Air Bags. Review the 128 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

6 crash reports0 fire reports4 injury reports

What owners actually said

214 reports

145,000 miles · Oct 14, 2020

Service Brakes, Hydraulic

Read full complaint

TL* THE CONTACT OWNS A 2006 MERCURY MILAN. THE CONTACT STATED WHILE DRIVING 15 MPH AND DEPRESSING THE BRAKE PEDAL TO THE FLOOR, THE VEHICLE FAILED TO STOP. THE CONTACT STATED THAT THE ABS WARNING LIGHT WAS ILLUMINATED. THE CONTACT STATED THE VEHICLE ROLLED TO A STOP. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER: 19V904000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER, MURRAY'S FORD LINCOLN (3007 BLINKER PKWY, DUBOIS, PA 15801; (800) 371-6601) WHERE IT WAS CONFIRMED THAT THE PART WAS NOT YET AVAILABLE. THE CONTACT EXPERIENCED THE FAILURE INTERMITTENTLY. THE MANUFACTURER HAD NOT BEEN INFORMED OF FAILURE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 145,000.

NHTSA ODI #11364348

130,000 miles · Jan 27, 2020

Service BrakesStructureCrashInjury

MY CAR DID NOT STOP WHEN BRAKE WAS APPLIED RESULTING IN A CRASH INTO THE CAR THAT WAS IN FRONT OF ME. BOTH CARS WERE GETTING READY TO ENTER THE MAIN ROAD FROM A SIDE STREET. I WAS STARTING TO PROCEED AND WE HAD TO STOP AND WAIT FOR ONCOMING TRAFFIC WHEN I HIT MY BRAKES IT DID NOT STOP BEFORE I HIT THE CAR. RECALL # 19S54

NHTSA ODI #11302317

28,900 miles · Jul 2, 2019

Structure

OPERATOR DOOR HANDLE BROKEN PAWL SPRING TAB, DOOR MAY OPEN WHILE DRIVING

NHTSA ODI #11228883

200,000 miles · Jun 12, 2019

Engine

MOUNTING BOLT CONTINUOUSLY UNWINDS AND BREAKS INSIDE PULLEY CAUSING SERPENTINE BELT TO TEAR AND/OR COME UNDONE. SAME BOLT @ LEAST 4(FOUR) TIMES WITHN A SEVERAL MONTH PERIOD. (OCTOBER 2018-MAY 2019)

NHTSA ODI #11219592

1,485,000 miles · May 25, 2019

Unknown Or Other

Read full complaint

WHILE DRIVING MY 2006 MERCURY MILAN ON 65MPH HIGHWAY ENGINE STARTED SOUNDING LIKE IT WAS REVING UP. THE SPEED OF THE VEHICLE SLOWED DOWN DRASTICALLY. A SMALL WARNING LIGHT THAT LOOK LIKE A WRENCH CAME ON. AFTER SHUTTING ENGINE OFF I RESTARTED VEHICLE AND MADE IT HOME WITH LIGHT OFF. NOW EACH TIME I START TO DRIVE ANYWHERE WRENCH LIGHT COMES BACK ON AND ENGINE SEEMS TO REV UP AND UNABLE TO INCREASE SPEED. VEHICLE IS ALSO IDLING FAST. I'VE NOTED PER ONINE CONVERSATION THIS IS A COMMON COMPLAINT WITH MERCURY MILAN VEHICLES. UNCERTAIN IF THIS IS RECURRING ISSUE AS I'VE OWNED CAR LESS THAN 30DAYS.

NHTSA ODI #11209956

66,000 miles · May 24, 2019

Air Bags

Read full complaint

TL* THE CONTACT OWNS A 2006 MERCURY MILAN. ONE MONTH AFTER THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 17V024000 (AIR BAGS), THE AIR BAG AND OTHER UNKNOWN WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN BACK TO KEITH HAWTHORNE FORD OF BELMONT (704-825-5186, LOCATED AT 617 N MAIN ST, BELMONT, NC 28012) WHERE IT WAS DIAGNOSED THAT THE AIR BAG SENSOR NEEDED TO BE REPLACED AT THE OWNER'S EXPENSE. THE CONTACT STATED THAT THERE WAS NOTHING WRONG WITH THE VEHICLE PRIOR TO THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 66,000. *BF *AS

NHTSA ODI #11209654

Mileage unknown · Apr 8, 2019

Air BagsElectrical System

HAD AIR BAG REPLACE APRIL 8 2019 RECALL. BUT AIR BAG ICON STAYS ON. DEALER WHO DID WORK WOULDN'T FIX. SAYING IT'S NOT PART OF RECALL. SO HOW DO I KNOWN THIS NEW AIR BAG WORKING PROPERLY

NHTSA ODI #11194794

80,103 miles · Jan 31, 2019

Air Bags

Read full complaint

TL* THE CONTACT OWNS A 2006 MERCURY MILAN. WHEN THE VEHICLE WAS STARTED, THE AIR BAG WARNING INDICATOR ILLUMINATED AND REMAINED LIT. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 16V384000 (AIR BAGS) AT MURPHY FORD (3310 TOWNSHIP LINE RD, CHESTER, PA 19013, 610-494-8800). THE CONTACT STATED THAT THE RECALL REMEDY FAILED AND THE AIR BAG INDICATOR CONTINUED TO ILLUMINATE. THE VEHICLE WAS NOT TAKEN BACK TO THE DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT COULD NOT OFFER ANY ADDITIONAL ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 80,103. *TT*JB

