IllustrationOdometer Fraud. The contact purchased a 2004 Mercury Monterey. It was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the mileage was 223,476 and at the time of registration, it was discovered that the mileage was 361,749.
2004 Mercury Monterey
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Monterey years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
60–25K
3525–50K
8250–75K
6275–100K
71100–150K
16150K+
272 reports with mileage · 11 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 203 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seats. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports6 fire reports1 injury reports
Electrical System complaints
11 reportsTL* THE CONTACT OWNS A 2004 MERCURY MONTEREY. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH, THE POWER TRAIN WARNING LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE WHERE THE ECM MODULE WAS REPLACED BY THE CONTACT. THE VEHICLE WAS REPAIRED BUT THE FAILURE PERSISTED. THE…
Read full complaint
TL* THE CONTACT OWNS A 2004 MERCURY MONTEREY. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH, THE POWER TRAIN WARNING LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE WHERE THE ECM MODULE WAS REPLACED BY THE CONTACT. THE VEHICLE WAS REPAIRED BUT THE FAILURE PERSISTED. THE CONTACT STATED THAT THE POWER TRAIN WARNING LIGHT ILLUMINATED INTERMITTENTLY AND OTHER UNKNOWN ELECTRICAL FAILURES OCCURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
WHILE DRIVING THE VAN THE LIGHTS ON THE DASH BOARD GOES OUT. THE SPEED DECLINES SLIGHTLY, AND THE HEADLIGHTS BLINK ON AND OFF. THE RADIO TURNS ON AND OFF. THE HEAT TURNS ON AND OFF. THE ALARMS INSIDE STARTS TO CHIME. THE POWER IS LOST TO THE WINDOWS AND THE DOOR LOCKS. WHEN DRIVING AT NIGHT THE DASH LIGHTS GO OFF AND WHEN THIS H…
Read full complaint
WHILE DRIVING THE VAN THE LIGHTS ON THE DASH BOARD GOES OUT. THE SPEED DECLINES SLIGHTLY, AND THE HEADLIGHTS BLINK ON AND OFF. THE RADIO TURNS ON AND OFF. THE HEAT TURNS ON AND OFF. THE ALARMS INSIDE STARTS TO CHIME. THE POWER IS LOST TO THE WINDOWS AND THE DOOR LOCKS. WHEN DRIVING AT NIGHT THE DASH LIGHTS GO OFF AND WHEN THIS HAPPENS YOU CANNOT SEE THE SPEEDOMETER OR ANYTHING ELSE FOR THAT MATTER. THIS REALLY NEEDS TO BE LOOKED INTO. I'M AFRAID THAT THIS ELECTRICAL PROBLEM WILL SOON CAUSE A FIRE OF SOME SORT. *TR
WHEN DRIVING THE LIGHTS ON THE DASHBOARD PANEL, BLINKS ON AND OFF CONSISTENTLY. STAYS OUT FOR 1-2 MINUTES.AFTER WHICH THE HEADLIGHTS START TO GO OUT STAYS OFF FOR 1-2 MINUTES. THEN THE CAR STARTS TO JERK AND DECLINE IN SPEED. THE SPEEDOMETER GOES TO ZERO THEN JUMPS BACK TO ACTUAL SPEED. WHEN THE POWER IS OUT THERE IS COMPLETE LO…
Read full complaint
WHEN DRIVING THE LIGHTS ON THE DASHBOARD PANEL, BLINKS ON AND OFF CONSISTENTLY. STAYS OUT FOR 1-2 MINUTES.AFTER WHICH THE HEADLIGHTS START TO GO OUT STAYS OFF FOR 1-2 MINUTES. THEN THE CAR STARTS TO JERK AND DECLINE IN SPEED. THE SPEEDOMETER GOES TO ZERO THEN JUMPS BACK TO ACTUAL SPEED. WHEN THE POWER IS OUT THERE IS COMPLETE LOSS OF POWER TO THE WINDOWS AND INTERIOR LIGHTS AND DOOR LOCK. TOOK THE CAR IN FOR SERVICE HE SAID THAT HE HAS HAD MANY PEOPLE COME IN WITH THIS TYPE OF VAN WITH THE SAME PROBLEM. THUS IS DANGEROUS WHEN DRIVING AT NIGHT WITH LOSS OF VISUAL AID. HE SAID THAT ONLY A FORD DEALER CAN REPAIR THE PROBLEM. THIS IS FRIGHTENING AND WRECK LESS. *TR
SPOUSE [XXX] WAS DRIVING THE FAMILY AND ME OUT TO DINNER ON MAY 9, 2014 FOR MOTHER'S DAY.THE GAS TANK WAS ON ONE-FOURTH A TANK SO BEFORE ON TO THE EXPRESSWAY WE STOP TO GET SOME GAS. [XXX] MADE A STATEMENT HE SAID, "HE SAID THE GAS HAND STILL HASN'T MOVED MUCH AFTER WE PUT $40.00 TOGETHER OF GAS IN THE VAN. WE PUT GAS IN THE…
Read full complaint
SPOUSE [XXX] WAS DRIVING THE FAMILY AND ME OUT TO DINNER ON MAY 9, 2014 FOR MOTHER'S DAY.THE GAS TANK WAS ON ONE-FOURTH A TANK SO BEFORE ON TO THE EXPRESSWAY WE STOP TO GET SOME GAS. [XXX] MADE A STATEMENT HE SAID, "HE SAID THE GAS HAND STILL HASN'T MOVED MUCH AFTER WE PUT $40.00 TOGETHER OF GAS IN THE VAN. WE PUT GAS IN THE VAN AT THE GAS STATION AT 63RD AND CALIFORNIA. AFTER GETTING GAS WE PROCEED TOWARD WESTERN AVE. ON WESTER AVE. [XXX] DROVE FROM71ST AND WESTERN TO 111 & WESTERN WHEN WE SMELLED SOMETHING BURNING. WE THOUGHT THE SMELL WAS COMING FROM A VEHICLE ON THE SIDE OF US. WE MADE NO BIG DEAL ABOUT IT UNTIL THE VAN BEGIN TO SMOKE TREMENDOUS. [XXX] STOP THE CAR AN PULLED OVER. THE SMOKE INCREASED IN FRONT OF THE CAR ON THE DRIVERS AS [XXX] STOOD THERE TRYING TO UNDERSTAND WHAT WAS GOING ON, I SAW A BLAZE OF FIRE. I BEGIN SCREAMING THE VAN IS ON FIRE, THE VAN IS ON FIRE. I JUMP OUT OF THE VEHICLE THE BLAZE GOT LARGER. MY DAUGHTER AND MY BROTHER-IN-LAW WHO IS MENTALLY CHALLENGED WAS IN THE SECOND ROW OF SEATS BUCKLED UP. I GOT BACK IN THE CAR TO TURN ON THE EMERGENCY SIGNAL TO LET THE OTHER DRIVERS KNOW THAT WE NEEDED HELP. I YELLED AT MY FAMILY ON THE SECOND ROW AGAIN, GET OUT THE VAN THE VAN IS ON FIRE. THEY BEHAVE AS IF THEY COULD NOT HEAR ME OR UNDERSTAND WHAT I WA SAYING. SO, I BEGIN TO BANG ON THE WINDOW GET OUT GET OUT THE VAN IS ON FIRE.AFTER THE VAN WAS FULL BLAZED AND THE EMERGENCY WAS ON THE BANGING GOT THEM OUT. THERE WAS REDDISH BROWN LIQUID ALL IN THE SURROUNDING AREA WHERE THE VAN WAS PARK. MY HUSBAND AND I BOTH CALLED THE POLICE DEPARTMENT BUT THE FIRE DEPARTMENT CAME WITH TWO TOW TRUCKS. I GOT MY FAMILY TO SAFETY ON THE OTHER SIDE OF THE TRAIN TRACKS BY 111 & MARSHFIELD WHILE [XXX] TALKED TO FIRE FIGHTERS AND THE TOW MEN. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
