEACTIVATION SWITCH WAS THE CAUSE OF THE FIRE. UPDATED 06/27/13 *BF UPDATED UPDATED 07/02/2013 *JS
NHTSA ODI #10510356
132,000 miles · May 25, 2012
Exterior LightingService BrakesVehicle Speed ControlFire
BRAKE LIGHTS WERE NOT LIGHTING. FUSE WAS BLOWN, REPLACED FUSE, STEPPED ON BRAKE PEDAL, THEN POOF OF SMOKE AT FUSE INSIDE, AND UNDER HOOD SMOKE CONTINUED FOR 2 MINUTES. FOUND CONNECTOR FOR SWITCH ON MASTER CYLINDER WAS MELTED AND SWITCH IS STILL BAD. DISCONNECTED CONNECTOR FROM SHORTED SWITCH CAUSING FUSE TO BLOW. THEN REPLACED F…
Read full complaint
BRAKE LIGHTS WERE NOT LIGHTING. FUSE WAS BLOWN, REPLACED FUSE, STEPPED ON BRAKE PEDAL, THEN POOF OF SMOKE AT FUSE INSIDE, AND UNDER HOOD SMOKE CONTINUED FOR 2 MINUTES. FOUND CONNECTOR FOR SWITCH ON MASTER CYLINDER WAS MELTED AND SWITCH IS STILL BAD. DISCONNECTED CONNECTOR FROM SHORTED SWITCH CAUSING FUSE TO BLOW. THEN REPLACED FUSE AND NOW BRAKE LIGHTS WORK. CRUISE CONTROL WAS INTERMITTENT FOR THE PAST 2 MONTHS PRIOR TO THIS EVENT. CONNECTOR IS TIED TO KEEP IT SECURE UNTIL REPAIR IS MADE. *TR
NHTSA ODI #10459712
Mileage unknown · Mar 26, 2012
Service Brakes, HydraulicVehicle Speed ControlCrash
WHILE I WAS PARKING THE CAR IN THE GARAGE, I CAME TO A STOP ABOUT 12 INCHES FROM A FILE CABINET AGAINST THE BACK WALL. THEN I PUT THE CAR IN REVERSE TO MOVE BACK A FEW INCHES FOR BETTER CLEARANCE. ALL OF A SUDDEN THE CAR UNEXPECTEDLY ACCELERATED FORWARD AND CRASHED INTO THE FILE CABINET AND TOTALED IT PLUS DAMAGED THE FRONT BU…
Read full complaint
WHILE I WAS PARKING THE CAR IN THE GARAGE, I CAME TO A STOP ABOUT 12 INCHES FROM A FILE CABINET AGAINST THE BACK WALL. THEN I PUT THE CAR IN REVERSE TO MOVE BACK A FEW INCHES FOR BETTER CLEARANCE. ALL OF A SUDDEN THE CAR UNEXPECTEDLY ACCELERATED FORWARD AND CRASHED INTO THE FILE CABINET AND TOTALED IT PLUS DAMAGED THE FRONT BUMPER, GRILL AND HOOD. NOTE THAT APPLYING THE BRAKE DID NOT STOP IT. VERY THANKFUL THAT NO ONE WAS IN THE FRONT OF THE CAR WHEN THIS HAPPEN. *TR
NHTSA ODI #10453102
Mileage unknown · Nov 1, 2010
Vehicle Speed ControlFire
TL*THE CONTACT OWNS A 2000 MERCURY MOUNTAINEER. THE VEHICLE WAS PARKED AND BECAME ENGULFED INTO MASSIVE FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE CAUSE OF FAILURE WAS RELATED TO THE CRUISE CONTROL. A POLICE REPORT WAS FILED WITH NO PERSONAL INJURY. THE VEHICLE WAS COMPLETELY DESTROYED AND TOWED TO A TOWING FACILITY.…
Read full complaint
TL*THE CONTACT OWNS A 2000 MERCURY MOUNTAINEER. THE VEHICLE WAS PARKED AND BECAME ENGULFED INTO MASSIVE FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE CAUSE OF FAILURE WAS RELATED TO THE CRUISE CONTROL. A POLICE REPORT WAS FILED WITH NO PERSONAL INJURY. THE VEHICLE WAS COMPLETELY DESTROYED AND TOWED TO A TOWING FACILITY. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10363579
Mileage unknown · Apr 2, 2008
Vehicle Speed Control
TL*THE CONTACT OWNS A 2000 MERCURY MOUNTAINEER. THE CONTACT RECEIVED A FORD RECALL NOTICE FOR THE VEHICLE SPEED CONTROL IN AUGUST OF 2007. SHE IMMEDIATELY SCHEDULED AN APPOINTMENT TO HAVE THE VEHICLE REPAIRED. THE CRUISE CONTROL SWITCH WAS DISCONNECTED AND SHE WAS INFORMED THAT THE PARTS WOULD BE UNAVAILABLE UNTIL NOVEMBER OF…
Read full complaint
