NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
85 reports99,000 miles · Apr 20, 2015
Exterior Lighting
WHILE TRAVELING HOME FROM CHURCH, MY CAR SUDDENLY SHUT DOWN WITH NO WARNING. I WAS IN TRAFFIC AND ABLE TO PULL OFF WITH NO POWER AT ALL. WHEN I STOPPED AND PUT IT IN PARK, THE CAR WOULD NOT ALLOW YOU TO TAKE IT OUT. IT WOULD NOT CRANK EVEN AFTER REPLACING THE BATTERY. I FOUND OUT THE NEXT DAY THAT I HAD A BLOWN PASSENGER SIDE…
Read full complaint
WHILE TRAVELING HOME FROM CHURCH, MY CAR SUDDENLY SHUT DOWN WITH NO WARNING. I WAS IN TRAFFIC AND ABLE TO PULL OFF WITH NO POWER AT ALL. WHEN I STOPPED AND PUT IT IN PARK, THE CAR WOULD NOT ALLOW YOU TO TAKE IT OUT. IT WOULD NOT CRANK EVEN AFTER REPLACING THE BATTERY. I FOUND OUT THE NEXT DAY THAT I HAD A BLOWN PASSENGER SIDE TAIL LIGHT. THIS CAUSED MY CAR TO CUT OFF AND FORD STATED THAT THIS IS WHAT HAPPENS. THIS IS A VERY DANGEROUS WIRING ISSUE. APPARENTLY, THE TAIL LIGHTS ARE CONNECTED TO THE MAIN SYSTEM AND IF ONE GOES OUT IT SHUTS THE CAR OFF AND ACTIVATES THE THEFT PROTECTION SYSTEM. THIS NEEDS TO BE LOOKED AT. IF I WOULD HAVE BEEN ON THE EXPRESS WAY, THE ISSUE COULD HAVE BECOME SERIOUS. IT WAS STILL A SERIOUS ISSUE. THANK YOU. *TR
NHTSA ODI #10706585
32,000 miles · Apr 5, 2015
Electrical SystemPower TrainUnknown Or Other
MY 2006 MONTEGO JERKS AND CLUNKS FEELS LIKE IT IS GOING TO DROP OUT. IT ALSO SLIPS INTO NEUTRAL FROM DRIVE . THE TRANS JERKS SO HARD IT FEELS LIKE IT IS GOING TO DROP ON THE STREET . FIRST NOTED THIS WITH LESS THAN32000 MILLER. ALSO HAD TO REPLACE FRONT ENGINE MOUNT $475 , FULL INSTRUMENT CLUSTER $1100 36000MILLION. THERE IS A L…
Read full complaint
MY 2006 MONTEGO JERKS AND CLUNKS FEELS LIKE IT IS GOING TO DROP OUT. IT ALSO SLIPS INTO NEUTRAL FROM DRIVE . THE TRANS JERKS SO HARD IT FEELS LIKE IT IS GOING TO DROP ON THE STREET . FIRST NOTED THIS WITH LESS THAN32000 MILLER. ALSO HAD TO REPLACE FRONT ENGINE MOUNT $475 , FULL INSTRUMENT CLUSTER $1100 36000MILLION. THERE IS A LOT OF PEOPLE COMPLAINING TO FORD BUT NOTHING IS BEING DONE.IF NOT TAKEN CARE OF THIS WILL BE MY LANGFORD PRODUCT.3FORD'S INMYIMMEDIATEFAMILY NOW. ALL WILL BE SCRAPPED ORDERING FOR CARS FROM A COMPANY THAT TAKES CARE OF ITS CUSTOMERS. FORD NEW THE CVT TRANS WAS A PROBLEM. *TR
NHTSA ODI #10703774
48,000 miles · Apr 3, 2015
Seat Belts
TL* THE CONTACT OWNS A 2006 MERCURY MONTEGO. THE CONTACT STATED THAT THE DRIVER SIDE SEAT BELT WAS FRAYED AND THE FABRIC WOULD UNRAVEL. THE FAILURE RECURRED CONTINUOUSLY FOR YEARS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 48,000.