THE FRONT END OF THE CAR WAS WELDED IMPROPERLY AND THE WEATHER STRIPPING WAS FAULTY ALLOWING WATER TO POUR DOWN INTO THE CAR AND ONTO THE POWERTRAIN CONTROL MODULE (PCM) AT ANY TIME AFTER IT RAINS CAUSING THE CAR TO LOSE POWER AND THE TRANSMISSION TO FAIL. THIS IS A KNOWN AND COMMON PROBLEM AMONG '04 MONTEREY AND FORD FREESTARS.…
Read full complaint
THE FRONT END OF THE CAR WAS WELDED IMPROPERLY AND THE WEATHER STRIPPING WAS FAULTY ALLOWING WATER TO POUR DOWN INTO THE CAR AND ONTO THE POWERTRAIN CONTROL MODULE (PCM) AT ANY TIME AFTER IT RAINS CAUSING THE CAR TO LOSE POWER AND THE TRANSMISSION TO FAIL. THIS IS A KNOWN AND COMMON PROBLEM AMONG '04 MONTEREY AND FORD FREESTARS. WHEN THE PCM IS WET IT SHORTS OUT ALL TRANSMISSION SHIFTING AND ENGINE REGULATION. THE FIRST TIME THIS HAPPENED THE CAR WOULD NOT START OR RUN PROPERLY, HAD IRREGULAR ENGINE POWER, AND THE TRANSMISSION WOULD NOT SHIFT. THE ENGINE WAS TRYING ACCELERATE EVEN IN PARK. THE CAR HAD BEEN PARKED OVERNIGHT AND RAN FINE THE DAY BEFORE, BUT CAUSED TROUBLE THE NEXT DAY. IT HAD RAINED DURING THE NIGHT. WHEN THE PCM DRIED OUT THE CAR RAN NORMALLY AGAIN. THE SECOND TIME HOWEVER, THE PCM COMPLETELY SHORTED OUT AND IS IRREPARABLE. THE ENGINE RUNS SPORADICALLY AND THE TRANSMISSION WILL NOT SHIFT OUT OF FIRST GEAR CREATING A DRIVING HAZARD. THE CAR SEEMED ALRIGHT UNTIL I WAS ON THE ROAD TEST DRIVING AND THE CAR WOULD NOT ACCELERATE, CAUSING ME TO BE STUCK GOING A MAX OF 15 MPH IN TRAFFIC. THE CAR THEN LOST POWER, FORCING ME TO PULL OF TO THE SIDE. *TR
IN EARLY 2012 BOTH BRAKE LIGHTS ON DASH WOULD COME ON SPORADICALLY WHILE DRIVING.THEN CAME ON MORE FREQUENTLY. SOON THE BATTERY LIGHT STARTED TO COME ON AT STOPS OR LOW IDLES. 8/2012 DEALER COULD NOT REPRODUCE THE BRAKE LIGHTS COMING ON, BUT REPLACED ALTERNATOR. 11/2012 STILL PROBLEM WITH BRAKE LIGHTS ON THE DASH COMING ON NOW P…
Read full complaint
IN EARLY 2012 BOTH BRAKE LIGHTS ON DASH WOULD COME ON SPORADICALLY WHILE DRIVING.THEN CAME ON MORE FREQUENTLY. SOON THE BATTERY LIGHT STARTED TO COME ON AT STOPS OR LOW IDLES. 8/2012 DEALER COULD NOT REPRODUCE THE BRAKE LIGHTS COMING ON, BUT REPLACED ALTERNATOR. 11/2012 STILL PROBLEM WITH BRAKE LIGHTS ON THE DASH COMING ON NOW PLUS THE CHECK ENGINE LIGHT. VEHICLE SPUTTERING AND STALLING (COULD NOT STOP WITHOUT VEHICLE TOTALLY STALLING AND HAD TO HAVE FOOT ON GAS AT ALL TIME, EVEN WHEN BRAKING, OR WOULD STALL.) 2ND DEALER STILL COULD NOT VERIFY THE DASH BRAKE LIGHTS BUT RESEALED CONNECTOR, REPLACED SPARK PLUGS, CLEAN MASS AIRFLOW, RESET KAM, REPLACED HEATED PCV HOSE. COULD DRIVE VEHICLE BUT BRAKE LIGHTS WERE BOTH STILL SPORADICALLY COMING ON WHILE DRIVING. 7/2013 STILL HAVING PROBLEMS WITH BOTH DASH BRAKE LIGHTS COMING ON ONLY NOW THE RADIO DIES WHEN THEY COME ON, WHEN THEY GO OFF, THE RADIO COMES BACK ON. IF THE RADIO DIDN'T GO OFF, SOMETIMES SHUTTING IT OFF WOULD RESULT IN THE BRAKE LIGHTS GOING OFF. DEALER STILL UNABLE TO VERIFY. THIS PROGRESSED TO THE BATTERY LIGHT COMING ON SPORADICALLY (AROUND TIME BRAKE LIGHTS WOULD COME ON) AND USUALLY GOING OFF IF THE AC WAS TURNED UP ON HIGH. THE VEHICLE ALSO STARTED TO LOSE POWER WHEN PASSING, FELT LIKE A DOWN SHIFT. THE DASH LIGHT ISSUE OCCURS DAILY, BUT THERE IS NO PATTERN. IT CAN BE WET, DRY, HOT, COLD, AFTER 5 MILES, AFTER 30 MILE, SIDE STREETS, EXPRESSWAY, MORNING, EVENING THERE IS NO CONSTANT. 10/2013 VEHICLE BACK AT DEALER SINCE THE PROBLEM HAPPENS EVERY DAY. THEY CAN'T REPRODUCE. ONLY CODE THEY GET IS THE ALTERNATOR, WHICH WAS REPLACED LAST YEAR AND DIDN'T HELP THE PROBLEM. THEY HAVE RESEALED THE CPU AND THAT DOESN'T HELP.THIS VEHICLE HAS BEEN PLAGUED BY ELECTRICAL PROBLEMS SINCE DAY ONE (HEATER, SEAT HEATER, CIGARETTE LIGHTERS, DOOR LOCKS ETC) CONCERNED ELECTRICAL ISSUES COULD RESULT IN LOSS OF POWER OR FIRE. *TR
1ST - RADIO STARTED FLASHING ON AND OFF RANDOMLY - TOOK TO FORD DEALER - NO ERROR CODE, NO ANSWER. 2ND - HEATED SEAT ON DRIVERS SIDE QUIT WORKING - TOOK TO FORD DEALER - NO ERROR CODE, NO ANSWER. TOOK TO PRIVATE REPAIR SHOP - ERROR CODE OF LOW VOLTAGE BATTERY - REPLACED BATTERY FOR $125 3RD - AUTOMATIC LIGHTS QUIT WORKING, DA…
Read full complaint
