NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
22 reportsClear category filter52,960 miles · Jun 12, 2015
Vehicle Speed Control
DRIVING UP AN ON RAMP TO AN INTERSTATE HIGHWAY, THE CAR WOULD NOT REACT TO INCREASED DEPRESSION OF THE THROTTLE PEDAL. TOOL INDICATOR WARNING LIGHT ILLUMINATED ON THE DASH. I BARELY WAS ABLE TO PULL OFF TO THE BERM, ALMOST REAR-ENDED. THIS HAS HAPPENED NUMEROUS TIMES SINCE FIRST OCCURRENCE ON 6/11/15-6/12/15 AND APPEARS TO OCCUR…
Read full complaint
DRIVING UP AN ON RAMP TO AN INTERSTATE HIGHWAY, THE CAR WOULD NOT REACT TO INCREASED DEPRESSION OF THE THROTTLE PEDAL. TOOL INDICATOR WARNING LIGHT ILLUMINATED ON THE DASH. I BARELY WAS ABLE TO PULL OFF TO THE BERM, ALMOST REAR-ENDED. THIS HAS HAPPENED NUMEROUS TIMES SINCE FIRST OCCURRENCE ON 6/11/15-6/12/15 AND APPEARS TO OCCUR ONLY WHEN I HAVE THE AIR CONDITIONING ON. VERY DANGEROUS SITUATION!
NHTSA ODI #10724880
Mileage unknown · Jun 22, 2014
Power TrainSuspensionVehicle Speed Control
ON SEVERAL OCCASIONS I WILL BE DRIVING MY CAR AND IT BEGINS TO SHAKE AND CUT OFF. THE BATTERY LIGHT COMES ON AND A WRENCH WILL APPEAR NEXT TO THE PARKING LIGHT. I WAS STOPPED AT A STOP LIGHT, ONCE THE LIGHT CHANGED I TOOK MY FEET OFF THE BREAK AND PUSHED ON THE GAS. MY CAR STALLED THEN SHOOK AS I DROVE FORWARD THROUGH THE INTERS…
Read full complaint
ON SEVERAL OCCASIONS I WILL BE DRIVING MY CAR AND IT BEGINS TO SHAKE AND CUT OFF. THE BATTERY LIGHT COMES ON AND A WRENCH WILL APPEAR NEXT TO THE PARKING LIGHT. I WAS STOPPED AT A STOP LIGHT, ONCE THE LIGHT CHANGED I TOOK MY FEET OFF THE BREAK AND PUSHED ON THE GAS. MY CAR STALLED THEN SHOOK AS I DROVE FORWARD THROUGH THE INTERSECTION MY CAR CUT OFF AGAIN. I HAD TO URGENTLY PUT ON MY FLASHERS. I HAVE A CHILD AND THAT US VERY DANGEROUS. I TRIED STARTING MY CAR AGAIN AND IT MADE THE SOUND AS IF IT WERE GOING TO START BUT IT DIDN'T. THE BATTERY LIGHT CAME ON AGAIN. I TRIED ANOTHER TIME AND IT WORKED. I BEGAN DRIVING FOR NO MORE THAN 3 MINUTES AND MY CAR SHUT OFF AGAIN. I TURNED INTO A PARKING LOT AND TRIED TO START MY CAR. WE SAT THERE FOR 5 MINUTES. THE I DROVE TO WALMART WHICH IS USUALLY ONLY A FEW MINUTES AWAY. MY CAR SHUT OFF AT 4 LIGHTS ON THE WAY TO WALMART, AND PULLING INTO THE WALMART PARKING LOT, 4 LIGHTS ON THE WAY HOME. THIS WAS ALL IN ONE DAY. I AM SO AFRAID TO GET ON THE HIGHWAY BECAUSE MY CAR COULD GO OUT WHILE I'M DRIVING AND SOMEONE MAY RUN INTO THE BACK OF MY CAR. *TR
NHTSA ODI #10605071
42,015 miles · Mar 4, 2014
Engine And Engine CoolingVehicle Speed Control
WRENCH AND ENGINE LIGHT CAME ON. VEHICLE WOULD NOT GO BEYOND 5 MPH. WAITED AND TURNED THE CAR BACK ON.,ENGINE LIGHT STAYED LIT AND WAS ABLE TO GET HOME. I TOOK THE VEHICLE TO AUTOZONE AND RECEIVED A DIAGNOSTIC CODE P2111: THROTTLE ACTUATOR CONTROL SYSTEM, TACHOMETER OPEN OR SHORTED. CALLED FORD AND THEY ARE AWARE BUT STATED THAT…
Read full complaint
WRENCH AND ENGINE LIGHT CAME ON. VEHICLE WOULD NOT GO BEYOND 5 MPH. WAITED AND TURNED THE CAR BACK ON.,ENGINE LIGHT STAYED LIT AND WAS ABLE TO GET HOME. I TOOK THE VEHICLE TO AUTOZONE AND RECEIVED A DIAGNOSTIC CODE P2111: THROTTLE ACTUATOR CONTROL SYSTEM, TACHOMETER OPEN OR SHORTED. CALLED FORD AND THEY ARE AWARE BUT STATED THAT THEY WILL NOT REPAIR WITH A RECALL BEING ISSUED.