TL*THE CONTACT OWNS A 2000 MERCURY MOUNTAINEER. THE CONTACT RECEIVED A FORD RECALL NOTICE FOR THE VEHICLE SPEED CONTROL IN AUGUST OF 2007. SHE IMMEDIATELY SCHEDULED AN APPOINTMENT TO HAVE THE VEHICLE REPAIRED. THE CRUISE CONTROL SWITCH WAS DISCONNECTED AND SHE WAS INFORMED THAT THE PARTS WOULD BE UNAVAILABLE UNTIL NOVEMBER OF 2007. IN JANUARY OF 2008, THE DEALER STATED THAT THEY WOULD NOTIFY HER VIA MAIL WHEN THE PARTS ARRIVE. AS OF APRIL 2, 2008, THE CONTACT HAS NOT RECEIVED A NOTICE. A REPRESENTATIVE FROM THE DEALER INFORMED HER THAT THEY STILL DID NOT KNOW WHEN THE PARTS WOULD BE AVAILABLE. THERE HAD BEEN NO FAILURE TO DATE. THE RECALL NUMBER WAS 05S28. THE CURRENT MILEAGE WAS 48,000. UPDATED 04/16/08. *LJ
NHTSA ODI #10223180
Mileage unknown · Mar 20, 2008
Vehicle Speed Control
2000 MERCURY MOUNTAINEER WITH A RECALL FOR SPEED CONTROL. CONSUMER STATED THAT SHE RECEIVED THE RECALL IN AUGUST OF 2007 AND THE VEHICLE HAS YET TO BE REPAIRED. *KB THE DEALER DISCONNECTED THE CRUISE CONTROL. *JB
NHTSA ODI #10222741
Mileage unknown · Mar 9, 2008
Vehicle Speed Control
I RECEIVED A MOTIVE IN AUGUST 2007 WHICH ADVISED ME TO CONTACT MY LOCAL DEALER WHO WAS AUTHORIZED BY FORD MOTOR COMPANY TO "INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM" OF MY 2000 MERCURY MOUNTAINEER (RECALL: 05S28). THAT UNTIL THIS REPAIR WAS COMPLETED, I SHOULD PARK MY VEHICLE "AWAY FROM STRUCTURES TO PREVENT …
Read full complaint
I RECEIVED A MOTIVE IN AUGUST 2007 WHICH ADVISED ME TO CONTACT MY LOCAL DEALER WHO WAS AUTHORIZED BY FORD MOTOR COMPANY TO "INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM" OF MY 2000 MERCURY MOUNTAINEER (RECALL: 05S28). THAT UNTIL THIS REPAIR WAS COMPLETED, I SHOULD PARK MY VEHICLE "AWAY FROM STRUCTURES TO PREVENT A POTENTIAL UNDERHOOD FIRE FROM SPREADING". I HAVE ATTEMPTED TO HAVE THIS REPAIR COMPLETED AT LEAST 10 TIMES SINCE RECEIVING THIS NOTICE, ALWAYS BEING TOLD THAT THE "REQUIRED PARTS ARE NOT IN YET". I BELIEVE I HAVE WORN DOWN THE SERVICE DEPARTMENT WITH MY CALLS, SINCE I WAS LAST TOLD: "THEY WILL PROBABLY NEVER BE IN" !! *TR
NHTSA ODI #10220493
60,000 miles · Oct 2, 2007
Vehicle Speed ControlFire
TL*THE CONTACT OWNS A 2000 MERCURY MOUNTAINEER. WHILE PULLING INTO THE DRIVEWAY AT 20 MPH, THE CONTACT NOTICED SMOKE COMING FROM UNDER THE HOOD. WITHIN FIVE MINUTES, THE VEHICLE BURST INTO FLAMES WITHOUT WARNING. SHE RECEIVED A RECALL LETTER (05S28) IN AUGUST OF 2007. THE MANUFACTURER WAS NOTIFIED AND THEY ADVISED HER TO SEN…
Read full complaint
TL*THE CONTACT OWNS A 2000 MERCURY MOUNTAINEER. WHILE PULLING INTO THE DRIVEWAY AT 20 MPH, THE CONTACT NOTICED SMOKE COMING FROM UNDER THE HOOD. WITHIN FIVE MINUTES, THE VEHICLE BURST INTO FLAMES WITHOUT WARNING. SHE RECEIVED A RECALL LETTER (05S28) IN AUGUST OF 2007. THE MANUFACTURER WAS NOTIFIED AND THEY ADVISED HER TO SEND PHOTOS UNDER REFERENCE NUMBER 383940900. THE FORD INVESTIGATION CONCLUDED THAT THE MOTOR WAS TOO BADLY BURNED TO DETERMINE IF THE FIRE WAS CAUSED BY THE RECALL. THE INVESTIGATOR AGREED WITH HER, BUT HE HAD TO FOLLOW THE COMPANY'S DECISION. THE CURRENT AND FAILURE MILEAGES WERE 60,000. UPDATED 12/12/07
NHTSA ODI #10204689
Official recalls
6Aug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Aug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL AND 4.0L SOHC ENGINES, IF THE STRAND COVER ON THE SPEED CONTROL CABLE BECOMES FLARED AT THE END, THE SPEED CONTROL CABLE MAY BIND WHEN THE SPEED CONTROL IS ACTIVATED.