NHTSA ODI #10703506
100,000 miles · Mar 9, 2015
Engine
TL* THE CONTACT OWNS A 2006 MERCURY MONTEGO. THE CONTACT STATED THAT THE SERVICE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE CODE WAS RESET, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10693103
Mileage unknown · Feb 17, 2015
EnginePower Train
WHEN I STARTED ACCELERATING IT WOULD STUDDER WHEN RPMS WENT UP AND THEN BASICALLY WOULDN'T LET ME GO OVER 50. I TOOK IT INTO CAR REPAIR SHOP AND THEY SAID MY THROTTLE BODY NEEDED TO BE REPLACED. I LOOKED ONLINE AND SAW THIS WAS A RECENT RECALL. HAVE I MISSED OUT ON THIS OR WHAT? I NEED SOME ANSWERS PLEASE! *TR
NHTSA ODI #10683804
100 miles · Oct 21, 2014
Power Train
WHEN ACCELERATING I NOTED THE TRANNY STARTED TO SLIP, I DRIVE VERY CAUTIOUS, NOT A SPEEDSTER, I WATCHED THE RPM SHOOT TO FIVE AND NO SPEED SHIFT, I DROVE THE CAR FOR A WHILE HOPING IT WOULD COME OUT OF IT, I WAS DRIVING BACK AND FOURTH SOME 4000 MILES TO WORK AND HAD LITTLE TIME TO GET TO MECHANICS FINALLY MY WIFE TOOK IT IN TH…
Read full complaint
WHEN ACCELERATING I NOTED THE TRANNY STARTED TO SLIP, I DRIVE VERY CAUTIOUS, NOT A SPEEDSTER, I WATCHED THE RPM SHOOT TO FIVE AND NO SPEED SHIFT, I DROVE THE CAR FOR A WHILE HOPING IT WOULD COME OUT OF IT, I WAS DRIVING BACK AND FOURTH SOME 4000 MILES TO WORK AND HAD LITTLE TIME TO GET TO MECHANICS FINALLY MY WIFE TOOK IT IN THEY SAID 4 GEAR WAS MISSING IN TRANNY, JUST GETTING BACK TO WORK I HAD TO LOOK UP A USED TRANNY BECAUSE THE COST WAS WELL OVER 3000. I FOUND A 2007 USED TRANNY FROM A REPUTABLE USED DEALER , WE PLACE THE TRANNY IN AT A COST OF 700, THE TRANNY ITSELF 475, UPON GETTING CAR BACK THE TRANNY IS DOING IT ALL OVER AGAIN, I AM NOW TAKING IT TO A DEALERSHIP TO HAVE IT SYNCHRONIZED WITH COMPUTER PROGRAMING TO SEE IF THIS FIXES PROBLEM , I AM NOT HAPPY WITH THE RECALLS ON THIS CAR BUT IF FORD REFUNDS ME AND FIXES I WOULD BE SATISFIED WE LOVE FORD TRUCK AND THEIR PRODUCTS AND FEEL FORD DOES TAKE CARE OF THEIR CUSTOMERS. *TR
NHTSA ODI #10649059
48,942 miles · Oct 8, 2014
Engine
TL* THE CONTACT OWNS A 2006 MERCURY MONTEGO. WHILE DRIVING APPROXIMATELY 60 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE THROTTLE BODY WAS REPLACED, BUT THE FAILURE RECURRED TWICE AFTER THE REPAIR WAS PERFORMED. THE MANUFACTURER WAS NOTIF…
Read full complaint
TL* THE CONTACT OWNS A 2006 MERCURY MONTEGO. WHILE DRIVING APPROXIMATELY 60 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE THROTTLE BODY WAS REPLACED, BUT THE FAILURE RECURRED TWICE AFTER THE REPAIR WAS PERFORMED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 48,942.
NHTSA ODI #10643271
89,803 miles · Aug 13, 2014
EngineExterior Lighting
TL* THE CONTACT OWNS A 2006 MERCURY MONTEGO. WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE STALLED AND WOULD NOT RESTART. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THAT THE TAIL LIGHT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPR…
Read full complaint
TL* THE CONTACT OWNS A 2006 MERCURY MONTEGO. WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE STALLED AND WOULD NOT RESTART. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THAT THE TAIL LIGHT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 89,803.
NHTSA ODI #10622102
126,000 miles · Aug 5, 2014
Electrical System
TL * THE CONTACT OWNS A 2006 MERCURY MONTEGO. WHILE DRIVING VARIOUS SPEEDS, ALL OF THE INSTRUMENT PANEL GAUGES WOULD ILLUMINATE AND DROP TO ZERO AND THE SEAT BELT INDICATORS WOULD ILLUMINATE AND CHIME. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 126,000.