1ST - RADIO STARTED FLASHING ON AND OFF RANDOMLY - TOOK TO FORD DEALER - NO ERROR CODE, NO ANSWER. 2ND - HEATED SEAT ON DRIVERS SIDE QUIT WORKING - TOOK TO FORD DEALER - NO ERROR CODE, NO ANSWER. TOOK TO PRIVATE REPAIR SHOP - ERROR CODE OF LOW VOLTAGE BATTERY - REPLACED BATTERY FOR $125 3RD - AUTOMATIC LIGHTS QUIT WORKING, DASHBOARD CONTROL WENT BLANK - TOOK TO FORD DEALER - SAME LOW VOLTAGE ERROR CODE - DESPITE NEW BATTERY. NO OTHER ANSWERS. 4TH - AUTOMATIC SEATS STARTED MOVING WHEN USING CODE TO OPEN DOOR - TOOK TO FORD - FOUND THAT ALL PROBLEMS TRACED TO ONE RELAY BOX - REPLACED RELAY BOX FOR $650. 5TH - ENGINE LIGHT CAME ON ONE WEEK LATER - NO PROBLEMS STARTING/RUNNING, MADE APPOINTMENT TO TAKE TO DEALER IN 3 DAYS. 6TH - ENGINE DIED NEXT DAY, WOULD RESTART AND THEN DIE AGAIN AFTER 5 FEET, TOWED TO FORD DEALER, TOW TRUCK DRIVER NOTED ENGINE WOULD NOT GO INTO GEAR- REPEATEDLY GAVE NO CODE. ASKED THEM TO HAVE TECH TAKE CAR HOME AND DRIVE IT. FINALLY FOUND CORRODED AND WET PCM. QUOTED $1400 FOR THE REPAIR. I LOOKED UP PCM ON MERC. MONTEREY/FORD FREESTAR - AS THESE ARE ESSENTIALLY THE SAME VEHICLE. FOUND TONS OF SAME COMPLAINT. POOR DESIGN FROM FORD ALLOWING WATER TO DRIP ONTO MAIN COMPUTER/ELECTRICAL SUPPLY CAUSING THOUSANDS OF DOLLARS OF REPAIRS TO OWNERS. THE BATTERY WAS LIKELY JUST FINE, THE RELAY BOX LIKELY JUST FINE. I AM WORKING WITH DEALER TO PAY LESS FOR THE PCM SINCE THEY SHOULD HAVE FOUND THIS FROM THE FIRST OR SECOND ELECTRICAL COMPLAINT. CAR STILL AT DEALER, I WILL NOT PAY $1400 TO GET IT REPAIRED. *TR
VEHICLE STALLS LEAVING FAMILY STRANDED IN TRAFFIC (NUMEROUS EVENTS). DEALER TESTED AND REPLACED FUEL RAIL PRESSURE SENSOR AND VEHICLE WAS DRIVEN HOME, APPROX 8 MILES. VEHICLE FAILED TO START FOLLOWING MORNING. BASED ON ARTICLES AND TESTING PROCEDURES FOUND ONLINE, OWNER REPLACED CRANKSHAFT POSITION SENSOR, VEHICLE STARTED AND…
Read full complaint
VEHICLE STALLS LEAVING FAMILY STRANDED IN TRAFFIC (NUMEROUS EVENTS). DEALER TESTED AND REPLACED FUEL RAIL PRESSURE SENSOR AND VEHICLE WAS DRIVEN HOME, APPROX 8 MILES. VEHICLE FAILED TO START FOLLOWING MORNING. BASED ON ARTICLES AND TESTING PROCEDURES FOUND ONLINE, OWNER REPLACED CRANKSHAFT POSITION SENSOR, VEHICLE STARTED AND RAN FOR ABOUT 5 MIN. ENGINE DIED AND PRODUCED ERROR CODE P0320. EVIDENCE OF WATER HAS BEEN DETECTED IN THE PCM CONNECTOR AND FAULT HAS NOT YET BEEN CORRECTED. OTHER ITEMS REPLACED ON VEHICLE; TRANSMISSION, EGR, FUEL FILTER, PLUG WIRES AND PLUGS.
MY WIFE WAS BACKING OUT OF HER PARKING SPOT, PUT THE VAN IN FORWARD, AND DISCOVERED THAT IT WOULD NOT MOVE. THERE WERE NO INDICATIONS THAT THIS EVENT WAS GOING TO HAPPEN. OUR REPAIR TECHNICIAN HAD TO REPLACE OUR PLANETARY GEARSET, BECAUSE THEY WERE DESTROYED, THE TORQUE CONVERTER WAS REPLACED AS A PRECAUTION, AND THE NEUTRA…
Read full complaint
MY WIFE WAS BACKING OUT OF HER PARKING SPOT, PUT THE VAN IN FORWARD, AND DISCOVERED THAT IT WOULD NOT MOVE. THERE WERE NO INDICATIONS THAT THIS EVENT WAS GOING TO HAPPEN. OUR REPAIR TECHNICIAN HAD TO REPLACE OUR PLANETARY GEARSET, BECAUSE THEY WERE DESTROYED, THE TORQUE CONVERTER WAS REPLACED AS A PRECAUTION, AND THE NEUTRAL SWITCH WAS REPLACED BECAUSE IT WAS THOUGHT TO BE THE ROOT CAUSE. HOWEVER A BROKEN "CAM SWITCH" WIRE WAS PREVENTING THE CAR FROM OPERATING NORMALLY. WHEN THAT WAS FINALLY DISCOVERED, WE WERE ABLE TO GET OUR VAN BACK. *TR
Official recalls
413V081000 · Seats
Mar 7, 2013
Ford is recalling certain model year 2004-2007 Freestar and Mercury Monterey vehicles manufactured from March 24, 2003, through November 7, 2006, equipped with a third row seat and originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. The third row stowable seat can experience corrosion and structural degradation at the seat anchor mechanism mounted to the rear wheel wells. As a result of the corrosion, the third row seat may not fully latch into its seating position.
Consequence & remedy
Consequence: In the event that the vehicle is crashed into from the rear, an unlatched seat may increase the risk of personal injury.
Remedy: Ford will notify owners, and dealers will install new third row seat latch striker mounting brackets, free of charge. The recall began on March 28, 2013. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332.
12V006000 · Power Train:automatic Transmission; Power Train:automatic Transmission:torque Converter
Jan 9, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 2004 AND 2005 FORD FREESTAR AND MERCURY MONTEREY VEHICLES. THE TORQUE CONVERTER OUTPUT SHAFT MAY FAIL.
Consequence & remedy
Consequence: THIS CONDITION RESULTS IN A SUDDEN LOSS OF MOTIVE POWER WITH NO WARNING, INCREASING THE RISK OF A CRASH.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE TORQUE CONVERTER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 9, 2012. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Additional source detail variants (2)
Power Train:automatic Transmission:torque Converter
FORD IS RECALLING CERTAIN MODEL YEAR 2004 AND 2005 FORD FREESTAR AND MERCURY MONTEREY VEHICLES. THE TORQUE CONVERTER OUTPUT SHAFT MAY FAIL.
Consequence: THIS CONDITION RESULTS IN A SUDDEN LOSS OF MOTIVE POWER WITH NO WARNING, INCREASING THE RISK OF A CRASH.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE TORQUE CONVERTER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 9, 2012. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Power Train:automatic Transmission
FORD IS RECALLING CERTAIN MODEL YEAR 2004 AND 2005 FORD FREESTAR AND MERCURY MONTEREY VEHICLES. THE TORQUE CONVERTER OUTPUT SHAFT MAY FAIL.