Consequence & remedy
Consequence: THE THROTTLE RETURN SPRING FORCE MAY NOT BE SUFFICIENT TO OVERCOME THE BINDING CONDITION WHEN THE SPEED CONTROL IS DISENGAGED. BRAKING FUNCTION WOULD BE MAINTAINED THOUGH STOPPING DISTANCES MAY BE INCREASED.
Remedy: DEALERS WILL INSPECT THE SPEED CONTROL CABLE AND, IF NECESSARY, REPLACE IT. OWNER NOTIFICATION BEGAN AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Aug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT, THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. IF THE BOLT FRACTURES AND DOES NOT JAM IN THE SEAT BACK FRAME, THE SEAT BACK MAY RECLINE UNTIL IT MAKES CONTACT WITH AN OBJECT BEHIND THE SEAT, SUCH AS THE SECOND ROW SEAT CUSHION.
Consequence & remedy
Consequence: THE DRIVER COULD POTENTIALLY LOSE CONTACT WITH THE STEERING WHEEL OR FOOT PEDALS DURING SUCH AN EVENT, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE DRIVER SEAT UPPER BOLT WITH A METAL SPACER AND BOLT. IN ADDITION, SEATS WITH TUBULAR BACK FRAMES WILL HAVE THE FULLY THREADED LOWER RECLINER BOLT REPLACED WITH A PARTIALLY THREADED BOLT. OWNER NOTIFICATION BEGAN ON AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Aug 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Jul 5, 2000
VEHICLE DESCRIPTION: 4-DOOR SPORT UTILITY VEHICLES EQUIPPED WITH SIDE AIR BAGS. THE SUBJECT VEHICLES HAVE A REVISED LEVEL SIDE CRASH SENSOR THAT COULD DEPLOY THE SIDE AIR BAG IF THE IGNITION KEY IS IN THE "RUN" POSITION AND THE SEATBELT WEBBING IS FORCIBLY EXTRACTED FROM A LOCKED RETRACTOR WITH A JERKING MOTION.
Consequence & remedy
Consequence: INADVERTENT SIDE AIR BAG DEPLOYMENT COULD CAUSE PERSONAL INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL REPLACE THE SIDE CRASH SENSORS WITH A REVISED DESIGN THAT WILL REDUCE THE LIKELIHOOD OF AN UNEXPECTED SIDE AIR BAG DEPLOYMENT.
Mar 7, 2000
VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES EQUIPPED WITH 4.0L ENGINES AND ALL-TIME 4-WHEEL DRIVE (A4WD) POWERTRAINS. THE GENERIC ELECTRONIC MODULE (GEM) COULD EXPERIENCE A CONDITION REFERRED TO AS "LOCK-UP" IN WHICH THE GEM CONTROLLED ELECTRONIC FUNCTIONS (E.G., FRONT WINDSHIELD WIPERS, INTERIOR LIGHTS, 4X4 SYSTEM, ETC.) COULD NOT BE TURNED ON OR, IN SOME CASES IF THE FUNCTION IS ON, COULD NOT BE TURNED OFF.
Consequence & remedy
Consequence: AN INOPERATIVE WINDSHIELD WIPER SYSTEM COULD AFFECT DRIVER VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A RESISTOR IN THE GEM CIRCUIT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP05005 · Spark Plug Ejection From Cylinder Head
Opened Sep 22, 2005 · Closed Jan 4, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Additional source detail variants (3)
Engine And Engine Cooling:engine
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
PE03020 · Front Seat Back Recliner Attachment
Opened May 21, 2003 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
BY LETTER DATED AUGUST 4, 2003, FORD NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V281) INVOLVING CERTAIN MODEL YEAR (MY) 1998-2001 FORD EXPLORER / MERCURY MOUNTAINEER 4-DOOR, MY 1998-2000 FORD EXPLORER 2-DOOR AND MY 2001-2002 FORD EXPLORER SPORT AND SPORT TRAC VEHICLES EQUIPPED WITH HIGH BACK SEATS.COMPLAINTS ALLEGE THAT THE DRIVER'S SEAT BACK RECLINED WITHOUT WARNING.A BOLT BETWEEN THE UPPER SEAT RECLINER ATTACHMENT AND THE SEAT BACK FRAME MAY FRACTURE.FORD WILL REPLACE THE BOLT THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME ON THE DRIVER SIDE SEAT.BASED ON FORD'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Illustration