NHTSA ODI #10618930
60,000 miles · Jun 9, 2014
EngineSteering
TL* THE CONTACT OWNS A 2006 MERCURY MONTEGO. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE STEERING WHEEL BECAME INOPERABLE WHEN TURNED TO THE LEFT. THE VEHICLE WAS TAKEN TO A MECHANIC WHO STATED THAT THE STEERING COLUMN AND TOP MOTOR MOUNTS WERE RUSTED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED…
Read full complaint
TL* THE CONTACT OWNS A 2006 MERCURY MONTEGO. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE STEERING WHEEL BECAME INOPERABLE WHEN TURNED TO THE LEFT. THE VEHICLE WAS TAKEN TO A MECHANIC WHO STATED THAT THE STEERING COLUMN AND TOP MOTOR MOUNTS WERE RUSTED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 60,000. UPDATED 10/07/14*LJ UPDATED 05/12/2015 *JS
NHTSA ODI #10597149
NHTSA investigations
1PE11018 · Idle Instability
Opened May 11, 2011 · Closed Feb 7, 2013
Status: closed (inferred from source dates) · Vehicle Speed Control
On November 29, 2012, Ford Motor Company (Ford) initiated Customer Satisfaction Program 12N03 to extend warranty coverage terms for repair of engine idle RPM surge caused by throttle body deposits in all model year (MY) 2005 through 2007 Ford Freestyle, Five Hundred and Mercury Montego vehicles.The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle (all vehicles are eligible for the program through May 31, 2013, regardless of mileage).Dealers will repair vehicles exhibiting the condition by removing and cleaning the throttle body and reprogramming the PCM with software containing an updated idle speed control strategy.According to Ford, some of the affected vehicles may experience momentary, intermittent engine idle RPM surge (idle flare) when stopped or during low speed driving maneuvers such as in a parking lot or driveway.Unstable idle speed control (dips and flares) around the target engine speed (700 rpm) can occur in vehicles with deposit build-up in the throttle body when the system adjusts engine speed in response to changes in engine load, typically from power steering application or air-conditioner compressor cycling.Idle speed control logic is only active at vehicle speeds below 3.5 mph and when the accelerator pedal is not applied.Ford testing of a vehicle with a worst case throttle body measured a maximum idle flare of 1360 RPM lasting approximately 1 second, which Ford indicated was consistent with system design to limit vehicle speed and acceleration in idle control mode.Ford indicated that the test vehicle was held in place with normal brake effort and that vehicle speed remained under 4 mph without the brake pedal applied.In addition to throttle body deposit accumulation, symptoms associated with the condition may include Check Engine lamp illumination and diagnostic trouble codes (DTCs) P0505, P0506 or P061B.Ford attributed the surge condition to changes in idle air flow resulting from the progressive buildup of deposits in the throttle body from normal Positive Crankcase Ventilation (PCV) system operation.This condition was not adequately compensated for in the original Powertrain Control Module (PCM) calibration.Ford issued a technical service bulletin on August 15, 2011 (TSB 11-8-5), releasing an updated powertrain control calibration for vehicles with CVT transmissions.On October 19, 2011, Ford issued a second bulletin (TSB 11-10-21) superseding TSB 11-8-5 and including updated powertrain control calibration for vehicles with 6-speed transmissions.Prior to Ford issuing the TSB?s, owner?s experiencing the alleged defect either received no repairs, if dealers could not duplicate the condition, or had the throttle body cleaned or replaced, which only provided temporary correction until the throttle deposit build-up returned.Ford?s revised powertrain calibrations appear to be effective remedies for the idle instability caused by build-up of throttle body deposits.However, even after the TSB?s were released, many owners experiencing the condition continued to have difficulty with proper diagnosis and repair as dealers were often either unable to duplicate the condition or were unfamiliar with the new repair procedures.Ford's new program addresses those concerns.NHTSA's testing and complaint analysis indicate that the idle speed control issue in the subject vehicles can only occur at very low speeds, are very brief events, are easily controlled by moderate brake pedal forces and result in minor increases in vehicle speed even with no braking.This investigation is closed.The closing of this in
Illustration