Consequence: THIS CONDITION RESULTS IN A SUDDEN LOSS OF MOTIVE POWER WITH NO WARNING, INCREASING THE RISK OF A CRASH.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE TORQUE CONVERTER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 9, 2012. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
04V446000 · Wheels:hub
Sep 13, 2004
CERTAIN MINIVANS MAY HAVE BEEN PRODUCED WITH FRONT WHEEL HUB ASSEMBLIES THAT WERE NOT HEAT TREATED CORRECTLY. THIS CONDITION MAY LEAD TO THE DEVELOPMENT OF SMALL CRACKS IN THE HUB.
Consequence & remedy
Consequence: IF THE CRACKS WERE TO PROGRESS, THIS COULD EVENTUALLY RESULT IN WHEEL SEPARATION. WHEEL SEPARATION MAY LEAD TO LOSS OF VEHICLE CONTROL, AND POTENTIALLY RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT HUB, ROTORS, AND WHEEL BEARINGS. THE RECALL BEGAN SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
03V457000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Nov 6, 2003
ON CERTAIN MINIVANS, THE POWER STEERING LOW-PRESSURE LINE MAY NOT BE FULLY SEATED AT THE RACK AND PINION STEERING GEAR.
Consequence & remedy
Consequence: IF THIS LINE BECOMES DISCONNECTED, IT MAY CREATE THE POTENTIAL FOR FLUID TO COME INTO CONTACT WITH THE EXHAUST SYSTEM, WHICH COULD RESULT IN SMOKE OR FIRE.
Remedy: DEALERS WILL INSPECT THE POWER STEERING LOW-PRESSURE LINE TO ENSURE THAT IT IS SEATED PROPERLY AT THE RACK AND PINION STEERING GEAR. OWNER NOTIFICATION BEGAN NOVEMBER 10, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7EQ12010 · Stabilus Rear Liftgate Struts Failing
Opened Sep 28, 2012 · Closed Dec 31, 2012
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
Please see the attached closing resume summary.It has been attached to this document as a PDF.
EA12003 · Corrosion Of Third-Row Seat Attachment
Opened Apr 23, 2012 · Closed May 2, 2013
Status: closed (inferred from source dates) · Seats; Seats:mid/rear Assembly; Structure; Structure:body
Ford is conducting a safety recall to repair the third-row seat's latch mechanisms in approximately 196,667 model year (MY) 2004 through 2007 Ford Freestar and Mercury Monterey vehicles (see NHTSA recall 13V-081 for more details).The recall covers vehicles originally sold, or currently registered, in the salt belt states or high corrosion areas of the United States: Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin.Approximately 100,000 remaining MY 2004-2007 Freestar and Monterey vehicles--those vehicles that were not originally sold, or are not currently registered, in salt belt states--are not included in the recall action. Although these vehicles are the same as the ones described above, they experience significantly lower failure rates because of reduced road salt exposure.ODI is currently aware of only one complaint on vehicle outside of the recall scope.ODI will monitor complaints and take further action if warranted by the circumstances.For owners of vehicles that are outside of the recall scope but exhibit the defect condition, owners (and affected Ford dealers) can contact Ford to request the recall repair.This Engineering Analysis is closed.See attached report and associated recall file for additional information.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10399896, 10410491, 10420028, 10424850, 10433928, 10436592, 10438529, 10440616, 10441489, 10441641, 10442809, 10446564, 10450295, 10450559, 10450587, 10452933, 10453826, 10454977, 10455545, 10456985, 10457423, 10457910, 10458738, 10459042, 10460511, 10461074, 10462910, 10463126, 10463262, 10463366, 10463600, 10464243, 10467003, 10467680, 10468429, 10469188, 10469200, 10470216, 10470510, 10471280, 10471520, 10471813, 10471978, 10472514, 10473087, 10473159, 10477025, 10477387, 10477954, 10478449, 10479247, 10479758, 10480611, 10480665, 10481054, 10481412, 10482213, 10482236, 10482613, 10482620, 10487872, 10489445, 10490515, 10490641, 10490663, 10490744, 10491495, 10492220, 10493470, 10493572, 10496348, 10497631, 10497976, 10498310, 10498433, 10499681, 10499861, 10500495.
Additional source detail variants (4)
Seats
Ford is conducting a safety recall to repair the third-row seat's latch mechanisms in approximately 196,667 model year (MY) 2004 through 2007 Ford Freestar and Mercury Monterey vehicles (see NHTSA recall 13V-081 for more details).The recall covers vehicles originally sold, or currently registered, in the salt belt states or high corrosion areas of the United States: Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin.Approximately 100,000 remaining MY 2004-2007 Freestar and Monterey vehicles--those vehicles that were not originally sold, or are not currently registered, in salt belt states--are not included in the recall action. Although these vehicles are the same as the ones described above, they experience significantly lower failure rates because of reduced road salt exposure.ODI is currently aware of only one complaint on vehicle outside of the recall scope.ODI will monitor complaints and take further action if warranted by the circumstances.For owners of vehicles that are outside of the recall scope but exhibit the defect condition, owners (and affected Ford dealers) can contact Ford to request the recall repair.This Engineering Analysis is closed.See attached report and associated recall file for additional information.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10399896, 10410491, 10420028, 10424850, 10433928, 10436592, 10438529, 10440616, 10441489, 10441641, 10442809, 10446564, 10450295, 10450559, 10450587, 10452933, 10453826, 10454977, 10455545, 10456985, 10457423, 10457910, 10458738, 10459042, 10460511, 10461074, 10462910, 10463126, 10463262, 10463366, 10463600, 10464243, 10467003, 10467680, 10468429, 10469188, 10469200, 10470216, 10470510, 10471280, 10471520, 10471813, 10471978, 10472514, 10473087, 10473159, 10477025, 10477387, 10477954, 10478449, 10479247, 10479758, 10480611, 10480665, 10481054, 10481412, 10482213, 10482236, 10482613, 10482620, 10487872, 10489445, 10490515, 10490641, 10490663, 10490744, 10491495, 10492220, 10493470, 10493572, 10496348, 10497631, 10497976, 10498310, 10498433, 10499681, 10499861, 10500495.
Seats:mid/rear Assembly
Ford is conducting a safety recall to repair the third-row seat's latch mechanisms in approximately 196,667 model year (MY) 2004 through 2007 Ford Freestar and Mercury Monterey vehicles (see NHTSA recall 13V-081 for more details).The recall covers vehicles originally sold, or currently registered, in the salt belt states or high corrosion areas of the United States: Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin.Approximately 100,000 remaining MY 2004-2007 Freestar and Monterey vehicles--those vehicles that were not originally sold, or are not currently registered, in salt belt states--are not included in the recall action. Although these vehicles are the same as the ones described above, they experience significantly lower failure rates because of reduced road salt exposure.ODI is currently aware of only one complaint on vehicle outside of the recall scope.ODI will monitor complaints and take further action if warranted by the circumstances.For owners of vehicles that are outside of the recall scope but exhibit the defect condition, owners (and affected Ford dealers) can contact Ford to request the recall repair.This Engineering Analysis is closed.See attached report and associated recall file for additional information.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10399896, 10410491, 10420028, 10424850, 10433928, 10436592, 10438529, 10440616, 10441489, 10441641, 10442809, 10446564, 10450295, 10450559, 10450587, 10452933, 10453826, 10454977, 10455545, 10456985, 10457423, 10457910, 10458738, 10459042, 10460511, 10461074, 10462910, 10463126, 10463262, 10463366, 10463600, 10464243, 10467003, 10467680, 10468429, 10469188, 10469200, 10470216, 10470510, 10471280, 10471520, 10471813, 10471978, 10472514, 10473087, 10473159, 10477025, 10477387, 10477954, 10478449, 10479247, 10479758, 10480611, 10480665, 10481054, 10481412, 10482213, 10482236, 10482613, 10482620, 10487872, 10489445, 10490515, 10490641, 10490663, 10490744, 10491495, 10492220, 10493470, 10493572, 10496348, 10497631, 10497976, 10498310, 10498433, 10499681, 10499861, 10500495.