NHTSA ODI #10567356
49,300 miles · Nov 15, 2013
EnginePower TrainVehicle Speed Control
DRIVING NEAR 55 MPH ON LOCAL HIGHWAY AND APPLYING PRESSURE TO GAS PEDAL TO ACCELERATE. FELT AND HEARD A 'CLUNK'. VEHICLE IMMEDIATELY LOST ABILITY TO ACCELERATE WITH PRESSURE APPLIED TO GAS PEDAL. EXITED TO SHOULDER. NOTICED YELLOW SERVICE (WRENCH) INDICATOR LIGHT WAS ON. PUT THE CAR INTO PARK AND TURNED OFF IGNITION. RE-ST…
Read full complaint
DRIVING NEAR 55 MPH ON LOCAL HIGHWAY AND APPLYING PRESSURE TO GAS PEDAL TO ACCELERATE. FELT AND HEARD A 'CLUNK'. VEHICLE IMMEDIATELY LOST ABILITY TO ACCELERATE WITH PRESSURE APPLIED TO GAS PEDAL. EXITED TO SHOULDER. NOTICED YELLOW SERVICE (WRENCH) INDICATOR LIGHT WAS ON. PUT THE CAR INTO PARK AND TURNED OFF IGNITION. RE-STARTED VEHICLE; SERVICE INDICATOR LIGHT DID NOT COME BACK ON. PUT THE CAR INTO DRIVE AND RE-ENTERED TRAFFIC FLOW. DID NOT HAVE AN INCIDENT IN ANOTHER 30 MILES OF DRIVING. TOOK THE VEHICLE TO DEALER FOR DIAGNOSIS. DEALER DIAGNOSED PROBLEM AS REQUIRING NEW THROTTLE BODY. VERY DANGEROUS SITUATION. *TR
NHTSA ODI #10552415
60,460 miles · Nov 12, 2013
EngineFuel/propulsion SystemVehicle Speed Control
DRIVING ON A STRAIGHT AWAY THE VEHICLE SUDDENLY MAKES A NOISE AS IF IT WERE SHIFTING VERY HARD ALTHOUGH IT WAS NOT. IMMEDIATELY LOST ACCELERATION AND DASHBOARD LIGHT ILLUMINATES. PULLED VEHICLE TO THE SIDE OF THE ROAD AND RPM NEEDLE BOUNCED AS CAR LUNGED BUT WOULD NOT ACCELERATE. CALLED FOR ROADSIDE ASSISTANCE AND MY DEALER'S…
Read full complaint
DRIVING ON A STRAIGHT AWAY THE VEHICLE SUDDENLY MAKES A NOISE AS IF IT WERE SHIFTING VERY HARD ALTHOUGH IT WAS NOT. IMMEDIATELY LOST ACCELERATION AND DASHBOARD LIGHT ILLUMINATES. PULLED VEHICLE TO THE SIDE OF THE ROAD AND RPM NEEDLE BOUNCED AS CAR LUNGED BUT WOULD NOT ACCELERATE. CALLED FOR ROADSIDE ASSISTANCE AND MY DEALER'S SERVICE DEPARTMENT WHO KNEW BASED ON MY DESCRIPTION A POSSIBLE CAUSE. VEHICLE TOWED TO DEALER, DIAGNOSTICS PROVED THROTTLE BODY NEEDED TO BE REPLACED. REPAIR MADE. RESEARCH PROVED THAT THIS IS A KNOWN PROBLEM BUT NO RECALL HAS BEEN MADE. IT WAS A VERY FOGGY MORNING AND SEVERAL MULTI CAR ACCIDENTS HAD BEEN REPORTED. HAD I BEEN ON BUSIER STRETCH OF ROAD AT THE TIME OF THE BREAK DOWN I COULD HAVE EASILY BEEN KILLED WITH SLOWING DOWN SUDDENLY AND WITHOUT ANY EVIDENT CAUSE. A RECALL SHOULD BE ISSUED AND REFUNDS MADE TO THOSE WHO HAVE ALREADY EXPERIENCED THIS FAILURE. *TR