NHTSA ODI #11173272

Mileage unknown · Dec 21, 2018

Air Bags

TL* TAKATA RECALL. THE CONTACT OWNS A 2006 MERCURY MILAN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V384000 (AIR BAGS). GRIECO FORD DELRAY BEACH (3000 S FEDERAL HWY, DELRAY BEACH, FL 33483, 561-278-0303) WAS CONTACTED AND CONFIRMED THAT PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS NOT …

Read full complaint

NHTSA ODI #11162982

187,000 miles · Dec 10, 2018

Air Bags

THE AIR BAG LIGHT WOULD COME ON AND STAY ON FOR A FEW MINUTES. THEN IT WOULD GO OFF. I RECEIVED A RECALL NOTICE FOR THE AIRBAGS. I HAD NO IDEA WE HAVE BEEN DRIVING AN UNSAFE CAR FOR 2 YEARS THIS HAPPENED WHILE THE CAR IS MOTION AND WHILE ON IN TOWN STREETS

NHTSA ODI #11157348

Official recalls

21V158000 · Air Bags:frontal:driver Side:inflator Module

Mar 10, 2021

Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge. Owner notification letters were mailed on April 9, 2021 for the passenger side, and November 14, 2022 for the driver side. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S12.

19V904000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Dec 18, 2019

Ford Motor Company (Ford) is recalling certain 2006-2010 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ vehicles. The valves within the ABS Hydraulic Control Units (HCU) may react with brake fluids containing specific corrosion preventative additives. This reaction may cause the valves to not close properly.

Consequence & remedy

Consequence: If the valves do not properly close, additional brake pedal travel may be required to stop the vehicle, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will flush the brake system with DOT 4 fluid and install a new brake fluid reservoir cap. In addition, the HCU will be tested to detect a possible stuck valve condition, replacing the HCU as necessary. All services will be performed free of charge. The recall began April 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S54.

17V024000 · Air Bags:frontal:passenger Side:inflator Module

Jan 10, 2017

Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain 2009 Ford Ranger, Edge, Fusion and Mustang, Lincoln MKX, MKZ and Zephyr and Mercury Milan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Ford is recalling certain 2007-2008 Ford Ranger, Edge and Lincoln MKX, 2006-2008 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ, 2005-2008 Ford Mustang and 2005-2006 Ford GT vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Interim letters informing owners of the recall and that parts are not yet available began mailing March 1, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.

16V384000 · Air Bags:frontal:passenger Side:inflator Module

May 31, 2016

Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA12009 · Floor Mat Interference With Accelerator

Opened Dec 12, 2012 · Closed Jun 12, 2014

Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal

On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated clockwise.Both the single- and double-clip (Figure 2) all-weather floor mats may interfere with the accelerator pedal return to idle when the mats are not secured by the retention clip(s).Testing showed that this can occur if the mats are moved forward from the clipped position approximately two inches into a position in which the rear edge of the mats will abut the retention clip(s) when installed singly and align with the clip(s) when stacked on another floor mat.The pedal interference incidents reviewed by the Office of Defects Investigation (ODI) include 1 crash and 9 incidents with allegations of brake friction materials smoking and/or requiring repair for heat related damage.The crash incident occurred after the parking brake was applied at speed, resulting in loss-of-control vehicle yaw event caused by lock-up of the rear tires.The spin-out resulted in a side impact collision with an oncoming vehicle in an opposing lane of traffic. For the 29 incidents with sufficient information available to make an assessment; 23 (79%) were controlled by the driver either shifting to neutral, turning the engine off, or both; 4 (14%) were ended by the driver either kicking the pedal free (2) or pulling the mat away from the pedal (2); and 2 (7%) were ended by the pedal freeing itself from the mat with no apparent driver action.None of the drivers who reacted to the incident by shifting to neutral or turning the engine off reported any difficulties with either action.The subject mats were sold by Ford and Lincoln dealers directly to customers as an optional accessory equipment item or, beginning in November 2007, the mats were also available as a factory installed accessory if ordered with a new vehicle.Ford estimates that approximately 82,579 affected driver's side all weather floor mats were sold worldwide; either over the counter through Ford dealerships or as original equipment.Owners that purchased the subject all-weather floor mats as a factory installed accessory with their new vehicle will be notified to return their all weather floor mats to their Ford or Lincoln Dealership in exchange for replacement mats.Owners of all other potentially affected vehicles will be notified that, if they have an affected Ford driver's side all weather floor mat, they should return their mats to the dealership in exchange for replacement mats.The VOQs associated with the closing of this investigation are: 10327597, 10332233, 10334211, 10335336, 10339330, 10348772 (and duplicate 10342572), 10372674, 10379562, 10415911, 10426255, 10434107, 10521053, 10554966.This investigation is hereby closed.

Additional source detail variants (2)

Vehicle Speed Control:accelerator Pedal

Vehicle Speed Control