Structure:body
Ford is conducting a safety recall to repair the third-row seat's latch mechanisms in approximately 196,667 model year (MY) 2004 through 2007 Ford Freestar and Mercury Monterey vehicles (see NHTSA recall 13V-081 for more details).The recall covers vehicles originally sold, or currently registered, in the salt belt states or high corrosion areas of the United States: Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin.Approximately 100,000 remaining MY 2004-2007 Freestar and Monterey vehicles--those vehicles that were not originally sold, or are not currently registered, in salt belt states--are not included in the recall action. Although these vehicles are the same as the ones described above, they experience significantly lower failure rates because of reduced road salt exposure.ODI is currently aware of only one complaint on vehicle outside of the recall scope.ODI will monitor complaints and take further action if warranted by the circumstances.For owners of vehicles that are outside of the recall scope but exhibit the defect condition, owners (and affected Ford dealers) can contact Ford to request the recall repair.This Engineering Analysis is closed.See attached report and associated recall file for additional information.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10399896, 10410491, 10420028, 10424850, 10433928, 10436592, 10438529, 10440616, 10441489, 10441641, 10442809, 10446564, 10450295, 10450559, 10450587, 10452933, 10453826, 10454977, 10455545, 10456985, 10457423, 10457910, 10458738, 10459042, 10460511, 10461074, 10462910, 10463126, 10463262, 10463366, 10463600, 10464243, 10467003, 10467680, 10468429, 10469188, 10469200, 10470216, 10470510, 10471280, 10471520, 10471813, 10471978, 10472514, 10473087, 10473159, 10477025, 10477387, 10477954, 10478449, 10479247, 10479758, 10480611, 10480665, 10481054, 10481412, 10482213, 10482236, 10482613, 10482620, 10487872, 10489445, 10490515, 10490641, 10490663, 10490744, 10491495, 10492220, 10493470, 10493572, 10496348, 10497631, 10497976, 10498310, 10498433, 10499681, 10499861, 10500495.
Structure
Ford is conducting a safety recall to repair the third-row seat's latch mechanisms in approximately 196,667 model year (MY) 2004 through 2007 Ford Freestar and Mercury Monterey vehicles (see NHTSA recall 13V-081 for more details).The recall covers vehicles originally sold, or currently registered, in the salt belt states or high corrosion areas of the United States: Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin.Approximately 100,000 remaining MY 2004-2007 Freestar and Monterey vehicles--those vehicles that were not originally sold, or are not currently registered, in salt belt states--are not included in the recall action. Although these vehicles are the same as the ones described above, they experience significantly lower failure rates because of reduced road salt exposure.ODI is currently aware of only one complaint on vehicle outside of the recall scope.ODI will monitor complaints and take further action if warranted by the circumstances.For owners of vehicles that are outside of the recall scope but exhibit the defect condition, owners (and affected Ford dealers) can contact Ford to request the recall repair.This Engineering Analysis is closed.See attached report and associated recall file for additional information.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10399896, 10410491, 10420028, 10424850, 10433928, 10436592, 10438529, 10440616, 10441489, 10441641, 10442809, 10446564, 10450295, 10450559, 10450587, 10452933, 10453826, 10454977, 10455545, 10456985, 10457423, 10457910, 10458738, 10459042, 10460511, 10461074, 10462910, 10463126, 10463262, 10463366, 10463600, 10464243, 10467003, 10467680, 10468429, 10469188, 10469200, 10470216, 10470510, 10471280, 10471520, 10471813, 10471978, 10472514, 10473087, 10473159, 10477025, 10477387, 10477954, 10478449, 10479247, 10479758, 10480611, 10480665, 10481054, 10481412, 10482213, 10482236, 10482613, 10482620, 10487872, 10489445, 10490515, 10490641, 10490663, 10490744, 10491495, 10492220, 10493470, 10493572, 10496348, 10497631, 10497976, 10498310, 10498433, 10499681, 10499861, 10500495.
PE11039 · Corrosion Of Third-Row Seat Attachment
Opened Dec 21, 2011 · Closed Apr 27, 2012
Status: closed (inferred from source dates) · Latches/locks/linkages; Seats; Seats:mid/rear Assembly; Structure; Structure:body
ODI has received 18 complaints on the subject vehicles from the salt belt states that allege severe corrosion at the rear wheel wells.Additionally, ODI identified 4 similar reports from Ford's response to the investigation.Ford submitted a total of 10 reports to ODI (6 of 10 Ford reports are duplicates of ODI reports).The complaints indicated difficulty or inability to latch the rear seat as some of the complaints reported the entire anchor plate completely detached from the vehicle (rear wheel well).The first report of this condition was received in March 2011 and subsequent reporting frequency indicates a potentially increasing trend over time.ODI seeks to evaluate the potential occupant safety risks resulting from structurally degraded seat anchorages.In addition to the subject vehicles, ODI also will collect and review information on MY 2005-2007 Freestar/Monterey vehicles that appear to have a seat design identical to the subject vehicles.To date, ODI is not aware of any similar complaints on the MY 2005-2007 vehicles.ODI also will collect and review information on Freestar/Monterey vehicles used outside of the salt belt states.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-003) to further assess whether a safety defect exists in the subject vehicles.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10454977, 10453826, 10452933, 10450587, 10450559, 10450295, 10446564, 10442809, 10441641, 10441489, 10440616, 10438529, 10436592, 10433928, 10424850, 10420028, 10410491 and 10399896.
Additional source detail variants (5)
Latches/locks/linkages
ODI has received 18 complaints on the subject vehicles from the salt belt states that allege severe corrosion at the rear wheel wells.Additionally, ODI identified 4 similar reports from Ford's response to the investigation.Ford submitted a total of 10 reports to ODI (6 of 10 Ford reports are duplicates of ODI reports).The complaints indicated difficulty or inability to latch the rear seat as some of the complaints reported the entire anchor plate completely detached from the vehicle (rear wheel well).The first report of this condition was received in March 2011 and subsequent reporting frequency indicates a potentially increasing trend over time.ODI seeks to evaluate the potential occupant safety risks resulting from structurally degraded seat anchorages.In addition to the subject vehicles, ODI also will collect and review information on MY 2005-2007 Freestar/Monterey vehicles that appear to have a seat design identical to the subject vehicles.To date, ODI is not aware of any similar complaints on the MY 2005-2007 vehicles.ODI also will collect and review information on Freestar/Monterey vehicles used outside of the salt belt states.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-003) to further assess whether a safety defect exists in the subject vehicles.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10454977, 10453826, 10452933, 10450587, 10450559, 10450295, 10446564, 10442809, 10441641, 10441489, 10440616, 10438529, 10436592, 10433928, 10424850, 10420028, 10410491 and 10399896.