NHTSA ODI #10551906
41,000 miles · Nov 7, 2013
Vehicle Speed Control
I WAS DRIVING DOWN A LOCAL ROAD AT ABOUT 35 MPH. ALL OF A SUDDEN, WITHOUT WARNING, I COULD NOT GET MY GAS PEDAL TO DO ANYTHING, LIKE IT WAS OUT OF GEAR, AND THE ENGINE SEEMED TO BE SPUTTERING. I PULLED OFF THE ROAD, SHUT THE CAR OFF AND AFTER A FEW SECONDS, RESTARTED THE CAR, IT RESTARTED AND DROVE FINE. IT DID THE SAME THING A…
Read full complaint
I WAS DRIVING DOWN A LOCAL ROAD AT ABOUT 35 MPH. ALL OF A SUDDEN, WITHOUT WARNING, I COULD NOT GET MY GAS PEDAL TO DO ANYTHING, LIKE IT WAS OUT OF GEAR, AND THE ENGINE SEEMED TO BE SPUTTERING. I PULLED OFF THE ROAD, SHUT THE CAR OFF AND AFTER A FEW SECONDS, RESTARTED THE CAR, IT RESTARTED AND DROVE FINE. IT DID THE SAME THING AGAIN THE NEXT DAY. IT HAS HAPPENED A NUMBER OF TIMES SINCE THE FIRST TIME... HAPPENING ABOUT ONCE PER DAY. IT SEEMS TO START UP OK AFTER I SHUT IT DOWN, BUT VERY UNSAFE TO BE DRIVING DOWN THE ROAD AND THEN HAVE NO POWER AND HAVE TO PULL OFF. *TR
NHTSA ODI #10551242
67,000 miles · Sep 17, 2013
Vehicle Speed Control
TL* THE CONTACT OWNS A 2011 MERCURY MILAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE WRENCH WARNING SYMBOL ILLUMINATED AS THE VEHICLE BEGAN TO DECELERATE RAPIDLY. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD WHERE THE ENGINE WAS TURNED OFF. AFTER RESTARTING, THE VEHICLE WAS ABLE TO RESUME NORMALLY. TH…
Read full complaint
TL* THE CONTACT OWNS A 2011 MERCURY MILAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE WRENCH WARNING SYMBOL ILLUMINATED AS THE VEHICLE BEGAN TO DECELERATE RAPIDLY. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD WHERE THE ENGINE WAS TURNED OFF. AFTER RESTARTING, THE VEHICLE WAS ABLE TO RESUME NORMALLY. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS HOWEVER, THE TECHNICIAN WAS UNABLE TO DETECT A TROUBLE CODE OR DUPLICATE THE PROBLEM. THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 67,000.
NHTSA ODI #10544040
40,000 miles · Aug 29, 2013
Electrical SystemFuel/propulsion SystemVehicle Speed Control
DRIVING AT HIGHWAY SPEED, I LOST THE ABILITY TO USE THE THROTTLE. THE ENGINE RAN, BUT DID NOT RESPOND TO THE PEDAL. I WAS FORCED TO PULL THE CAR OVER, IN TRAFFIC, AND RESTART THE CAR. ONCE THE CAR WAS RESTARTED, I WAS ABLE TO ACCELERATE.
NHTSA ODI #10537974
54,000 miles · Aug 27, 2013
EngineVehicle Speed Control
THIS HAPPENED ONCE SEVERAL WEEKS AGO WITH MY WIFE OPERATING THE CAR AND NEWBORN IN THE BACK. I WASN'T IN THE CAR SO I DID NOT WITNESS THE PROBLEM. OVER THE PAST TWO DAYS I HAVE EXPERIENCED THE PROBLEM FIRST HAND SEVERAL TIMES. CAR STOPS ACCELERATING DURING NORMAL OPERATION. THE CHECK ENGINE LIGHT COMES ON, THE ACCELERATOR STOPS …
Read full complaint
THIS HAPPENED ONCE SEVERAL WEEKS AGO WITH MY WIFE OPERATING THE CAR AND NEWBORN IN THE BACK. I WASN'T IN THE CAR SO I DID NOT WITNESS THE PROBLEM. OVER THE PAST TWO DAYS I HAVE EXPERIENCED THE PROBLEM FIRST HAND SEVERAL TIMES. CAR STOPS ACCELERATING DURING NORMAL OPERATION. THE CHECK ENGINE LIGHT COMES ON, THE ACCELERATOR STOPS WORKING AND CAR BEGINS TO IDLE ERRATICALLY. THE ENGINE DOES NOT SHUT OFF. ONCE YOU COAST IN HEAVY TRAFFIC TO THE SIDE OF THE ROAD, YOU MAY TURN THE CAR OFF THEN RESTART AND DRIVE WITHOUT ISSUE FOR AN INDETERMINATE AMOUNT OF TIME (ONCE IT WAS SEVERAL WEEKS, ONCE IT WAS TEN MINUTES). THE CHECK ENGINE LIGHT WILL BE OFF AND NO CODE WILL BE LOGGED INTO THE COMPUTER. I TOOK THE CAR TO A MECHANIC TEN MINUTE AFTER AN INCIDENT AND THE COMPUTER PICKED UP NOTHING WRONG WITH THE CAR. WITH ALL THESE COMPLAINTS AND ANECDOTAL EVIDENCE, BY THIS TIME FORD AND THE NHTSA MUST BE AWARE OF THE PROBLEM. WHERE IS THE RECALL? *TR
NHTSA ODI #10537550
37,102 miles · Aug 21, 2013
Electrical SystemVehicle Speed Control
DRIVING DOWN A BUSY ROAD AND CAR WENT INTO LIMP MODE, GAS PEDAL NOT RESPONDING. ALMOST GOT REARENDED BECAUSE THE CAR SLOWED DOWN AND I HAD MY 8 MONTH OLD GRANDDAUGHTER IN THE VEHICLE. TOOK IT TO AUTOZONE AND THEY RAN A DIAGNOSTIC SAID IT WAS THE ELECTRONIC THROTTLE SENSOR PROBLEM. READ ONLINE WHERE THIS IS A RECURRENT THING G…
Read full complaint
DRIVING DOWN A BUSY ROAD AND CAR WENT INTO LIMP MODE, GAS PEDAL NOT RESPONDING. ALMOST GOT REARENDED BECAUSE THE CAR SLOWED DOWN AND I HAD MY 8 MONTH OLD GRANDDAUGHTER IN THE VEHICLE. TOOK IT TO AUTOZONE AND THEY RAN A DIAGNOSTIC SAID IT WAS THE ELECTRONIC THROTTLE SENSOR PROBLEM. READ ONLINE WHERE THIS IS A RECURRENT THING GOING ON BUT NO RECALL YET. WHAT IS IT GOING TO TAKE SOMEONE OR ALOT OF PEOPLE DYING FOR THIS TO BE RECALLED? I AM ON DISABILITY AND IT BETTER BE COVERED UNDER EXTENDED WARRANTY OR WARRANTY SINCE FORD KNOWS THIS IS AN ONGOING PROBLEM. *TR
NHTSA ODI #10536568
Official recalls
7Mar 10, 2021
Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge. Owner notification letters were mailed on April 9, 2021 for the passenger side, and November 14, 2022 for the driver side. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S12.