Seats
ODI has received 18 complaints on the subject vehicles from the salt belt states that allege severe corrosion at the rear wheel wells.Additionally, ODI identified 4 similar reports from Ford's response to the investigation.Ford submitted a total of 10 reports to ODI (6 of 10 Ford reports are duplicates of ODI reports).The complaints indicated difficulty or inability to latch the rear seat as some of the complaints reported the entire anchor plate completely detached from the vehicle (rear wheel well).The first report of this condition was received in March 2011 and subsequent reporting frequency indicates a potentially increasing trend over time.ODI seeks to evaluate the potential occupant safety risks resulting from structurally degraded seat anchorages.In addition to the subject vehicles, ODI also will collect and review information on MY 2005-2007 Freestar/Monterey vehicles that appear to have a seat design identical to the subject vehicles.To date, ODI is not aware of any similar complaints on the MY 2005-2007 vehicles.ODI also will collect and review information on Freestar/Monterey vehicles used outside of the salt belt states.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-003) to further assess whether a safety defect exists in the subject vehicles.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10454977, 10453826, 10452933, 10450587, 10450559, 10450295, 10446564, 10442809, 10441641, 10441489, 10440616, 10438529, 10436592, 10433928, 10424850, 10420028, 10410491 and 10399896.
Seats:mid/rear Assembly
ODI has received 18 complaints on the subject vehicles from the salt belt states that allege severe corrosion at the rear wheel wells.Additionally, ODI identified 4 similar reports from Ford's response to the investigation.Ford submitted a total of 10 reports to ODI (6 of 10 Ford reports are duplicates of ODI reports).The complaints indicated difficulty or inability to latch the rear seat as some of the complaints reported the entire anchor plate completely detached from the vehicle (rear wheel well).The first report of this condition was received in March 2011 and subsequent reporting frequency indicates a potentially increasing trend over time.ODI seeks to evaluate the potential occupant safety risks resulting from structurally degraded seat anchorages.In addition to the subject vehicles, ODI also will collect and review information on MY 2005-2007 Freestar/Monterey vehicles that appear to have a seat design identical to the subject vehicles.To date, ODI is not aware of any similar complaints on the MY 2005-2007 vehicles.ODI also will collect and review information on Freestar/Monterey vehicles used outside of the salt belt states.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-003) to further assess whether a safety defect exists in the subject vehicles.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10454977, 10453826, 10452933, 10450587, 10450559, 10450295, 10446564, 10442809, 10441641, 10441489, 10440616, 10438529, 10436592, 10433928, 10424850, 10420028, 10410491 and 10399896.
Structure:body
ODI has received 18 complaints on the subject vehicles from the salt belt states that allege severe corrosion at the rear wheel wells.Additionally, ODI identified 4 similar reports from Ford's response to the investigation.Ford submitted a total of 10 reports to ODI (6 of 10 Ford reports are duplicates of ODI reports).The complaints indicated difficulty or inability to latch the rear seat as some of the complaints reported the entire anchor plate completely detached from the vehicle (rear wheel well).The first report of this condition was received in March 2011 and subsequent reporting frequency indicates a potentially increasing trend over time.ODI seeks to evaluate the potential occupant safety risks resulting from structurally degraded seat anchorages.In addition to the subject vehicles, ODI also will collect and review information on MY 2005-2007 Freestar/Monterey vehicles that appear to have a seat design identical to the subject vehicles.To date, ODI is not aware of any similar complaints on the MY 2005-2007 vehicles.ODI also will collect and review information on Freestar/Monterey vehicles used outside of the salt belt states.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-003) to further assess whether a safety defect exists in the subject vehicles.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10454977, 10453826, 10452933, 10450587, 10450559, 10450295, 10446564, 10442809, 10441641, 10441489, 10440616, 10438529, 10436592, 10433928, 10424850, 10420028, 10410491 and 10399896.
Structure
ODI has received 18 complaints on the subject vehicles from the salt belt states that allege severe corrosion at the rear wheel wells.Additionally, ODI identified 4 similar reports from Ford's response to the investigation.Ford submitted a total of 10 reports to ODI (6 of 10 Ford reports are duplicates of ODI reports).The complaints indicated difficulty or inability to latch the rear seat as some of the complaints reported the entire anchor plate completely detached from the vehicle (rear wheel well).The first report of this condition was received in March 2011 and subsequent reporting frequency indicates a potentially increasing trend over time.ODI seeks to evaluate the potential occupant safety risks resulting from structurally degraded seat anchorages.In addition to the subject vehicles, ODI also will collect and review information on MY 2005-2007 Freestar/Monterey vehicles that appear to have a seat design identical to the subject vehicles.To date, ODI is not aware of any similar complaints on the MY 2005-2007 vehicles.ODI also will collect and review information on Freestar/Monterey vehicles used outside of the salt belt states.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-003) to further assess whether a safety defect exists in the subject vehicles.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10454977, 10453826, 10452933, 10450587, 10450559, 10450295, 10446564, 10442809, 10441641, 10441489, 10440616, 10438529, 10436592, 10433928, 10424850, 10420028, 10410491 and 10399896.
PE11033 · Service Jack Failure
Opened Sep 13, 2011 · Closed Dec 7, 2012
Status: closed (inferred from source dates) · Equipment:mechanical:accessory Scissor/screw/bottle Jack/lift
The subject vehicles (SV) are all automatic transmission, front wheel drive vehicles with hand actuated mechanical park brakes. The investigation focused on allegations that the service jack failed and caused the vehicles to fall. The subject scissors-type jack appears to fail at the slotted hinge joints where the jack screw is located (bends at mid-point). The failures occur while the jack is in use, and vehicle movement (forward or backward) is typically reported coincident with the failure. Ford reported that most MY 2003 Windstar and all MY 2006-2007 Freestar/Monterey also use the subject jack, an additional 223,246 vehicles.NHTSA has received six consumer complaints (VOQs) involving three injury incidents and a fatality.Ford reported 26 complaints for the SVs involving an additional 4 injuries. In the fatal incident, the van fell on a person working on the engine under the otherwise unsupported vehicle; ODI was unable to determine whether the vehicle was adequately chocked or the park brake was properly set. Reported injuries include a broken arm, head and hand injuries, arm and rib bruises, and muscle strains. NHTSA has received just one new report since opening this investigation. The complaint trend in ODI and Ford data is flat if not declining.Ford provides instructions and warnings in the owner's manual, on a placard placed with the jack, and on the jack itself. These instruct consumers to put the vehicle gear selector in Park, properly set the parking brake, chock the opposite wheel, use the jack only for changing a tire, loosen the lug nuts prior to jacking, and to not get under a vehicle supported by the jack only (NHTSA also recommends that jacks only be used for tire changing).In the VOQs, roughly half the consumers were using the jack for something other than tire changing, half had not chocked a wheel, and half had not properly set the parking brake. ODI notes that since the front wheels are drive wheels (with an open center differential) the Park gear cannot provide vehicle stability (longitudinally) when a front wheel is raised. All NHTSA complaints and most of the complaints to Ford involved failures while a front wheel was raised.In response to ODI's inquiry, Ford conducted testing on a 2004 Freestar. Ford's tests showed that when a front tire was raised the service jack held without failing under various scenarios except when a rocking force was applied and the parking brake was not properly set. Based on its testing and its analysis of field data, Ford concluded that the type of jack failure evidenced in this investigation (bending at mid-point) was likely caused by vehicle movement due to an improperly secured vehicle, or other misuse of the jack. Ford notes that rates in this investigation were similar to those in another investigation (EA91-049) which ODI closed. ODI also analyzed jack data for MY 2003 and newer vehicles to compare to the SV population. To assist with this analysis, ODI requested data from the jack manufacturer (actually its successor company) who provided limited data but did identify other models using the same design jack. ODI was unable to identify a significant difference in the incidence of jack failures (including those involving bending failures) between the SVs, other vehicles which used the same jack, or other vehicles where the jack type was unknown or different.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, investigation PE11-033 is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist and ODI reserves