Feb 16, 2021
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Additional source detail variants (3)
Air Bags:frontal:passenger Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal:driver Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Jan 7, 2019
Ford Motor Company (Ford) is recalling certain 2014 Ford Mustang vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Ford is recalling certain 2011 Ford Ranger and Mercury Milan vehicles, 2011-2012 Ford Fusion and Lincoln Zephyr/MKZ vehicles and 2011-2014 Ford Mustang vehicles sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Ford is also recalling certain 2010 Ford Edge and Lincoln MKX vehicles, 2010-2011 Ford Ranger and Mercury Milan vehicles, 2010-2012 Ford Fusion and Lincoln Zephyr/MKZ vehicles, and 2010-2014 Ford Mustang vehicles sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with air bag inflators assembled as part of the passenger frontal air bag modules, used as original equipment or replacement equipment (such as after a vehicle crash necessitating replacement of the original air bags), that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 13, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall 19S01.
May 31, 2016
Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
Nov 24, 2015
Ford Motor Company (Ford) is recalling certain model year 2010-2011 Ford Fusion vehicles manufactured July 21, 2008, to March 4, 2011, and 2010-2011 Mercury Milan vehicles manufactured July 23, 2008, to December 10, 2010. The affected vehicles have fuel vapor canisters whose purge valves may not operate properly resulting in abnormal pressure changes in the fuel tank.
Consequence & remedy
Consequence: The pressure changes may cause the tank to crack and leak fuel. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Ford will notify owners, and dealers will update the vehicle powertrain control modules and inspect the vehicle for any diagnostic trouble codes (DTCs) for this issue and perform a leak test on the Canister Purge Valve (CPV). The fuel tank will be inspected for cracks. The CPV and fuel tank will be replaced as necessary. These repairs will be performed free of charge. The recall began on January 15, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S34.
Jun 2, 2015
Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford Fusion vehicles without a 3.5L engine and Lincoln MKZ hybrid electric vehicles, 2011 Mercury Milan vehicles, 2011-2012 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with a 3.5L GTDI engine and 2013 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with any available engine. The affected vehicles have electric power steering assist systems that may shut down as a result of a steering motor sensor fault.
Consequence & remedy
Consequence: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, increasing the risk of a vehicle crash.
Remedy: Ford will notify owners, and dealers will check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTC). If dealers find any loss of steering assist DTCs, the steering gear will be replaced, free of charge. If, no codes are found during the PSCM inspection, the PSCM software will be updated, free of charge. The recall began on July 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S18.
Dec 7, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2010-2011 FORD FUSION AND MERCURY MILAN VEHICLES EQUIPPED WITH 17 INCH STEEL WHEELS AND BUILT FROM APRIL 1, 2009, THROUGH APRIL 30, 2009, AND FROM DECEMBER 1, 2009, THROUGH NOVEMBER 13, 2010. THE WHEEL STUDS MAY FRACTURE, POTENTIALLY CAUSING A WHEEL TO SEPARATE.