PE10033 · Engine Stalling
Opened Aug 23, 2010 · Closed Jul 15, 2011
Status: closed (inferred from source dates) · Power Train:automatic Transmission:control Module (tcm/pcm/tecm); Vehicle Speed Control
The subject vehicles suffered from a design issue whereby water could run down onto the cowling under the hood and located in the area of the windshield wipers and then drip onto a computer module, the Powertrain Control Module (PCM), which could be manifested in a variety of symptoms depending on which part of the circuit board became wet or which of the connector pins shorted out.In addition to causing an engine to stall, which may or may not then restart, the water intrusion could also cause the transmission to shift poorly, the vehicle to have erratic power, a malfunction indicator light to come on, or result in an inability to start the vehicle, an inability to shift the vehicle into either forward or reverse. Also the problem could cause a higher than normal idle RPM in Park, or for the radio to malfunction, or the interior lights to stay on.During this investigation ODI was concerned with the effect of the engine stalling or a drastic and sudden loss of power either of which may create a safety risk.In reviewing the actual number of these types of incidents, collectively referred to here as engine stalls, the number was found to be below what would be considered a defect trend.For example, the number of engine stalls identified in Ford's warranty claims for the model year (MY) 2004 subject vehicles, the MY with the most failures, was 200 out of population of 125,865, for a failure rate of 0.16%.The one crash recorded by a complainant to NHTSA, VOQ 10311522, alleged that the engine stalled, due to water intrusion into the PCM, while the road was turning causing her to go off the road and according to the police report the vehicle then hit an embankment and a tree stump. Ford reported in their response that there were three alleged crashes but none of these were validated as being caused by a problem with water intrusion into the PCM causing a stall.Accordingly this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
The subject vehicles suffered from a design issue whereby water could run down onto the cowling under the hood and located in the area of the windshield wipers and then drip onto a computer module, the Powertrain Control Module (PCM), which could be manifested in a variety of symptoms depending on which part of the circuit board became wet or which of the connector pins shorted out.In addition to causing an engine to stall, which may or may not then restart, the water intrusion could also cause the transmission to shift poorly, the vehicle to have erratic power, a malfunction indicator light to come on, or result in an inability to start the vehicle, an inability to shift the vehicle into either forward or reverse. Also the problem could cause a higher than normal idle RPM in Park, or for the radio to malfunction, or the interior lights to stay on.During this investigation ODI was concerned with the effect of the engine stalling or a drastic and sudden loss of power either of which may create a safety risk.In reviewing the actual number of these types of incidents, collectively referred to here as engine stalls, the number was found to be below what would be considered a defect trend.For example, the number of engine stalls identified in Ford's warranty claims for the model year (MY) 2004 subject vehicles, the MY with the most failures, was 200 out of population of 125,865, for a failure rate of 0.16%.The one crash recorded by a complainant to NHTSA, VOQ 10311522, alleged that the engine stalled, due to water intrusion into the PCM, while the road was turning causing her to go off the road and according to the police report the vehicle then hit an embankment and a tree stump. Ford reported in their response that there were three alleged crashes but none of these were validated as being caused by a problem with water intrusion into the PCM causing a stall.Accordingly this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.
Vehicle Speed Control
The subject vehicles suffered from a design issue whereby water could run down onto the cowling under the hood and located in the area of the windshield wipers and then drip onto a computer module, the Powertrain Control Module (PCM), which could be manifested in a variety of symptoms depending on which part of the circuit board became wet or which of the connector pins shorted out.In addition to causing an engine to stall, which may or may not then restart, the water intrusion could also cause the transmission to shift poorly, the vehicle to have erratic power, a malfunction indicator light to come on, or result in an inability to start the vehicle, an inability to shift the vehicle into either forward or reverse. Also the problem could cause a higher than normal idle RPM in Park, or for the radio to malfunction, or the interior lights to stay on.During this investigation ODI was concerned with the effect of the engine stalling or a drastic and sudden loss of power either of which may create a safety risk.In reviewing the actual number of these types of incidents, collectively referred to here as engine stalls, the number was found to be below what would be considered a defect trend.For example, the number of engine stalls identified in Ford's warranty claims for the model year (MY) 2004 subject vehicles, the MY with the most failures, was 200 out of population of 125,865, for a failure rate of 0.16%.The one crash recorded by a complainant to NHTSA, VOQ 10311522, alleged that the engine stalled, due to water intrusion into the PCM, while the road was turning causing her to go off the road and according to the police report the vehicle then hit an embankment and a tree stump. Ford reported in their response that there were three alleged crashes but none of these were validated as being caused by a problem with water intrusion into the PCM causing a stall.Accordingly this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.
EA09016 · Transmission Torque Converter Failure
Opened Nov 10, 2009 · Closed Feb 2, 2012
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:torque Converter
On January 4, 2012 Ford Motor Company submitted a Defect Information Report (NHTSA Recall No. 12V-006) to NHTSA regarding a defect in the performance of the transmission torque converter for approximately 205,896 Ford Freestar and Mercury Monterey vehicles.The supplier of the torque converter manufactured converters containing a pump shaft spline that did not consistently meet the specified heat treatment requirements.In normal use, the spline may wear excessively and eventually fails without warning.If a torque converter malfunctions due to a sheared pump drive spline, the vehicle will abruptly lose motive power.This problem affected model year 2004 and 2005 Freestar and Monterey minivans.During the investigation NHTSA identified 532 complaints alleging incidents of vehicle stall while driving due to torque converter failure.These failures were sudden and without any prior warning.Of the 490 complaints that reported the speed at the time of the failure:218 (44%) occurred at or above 55 mph; and 344 (70%) occurred at or above 40 mph.Of the 382 complaints that reported the position of the vehicle relative to traffic after it came to a stop following the loss of motive power: 122 (32%) alleged that the vehicle came to a stop in the flow of traffic and remained in the flow of traffic until pushed or towed out of the way; 225 (59%) reported that the vehicle was maneuvered to the side of the roadway and remained there until towed; and 35 (9%) reported that they were able to maneuver to a location away from the flow of traffic, such as a parking lot.Two crashes were allegedly caused by torque converter failure, including an incident in which a Freestar suddenly lost power in 65 mph traffic in an area where there was no shoulder available.As a result, the Freestar stopped in a travel lane and when trailing traffic maneuvered to avoid the stalled vehicle, a four vehicle collision occurred.In these types of circumstances NHTSA believes the defect presents an unreasonable risk to motor vehicle safety and so advised Ford.In its Defect Information Report, Ford refers to its response to NHTSA's Preliminary Evaluation information request, which stated that a vehicle that loses motive power due to torque converter malfunction remains readily controllable; the vehicle will coast during which it can be safely maneuvered and stopped because the engine continues to run.Because the engine continues to run, steering and braking are unaffected, and the vehicle's electrical system and directional signals remain functional.In view of the foregoing, NHTSA does not agree with this statement.This investigation is closed based on Ford's recall.