Consequence & remedy
Consequence: WHILE DRIVING, MULTIPLE STUD FRACTURES COULD OCCUR AT THE WHEEL LOCATION, AND THE OPERATOR MAY EXPERIENCE VEHICLE VIBRATION AND/OR WHEEL SEPARATION, INCREASING THE RISK OF A CRASH.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE REAR BRAKE DISC SURFACE FOR FLATNESS AND REPLACE THE DISCS AS NECESSARY. ADDITIONALLY, THE WHEEL LUG NUTS WILL BE REPLACED ON ALL FOUR WHEELS. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JANUARY 24, 2012. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE14030 · Electric Power Steering Failure
Opened Oct 2, 2014 · Closed Sep 10, 2015
Status: closed (inferred from source dates) · Steering:electric Power Assist System
The Office of Defects Investigation (ODI) opened a preliminary evaluation to investigate complaints of the loss of power steering while driving. The subject vehicles are equipped with a rack mounted Electric Power Assisted Steering (EPAS) unit.Some of the complaints alleged that the steering assist failed and resulted in increased steering efforts that contributed to a loss of control and in some cases a crash.The EPAS system was manufactured by TRW Automotive for Ford and was designated as Generation I.These units were first produced and put into vehicle production in July 2008 beginning with the model year (MY) 2010 Ford Fusion and Mercury Milan.The system is comprised of a mechanical steering rack-and-pinion gear with torque sensor, electric assist motor, motor position sensor and a power steering control module (PSCM). The PSCM is self-monitoring and designed to detect faults within the system and can store diagnostic trouble codes (DTCs) if a problem is detected.There are 29 potential DTCs the system can detect.Many of these allow the system to go into reduced-assist steering mode by using the default vehicle speed signal should the live speed signal be lost, if voltage to EPAS system falls below 10.7 or goes above 17 volts, the temperature at the PSCM goes above 105C (221F), or if high friction is detected.Some DTCs will cause the system to go into manual steering mode (no assist). On July 1, 2015, Ford filed a Defect Information Report (DIR) identifying a safety related defect in TRW GEN I EPAS systems installed in some of the subject vehicles (NHTSA Recall 15V-340, Ford No. 15S18).The DIR indicated that intermittent electrical connections caused by quality issues associated with conformal coat contamination and ribbon cable pin misalignment within the steering gear motor may lead to a loss of the motor position sensor signal, resulting in a sudden loss of power assist while driving.The recall covers approximately 393,623 vehicles built from September 2010 through February 2012:2011-12 Fusion built SEP 2010 - FEB 2012; 2011-12 Lincoln MKZ built SEP 2010 - FEB 2012; 2011 Milan built SEP 2010 - DEC 2010; 2011-13 Taurus built SEP 2010 - FEB 2012; 2011-13 Flex with 3.5L GTDI engine built SEP 2010 - FEB 2012; and 2011-13 MKS, MKT with 3.5L GTDI engine built SEP 2010 - FEB 2012.The repair consists of updating the PSCM software to prevent a loss of steering assist while driving. The revised software will provide audible and visual warnings to the driver. If one or more of the following DTCs are stored, C1B00-62, C200B-2F, C200B-61, C200B-62, C200C-2F, C200D-49, U0300-00, U2011-49, U2011-61, U3000-46, U3000-49, U3000-61, U3000-72, U3000-96, P07AE-09, the dealer will replace the EPAS system at no charge to the owner.ODI's analysis of failure data for this PE identified a total of 2,584 complaints to ODI and Ford and 9,967 Ford warranty claims related to the alleged defect.The recalled vehicles account for 1,634 of the complaints and 7,311 of the warranty claims.ODI's analysis identified 40 complaints alleging crashes that may be related to loss of steering assist while driving, 20 of which involved vehicles included in Ford's recall.The information available for the alleged crashes were not sufficient to assess specific causes of the incidents or to verify EPAS malfunctions in each case.Most of the crashes were low-speed impacts with curbs or roadside objects resulting in wheel or minor body damage.None of the injury claims indicated medical attention was required.In addition, statistical modeling of the failure data by NHTSA's National Center for Statistics and Analysis projected 10-year failur
PE13003 · Electronic Throttle Body Malfunction
Opened Feb 21, 2013 · Closed Feb 28, 2014
Status: closed (inferred from source dates) · Engine
On February 21, 2013, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE13-003 to investigate allegations of electronic throttle body (ETB) failures resulting in sudden reduction of engine power in model year (MY) 2009-2013 Ford Escape, Fusion, Mariner and Milan vehicles. During this investigation, Ford identified a condition in subject vehicles equipped with 2.5L and 3.0L engines that may result in a sudden reduction of engine power.According to Ford, the ETB internal motor contacts may develop a high resistance material buildup condition on the commutator, resulting in intermittent electrical connectivity and reduced engine power. When this condition occurs, the Malfunction Indicator Lamp (MIL) or Wrench light will illuminate and the vehicle may enter a limited limp home mode.Ford?s trade name for the feature is Failure Mode Effects Management (FMEM) mode.In this mode, engine power and vehicle speed are reduced, while full function of the power steering, power braking, lighting, and climate control systems are maintained.ODI?s complaint analysis indicate that the predominant failure mode involved reduced motive power associated with the limited limp home mode with engine speeds limited to approximately 900 RPM. Analysis of warranty claims provided by Ford identified 59,807 claims related to ETB replacements and approximately 50 percent of claims are associated with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed.Ford described several factors where the ETB motor may fail resulting in DTCs P2111 or P2112 but the failure is not an existing stuck open or closed ETB valve position.According to Ford, the ETB control strategy provides the driver with three FMEM modes that allow varying degrees of vehicle mobility depending on the severity of the fault detected.DTCs associated with stuck open or closed throttle valves are designated the highest failure severity resulting in engine speeds limited to high idle corresponding to the limited limp home mode.Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability.Other FMEM limp modes may result in reduced engine performance but will maintain vehicle speed above 20mph. During this investigation, Ford and its suppliers, Delphi and Igarashi, updated the powertrain control module (PCM) software to include a throttle body motor cleaning cycle during key-on and modified the ETB internal motor components design, surface finish and material composition to improve durability. Additionally, Ford developed a remedy procedure and issued a special Customer Satisfaction Program (CSP) 13N03 extending the ETB warranty coverage and instructing dealers to update the powertrain calibration to improve vehicle performance in the event that intermittent electrical connectivity of the throttle body motor contacts occurs. The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle, all vehicles are eligible for the program through January 31, 2015 regardless of mileage.Owners of the affected vehicles will be contacted by mail to take their vehicle to a Ford dealer who will reprogram the PCM to the latest calibration. The bulletin was sent to dealers on January 17, 2014 and the owner letter mailing began on January 27, 2014. See the investigative file for copies of Ford's bulletin and owner letter. This preliminary evaluation is closed. The closing of this investigation does not constitute a finding that
EA12009 · Floor Mat Interference With Accelerator
Opened Dec 12, 2012 · Closed Jun 12, 2014
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal
On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated clockwise.Both the single- and double-clip (Figure 2) all-weather floor mats may interfere with the accelerator pedal return to idle when the mats are not secured by the retention clip(s).Testing showed that this can occur if the mats are moved forward from the clipped position approximately two inches into a position in which the rear edge of the mats will abut the retention clip(s) when installed singly and align with the clip(s) when stacked on another floor mat.The pedal interference incidents reviewed by the Office of Defects Investigation (ODI) include 1 crash and 9 incidents with allegations of brake friction materials smoking and/or requiring repair for heat related damage.The crash incident occurred after the parking brake was applied at speed, resulting in loss-of-control vehicle yaw event caused by lock-up of the rear tires.The spin-out resulted in a side impact collision with an oncoming vehicle in an opposing lane of traffic. For the 29 incidents with sufficient information available to make an assessment; 23 (79%) were controlled by the driver either shifting to neutral, turning the engine off, or both; 4 (14%) were ended by the driver either kicking the pedal free (2) or pulling the mat away from the pedal (2); and 2 (7%) were ended by the pedal freeing itself from the mat with no apparent driver action.None of the drivers who reacted to the incident by shifting to neutral or turning the engine off reported any difficulties with either action.The subject mats were sold by Ford and Lincoln dealers directly to customers as an optional accessory equipment item or, beginning in November 2007, the mats were also available as a factory installed accessory if ordered with a new vehicle.Ford estimates that approximately 82,579 affected driver's side all weather floor mats were sold worldwide; either over the counter through Ford dealerships or as original equipment.Owners that purchased the subject all-weather floor mats as a factory installed accessory with their new vehicle will be notified to return their all weather floor mats to their Ford or Lincoln Dealership in exchange for replacement mats.Owners of all other potentially affected vehicles will be notified that, if they have an affected Ford driver's side all weather floor mat, they should return their mats to the dealership in exchange for replacement mats.The VOQs associated with the closing of this investigation are: 10327597, 10332233, 10334211, 10335336, 10339330, 10348772 (and duplicate 10342572), 10372674, 10379562, 10415911, 10426255, 10434107, 10521053, 10554966.This investigation is hereby closed.