Additional source detail variants (2)
Power Train:automatic Transmission
On January 4, 2012 Ford Motor Company submitted a Defect Information Report (NHTSA Recall No. 12V-006) to NHTSA regarding a defect in the performance of the transmission torque converter for approximately 205,896 Ford Freestar and Mercury Monterey vehicles.The supplier of the torque converter manufactured converters containing a pump shaft spline that did not consistently meet the specified heat treatment requirements.In normal use, the spline may wear excessively and eventually fails without warning.If a torque converter malfunctions due to a sheared pump drive spline, the vehicle will abruptly lose motive power.This problem affected model year 2004 and 2005 Freestar and Monterey minivans.During the investigation NHTSA identified 532 complaints alleging incidents of vehicle stall while driving due to torque converter failure.These failures were sudden and without any prior warning.Of the 490 complaints that reported the speed at the time of the failure:218 (44%) occurred at or above 55 mph; and 344 (70%) occurred at or above 40 mph.Of the 382 complaints that reported the position of the vehicle relative to traffic after it came to a stop following the loss of motive power: 122 (32%) alleged that the vehicle came to a stop in the flow of traffic and remained in the flow of traffic until pushed or towed out of the way; 225 (59%) reported that the vehicle was maneuvered to the side of the roadway and remained there until towed; and 35 (9%) reported that they were able to maneuver to a location away from the flow of traffic, such as a parking lot.Two crashes were allegedly caused by torque converter failure, including an incident in which a Freestar suddenly lost power in 65 mph traffic in an area where there was no shoulder available.As a result, the Freestar stopped in a travel lane and when trailing traffic maneuvered to avoid the stalled vehicle, a four vehicle collision occurred.In these types of circumstances NHTSA believes the defect presents an unreasonable risk to motor vehicle safety and so advised Ford.In its Defect Information Report, Ford refers to its response to NHTSA's Preliminary Evaluation information request, which stated that a vehicle that loses motive power due to torque converter malfunction remains readily controllable; the vehicle will coast during which it can be safely maneuvered and stopped because the engine continues to run.Because the engine continues to run, steering and braking are unaffected, and the vehicle's electrical system and directional signals remain functional.In view of the foregoing, NHTSA does not agree with this statement.This investigation is closed based on Ford's recall.
Power Train:automatic Transmission:torque Converter
On January 4, 2012 Ford Motor Company submitted a Defect Information Report (NHTSA Recall No. 12V-006) to NHTSA regarding a defect in the performance of the transmission torque converter for approximately 205,896 Ford Freestar and Mercury Monterey vehicles.The supplier of the torque converter manufactured converters containing a pump shaft spline that did not consistently meet the specified heat treatment requirements.In normal use, the spline may wear excessively and eventually fails without warning.If a torque converter malfunctions due to a sheared pump drive spline, the vehicle will abruptly lose motive power.This problem affected model year 2004 and 2005 Freestar and Monterey minivans.During the investigation NHTSA identified 532 complaints alleging incidents of vehicle stall while driving due to torque converter failure.These failures were sudden and without any prior warning.Of the 490 complaints that reported the speed at the time of the failure:218 (44%) occurred at or above 55 mph; and 344 (70%) occurred at or above 40 mph.Of the 382 complaints that reported the position of the vehicle relative to traffic after it came to a stop following the loss of motive power: 122 (32%) alleged that the vehicle came to a stop in the flow of traffic and remained in the flow of traffic until pushed or towed out of the way; 225 (59%) reported that the vehicle was maneuvered to the side of the roadway and remained there until towed; and 35 (9%) reported that they were able to maneuver to a location away from the flow of traffic, such as a parking lot.Two crashes were allegedly caused by torque converter failure, including an incident in which a Freestar suddenly lost power in 65 mph traffic in an area where there was no shoulder available.As a result, the Freestar stopped in a travel lane and when trailing traffic maneuvered to avoid the stalled vehicle, a four vehicle collision occurred.In these types of circumstances NHTSA believes the defect presents an unreasonable risk to motor vehicle safety and so advised Ford.In its Defect Information Report, Ford refers to its response to NHTSA's Preliminary Evaluation information request, which stated that a vehicle that loses motive power due to torque converter malfunction remains readily controllable; the vehicle will coast during which it can be safely maneuvered and stopped because the engine continues to run.Because the engine continues to run, steering and braking are unaffected, and the vehicle's electrical system and directional signals remain functional.In view of the foregoing, NHTSA does not agree with this statement.This investigation is closed based on Ford's recall.
PE09033 · Torque Converter Output Shaft Failure
Opened Jul 15, 2009 · Closed Nov 17, 2009
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:torque Converter
ODI HAS RECEIVED 227 OWNER COMPLAINTS ALLEGING A SUDDEN AND UNEXPECTED LOSS OF MOTIVE POWER DUE TO AN INTERNAL TRANSMISSION FAILURE IN THE SUBJECT VEHICLES.OF THOSE COMPLAINTS, 124 CAN BE ATTRIBUTED TO THE TORQUE CONVERTER OUTPUT SHAFT SPLINES STRIPPING CAUSING A SUDDEN LOSS OF POWER TO THE DRIVETRAIN.THE REMAINING 103 COMPLAINTS EXPERIENCED A LOSS OF MOTIVE POWER BUT THE SPECIFIC INTERNAL FAILURE CAUSE WITHIN THE TRANSMISSION IS NOT KNOWN.ODI HAS UPGRADED THE INVESTIGATION TO AN ENGINEERING ANALYSIS (EA09-016) TO CONTINUE ITS ASSESSMENT OF THE SCOPE, FREQUENCY AND SAFETY-RELATED CONSEQUENCES OF THE ALLEGED DEFECT.
Additional source detail variants (2)
Power Train:automatic Transmission
ODI HAS RECEIVED 227 OWNER COMPLAINTS ALLEGING A SUDDEN AND UNEXPECTED LOSS OF MOTIVE POWER DUE TO AN INTERNAL TRANSMISSION FAILURE IN THE SUBJECT VEHICLES.OF THOSE COMPLAINTS, 124 CAN BE ATTRIBUTED TO THE TORQUE CONVERTER OUTPUT SHAFT SPLINES STRIPPING CAUSING A SUDDEN LOSS OF POWER TO THE DRIVETRAIN.THE REMAINING 103 COMPLAINTS EXPERIENCED A LOSS OF MOTIVE POWER BUT THE SPECIFIC INTERNAL FAILURE CAUSE WITHIN THE TRANSMISSION IS NOT KNOWN.ODI HAS UPGRADED THE INVESTIGATION TO AN ENGINEERING ANALYSIS (EA09-016) TO CONTINUE ITS ASSESSMENT OF THE SCOPE, FREQUENCY AND SAFETY-RELATED CONSEQUENCES OF THE ALLEGED DEFECT.
Power Train:automatic Transmission:torque Converter
ODI HAS RECEIVED 227 OWNER COMPLAINTS ALLEGING A SUDDEN AND UNEXPECTED LOSS OF MOTIVE POWER DUE TO AN INTERNAL TRANSMISSION FAILURE IN THE SUBJECT VEHICLES.OF THOSE COMPLAINTS, 124 CAN BE ATTRIBUTED TO THE TORQUE CONVERTER OUTPUT SHAFT SPLINES STRIPPING CAUSING A SUDDEN LOSS OF POWER TO THE DRIVETRAIN.THE REMAINING 103 COMPLAINTS EXPERIENCED A LOSS OF MOTIVE POWER BUT THE SPECIFIC INTERNAL FAILURE CAUSE WITHIN THE TRANSMISSION IS NOT KNOWN.ODI HAS UPGRADED THE INVESTIGATION TO AN ENGINEERING ANALYSIS (EA09-016) TO CONTINUE ITS ASSESSMENT OF THE SCOPE, FREQUENCY AND SAFETY-RELATED CONSEQUENCES OF THE ALLEGED DEFECT.