Additional source detail variants (2)
Vehicle Speed Control:accelerator Pedal
On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated clockwise.Both the single- and double-clip (Figure 2) all-weather floor mats may interfere with the accelerator pedal return to idle when the mats are not secured by the retention clip(s).Testing showed that this can occur if the mats are moved forward from the clipped position approximately two inches into a position in which the rear edge of the mats will abut the retention clip(s) when installed singly and align with the clip(s) when stacked on another floor mat.The pedal interference incidents reviewed by the Office of Defects Investigation (ODI) include 1 crash and 9 incidents with allegations of brake friction materials smoking and/or requiring repair for heat related damage.The crash incident occurred after the parking brake was applied at speed, resulting in loss-of-control vehicle yaw event caused by lock-up of the rear tires.The spin-out resulted in a side impact collision with an oncoming vehicle in an opposing lane of traffic. For the 29 incidents with sufficient information available to make an assessment; 23 (79%) were controlled by the driver either shifting to neutral, turning the engine off, or both; 4 (14%) were ended by the driver either kicking the pedal free (2) or pulling the mat away from the pedal (2); and 2 (7%) were ended by the pedal freeing itself from the mat with no apparent driver action.None of the drivers who reacted to the incident by shifting to neutral or turning the engine off reported any difficulties with either action.The subject mats were sold by Ford and Lincoln dealers directly to customers as an optional accessory equipment item or, beginning in November 2007, the mats were also available as a factory installed accessory if ordered with a new vehicle.Ford estimates that approximately 82,579 affected driver's side all weather floor mats were sold worldwide; either over the counter through Ford dealerships or as original equipment.Owners that purchased the subject all-weather floor mats as a factory installed accessory with their new vehicle will be notified to return their all weather floor mats to their Ford or Lincoln Dealership in exchange for replacement mats.Owners of all other potentially affected vehicles will be notified that, if they have an affected Ford driver's side all weather floor mat, they should return their mats to the dealership in exchange for replacement mats.The VOQs associated with the closing of this investigation are: 10327597, 10332233, 10334211, 10335336, 10339330, 10348772 (and duplicate 10342572), 10372674, 10379562, 10415911, 10426255, 10434107, 10521053, 10554966.This investigation is hereby closed.
Vehicle Speed Control
On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated clockwise.Both the single- and double-clip (Figure 2) all-weather floor mats may interfere with the accelerator pedal return to idle when the mats are not secured by the retention clip(s).Testing showed that this can occur if the mats are moved forward from the clipped position approximately two inches into a position in which the rear edge of the mats will abut the retention clip(s) when installed singly and align with the clip(s) when stacked on another floor mat.The pedal interference incidents reviewed by the Office of Defects Investigation (ODI) include 1 crash and 9 incidents with allegations of brake friction materials smoking and/or requiring repair for heat related damage.The crash incident occurred after the parking brake was applied at speed, resulting in loss-of-control vehicle yaw event caused by lock-up of the rear tires.The spin-out resulted in a side impact collision with an oncoming vehicle in an opposing lane of traffic. For the 29 incidents with sufficient information available to make an assessment; 23 (79%) were controlled by the driver either shifting to neutral, turning the engine off, or both; 4 (14%) were ended by the driver either kicking the pedal free (2) or pulling the mat away from the pedal (2); and 2 (7%) were ended by the pedal freeing itself from the mat with no apparent driver action.None of the drivers who reacted to the incident by shifting to neutral or turning the engine off reported any difficulties with either action.The subject mats were sold by Ford and Lincoln dealers directly to customers as an optional accessory equipment item or, beginning in November 2007, the mats were also available as a factory installed accessory if ordered with a new vehicle.Ford estimates that approximately 82,579 affected driver's side all weather floor mats were sold worldwide; either over the counter through Ford dealerships or as original equipment.Owners that purchased the subject all-weather floor mats as a factory installed accessory with their new vehicle will be notified to return their all weather floor mats to their Ford or Lincoln Dealership in exchange for replacement mats.Owners of all other potentially affected vehicles will be notified that, if they have an affected Ford driver's side all weather floor mat, they should return their mats to the dealership in exchange for replacement mats.The VOQs associated with the closing of this investigation are: 10327597, 10332233, 10334211, 10335336, 10339330, 10348772 (and duplicate 10342572), 10372674, 10379562, 10415911, 10426255, 10434107, 10521053, 10554966.This investigation is hereby closed.
Illustration